2008 TOYOTA FJ CRUISER Recalls, Complaints & Safety

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

7,749 vehicles affected

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

3,233 vehicles affected

EQUIPMENT:OTHER:LABELS

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."

Remedy: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.

20,000 vehicles affected

EXTERIOR LIGHTING

Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."

Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.

208,000 vehicles affected

SEAT BELTS:FRONT:ANCHORAGE

Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.

Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.

209,000 vehicles affected

EQUIPMENT

Toyota is recalling certain Toyota Racing Development (TRD) brake kits, P/N PTR09-35070, and TRD High-Performance brake kits, P/N PTR09-35100, installed by Toyota vehicle processing centers and sold by Toyota dealers as an optional accessory for model year 2007 through 2012 Toyota FJ Cruiser vehicles. The subject TRD brake kit is specifically designed for the front wheels of 2007-2012 model year FJ Cruiser vehicles. Due to the shape of the outer brake tube of the brake kit, the clearance between the outer brake tube and a TRD 16 inch 6-spoke alloy wheel is minimal. If wheel balance weights are installed in an incorrect location, there is a possibility that the outer brake tube could be damaged due to interference with the balance weight, and brake fluid could leak from the damaged tube.

Remedy: All known owners of 2007-2012 model year FJ Cruiser vehicles will be notified by first class mail. If the vehicle is equipped with one of the TRD brake kits, the brake caliper outer brake tube will be replaced with a newly designed one at no charge. During this service, if necessary, the dealer will make wheel balance adjustments. This remedy will be performed even if the vehicle has original equipment 16 inch or 17 inch wheels or TRD 16 inch Beadlock ring type wheels, which are not affected by the condition, to assure sufficient clearance in the event wheels are changed at a later time. Notification to owners began on December 17, 2012. Owners may contact Toyota Customer Experience Center at 1-800-331-4331.

200,000 vehicles affected

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.

Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

22,000 vehicles affected

EQUIPMENT

MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.

Remedy: MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.

294 vehicles affected

EQUIPMENT:OTHER:LABELS

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

153,418 vehicles affected

EQUIPMENT:OTHER:LABELS

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

271,417 vehicles affected

EQUIPMENT:OTHER:LABELS

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

27,080 vehicles affected

I have 47k miles on my car. I took it in for an oil change (Fox Toyota, Rochester Hills, MI) and was told that it was dangerous to drive. I needed a new rear axle and much more. No details were provided. I could not open the email link they sent to my phone. I left the car at the service dept. 10/21/25 -prior to this visit I brought my car in to Fox for an oil change august 2024 and was told I would probably need new struts soon. I had appx 44,000 miles on my car at that time. - I park in my garage every night and have had an undercarriage wash each month at a car wash. - I live on a dirt road but my husband's 2017 Chevy Silverado has 180,000+ miles. -People online have asked me if I parked in the ocean -I contact Toyota Brand Engagement immediately. They paid a small amount ($3900) toward fixing the $17,000 bill. My car was in limbo at service for 30 days. I had not care. So I had to accept.

The contact owns a 2008 Toyota FJ Cruiser. The contact stated while driving at an undisclosed speed, the contact became aware that the electronic power steering was not functioning properly, requiring increased steering wheel rotation before the vehicle started to maneuver in either direction. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 197,000.

Premature frame rust

The frame of the vehicle is rotted out. Holes in it. Front to back , side to side ROTTED. TOYOTA DEALER looked at it at my request when it was in for service and said it was very bad. I’m [XXX] on Social Security, I cannot afford a frame or a new car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Seat belt just started to not work. retractor is not working and I am concern for my safety due to relocating to Florida and seat belt is not working.

the brakes are constantly binding up due to rust and need replaced, recently ABS brake lines rusted off causing me to miss a stop sign, very dangerous, Upper rear control arm mount rusted and cracked completely off causing steering and braking problems and had to be replaced to even use this vehicle, , The front rack has been replaced due to excessive rust of lines and fittings, same with transmission cooler lines-rotted off...brake backing plates rotted off.. Even though I have had this undercoated and rust treated, the frame is rusting inside-out...frame braces, everything on the frame is rusted much more than one would expect, even in a salt state like Ohio....my safety was put at risk by faulty brakes, the frame is not safe under hard braking and may cause an accident, the dealer has seen this vehicle, a local independent says "get rid of it"...no warning lamps, just wild things happen with brakes, pulls left, pulls right, front, then back and this past time ...NONE!...only 111,000 miles.

On the home my wife went to apply the brakes and she had no brake pressure. The pedal went all the way to the floor. Then several lights and a buzzer sound started, and she could not stop the car. She was able to pull up on the e-brake just before she drove completely into the intersection, where several cars were driving in both directions. The front end of car ended partially in the north bound lane of US MD-5. There was also a home at the end of the road that she could have also driven into. I researched on several forums where other owners have had the same issue and the dealership has been unable to diagnose the issue. No TSB or recall has been made, but the number of people that have had this issue, something should have been done. My 4-year-old daughter was in the car, and I could have lost both of them. People need to aware of this. I had no idea that a total brake failure was possible with these vehicles.

I was given this car seat as a gift 12/18/2021. The metal buckle is inserted backwards on the left side. This results in a twist of the seat belt that can’t be corrected. I cannot remove the metal piece to fix this because the strap is sewn together. I thought it was just twisting because that’s what car seats sometimes do. But when I remove the padding to clean it today I realized it was a manufacturer error.

Rear fuel tank strap rusted and broke, leaving my tank hanging several inches lower to the ground.

After buying my vehicle I have began to notice a growing rust problem that is not due to salt water or other environmental conditions, but clearly a defect in manufacturing. After joining a few Facebook groups with other FJ owners I’ve found countless other people have had the same problem and that without massive trust removal my vehicle is expected to have failures in the frame and suspension at some point.

My Toyota FJ Cruiser 2008 "FUEL PUMP" failed to indicate the amount of gasoline I had in the tank, the car completely stop working on the freeway while I was driving approximately at 70 MPH right in the fast lane, the car/motor just ugly shook and suddenly it stall/shut down... luckily the cars behind me were able to maneuver their cars and avoided a possible crash. I tried to start the car again and gave me some forward jumps until i got it off of the road. the gas panel indicator was still reading 1/2 filled tank but not gas inside tank...I called freeway service patrol (511) and they Offered me a gallon of gas, as i run out (they saved my day). i thought this was just one hit wonder problem but not the car has been getting me in trouble ever since now my wife drives it too, she or me assume there is still gas in the car and out of the blue i wind out carrying gas in a red gallon... i asked mechanics if they can replace but they said no easy - access to replace the pump is not well designed to extract the fuel pump and the floor mats on the car and the rear seat must be removed and some how the car will have some cosmetic damage... best is to lower the full gas tank from underneath but there is also a problem as the wire connector length are extremely short and they must be cut out and add extensions after replacing pump and may affect sensor lights... and repair for that is quite expensive. The car pump goes up when full tank but as gas is used needle stops at 1/2 mark and there is no way to tell if i have gas- I had experienced 8 time stalls, luckily no accidents - I found this online and called Toyota but they are unaware of this recall: "if stall pump fails, the engine can stall while driving, increasing the risk of a crash. Toyota will notify owners, and dealers will replace the fuel pump, free of charge. The recall began May 4, 2020. Owners may contact Toyota customer service at 1-888-270-9371" is it true?

The driver seat belt will not contract back.

The frame of my Truck has started to rust out as to many FJ Cruisers. It's been a known issue that these frame have this problem along with the Toyota Tacoma and Toyota Tundra. Which Toyota have a recall on those two models but they've yet to recognize the Toyota FJ Cruiser for the same issue. If this issue isn't resolved, it can result in weak points in the chassis making those area fail and cause an accident underload. I have had my shop look at it and said they can only treat the affected areas so much but the issue will keep coming back over time as rust does not go away unless its cut out. For the safety for myself, any FJ Owners as well as the roads we share with the public I hope that we get this issue corrected through the Manufacturer. Thank you

While inspecting a broken rear fuel tank strap, several holes were noticed in the frame of the vehicle. Excessive corrosion was present all along the welds on the frame and its crossmembers. There were spots where I could poke my finger through the frame. There was no warning that this corrosion was happening. I am the third owner of this FJ and it was inspected before I purchased it. The vehicle has not yet been taken to a dealership, police or an insurance company.

The rear fuel tank strap broke due to corrosion and it was retained. The Fuel tank was spotted hanging lower than normal after driving on a long trip on a vacation. I removed the tank shield and have removed the vehicle from service until new tank straps arrive. No police or insurance have been contacted. There was no warning of this failure or evidence this failure was imminent.

UPON HARD BRAKING, IF VEHICLE HITS A BUMP, POTHOLE, UNEVEN ROAD SURFACE, ETC, THE ABS KICKS IN MAKING IT ALMOST IMPOSSIBLE TO STOP UNLESS I COMPLETELY RELEASE THE BRAKES THUS REQUIRING ME TO SLAM ON IT HARD TO PREVENT REAR ENDING ANOTHER OBJECT.

GAS TANK SUPPORT STRAPS FAILED WHILE DRIVING. DEALER INSTALLED TEMPORARY NYLON RATCHET STRAPS UNTIL PARTS ARRIVED.

MY STEERING HAD BECOME STIFF, NO STEERING FLUID LEAKS OR ISSUES WITH THE RACK, DEALER DROVE VEHICLE SAID NOTHING IT WRONG. I GOT HOME AND TOOK A BETTER LOOK, THE U JOINTS ON THE LOWER INTERMEDIATE STEERING SHAFT ARE RUSTED AND ROTTED. THE STEERING IN NOTICEABLY TIGHT AND HAS TROUBLE RETURNING TO CENTER.

DRIVER SIDE SEAT BELT NOT RETRACTING

FRAME, SUSPENSION, AND BRAKES HAVE EXTREME DAMAGE FROM RUST. REAR BRAKES ARE NON-FUNCTIONAL BECAUSE OF RUST.

EXTREME RUST AND CRACKING IN FRAME

EXCESSIVE RUST ON THE FRAME AND UNDERCARRIAGE. NEEDED TO BE CLEANED AND TREATED.

THIS VEHICLE STARTED TO DEVELOPE RUST IMMEDIATELY AFTER PURCHASE. THE VEHICLE IS A 2008 AND IS SCARY RUSTY ON THE FRAME AND OTHER COMPONENTS. AN ABNORMAL AMOUNT OF RUST COMPARED TO OTHER 2008 ERA VEHICLES. EVENTUALLY ONE OF THESE FAULTY FRAMES ARE GOING TO BREAK IN A HIGH SPEED SCENARIO AND SERIOUS INJURY OR DEATH WILL OCCUR. MY OTHERWISE PERFECT FJ CRUISER ONLY HAS 35000 MILES ON IT AND SAT IN STORAGE FOR THE WINTER OF 2016 AND 2017.

THE REAR GAS TANK STRAP SNAPPED ON THE VEHICLE (THE STRAP SIDE FACING TO THE OUTSIDE OF THE VEHICLE). THE STRAP FAILED DUE TO RUST. THE STRAP MUST HAVE SNAPPED WHEN I HIT A BUMP IN THE ROAD. HOWEVER, I DID NOT KNOW THAT THE STRAP HAD FAILED UNTIL I HAPPENED TO BE STANDING BEHIND THE VEHICLE ONE DAY AND NOTICED THE TANK SAGGING. THEREFORE, I DO NOT KNOW HOW MANY DAYS THAT I HAD BEEN DRIVING AROUND WITH THE TANK HANGING, SUPPORTED ONLY BY THE FRONT STRAP. BUT I THINK THAT POSSIBLY I NOTICED THE FAILURE WITHIN ONE DAY OF THE FAILURE. THE RED STRAP IN THE PHOTO IS MY TEMPORARY SUPPORT UNTIL I CAN HAVE THE STRAPS REPLACED.

SEVERE RUST ON ALL PARTS OF THE FRAME 'UNDERCARRIAGE', BRAKE LINES, GAS TANK STRAPS. THIS ISSUE HAS BEEN WIDELY REPORTED BY FJ OWNERS AND NOTHING DONE BY THE MANUFACTURER. TRUCK WAS NEVER DRIVEN THROUGH SALT WATER NOR IS IT STORED BY THE WATER FRONT. I AM FRIGHTENED THAT IN AN ACCIDENT THE WHOLE BODY OF THE TRUCK WILL JUST COME OFF THE FRAME.

2008 TOYOTA FJ CRUISER FRAME ROTTING FROM INSIDE AND OUT. ALL SUSPENSION COMPONENTS HAVE BEEN REPLACED DUE PARTS FAILING BECAUSE OF CORROSION THAT BLED OVER FROM THE FRAME TO INCLUDE BOTH FRONT STEERING KNUCKLES, TWO PARTS THAT ONLY EVER GET REPLACED IN THE EVENT OF AN ACCIDENT. SEVERAL FRAME SUPPORTS HAVE CORRODED FROM THE INSIDE OUT AND ARE FLAKING OFF. BRAKE COMPONENTS THAT RUN ALONG THE FRAME HAVE CORRODED FROM THE FRAME TO THE BRACKET THAT HOLDS THEM TO THE LINES THEMSELVES. CAUSE A SLOW BRAKE LEAK OVER TIME THAT EVENTUALLY RESULTED IN A DANGEROUS NEAR ACCIDENT SITUATION THAT WAS CAUSED BY COMPLETE IMMEDIATE LACK OF BRAKE PRESSURE. EVASIVE DRIVING AND A SOUND MIND AVOIDED A LEGITIMATE ACCIDENT, HAD TO TOW THE TRUCK TO A SHOP. UNSAFE TO DRIVE. FRAME WILL NOT HOLD UP IN AN ACCIDENT. 12 YEAR OLD FRAME SHOULD NOT BE ANYWHERE NEAR THIS CONDITION. DUE TO OVERSIGHTS AT THE MANUFACTURER THIS FRAME IS NOW CORRODING FROM THE INSIDE OUT.

THE FRAME AND SUSPENSION PIECES ON MY FJ HAVE RUSTED DUE TO POOR COATINGS AND MATERIALS USED BY TOYOTA. *TR

VEHICLE WAS STATIONARY IN DRIVEWAY MY FRAME, SOME SUSPENSION COMPONENTS, AND MY ROCKER PANELS WERE FALLING APART IN MY HANDS

SEVER RUSTING OF FRAME, BREAK AND SUSPENSION COMPONENTS AND BRACKETS. THIS 2008 TOYOTA FJ CRUISER IS QUICKLY BECOMING A SAFETY HAZARD ON THE ROADS. I HAVE A 92 SABB AND A 93 VW THAT DON'T HAVE HAVE THE RUST ISSUES THIS TOYOTA HAS. TOYOTA SHOULD HAVE RECALLED THE FJ CRUISERS FOR FAULTY FRAMES AND UNDERCARRIAGE LONG AGO.

EXCESSIVE RUST ON THE FUEL TANK STRAPS AND VEHICLE FRAME. UNDERBODY OF THIS VEHICLE COULDN'T HAVE BEEN MANUFACTURED TO U.S CORROSION STANDARDS SINCE I'VE NOT SEEN ANY AMERICAN VEHICLES WITH THIS WIDESPREAD RUST ISSUE.

THE VEHICLE HAS A SEVERELY RUSTY FRAME. REST OF THE FJ BODY IS MINT WITH A TOTAL OF 80K MILES. THE REAR CROSS SECTION WHERE THE GEM HITCH BOLTS TO IS PARTICULARLY BAD AND HAS HOLE. THE HITCH ITSELF IS ALSO SITTING A LITTLE CROOKED WHICH I BELIEVE IS DUE TO THE POOR STRUCTURAL INTEGRITY OF THE CROSS BAR. TOWING IS OUT OF THE QUESTION AT THIS POINT BUT MORE IMPORTANTLY, I AM VERY WORRIED WHAT MIGHT HAPPEN IN AN EVENT I GET REAR ENDED.

WE BOUGHT OUR FJ CRUISER NEW IN 2008. I HAVE METICULOUSLY MAINTAINED (WITH SEVICE RECORDS FROM TOYOTA DEALERSHIP), AND I HA E ALWAYS KEPT IT METICULOUS INSIDE AND OUT. THE VEHICLE IS A 2008 WITH 100K MILES AND LOOKS BRAND NEW UP TOP... HOWEVER THE UNDERCARRIAGE IS A COMPLETELY DIFFERENT STORY. NO MATTER HOW OFTEN I CLEANED THE FRAME, SUSPENSION, AND DRIVETRAIN I COULD NOT KEEP THE RUST AT BAY, NOW I'M EXTREMELY CONCERNED ABOUT MY FAMILIES SAFETY. I'M WORRIED BRACKETS ARE ABOUT TO RUST OFF, AND BODY MOUNTS AND BOLTS ARE SHOWING SEVERE RUST, THIS IS UNACCEPTABLE. I HAVE NEVER SEEN A CARS UNDERCARRIAGE RUST SO QUICKLY AND COMPLETELY IN ALL MY LIFE. THIS NEEDS TO BE REMEDIED BEFORE PEOPLE START GETTING HURT WHILE DRIVING WITH THESE WITH THESE UNSAFE CHASSIS AND COMPONENTS. AND MY GAS TANK STRAPS ARE ROTTING FAST. I HAVE OWNED TOYOTA'S MY WHOLE LIFE. I CURRENTLY OWN 5 DIFFERENT LAND CRUISERS. WE LOVED OUR FJ AND BOUGHT IT BECAUSE WE THOUGHT IT WOULD LAST.