2007 PREVOST X3-45

8 recalls — 0 complaints — 56 TSBs

EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP

Defect Description

Prevost Car (US) Inc. (Prevost) is recalling certain 2005-2024 X3-45, 2017-2019 and 2021-2023 X3-45 Commuter, 2006-2007, 2014, and 2018 H3-41, 2005-2020 and 2022-2024 H3-45, and 2019 H3-45 VIP buses equipped with a wheelchair lift. The wheelchair platform bridging device may be too steep, which can... Read more

Consequence

An unstable wheelchair increases the risk of injury to lift occupants.

Remedy

Prevost will replace the wheelchair lift bridging device, free of charge. Owner letters were mailed April 25, 2025. Owners may contact Prevost customer service at 1-866-870-2046. Prevost's number for this recall is SR24-26.

2,653 vehicles affected

Manufacturer: Prevost Car (US) Inc.

STEERING:LINKAGES:DRAG:LINK:CONNECTION

Defect Description

Prevost Cars, Inc (Prevost) is recalling certain 2000 XL-45 buses, 2000-2006 XL2-45 buses and 2007-2014 X3-45 buses. The draglink tube turnbuckle may fracture causing a loss of steering.

Consequence

A complete loss of steering would increase the risk of a crash.

Remedy

Prevost has notified owners, and dealers will replace the draglink, free of charge. Prevost issued an interim notification to owners on February 13, 2019. The recall began June 3, 2019. Owners may contact Prevost customer service at 1-866-870-2046. Prevost's number for this recall is SR19-04.

676 vehicles affected

Manufacturer: Prevost Cars, Inc.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Defect Description

Prevost Cars, Inc. (Prevost) is recalling certain model year 2006-2010 X3-45 coaches manufactured January 11, 2006, to April 12, 2010. The affected vehicles have booster stud connections that may rust. As they rust, the stud may weaken and break, allowing the power cable to ground against the vehi... Read more

Consequence

If the power cable electrically shorts against the frame, there would be an increased risk of a fire.

Remedy

Prevost will notify owners, and dealers will install a protective box over the connection to prevent the power cable from contacting the frame if it comes loose. Any cable that is corroded will be replaced, free of charge. The recall began on July 24, 2015. Owners may contact Prevost customer ser... Read more

314 vehicles affected

Manufacturer: Prevost Cars, Inc.

FUEL SYSTEM, DIESEL

Defect Description

Prevost Cars, Inc. (Prevost) is recalling certain model year 2007-2012 XLII, X3-45, H3-41, H3-45, and H3-45 VIP vehicles manufactured July 5, 2007, to May 11, 2012. The affected vehicles may be missing a fuel line locating clip, allowing the fuel line to rub against the braided coolant hose.

Consequence

The fuel line rubbing may result in abrasion and a fuel leak, increasing the risk of a fire.

Remedy

Prevost will notify owners, and dealers will inspect the fuel line for abrasion, replacing it as necessary, and will properly secure the fuel line and coolant line, free of charge. The recall began on March 26, 2015. Owners may contact Prevost customer service at 1-418-883-3391. Prevost's number f... Read more

455 vehicles affected

Manufacturer: Prevost Cars, Inc.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Defect Description

PREVOST IS RECALLING CERTAIN MODEL YEAR 2007-2009 X3-45 COACHES EQUIPPED WITH VOLVO D13 ENGINES. THE JUMP-START POSITIVE TERMINAL BLOCK CABLE MAY BE MISSING A PROTECTIVE SLEEVE, WHICH MAY ALLOW A SHORT-CIRCUIT IF IT CONTACTS OTHER VEHICLE STRUCTURES.

Consequence

IF A SHORT-CIRCUIT OCCURS, THERE IS AN INCREASED RISK OF FIRE.

Remedy

PREVOST WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE CABLE AND, AS NECESSARY, ADD PROTECTIVE TUBING FREE OF CHARGE. THE RECALL BEGAN ON JULY 17, 2012. OWNERS MAY CONTACT PREVOST AT 1-418-883-2888.

428 vehicles affected

Manufacturer: PREVOST CARS, INC.

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Defect Description

PREVOST IS RECALLING 395 MY 2007-2009 MTH XL2-45, MTH XL2-45E, AND X3-45 MOTOR HOMES AND MOTOR COACHES. ON SOME VEHICLES, THE POWER STEERING HOSE PROTECTIVE SKIN HAS BEEN DAMAGED AT ASSEMBLY, LEAVING THE METAL BRAIDING EXPOSED TO THE ENVIRONMENT.

Consequence

OVER TIME, THE METALLIC BRAIDING MAY RUST UP TO A POINT WHERE THE HOSE WILL GIVE UP UNDER PRESSURE. THIS COULD RESULT IN A LOSS OF CONTROL INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL REPAIR THE POWER STEERING HOSE ASSEMBLY. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2008. OWNERS MAY CONTACT PREVOST AT 1-418-831-5432.

640 vehicles affected

Manufacturer: PREVOST CARS, INC.

EQUIPMENT

Defect Description

ON CERTAIN MOTOR COACHES EQUIPPED WITH ZF/ARENS ASTRONIC SHIFT SELECTORS, A CELL PHONE PLACED IN THE PROXIMITY OF THE SHIFTER TOUCH PAD COULD CAUSE THE DISPLAY TO CHANGE FROM 'R' (REVERSE) TO 'D' (DRIVE) SHOULD THE PHONE RECEIVE A CALL.

Consequence

THIS INTERFERENCE CAN CAUSE THE TRANSMISSION TO NOT OPERATE OR CAUSE IMPROPER SHIFTING, AS FORWARD GEAR CAN BE ENGAGED FROM NEUTRAL ONLY, IF THE VEHICLE HAS BEEN STOPPED, AND IF THE BRAKE PEDAL HAS BEEN DEPRESSED. IF THE MALFUNCTION OCCURS WHILE 'R' (REVERSE) IS BEING SELECTED, THE SHIFTER MAY POSS... Read more

Remedy

PREVOST WILL MAIL STICKERS AND INSTALLATION INSTRUCTIONS TO THEIR OWNERS AND WILL ALSO ARRANGE TO HAVE THE TRANSMISSION SOFTWARE UPGRADED. THE RECALL BEGAN ON FEBRUARY 13, 2008. OWNERS MAY CONTACT PREVOST AT 1-418-831-5432.

392 vehicles affected

Manufacturer: PREVOST CARS, INC.

PARKING BRAKE

Defect Description

ON CERTAIN MOTOR COACHES EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence

THIS COULD CAUSE DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.

Remedy

PREVOST IS WORKING WITH BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 14, 2007. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000 OR PREVOST AT 1-418-831... Read more

686 vehicles affected

Manufacturer: PREVOST CARS, INC.

No complaints found for this vehicle.

Technical Service Bulletins — 2007 PREVOST X3-45

56 manufacturer communications from 36 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	12
110000 ELECTRICAL SYSTEM	8
060000 ENGINE AND ENGINE COOLING	4
010000 STEERING	4
040000 SERVICE BRAKES, AIR	3
356000 EQUIPMENT ADAPTIVE/MOBILITY	3
020000 SUSPENSION	2
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	2

020000 SUSPENSION

SWAY BAR COLLARS IMPROVEMENT

110000 ELECTRICAL SYSTEM

STEERING GATEWAY. Revision B - PIN 2 and 10 were inverted on connector A139

040000 SERVICE BRAKES, AIR

Air Tanks Draining Sequence. Revision: B - General Update

040000 SERVICE BRAKES, AIR

Air Tanks Draining Sequence. Revision: A - Erroneous Secondary & Accessory tanks location.

040000 SERVICE BRAKES, AIR

Air Tanks Draining Sequence

130000 VISIBILITY

Halogen to LED fog light replacement kit. Revision: C - Advanced kits canceled

120000 EXTERIOR LIGHTING

Halogen to LED fog light replacement kit. Revision: C - Advanced kits canceled

350000 EQUIPMENT

STORAGE AND STARTUP GUIDELINES : part number updates

130000 VISIBILITY

CENTRAL HVAC MERV FILTERS INSTALLATION

350000 EQUIPMENT

Sound Selector replacement, VSS04 to VSS05; When replacing a vehicle sound selector model VSS04 with a new sound selector model VSS05, an interface harness is required to connect the vehicle harness to the new sound selector model and a new

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

CENTRAL HVAC MERV FILTERS INSTALLATION REVA

160000 STRUCTURE

STORAGE AND STARTUP GUIDELINES: Periodically, circumstances arise requiring operators to temporarily park a coach in storage. Whether it is a few weeks or several months, sporadic out of service times or a full stop, Prevost recommends foll

010000 STEERING

TIE ROD 610052 FIRST INSTALLATION INSTRUCTIONS: Use these instructions when replacing the drop joint tie rod on S82, S84 / S84U I-beam axles. The new tie rod will be adjusted to the length of the original; however, a steering alignment ne

350000 EQUIPMENT

INTRODUCING A NEW ENGINE COOLANT INTO PREVOST SERVICE CENTER NETWORK

060000 ENGINE AND ENGINE COOLING

INTRODUCING A NEW ENGINE COOLANT INTO PREVOST SERVICE CENTER NETWORK

350000 EQUIPMENT

Rev A: Mention added concerning DDC Series 60 engine SCA requirement

060000 ENGINE AND ENGINE COOLING

Rev A: Mention added concerning DDC Series 60 engine SCA requirement

350000 EQUIPMENT

INTRODUCING A NEW ENGINE COOLANT INTO SERVICE

060000 ENGINE AND ENGINE COOLING

INTRODUCING A NEW ENGINE COOLANT INTO SERVICE

060000 ENGINE AND ENGINE COOLING

FAN CLUTCH PLATE BOLTS RE-TORQUING

350000 EQUIPMENT

STORAGE AND STARTUP GUIDELINES Revision: B Parts added to Suggested Material 08-10-2020

010000 STEERING

JERKY, NOISY OR HARD TO TURN STEERING GEARBOX. HYDRAULIC END LIMITER ADJUSTMENT. All models a?? equipped with RB Bosch/ZF Servocom or Servocomtronic steering gearbox

350000 EQUIPMENT

STORAGE AND STARTUP GUIDELINES: Rev A: 21516229 replaced by 23381562 20523393 replaced by 21454749 800383 removed 611471 replaced by 611360 70376808 replaced by 21036050 21396642 replaced by 20967831

356000 EQUIPMENT ADAPTIVE/MOBILITY

Plexiglass Panel Behind Driver X3

350000 EQUIPMENT

Plexiglass Panel Behind Driver X3

350000 EQUIPMENT

HAND SANITIZER DISPENSER INSTALLATION

355100 EQUIPMENT:OTHER:LABELS

PREVOST VEHICLE DISINFECTION PROCEDURE

980000 UNKNOWN OR OTHER

STORAGE AND STARTUP GUIDELINES - ALL PREVOST VEHICLES & VOLVO 9700

356000 EQUIPMENT ADAPTIVE/MOBILITY

Added: Power cables for L.H. side alternator & fan drive breaker box

350000 EQUIPMENT

Added: Power cables for L.H. side alternator & fan drive breaker box

110000 ELECTRICAL SYSTEM

Added: Power cables for L.H. side alternator & fan drive breaker box

353000 EQUIPMENT:ELECTRICAL

Revision : Addition of Wiring Schematics at the end of this document

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

The intent of this procedure is to guide you through the steps required to program a MCM especially for the control of the HVAC module as described in instruction sheets IS-19923.

350000 EQUIPMENT

The intent of this procedure is to guide you through the steps required to program a MCM especially for the control of the HVAC module as described in instruction sheets IS-19923.

110000 ELECTRICAL SYSTEM

The intent of this procedure is to guide you through the steps required to program a MCM especially for the control of the HVAC module as described in instruction sheets IS-19923.

170000 LATCHES/LOCKS/LINKAGES

This instruction sheet explains how to install 780428 door actuator replacement.

162300 STRUCTURE:BODY:DOOR

This instruction sheet explains how to install 780428 door actuator replacement.

110000 ELECTRICAL SYSTEM

This instruction sheet explains how to install 780428 door actuator replacement.

110000 ELECTRICAL SYSTEM

MP-1000 MULTIMEDIA PLAYER INSTALLATION

350000 EQUIPMENT

MP-1000 MULTIMEDIA PLAYER INSTALLATION

010000 STEERING

Vehicles identified below are compatible with a new tie rod design. This new tie rod 610052 has updated ball joints and a fine adjuster sleeve. It replaces former drop type ball joint tie rods. Refer to IS-18091 for installation instruction

020000 SUSPENSION

100000 POWER TRAIN

015200 STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

POWER STEERING PUMP DISCHARGE HOSE (PRESSURE) REPLACEMENT

010000 STEERING

POWER STEERING PUMP DISCHARGE HOSE (PRESSURE) REPLACEMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

On vehicles mentioned above, should the curbside electric sunshade fail to operate without encountering a drive mechanism issue, perform the following procedure.

110000 ELECTRICAL SYSTEM

On vehicles mentioned above, should the curbside electric sunshade fail to operate without encountering a drive mechanism issue, perform the following procedure.

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

PREVOST: 12" BRUSHLESS CONDENSER FAN REPLACEMENT. MODELS INCLUDE XLII MTH, AND H3VIP MTH. MODEL YEARS ARE 2008-2011. *KB

150000 SEAT BELTS

PREVOST: INSTALLING THREE-POINT PASSENGER SEAT RESTRAINT SYSTEM. THE PURPOSE OF THE FOLLOWING PROCEDURE IS TO FACILITATE THE JOB AND TO HELP IDENTIFY THE DIFFICULT AREAS. ALSO INCLUDED MODELS HE-41 AND HE-45 COACHES MODEL YEARS 1998-2008; M

160000 STRUCTURE

PREVOST: INSPECTION OF WELD BEADS ON 85' SUPER CARGO DOOR PANTOGRAPH ARM. IF BEADS ARE MISSING COULD CAUSE FATIGUE OR CRACKING. MODELS X3-45 COACHES. MODEL YEAR 2007-2008. *JS

021800 SUSPENSION:FRONT:KING PIN

FRONT AND TAG AXLE HUB BEARING AND KING PIN PERIODIC MAINTENANCE. BEARINGS MUST BE INSPECTED AT INTERVALS OF 30,000 MILES (48 000KM). KING PINS SHOULD BE SERVICED EVERY 6, 250 MILES (10,000 KM) OR TWICE A YEAR. ALSO INCLUDED MODEL VIP-45 MT

021700 SUSPENSION:FRONT:HUB

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

POWER WINDOW HARNESS- REMOVAL OF ZENER SUPPRESSOR DIODES. A FAULTY DIODE WILL CAUSE THE BURNING OF THE FUSE PROTECTING THE CIRCUIT. ALSO INCLUDED MODEL XLII-40, XLII-45 MOTORHOMES & ENTERTAINER XLII-45. MODEL YEARS 2007-2008. MODEL VIP MOTO

110000 ELECTRICAL SYSTEM

021000 SUSPENSION:FRONT

RETAINING RING INSTALLATION ONTO FRONT SUSPENSION SWAY BAR. *KB

NHTSA Safety Investigations — PREVOST X3-45

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EQ — Closed — Model Year: 2018

Seat Belt Buckle Casings may Fail

On March 30, 2018, Van Hool N.V. (Van Hool) notiﬁed the Oﬃce of Defects Investigation (ODI) of a safety defect that exists in certain model year (MY) 2015-2018 CX45, TD925, TDX25, TX40, TX45, and 2016-2018 CX35 motorcoaches. The passenger seat belt buckle’s outer casing may fail, leaving the s... eat belt buckle mechanisms exposed. The exposed seat belt buckle mechanisms may reduce the seat occupants’ likelihood of using the seat belt, increasing the risk of injury in the event of a crash. This recall of vehicles with the subject seat belt buckle casings was designated recall 18V-209. In its recall ﬁling, Van Hool identiﬁed the component manufacturer as Fasching Salzburg. Based on Early Warning Reporting (EWR), ﬁeld reports, and warranty claims aggregate data, NHTSA identiﬁed that the defective part in Van Hool’s recall was potentially used in vehicles manufactured by Volvo Bus Corporation (Volvo), Motor Coach Industries (MCI), and Prevost Car (US) Inc. (Prevost). NHTSA opened this Equipment Query (EQ) investigation, EQ19-001, to determine if the seat belt buckle casing at issue in recall 18V-209 constituted a safety defect in Volvo, MCI or Prevost vehicles, thereby requiring additional recalls. On July 23, 2019, NHTSA sent an Information Request (IR) letter to Volvo requesting that for all of the seatbelt buckles Volvo uses, or has used, as original or replacement equipment on 2016 model year Volvo 9700 buses, that it provide the Volvo part number(s), the seatbelt manufacturer’s or supplier’s part number(s), the manufacturer’s or supplier’s name and their contact information. In the IR, NHTSA further requested that Volvo state the number of each of the above seatbelts that Volvo has distributed as replacement items for the original equipment seatbelts and provide the model and model year of the vehicle in which it is used and month/year of sale (including the cut-oﬀ date for sales, if applicable). Finally, NHTSA requested that Volvo provide two samples of each seat belt type/brand/part number identiﬁed by Volvo. On October 23, 2019, NHTSA sent an IR letter to Amaya-Astron Seating, the seat manufacturer that installed the subject Fasching Salzburg seat belt buckle assemblies on the seats supplied to Van Hool. The purpose of this letter was to obtain, in part, a list of purchasers that were sold the seatbelt buckles as individual replacements or part of a seat and a list of all customers/manufacturers that received the same or similarly aﬀected seatbelt buckles. Amaya-Astron identiﬁed MCI, Prevost, and Volvo as the motorcoach manufacturers to which it supplied seats with subject seat belt buckle casings. NHTSA sent two IR Letters and Comprehensive Inquiry (CI) 21650H002 in support of EQ19-001 to MCI, Prevost, and Volvo Bus, in order to determine the relevant population. The IR letters and CI identiﬁed that the following vehicles used the subject seat belt buckle casings: 2016 Volvo Bus 9700 and 2018 Prevost X3-45. MCI reported that it had no vehicles with the suspected subject seat belt buckle casings. Prevost and Volvo Bus reported that they did not observe a trend of seat belt buckle casing failures as observed in recall 18V-209. EWR, ﬁeld reports, warranty claims data, and the information provided in the IR responses and CI similarly did not identify failure trends in the seat belt buckle casings. In addition, Prevost recalled the population of its vehicles subject to this investigation, containing the subject seat belt buckle casings, in recall 22V-236 (2018 Prevost X3-45) based on a diﬀerent safety defect of the seat belt buckle assembly. The recall addressed vehicles with seat belt buckles that may have exposed, frayed retaining cables. As a result, the seat belt assemblies may not secure the seat occupants in the event of a crash. The remedy for recall 22V-236 was the replacement of the entire seat belt buckle, including its casing, with a diﬀerent part. That remedy also obviated the potential concern regarding casing failure that was at issue in recall 18V-209 and EQ19-001. ODI is closing this investigation. Duringthe course of this investigation, the agency reviewed the information that it received and also closely monitored the data over multiple years to see if any trends would emerge. During this time, a portion of the vehicles that were part of the original population of this investigation were recalled. NHTSA believes that enough time has now passed with such monitoring to consider the data as presenting no observable trends to suggest that the seat belt buckle casings subject to recall 18V-209 similarly pose a safety defect in the remaining population of vehicles equipped with the seat belt buckle casings. The agency will continue to monitor the issue and will not hesitate to take appropriate action should such trends emerge in the future. The closing of this investigation does not constitute a ﬁnding by NHTSA that a safety-related defect does not exist, including on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.Read more

PREVOST X3-45 — All Years Overview

Complete safety history for the PREVOST X3-45 across all model years (2005–2025).

183 Total Recalls

0 Total Complaints

1 Investigations

0 Reported Crashes

0 Reported Fires

0 Reported Deaths

PREVOST X3-45 — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls
2025	2	View
2024	3	View
2023	5	View
2022	3	View
2021	3	View
2020	6	View
2019	4	View
2018	9	View
2017	11	View
2016	9	View
2015	11	View
2014	12	View
2013	16	View
2012	16	View
2011	14	View
2010	15	View
2009	17	View
2008	15	View
2007 (current)	8
2006	3	View
2005	1	View

Other PREVOST Models

Model	Recalls	Complaints
45 VIP	0	0	View
ALTERNATOR BELT	0	0	View
ASTRAL	0	0	View
ASTRAL XL	0	0	View
CHAMPION	0	0	View
ENTERTAINER	0	0	View
H SERIES	0	0	View
H3	0	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2007 PREVOST X3-45

Technical Service Bulletins — 2007 PREVOST X3-45

Most Affected Components

NHTSA Safety Investigations — PREVOST X3-45

PREVOST X3-45 — All Years Overview

PREVOST X3-45 — Year by Year

Other PREVOST Models