SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
Tenneco Automotive (DRiV) is recalling certain aftermarket ball joints for 2004-2007 Toyota Sequoia and 2004-2006 Toyota Tundra vehicles, MOOG part number K80521, K80522, NAPA part number NCP2601633, NCP2601634, ACDelco part number 45D2344, and 45D2345. The ball joint housing may have inadequate hardness, causing premature failure.
Remedy: DRiV will work with distributors to return unsold parts. Dealers will inspect and replace the ball joint as necessary, free of charge. Owner notification letters were mailed on March 17, 2022. Owners may contact DRiV customer service at 1-877-489-6659 or at
[email protected].
15,200 vehicles affected
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
928,220 vehicles affected
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
928,220 vehicles affected
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator, or replace the air bag assembly that includes an alternate inflator, free of charge. The recall began January 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371, Lexus customer service at 1-800-255-3987 or Pontiac customer service at 1-800-762-2737. Toyota's numbers for these recalls are J0A (Zone A Toyota), J0B (Zone B Toyota), J0C (Zone C Toyota), JLI (Zone A Lexus), JLJ (Zone B Lexus), and JLK (Zone C Lexus). Note: This recall includes vehicles that have had their air bag previously replaced under an earlier air bag campaign.
168,993 vehicles affected
AIR BAGS
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.
1,973,468 vehicles affected
AIR BAGS
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.
1,069,055 vehicles affected
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Remedy: CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
13,128 vehicles affected
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS. THE RECALL BEGAN ON FEBRUARY 28, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
533,124 vehicles affected
EXTERIOR LIGHTING
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
27,176 vehicles affected
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
768,379 vehicles affected
Rust! Frame completely rusted, even though the CRC was applied back in 2013.
The contact owns a 2004 Toyota Sequoia. The contact stated that while completing an inspection and emissions test on the vehicle, the mechanic informed the contact that there was severe rust on the rear subframe of the vehicle, near the control arm, and several other areas on the subframe. The contact stated that there were several holes on the subframe caused by the extreme rust. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 203,000.
See attached document for complaint.
See attached document for complaint.
The contact owns a 2004 Toyota Sequoia. The contact stated while driving at approximately 35 MPH, the brake pedal was depressed and went to the floorboard. The contact stated that the check brakes and a traction control warning lights illuminated. The contact stated that the failure was intermittent at first but had become a recurring failure. When Toyota issued a recall for the braking issue, the contact did not receive notices, so the contact called them and was told it was a few selected 2004 Toyota Sequoia recalled for those who had complained but, it was not broadcasted like that. The contact had taken the vehicle to a local dealer, but the vehicle was not yet diagnosed. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 07E023000 (Service Brakes, Hydraulic). The manufacturer was informed of the failure. The failure mileage was approximately 143,000.
The contact owns a 2004 Toyota Sequoia. The contact stated while driving at approximately 35 MPH, the brake pedal was depressed and went to the floorboard. The contact stated that the check brakes and a traction control warning lights illuminated. The contact stated that the failure was intermittent at first but had become a recurring failure. When Toyota issued a recall for the braking issue, the contact did not receive notices, so the contact called them and was told it was a few selected 2004 Toyota Sequoia recalled for those who had complained but, it was not broadcasted like that. The contact had taken the vehicle to a local dealer, but the vehicle was not yet diagnosed. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 07E023000 (Service Brakes, Hydraulic). The manufacturer was informed of the failure. The failure mileage was approximately 143,000.
TOYOTA frame is falling apart due to the use of faulty metal to manufacture those frames they ran a limited service campaign to replace some of the frames and they denied many other owners that right please help by telling TOYOTA North America to take care of this very hazardous issue thank you
TOYOTA frame is falling apart due to the use of faulty metal to manufacture those frames they ran a limited service campaign to replace some of the frames and they denied many other owners that right please help by telling TOYOTA North America to take care of this very hazardous issue thank you
The undercarriage is rotten you help my thanks
The undercarriage is rotten you help my thanks
The undercarriage is rotten you help my thanks
Frame has rust issues throughout. Frame not properly treated at the factory and now I am suffering because it has virtually rusted through in front of the drivers side rear wheel which was pointed out to me at Toyota when my car was in for service.
The frame is rusting away due to poor grade of metal that it is built from.
The tail gate will not open. I had the vehicle since 2018 and it was working and now it's not working. I taken it to toyota dealership and the cost is to much for at this point. I was wondering is there anything that can be done?
SIGNIFICANT FRAME RUST IN THE REAR LEFT AND RIGHT
I WAS SIMPLY PARKING MY 2004 TOYOTA SEQUOIA IN PARKING LOT SPACE. LEFT FRONT TIRE FELL COMPLETELY OFF THE CAR WITHOUT ANY PREVIOUS WARNING OF PENDING PROBLEMS! BALL JOINT CATASTROPHICALLY FAILED! PRIOR RECENT NEW TIRES AND ALIGNMENT SHOWED NO PENDING PROBLEMS. DID A CHECK AND FOUND MANY PRIOR BALL JOINT ISSUES FOR THIS CAR AND A PRIOR RECALL YEARS AGO. TOWED TO TOYOTA DEALERSHIP IN CAPITOLA CA. THEY REPLACED BALL JOINT AND RELATED PARTS. THEY CHARGED ME LOTS OF MONEY CLAIMING THAT THIS VEHICLE HAD "PREVIOUSLY BEEN RECALLED AND REPAIRED IN 2007 SO NO LIABILITY ON THEIR PART. I CALLED TOYOTA CORPORATE AND COMPLAINED AND WAS BOUNCED AROUND UNTIL A FELLOW NAMED "GARRET" TOLD ME THE BALL JOINTS HAD BEEN "FIXED" IN 2007 DURING A RECALL. GREAT. THEN WHY DO THESE ISSUES CONTINUE? MY CAR IS DRIVEN ONLY ON PUBLIC STREETS AND THERE WAS NO WARNING OF THIS IMPENDING FAILURE. THE BALL JOINT AND RELATED SIMPLY FAILED CATASTROPHICALLY. I TAKE EXCELLENT CARE OF THIS VEHICLE AS I INTENDED ON KEEPING IT REGARDLESS OF MILEAGE. WHAT BS IS TOYOTA PULLING WHEN THEIR SEQUOIA (AND OTHER SIMILAR TOYOTA VEHICLES) CONTINUE TO CATASTROPHICALLY FAIL WITHOUT WARNING? I WONDER HOW MANY PEOPLE DIED ON THE FREEWAY ETC BECAUSE OF THIS? I HAVE PERSONALLY OWNED AND/OR FAMILY, FRIENDS ETC. MANY CARS, TRUCKS ETC. BALL JOINTS LIKE BRAKES, TIRES HOSES ETC WEAR OUT SLOWLY AND GIVE AMPLE WARNING WHEN THEY NEED REPLACEMENT IE TIRE WEAR IS INCREASED, STEERING DIFFICULTY ETC. NOT IN TOYOTA'S CASE. THERE WAS NO WARNING AT ALL BEFORE THE WHEEL JUST FELL OFF THE VEHICLE. THESE CATASTROPHIC FAILURES OF WHEELS FALLING OFF WITHOUT WARNING AT ANY MOMENT ARE HORRIBLY DANGEROUS AND YET COMMON KNOWLEDGE INCLUDING PRIOR RECALL(S) AND YET THEY STILL ARE ALLOWED TO CONTINUE. THIS IS RIDICULOUS!
LEFT FRONT (DRIVERS SIDE) WHEEL BALL JOINT(S) FAILED CATASTROPHICALLY CAUSING WHEEL TO FALL OFF AND WEDGE UNDER CAR WHILE PULLING INTO A PARKING SPACE. NO PRIOR WARNING, NO PRIOR NOISE, NO PRIOR STEERING ISSUES, NO STRANGE TIRE WEAR (TIRES JUST REPLACED 6 MONTHS AGO). JUST INSTANT AND CATASTROPHIC FAILURE!
FOR THE SECOND TIME IN 4 YEARS FIRST FAILED IN 2010., REAR HATCH DOOR WOULD NOT CLOSE. HANDLE FAILED DEALER REPLACED LOCK SUB ASSY AND HANDLE ASSY.
REAR HATCH DOOR WOULD NOT OPEN. HANDLE FAILED DEALER REPLACE LOCK SUB ASSY AND HANDLE ASSY. THIRD FAILURE IN 8 YEARS, 2010, 2014 AND 2018. PARTS ARE FAILING ABOUT EVERY 4 YEARS. OWNED CAR 6 YEARS BEFORE FIRST FAILURE.
REAR HATCH DOOR WOULD NOT CLOSE. HANDLE FAILED DEALER REPLACE LOCK SUB ASSY AND HANDLE ASSY.
REAR HATCH DOOR WOULD NOT OPEN DEALER HAS REPLACED LOCK SUB ASSY AND HANDLE ASSY 3 TIMES IN THE PAST 10 YEARS. THIS IS THE FOURTH FAILURE LATCH HAS, 2010, 2014, 2018 AND 2021. THE FIRST THREE FAILURES OCCURRED ABOUT EVERY 4 YEARS THE CURRENT FAILURE WAS 2 YEARS AND 3 MONTHS. OWNED. CAR 6 YEARS BEFORE FIRST FAILURE.
TRAC OFF LIGHT AND VAC TRAC LIGHTS ON ALL THE TIME! GRINDING NOISE WHEN BRAKES APPLIED AT RANDOM TIMES. CAUSE FOR CONCERN! HAVE HAD EVERYTHING REPLACED THAT COULD CAUSE THIS OVER THE PAST 2 YEARS AND STILL HAVING THE SAME ISSUE!
MY 2004 TOYOTA SEQUOIA HATCH (LOCK SUS ASSY AND HANDLE ASSY) HAVE FAILED AND BEEN REPLACED ON TWO OCCASIONS. ON 10 JULY 2014 AND 23 NOVEMBER 2018 EACH WERE COSTLY REPAIRS FOR A SIMPLE HANDLE/LOCK THAT WERE POORLY DESIGNED. A DOOR HANDLE AND LOCK SHOULD NOT COST OVER ONE THOUSAND DOLLARS DURING THE LIFE OF THE VEHICLE. AS THE ORIGINAL OWNER AND A LOYAL TOYOTA CUSTOMER I AM DISAPPOINTED WITH QUALITY OF SMALL PART REPLACEMENT JOBS I HAVE HAD TO COMPLETE TO MAINTAIN MY VEHICLE. HATCH DOOR FAILED WITH NO WARNING OR PREVIOUS PROBLEMS SUMMER AND WINTER CONDITIONS.
MY 2004 TOYOTA SEQUOIA HATCH (LOCK SUS ASSY AND HANDLE ASSY) HAVE FAILED AND BEEN REPLACED ON TWO OCCASIONS. ON 10 JULY 2014 AND 23 NOVEMBER 2018 EACH WERE COSTLY REPAIRS FOR A SIMPLE HANDLE/LOCK THAT WERE POORLY DESIGNED. A DOOR HANDLE AND LOCK SHOULD NOT COST OVER ONE THOUSAND DOLLARS DURING THE LIFE OF THE VEHICLE. AS THE ORIGINAL OWNER AND A LOYAL TOYOTA CUSTOMER I AM DISAPPOINTED WITH QUALITY OF SMALL PART REPLACEMENT JOBS I HAVE HAD TO COMPLETE TO MAINTAIN MY VEHICLE. HATCH DOOR FAILED WITH NO WARNING OR PREVIOUS PROBLEMS SUMMER AND WINTER CONDITIONS.
WHEN TURNING LEFT OR RIGHT, AND AT LOW SPEEDS, VTS IS TURNING ON AND CAUSING THE VEHICLE TO LOSE POWER. THIS HAPPENS WHEN PULLING OUT IN FRONT OF TRAFFIC AND I CANNOT SPEED UP UNTIL THE VEHICLE IS STRAIGHT. *TR
WHEN TURNING LEFT OR RIGHT, AND AT LOW SPEEDS, VTS IS TURNING ON AND CAUSING THE VEHICLE TO LOSE POWER. THIS HAPPENS WHEN PULLING OUT IN FRONT OF TRAFFIC AND I CANNOT SPEED UP UNTIL THE VEHICLE IS STRAIGHT. *TR
WHEN TURNING LEFT OR RIGHT, AND AT LOW SPEEDS, VTS IS TURNING ON AND CAUSING THE VEHICLE TO LOSE POWER. THIS HAPPENS WHEN PULLING OUT IN FRONT OF TRAFFIC AND I CANNOT SPEED UP UNTIL THE VEHICLE IS STRAIGHT. *TR
I HAVE A 2004 TOYOTA SEQUOIA. THE VEHICLE HAS BEEN WELL TAKEN CARE OF WITH NUMEROUS RECEIPTS TO PROVE IT. UPON FURTHER INSPECTION OF THE VEHICLE, I HAVE OBSERVED A 'ROT' HOLE IN THE REAR PART OF THE FRAME. THE WHOLE IN THE FRAME IS APPROXIMATELY THE SIZE OF A DOLLAR BILL AND SPREADING. THERE ARE OTHER PARTS OF THE FRAME THAT WILL NEED ATTENTION IN THE FUTURE. TOYOTA HAS RECALLED SEQUOIA MODEL YEARS 2005 AND UP AND HAVE NEGLECTED TO INCLUDE THE 2004. IT IS APPARENT THAT THE 2004 SEQUOIA IS SUBJECT TO THE SAME FAULTY FRAME MANUFACTURING AS OTHER MODELS/ YEARS OF NUMEROUS TOYOTA'S. MY VEHICLE HAS APPROXIMATELY 137,600 MILES ON IT. I HAVE MAINTAINED VEHICLES FROM FROM THE 90S THAT HAVE BETTER FRAME CONSTRUCTION THAN MY TOYOTA. I BELIEVE THAT THE FRAME ON MY 2004 SEQUOIA WILL NEED FRAME PATCHES IN THE FUTURE AS WELL AS MANY OTHER METAL COMPONENTS CONNECTED TO THE FRAME REPLACED.
WHEN TEMPERATURES FALL TO 32 DEGREES F (SOMETIMES HIGHER) OR BELOW AIRBAG LIGHT ILLUMINATES ON 2004 TOYOTA SEQUOIA. WHEN THE CAR IS STARTED THE SRS (AIRBAG) LIGHT ILLUMINATES IN COLD TEMPERATURES. AFTER CAR WARMS UP AND IF THE CAR IS TURNED OFF AND BACK ON SRS LIGHT WILL GO BACK OFF. FOLLOWING AIRBAG CODES ARE STORED IN SRS AIRBAG MODULE (ECU): B1141 B0116 THIS IS A KNOWN PROBLEM BY TOYOTA SINCE 2004 BUT THEY ARE NOT RECALLING THIS PART OR OFFERING REPLACEMENT. AFFECTED PART NUMBER: 89170-0C070 THIS IS ESPECIALLY DANGEROUS SINCE IT DISABLES ALL AIRBAGS. THE ONLY REPAIR OPTION IS TO REPLACE THE AIRBAG ECU THAT HAS BEEN UPDATED. THIS AFFECTS THE FOLLOWING VEHICLES: 2003 - 2004 TOYOTA SEQUOIA 2001 - 2003 TOYOTA HIGHLANDER HERE IS THE OFFICIAL TOYOTA TECHNICAL SERVICE BULLETIN: AIR BAG SYSTEM - MIL ON/DTC'S B1140/B1141 SET ELECTRICAL EL007-04 TITLE: M.I.L. "ON" DTC B1140 & B1141 MODELS: '03 - '04 SEQUOIA MAY 26, 2004 INTRODUCTION UNDER CERTAIN COLD CONDITIONS (APPROXIMATELY 0F /-18C OR BELOW), SOME 2003 AND 2004 MODEL YEAR SEQUOIA VEHICLES EQUIPPED WITH SIDE AIRBAGS MAY EXHIBIT A M.I.L. "ON" CONDITION WITH A DIAGNOSTIC TROUBLE CODE (DTC) B1140 OR B1141 STORED IN THE AIRBAG ECU MEMORY. TO PREVENT A M.I.L. "ON" CONDITION, THE AIRBAG ECU HAS BEEN UPDATED. APPLICABLE VEHICLES ^2003 - 2004 MODEL YEAR SEQUOIA VEHICLES EQUIPPED WITH SIDE AIRBAGS AND PRODUCED BEFORE THE PRODUCTION CHANGE EFFECTIVE VINS SHOWN. MANY PEOPLE ARE AFFECTED BY THIS: HTTPS://WWW.TOYOTANATION.COM/THREADS/AIRBAG-ERROR-LIGHT-WHEN-COLD.369378/ HTTPS://WWW.TOYOTANATION.COM/THREADS/AIR-BAG-LIGHT-FLASHING.229336/ HTTPS://REPAIRPAL.COM/AIR-BAG-LIGHT-DUE-TO-DEFECTIVE-SENSOR-IN-AIR-BAG-SYSTEM-921 HTTPS://WWW.TOYOTANATION.COM/THREADS/BLINKING-AIRBAG-LIGHT-WHEN-VERY-COLD.182500/ MANY MORE PEOPLE ARE AFFECTED IF YOU GOOGLE THIS ISSUE.
WE BOUGHT IT IN 2014 WITH 76K AND THE FRAME HAD RECENTLY BEEN COATED. SUPPOSEDLY IT WAS FROM TEXAS, AND WE LIVE IN NORTHERN MINNESOTA. THE FRAME LOOKED GOOD AND SEEMED SOLID, BUT WITHIN A YEAR OR TWO ALL OF THE COATING FELL OFF REVEALING VERY RUSTY METAL. BY 3 YEARS (2017) THERE WERE HOLES IN THE BOTTOM OF THE FRAME MAINLY BEHIND THE FRONT TIRES AREA, AND THE REST OF THE FRAME IS ALSO QUITE RUSTY. I HAD TO REPLACE THE FRONT SWAY BAR END LINKS BUT THEY BROKE SOON AFTER AND KEPT BREAKING WITHIN A FEW MONTHS AFTER REPEATED REPLACEMENT DUE TO EXCESSIVE FRAME MOVEMENT. IT FEELS LESS SAFE WITHOUT A FUNCTIONAL SWAY BAR ATTACHED TO THE FRAME AND HAS MORE BODY ROLL WITH MORE RISK OF ROLLOVER. THE FRAME IS ROTTING FROM THE INSIDE OUT, AND THE RUST IS SPREADING LIKE CANCER IN THE SURROUNDING AREAS UNDERNEATH. THE BODY HAS ALMOST NO RUST AT ALL. I PARKED IT IN THE WINTERS TWICE NOW, HOPING TO BUY TIME. BUT I'M COUNTING THE DAYS THAT IT WILL BE UNSAFE TO DRIVE ANYMORE. I'M NOT EVEN SURE WHEN TO DETERMINE WHEN THAT WILL BE, AND AM HOPING IT DOESN'T HAVE CATASTROPHIC FAILURE AT HIGHWAY SPEEDS LIKE OTHERS HAVE HAD WITH THE EARLIER SEQUOIAS. I BOUGHT THIS FOR MY WIFE AND PAID $16000 CASH FOR IT. WE'VE PUT ON 60K MILES BUT EXPECTED TO GET MANY MORE YEARS OUT OF IT BEING THAT IT IS SO SOLID AND RELIABLE OTHERWISE. THIS FRAME IS HORRIBLE, AND PROBABLY WOULD HAVE SHOWN ITSELF A PROBLEM SOONER, HAD IT NOT BEEN IN TEXAS MOST OF ITS PREVIOUS YEARS. IT IS WRONG THAT THE 01-04 YEARS ARE EXCLUDED FROM THE RECALL THAT ONLY COVERED THE 05-08 MODELS, WHEN IT IS OBVIOUS THE SAME PROBLEM EXISTED THEN AS WELL BASED ON SO MANY SIMILAR REPORTS. TOYOTA GOT MONEY FROM THE FRAME MAKERS AND US CUSTOMERS SHOULD BE REIMBURSED FOR THE SEVERELY PREMATURELY RUSTING FRAMES, THAT WILL BE TAKING 10 OR MORE YEARS OFF THE LIFE OF THE VEHICLE OTHERWISE. PLEASE ADDRESS AND TAKE THIS PROBLEM SERIOUSLY.
WE BOUGHT IT IN 2014 WITH 76K AND THE FRAME HAD RECENTLY BEEN COATED. SUPPOSEDLY IT WAS FROM TEXAS, AND WE LIVE IN NORTHERN MINNESOTA. THE FRAME LOOKED GOOD AND SEEMED SOLID, BUT WITHIN A YEAR OR TWO ALL OF THE COATING FELL OFF REVEALING VERY RUSTY METAL. BY 3 YEARS (2017) THERE WERE HOLES IN THE BOTTOM OF THE FRAME MAINLY BEHIND THE FRONT TIRES AREA, AND THE REST OF THE FRAME IS ALSO QUITE RUSTY. I HAD TO REPLACE THE FRONT SWAY BAR END LINKS BUT THEY BROKE SOON AFTER AND KEPT BREAKING WITHIN A FEW MONTHS AFTER REPEATED REPLACEMENT DUE TO EXCESSIVE FRAME MOVEMENT. IT FEELS LESS SAFE WITHOUT A FUNCTIONAL SWAY BAR ATTACHED TO THE FRAME AND HAS MORE BODY ROLL WITH MORE RISK OF ROLLOVER. THE FRAME IS ROTTING FROM THE INSIDE OUT, AND THE RUST IS SPREADING LIKE CANCER IN THE SURROUNDING AREAS UNDERNEATH. THE BODY HAS ALMOST NO RUST AT ALL. I PARKED IT IN THE WINTERS TWICE NOW, HOPING TO BUY TIME. BUT I'M COUNTING THE DAYS THAT IT WILL BE UNSAFE TO DRIVE ANYMORE. I'M NOT EVEN SURE WHEN TO DETERMINE WHEN THAT WILL BE, AND AM HOPING IT DOESN'T HAVE CATASTROPHIC FAILURE AT HIGHWAY SPEEDS LIKE OTHERS HAVE HAD WITH THE EARLIER SEQUOIAS. I BOUGHT THIS FOR MY WIFE AND PAID $16000 CASH FOR IT. WE'VE PUT ON 60K MILES BUT EXPECTED TO GET MANY MORE YEARS OUT OF IT BEING THAT IT IS SO SOLID AND RELIABLE OTHERWISE. THIS FRAME IS HORRIBLE, AND PROBABLY WOULD HAVE SHOWN ITSELF A PROBLEM SOONER, HAD IT NOT BEEN IN TEXAS MOST OF ITS PREVIOUS YEARS. IT IS WRONG THAT THE 01-04 YEARS ARE EXCLUDED FROM THE RECALL THAT ONLY COVERED THE 05-08 MODELS, WHEN IT IS OBVIOUS THE SAME PROBLEM EXISTED THEN AS WELL BASED ON SO MANY SIMILAR REPORTS. TOYOTA GOT MONEY FROM THE FRAME MAKERS AND US CUSTOMERS SHOULD BE REIMBURSED FOR THE SEVERELY PREMATURELY RUSTING FRAMES, THAT WILL BE TAKING 10 OR MORE YEARS OFF THE LIFE OF THE VEHICLE OTHERWISE. PLEASE ADDRESS AND TAKE THIS PROBLEM SERIOUSLY.
TOOK 2004 SEQUOIA TO KINGS TOYOTA FOR THE AIRBAG RECALL AS WELL AS DIAGNOSTIC EVAL OF VSC ABS LIGHTS ISSUE. RECEIVED A PHONE CALL THAT THE TECH COULD NOT DETERMINE THE ELECTRICAL PROBLEM UNLESS WE PAID AN ADDITIONAL $360 FOR MORE TIME TO DIAGNOSE AND THAT THE FRAME WAS RUSTED THROUGH WITH LARGE HOLES. WONDERED IF WE WANTED TO PURSUE THE ELECTRICAL ISSUE WITH THE LARGER SAFETY ISSUE WITH THE FRAME. ORIGINAL ISSUE OCCURRED WITH LIGHTS COMING ON (HAD HAPPENED SEVERAL TIMES PREVIOUSLY) FOLLOWED BY THE POWER WINDOWS CEASING TO WORK, SEVERAL HOURS LATER THE WIPERS AND WINDOW SEEMED SLUGGISH AND THE CAR LOST ALL POWER. HAD TO JUMP THE CAR SEVERAL TIMES TO GET OFF THE ROAD AND THEN WHEN JUMPING NO LONGER WORKED, WE HAD TO PUSH THE VEHICLE INTO A CHURCH PARKING LOT. AFTER BEING TOLD BY MR. HOWARD THAT THEY DON'T SEE VEHICLES COME INTO SERVICE WITH LARGE HOLES IN THE FRAME, I RESEARCHED ONLINE AND FOUND THAT 10S OF THOUSANDS OF TOYOTA TRUCKS, INCLUDING 05-08 SEQUOIAS, HAVE BEEN RECALLED - CRC APPLIED AND FRAMES REPLACED AS WELL AS TOYOTA BUYING BACK 95-00 TRUCKS WITH RUSTED FRAMES FOR 1.5 TIMES THE BLUE BOOK VALUE. 04 SEQUOIAS MENTIONED MORE THAN 300 TIMES FOR THE VSC, TAILGATE AND RUSTED FRAME ISSUES THAT ARE PREVALENT IN THIS MODEL - MY VEHICLE HAS ALL 3. SPOKE WITH COLIN, THE SERVICE MANAGER, WHO REITERATED WHAT I FOUND ONLINE. TOYOTA WILL DO NOTHING SINCE THE RECALL IS CLOSED AND DID NOT INCLUDE THE 04 MODELS.
TOOK 2004 SEQUOIA TO KINGS TOYOTA FOR THE AIRBAG RECALL AS WELL AS DIAGNOSTIC EVAL OF VSC ABS LIGHTS ISSUE. RECEIVED A PHONE CALL THAT THE TECH COULD NOT DETERMINE THE ELECTRICAL PROBLEM UNLESS WE PAID AN ADDITIONAL $360 FOR MORE TIME TO DIAGNOSE AND THAT THE FRAME WAS RUSTED THROUGH WITH LARGE HOLES. WONDERED IF WE WANTED TO PURSUE THE ELECTRICAL ISSUE WITH THE LARGER SAFETY ISSUE WITH THE FRAME. ORIGINAL ISSUE OCCURRED WITH LIGHTS COMING ON (HAD HAPPENED SEVERAL TIMES PREVIOUSLY) FOLLOWED BY THE POWER WINDOWS CEASING TO WORK, SEVERAL HOURS LATER THE WIPERS AND WINDOW SEEMED SLUGGISH AND THE CAR LOST ALL POWER. HAD TO JUMP THE CAR SEVERAL TIMES TO GET OFF THE ROAD AND THEN WHEN JUMPING NO LONGER WORKED, WE HAD TO PUSH THE VEHICLE INTO A CHURCH PARKING LOT. AFTER BEING TOLD BY MR. HOWARD THAT THEY DON'T SEE VEHICLES COME INTO SERVICE WITH LARGE HOLES IN THE FRAME, I RESEARCHED ONLINE AND FOUND THAT 10S OF THOUSANDS OF TOYOTA TRUCKS, INCLUDING 05-08 SEQUOIAS, HAVE BEEN RECALLED - CRC APPLIED AND FRAMES REPLACED AS WELL AS TOYOTA BUYING BACK 95-00 TRUCKS WITH RUSTED FRAMES FOR 1.5 TIMES THE BLUE BOOK VALUE. 04 SEQUOIAS MENTIONED MORE THAN 300 TIMES FOR THE VSC, TAILGATE AND RUSTED FRAME ISSUES THAT ARE PREVALENT IN THIS MODEL - MY VEHICLE HAS ALL 3. SPOKE WITH COLIN, THE SERVICE MANAGER, WHO REITERATED WHAT I FOUND ONLINE. TOYOTA WILL DO NOTHING SINCE THE RECALL IS CLOSED AND DID NOT INCLUDE THE 04 MODELS.
TOOK 2004 SEQUOIA TO KINGS TOYOTA FOR THE AIRBAG RECALL AS WELL AS DIAGNOSTIC EVAL OF VSC ABS LIGHTS ISSUE. RECEIVED A PHONE CALL THAT THE TECH COULD NOT DETERMINE THE ELECTRICAL PROBLEM UNLESS WE PAID AN ADDITIONAL $360 FOR MORE TIME TO DIAGNOSE AND THAT THE FRAME WAS RUSTED THROUGH WITH LARGE HOLES. WONDERED IF WE WANTED TO PURSUE THE ELECTRICAL ISSUE WITH THE LARGER SAFETY ISSUE WITH THE FRAME. ORIGINAL ISSUE OCCURRED WITH LIGHTS COMING ON (HAD HAPPENED SEVERAL TIMES PREVIOUSLY) FOLLOWED BY THE POWER WINDOWS CEASING TO WORK, SEVERAL HOURS LATER THE WIPERS AND WINDOW SEEMED SLUGGISH AND THE CAR LOST ALL POWER. HAD TO JUMP THE CAR SEVERAL TIMES TO GET OFF THE ROAD AND THEN WHEN JUMPING NO LONGER WORKED, WE HAD TO PUSH THE VEHICLE INTO A CHURCH PARKING LOT. AFTER BEING TOLD BY MR. HOWARD THAT THEY DON'T SEE VEHICLES COME INTO SERVICE WITH LARGE HOLES IN THE FRAME, I RESEARCHED ONLINE AND FOUND THAT 10S OF THOUSANDS OF TOYOTA TRUCKS, INCLUDING 05-08 SEQUOIAS, HAVE BEEN RECALLED - CRC APPLIED AND FRAMES REPLACED AS WELL AS TOYOTA BUYING BACK 95-00 TRUCKS WITH RUSTED FRAMES FOR 1.5 TIMES THE BLUE BOOK VALUE. 04 SEQUOIAS MENTIONED MORE THAN 300 TIMES FOR THE VSC, TAILGATE AND RUSTED FRAME ISSUES THAT ARE PREVALENT IN THIS MODEL - MY VEHICLE HAS ALL 3. SPOKE WITH COLIN, THE SERVICE MANAGER, WHO REITERATED WHAT I FOUND ONLINE. TOYOTA WILL DO NOTHING SINCE THE RECALL IS CLOSED AND DID NOT INCLUDE THE 04 MODELS.
I'VE BEEN DEALING FOR SEVERAL YEARS HAVING AIR-BAGS BEING REPLACED. WHEN AN APPOINTMENT IS GIVEN, I GO TO DEALERSHIP AND AM TOLD NO ONE HAS PLACED AN ORDER FOR THE PARTS.MS DEPT. OF TRANSPORTATION CONTACTED ME AND SAID THEY HAVE MADE THE REQUEST FOR REPAIR AND ESTABRROOK TOYOTA OF PASCAGOULA HAS SAID THERE IS NO RECORD OF ANY CORRESPONDENCE.
FRAME HAS RUST HOLES AND THE STEERING STABILIZER MOUNT RUSTED COMPLETELY OFF. VERY UNSAFE ! THE REST OF THE CAR IS IN EXCELLENT CONDITION SO THE SEVERITY OF RUST ON THE FRAME SEEMS VERY OUT OF PLACE. THIS ISSUE IS EXTREME AND NOT NORMAL. NOT ACCEPTABLE FROM A MANUFACTURER KNOWN FOR ITS QUALITY SYSTEMS. TPS SIX SIGMA EMBARRASMENT IN MY OPINION
FRAME HAS RUST HOLES AND THE STEERING STABILIZER MOUNT RUSTED COMPLETELY OFF. VERY UNSAFE ! THE REST OF THE CAR IS IN EXCELLENT CONDITION SO THE SEVERITY OF RUST ON THE FRAME SEEMS VERY OUT OF PLACE. THIS ISSUE IS EXTREME AND NOT NORMAL. NOT ACCEPTABLE FROM A MANUFACTURER KNOWN FOR ITS QUALITY SYSTEMS. TPS SIX SIGMA EMBARRASMENT IN MY OPINION
FRAME HAS RUST HOLES AND THE STEERING STABILIZER MOUNT RUSTED COMPLETELY OFF. VERY UNSAFE ! THE REST OF THE CAR IS IN EXCELLENT CONDITION SO THE SEVERITY OF RUST ON THE FRAME SEEMS VERY OUT OF PLACE. THIS ISSUE IS EXTREME AND NOT NORMAL. NOT ACCEPTABLE FROM A MANUFACTURER KNOWN FOR ITS QUALITY SYSTEMS. TPS SIX SIGMA EMBARRASMENT IN MY OPINION
FUEL GAUGE NOT MEASURING FUEL PROPERLY. AFTER A FULL TANK, GAUGE INDICATES EMPTY TANK AFTER FEW DAYS. SPEEDOMETER NOT WORKING AND ENGINE LOSES POWER FOR A WHILE WHILE THE GAUGE GOES TO 100 MILES ON THE HIGHWAY AND GOES BACK TO ZERO AND RESTORES POWER TO THE ENGINE. THE VEHICLE HAS ONLY 145,000 MILES ON IT. ALSO RUST ON THE BODY FRAME .
FUEL GAUGE NOT MEASURING FUEL PROPERLY. AFTER A FULL TANK, GAUGE INDICATES EMPTY TANK AFTER FEW DAYS. SPEEDOMETER NOT WORKING AND ENGINE LOSES POWER FOR A WHILE WHILE THE GAUGE GOES TO 100 MILES ON THE HIGHWAY AND GOES BACK TO ZERO AND RESTORES POWER TO THE ENGINE. THE VEHICLE HAS ONLY 145,000 MILES ON IT. ALSO RUST ON THE BODY FRAME .
FUEL GAUGE NOT MEASURING FUEL PROPERLY. AFTER A FULL TANK, GAUGE INDICATES EMPTY TANK AFTER FEW DAYS. SPEEDOMETER NOT WORKING AND ENGINE LOSES POWER FOR A WHILE WHILE THE GAUGE GOES TO 100 MILES ON THE HIGHWAY AND GOES BACK TO ZERO AND RESTORES POWER TO THE ENGINE. THE VEHICLE HAS ONLY 145,000 MILES ON IT. ALSO RUST ON THE BODY FRAME .
TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. IN 2011, THE CONTACT STATED THAT THE LIFTGATE LATCH FRACTURED. THE LATCH WAS REPLACED BY CULVER CITY TOYOTA (9077 WASHINGTON BLVD, CULVER CITY, CA 90232); HOWEVER, THE LATCH FRACTURED AGAIN AND THE TAIL LIGHT NEEDED TO BE REPLACED. IN ORDER FOR THE DEALER TO REPAIR THE VEHICLE, THEY HAD TO OPEN THE LIFTGATE, BUT WERE UNABLE TO DO SO. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 227,557.
OUR 2004 TOYOTA SEQUOIA HAS EXTENSIVE RUST ON THE FRAME OF THE CAR THAT HAS MADE IT UNSAFE TO OPERATE. WE UNDERSTAND THAT TOYOTA USED POOR QUALITY STEEL TO MAKE THE FRAME. WE HAVE CONTACTED TOYOTA, WHICH HAS REFUSED TO FIX OR REPLACE THE FRAME BECAUSE WE MISSED THE JULY 31 2014 DEADLINE. WE KNOW THAT THERE IS A RECALL FOR 2005-08 MODELS AND THE 2004 MODEL SHOULD BE INCLUDED AS WELL. WE WANT THE FRAME TO BE REPLACED. THE REST OF THE CAR IS IN GOOD WORKING CONDITION.
I WAS CHECKING EVERYTHING ON MY VEHICLE OVER BEFORE I WENT FOR INSPECTION AND I NOTICED RUST CORROSION STARTING ON THE FRAME. I TOOK TO A FRIEND TO CHECK FOR ME AND THEY TOLD ME THAT THERE WAS A SAFETY ISSUE WITH THE FRAMES AND THERE WAS A RECALL OF SORTS BACK IN 2012 REGARDING THE FRAMES WERE NOT COATED CORRECTLY FOR THE COLDER STATES. I HAD HEARD ABOUT THIS WARRANTY ISSUE BEFORE BUT WAS NEVER NOTIFIED. MY BROTHER IN LAW TOLD ME TO CHECK IT OUT BACK IN 2016 WHEN THERE WAS A RECALL ON THE AIRBAG/STEERING COMPONENT. I WAS TOLD AT THAT TIME THAT THE RECALL/ WARRANTY ISSUE HAD EXPIRED AND NOTHING COULD BE DONE. I HAVE NOT NOTICED ANY RUST UNTIL THIS YEAR. THIS VEHICLE DOES NOT GO OFF ROAD AND IS ONLY DRIVEN ON PAVED ROADS. I CALLED TOYOTA USA ON 7/24/2019 AND EXPLAINED TO THEM THE SITUATION. ONE OF THE LADIES FELT CONFIDENT THAT I COULD BE HELPED. THEN WHEN I WAS TRANSFERRED TO A LADY NAMED ASHLEY, SHE INFORMED ME THAT THERE WAS NOTHING THEY COULD DO. SHE TOLD ME THAT THE WARRANTY ISSUE WAS SENT TO THE ORIGINAL OWNER IN JUNE OF 2012 AND THEY DID NOT RESPOND. THEY PROBABLY DID NOT RESPOND SEEING HOW I HAVE BEEN THE OWNER OF THIS VEHICLE SINCE 1/26/2012. I WAS THEN TOLD THAT SINCE I DO NOT TAKE IT TO A CERTIFIED TOYOTA SERVICE CENTER TO HAVE MY REGULAR MAINTENANCE DONE THAT THERE WAS STILL NOTHING THEY CAN DO. I SHOULD HAVE THE RIGHT TO TAKE MY VEHICLE WHERE I WANT WITHOUT THE MANUFACTURER DECIDING TO HONOR A WARRANTY BASED ON THE FACT THAT I GO TO ONE OF THEIR SERVICE CENTERS. I WOULD HAVE TAKEN MY VEHICLE DURING THE CORRECT DATES TO HAVE THE COATING PUT ON MY VEHICLE IF THEY WOULD HAVE SENT ME THE NOTICE AND NOT TO THE ORIGINAL OWNER. ESPECIALLY SINCE I WAS THE OWNER OF THE VEHICLE FOR 5 MONTHS WHEN THEY SENT OUT THE WARRANTY NOTICE BUT THEY SENT IT TO THE WRONG OWNER. I FEEL THAT TOYOTA SHOULD TAKE CARE OF THIS ISSUE.
TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. WHILE THE VEHICLE'S OIL WAS BEING CHANGED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT THE FRONT SWAY BAR BRACKET WAS ROTTED OUT. THE VEHICLE WAS TAKEN TO IRA TOYOTA OF TEWKSBURY (LOCATED AT 468 MAIN ST, TEWKSBURY, MA 01876, (978) 863-9009) WHERE IT WAS DIAGNOSED THAT THE ENTIRE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 219,000.