SEAT BELTS
Defect Description
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to th
... e requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."Read moreConsequence
In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
Remedy
Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
1,496 vehicles affected
Manufacturer: Volvo Trucks North America
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH VALEO WIPER SYSTEMS, THE WIPER MOTOR MAY BE SUSCEPTIVE TO SALT INTRUSION THAT COULD POSSIBLY LEAD TO A CONDITION WHERE THE CONNECTOR OVERHEATS TO A POINT WHERE THE CONNECTOR COULD IGNITE.
Consequence
IF THIS OCCURS, EXCESSIVE HEAT AND SMOKE COULD RESULT IN AN UNDER HOOD FIRE.
Remedy
DEALERS WILL INSPECT AND REPLACE THE CONNECTOR PLATE ON THE WINDSHIELD WIPER MOTOR. PHASE 2 OF THE RECALL BEGAN ON NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
56,154 vehicles affected
Manufacturer: VOLVO TRUCKS NORTH AMERICA, INC.
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Defect Description
ON CERTAIN TRUCKS, A MALFUNCTION IN THE SOLENOID VALVE MAY ALLOW AIR TO BE RELEASED TO FIFTH WHEEL LATCH WHEN THE PARK BRAKE IS ENGAGED.
Consequence
THIS CONDITION COULD CAUSE THE FIFTH WHEEL LATCH TO RELEASE INADVERTENTLY WHEN THE PARK BRAKE IS ENGAGED, CREATING THE POTENTIAL FOR LOSS OF THE TRAILER. A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy
DEALERS WILL ADD AN ADDITIONAL SOLENOID VALVE IN SERIES WITH THE EXISTING PNEUMATIC CIRCUIT FOR THE FIFTH WHEEL AIR RELEASE. THE RECALL BEGAN ON AUGUST 9, 2004. OWNERS SHOULD CONTACT VOLVO AT 1-800-528-6586.
1,374 vehicles affected
Manufacturer: VOLVO TRUCKS NORTH AMERICA, INC.
ENGINE AND ENGINE COOLING
Defect Description
ON CERTAIN HEAVY-DUTY CLASS 8 TRUCKS, THE ASSEMBLED ENGINE PRE-HEATER JUMPER WIRING HARNESS WAS INCORRECTLY ASSEMBLED.
Consequence
THE ENGINE PRE-HEATER COULD OVERHEAT RESULTING IN DAMAGE TO THE PRE-HEATER AND OTHER ENGINE HEAT SENSITIVE COMPONENTS NEAR THE PRE-HEATER AND THE ABILITY TO RE-START THE ENGINE COULD BE COMPROMISED, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPAIR THE AFFECTED CIRCUITS IN THE JUMPER WIRING HARNESS CONNECTOR. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTA
... CT VOLVO TRUCKS AT 1-800-528-6586.Read more2,112 vehicles affected
Manufacturer: VOLVO TRUCKS NORTH AMERICA, INC.
Complaint Statistics
3 total complaints
1 crashes
Top Reported Components
| Component | Complaints |
|---|
| SUSPENSION:FRONT:HUB | 1 |
| LATCHES/LOCKS/LINKAGES:HOOD:LATCH | 1 |
| UNKNOWN OR OTHER | 1 |
Incident date: Jul 14, 2010
2003 VOLVO 660, UNIT 1 STRUCK THE REAR OF UNIT 2. UNIT 1 THEN WENT OFF THE RIGHT SIDE OF THE ROADWAY AND STRUCK THE GUARDRAIL. *BF ACCORDING TO THE POLICE REPORT, UNIT 1 WAS TRAVELING TO CLOSELY BEHIND THE TRUCK IN FRONT OF HIM. (OHIO TRAFFIC REPORT # 10-0467-90) *JB UPDATED 09/13/10*BF
Crash
Incident date: Apr 1, 2005
HOOD SHOCKS ON VOLVO TRUCKS ARE COMING OFF AT HOOD CONECTION SIDE. WHEN PULLING HOOD OPEN IF BOTH SHOCKS ARE LOSE HOOD CAN COME OVER ON DRIVER, CAUSING DRIVER POSSIBLE INJURIES. *AK
Incident date: Jan 23, 2005
THE BEARINGS IN THE INTEGRAL HUB/BEARING ON THE RIGHT FRONT WHEEL (STEERING AXLE) FAILED AT 247,000 MILES. THIS IS A UNIT DESIGNED TO LAST THE LIFE OF THE VEHICLE, AND THERE IS NO MAINTENANCE POSSIBLE. THIS WAS A VERY LOW MILEAGE FOR SUCH A FAILURE. NO ACCIDENT OR INJURIES WERE CAUSED BY THE FAI
... LURE BECAUSE IT WAS NOTICED BEFORE THAT COULD HAPPEN, BUT SUCH A FAILURE COULD CAUSE A CATASTROPHIC ACCIDENT. WE PAID APPROXIMATELY $625 FOR PARTS, LABOR, AND SHIPPING FOR A NEW PART. THE DEALERSHIP REMOVED AN IDENTICAL HUB FROM A NEW TRUCK ON THE LOT AND REPLACED OUR HUB. I DOUBT THEY KEPT THE OLD HUB, ALTHOUGH THEY MIGHT HAVE. THIS WAS AT THE VOLVO DEALERSHIP IN VINTON, TX, I-10 EXIT 2 IN TEXAS.*AKRead more
NHTSA Safety Investigations — VOLVO VN
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE — Closed
— Model Year: 2005
DRAG LINK FAILURE
ODI HAS DECIDED TO UPGRADE THIS PE AND CONDUCT FIELD WORK AND TESTING.SUMMARY NUMBERS IN THIS RESUME ARE REPRESENATIVE OF ONLY THE 2005 MODEL YEAR VEHICLES. SEE THE ATTACHED REPORT FOR DETAILS.
PE — Closed
— Model Year: 2002
HOOD STRUT FAILURE
VOLVO REPORTED FOUR FIELD REPORTS AND 62 WARRANTY CLAIMS RELATED TO HOOD STRUT FAILURE ON THE SUBJECT TRUCK/TRACTORS. THE HOOD STRUTS ARE A SINGLE ACTING OIL SHOCK THAT CONTROLS THE RATE OF THE OPENING OF THE HOOD. THERE ARE TWO STRUTS ATTACHED TO THE HOOD ASSEMBLY, ONE ON EACH SIDE. ODI'S CONCERN W
... AS THAT A FAILED HOOD STRUT WOULD ALLOW THE HOOD TO DROP ON ONE SIDE, POSSIBLY INJURING SOMEONE WORKING ON THE ENGINE. IN EXAMINING THE LIFE CYCLE OF HOOD STRUTS IN BOTH TRUCK AND PASSENGER CAR APPLICATIONS, ODI FOUND THATALL HOOD STRUTS REQUIRE PERIODIC REPLACEMENT DUE TO NORMAL ?WEAR-OUT.?DURING THE INVESTIGATION, ODI DISCOVERED THAT WHEN THE STRUTS WERE REPLACED, THE PROBLEM STARTED TO OCCUR ON THE SUBJECT TRUCKS.THE FAILURES RESULTED FROM THE IMPROPER INSTALLATION OF THE HOOD STRUT.THIS FINDING WAS SUBSTANTIATED BY FLEETS CONTACTED FROM INFORMATION SUPPLIED BY VOLVO, AS WELL AS VISITS TO LOCAL DEALERS. DURING THISINVESTIGATION, ODI PERFORMED THE FOLLOWING ACTIONS:A.REVIEWED WARRANTY/ENGINEERING DATA PROVIDED BY VOLVO;B.CONTACTED THE TWO INITIAL COMPLAINANTS TO GATHER MOREINFORMATION;C.CONDUCTED FIELD TRIPS TO AREA DEALERS TO INSPECT SUBJECTVEHICLES;D.CONTACTED TWO FLEETS FROM OUTSIDE THE WASHINGTON D.C. AREA TO DISCUSS THEIR EXPERIENCE WITH THESE HOOD STRUTS;ANDE.REVIEWED THE APPROPRIATE SERVICE MANUALS.BASED ON THE DATA PROVIDED BY VOLVO AND THE INFORMATION GATHERED BY ODI, IT IS APPARENT THAT SOME DEALERS AND OWNERS MAY HAVE BEENINSTALLINGREPLACEMENT STRUTS INCORRECTLY.DEPENDING ON WHICH MODEL TRUCK IS BEING WORKED ON, THERE ARE TWO DISTINCT WAYS TO MOUNT THE REPLACEMENT STRUT TO THE FRAME RAILS.FLEETS CONTACTED DURING THIS INVESTIGATION REPORTED NO FURTHER ISSUES WITH THE STRUTS ONCE PROPER INSTALLATION INSTRUCTIONS WERE PROVIDED TO THEM FROM VOLVO. ODI HAS DISCUSSED THE MATTER WITH VOLVO AND THEY HAVE DECIDED TO REVISE THE SERVICE MANUALS FOR THESE TRUCKS TO INCLUDE PICTURES OF BOTH HOOD STRUT MOUNTING ARRANGEMENTS IN EVERY SERVICE MANUAL, REGARDLESS OF TRUCK MODEL.THEREFORE,IF SOMEONE WAS USING THE INCORRECT MANUAL, THEY WOULD STILL BE ABLE TO VIEWALL THE POSSIBLE STRUT MOUNTINGARRANGEMENTS, REGARDLESS OF MODEL.THIS INVESTIGATION IS CLOSED, AS A SAFETY RELATED DEFECT WITH THE HOOD STRUTS HAS NOT BEEN IDENTIFIED AT THIS TIME. FURTHER USE OF THE AGENCY?S RESOURCES ARE NOT CURRENTLY WARRANTED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THE VEHICLES IF WARRANTED BY NEW CIRCUMSTANCES.ODI WILL CONTINUE TO MONITOR FIELD REPORTS AND TAKE APPROPRIATE ACTION IF INDICATED.Read more
DP — Closed
— Model Year: 1998
EQUIPMENT CERTIFICATION LABEL
There is no summary currently available
EA — Closed
— Model Year: 1998
U-BOLT FAILURES ON DRIVE -AXLE ASSEMBLIE