2004 NISSAN XTERRA

3 recalls, 110 complaints - 69 TSBs

STEERING:COLUMN

Defect Description

NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MO... Read more

Consequence

THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.

Remedy

THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

500,552 vehicles affected

Manufacturer: NISSAN NORTH AMERICA, INC.

EQUIPMENT

Defect Description

CERTAIN HOPKINS AFTERMARKET TRAILER BRAKE CONTROL CONNECTION HARNESSES SOLD FOR USE ON CERTAIN MODELS OF NISSAN VEHICLES WHICH ARE LISTED ABOVE. THE INTERNAL PART NUMBERS WITHIN HOPKINS ARE: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035,... Read more

Consequence

THIS HARNESS WOULD RESULT IN POWER FROM THE TRAILER BRAKE CONTROLLER GOING TO THE TOWING VEHICLE DASH LIGHT CIRCUIT RATHER THAN THE TRAILER BRAKES. THIS RESULT WOULD BE THE LACK OF TRAILER BRAKING WHEN THE TOWING VEHICLE BRAKES WERE APPLIED. IT WOULD ALSO RESULT IN THE TOWING VEHICLES DASH LIGHTS ... Read more

Remedy

HOPKINS WILL NOTIFY OWNERS AND REPLACE THE ORIGINAL HARNESS WITH A REVISED HARNESS FREE OF CHARGE. THE RECALL BEGAN AUGUST 17, 2007. OWNERS CAN CONTACT HOPKINS AT 800-835-0129.

3,500 vehicles affected

Manufacturer: HOPKINS MANUFACTURING CORP.

TRAILER HITCHES

Defect Description

ON CERTAIN SPORT UTILITY VEHICLES, THE ACCESSORY TOW HITCH ATTACHMENT BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.

Consequence

THIS COULD CAUSE THE TOW HITCH TO LOOSEN OR SEPARATE FROM THE VEHICLE WHICH COULD RESULT IN A CRASH WITHOUT WARNING.

Remedy

DEALERS WILL TIGHTEN THE TOW HITCH. THE RECALL BEGAN ON JANUARY 3, 2005. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.

131 vehicles affected

Manufacturer: NISSAN NORTH AMERICA, INC.

Complaint Statistics

110 total complaints 10 crashes 4 fires 11 injuries

Top Reported Components

Component	Complaints
STEERING	16
ELECTRICAL SYSTEM	8
ENGINE	8
SUSPENSION	7
FUEL/PROPULSION SYSTEM	6
FUEL SYSTEM, GASOLINE	5
UNKNOWN OR OTHER	5
SERVICE BRAKES, HYDRAULIC	4
ENGINE AND ENGINE COOLING	4
POWER TRAIN:AUTOMATIC TRANSMISSION	3

Incident date: Jan 1, 2019

Safety Defect Remedies on 2014 Cadillac SRX (VIN: [XXX] ) Dear Sir/Madam, I am writing as the owner of a 2014 Cadillac SRX, VIN [XXX] , to address two critical safety defects that I believe are the manufacturer's responsibility to remedy. Water Intrusion and Electrical Failure: My vehicle has a kn... Read more

Incident date: Jun 1, 2025

The contact owns a 2016 Hyundai Accent. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated the vehicle went into LIMP Mode. There was no warning light illuminated. The vehicle w... Read more

Incident date: Dec 27, 2024

Very strong smell of gas in my car , affecting me badly , got sick and threw up and took car in , and ford changed my catalyst convertor among other things , no lights lit up for anything , the smell that was there is why I took it in and they kept the car until fixed and picked up , now I don’t f... Read more

Incident date: Jan 6, 2019

On June 07, 2023, I was driving on the highway when I noticed a rumbling noise from the front driver-side tire (215/65R18). I got out and inspected the tires and observed nothing wrong with the tires. The next day (06/08) my wife was driving the vehicle on the highway (60 mph) and the vehicle starte... Read more

Incident date: Jan 24, 2022

UNKNOWN. Wanting to make a recall appointment that was reported on my SMOG check.

Incident date: Sep 10, 2020

THE STEERING WEAL IT'S BECOMING STIFF AND IS BECOMING HARD TO MANEUVER AROUND AND IT MIGHT AFFECT MY DRIVING AND I'M SCARED I MIGHT CRASH AND THIS IS THE ONLY VEHICLE I HAVE AND OWN AND HAVE NO OTHER MEANS TO PURCHASE ANOTHER CAR. I WAS HEADING TO WORK AND I TRIED TURNING ON THE CORNER AND IT JUST B... Read more

Incident date: Oct 17, 2020

SPEEDS OVER 60 HITS A BUMP AND STARTS ROCKING AND BOUNCING

Incident date: Oct 17, 2020

SPEEDS OVER 60 HITS A BUMP AND STARTS ROCKING AND BOUNCING

Incident date: Oct 17, 2020

SPEEDS OVER 60 HITS A BUMP AND STARTS ROCKING AND BOUNCING

Incident date: Aug 3, 2020

WHEN DRIVING MY XTERRA, IT LOSES POWER AND CUTS OUT ON ME. THIS IS VERY DANGEROUS AND CUTS COMPLETELY OFF WHEN I'M ACCELERATING. THERE IS A DECLARATION AND THEN THE VEHICLE WON'T CRANK OR START LEAVING ME STRANDED. THIS IS NOT THE FIRST TIME OVER YEARS THAT THE XTERRA HAS CUT OFF ON ME. ALL DASH... Read more

Incident date: Aug 3, 2020

Incident date: Dec 12, 2019

COOLANT IN TRANSMISSION! BOUGHT NEW IN MARCH OF 2015. WAS DRIVING ON I-10 IN BILOXI AND IT STARTED SMELLING LIKE A BURNT RUBBER SMELL AND IT STARTED SMOKING! PULLED OVER AND GOT OUT OF IT! LEFT ME AND MY DAUGHTER STRANDED ON THE SIDE OF THE HIGHWAY! *TR

Incident date: Sep 19, 2019

FUEL GAUGE REGISTERING IMPROPERLY. ONLY SHOWS 3/4 TANK UPON FILLING TANK FULL AND WILL NOT DROP UPON USAGE OF FUEL. GAUGE HAS ONLY DROPPED ONCE SINCE I HAVE OWNED THE VEHICLE.

Incident date: Sep 19, 2019

FUEL GAUGE REGISTERING IMPROPERLY. ONLY SHOWS 3/4 TANK UPON FILLING TANK FULL AND WILL NOT DROP UPON USAGE OF FUEL. GAUGE HAS ONLY DROPPED ONCE SINCE I HAVE OWNED THE VEHICLE.

Incident date: Aug 22, 2019

WHEN VEHICLE IS STARTED, THE BRAKE LIGHTS WILL STAY LIT AS IF YOU WERE PRESSING THE BRAKE EVEN WHEN ENGINE IS OFF, CRUISE CONTROL WILL NOT SET EITHER SO YOU CAN TURN IT ON BUT WILL NOT ENGAGE. IT MAY HAVE SOMETHING TO DO WITH THE CRUISE CONTROL SWITCH LOCATED BY THE BRAKE PEDAL. I'VE FASHIONED A S... Read more

Incident date: Sep 6, 2019

TL* THE CONTACT OWNS A 2004 NISSAN XTERRA. THE CONTACT STATED THAT THE VEHICLE WAS TOWED TO COURTESY NISSAN (1777 N CENTRAL EXPY, RICHARDSON, TX 75080) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 10V554000 (STEERING). AFTER RETRIEVING THE VEHICLE FROM THE DEALER, IT WAS DISCOVERED THAT THE STEERING WH... Read more

Incident date: Nov 15, 2009

I HAVE CHANGED MY FUEL PUMP 11 TIMES IN TWO YEARS SOMETHING AIN'T RIGHT

Incident date: Jan 20, 2018

GOT INTO MY CAR ONE DAY AND UPON TRYING TO CRANK IT , WHEN TURNING THE KEY IT HESITATED TO CRANK AND FINALLY DID SO. WHEN I REACHED MY DESTINATION, WHEN I LEFT MY CAR WOULD JUST NOT CRANK. NO CLICKS. LIGHTS WORK FINE. NOTHING IS WRONG WITH SECURITY, BATTERY. JUST REPLACED THE STARTER AROUND OCT OF... Read more

Incident date: Jan 20, 2018

Incident date: Dec 21, 2018

TL* THE CONTACT OWNS A 2004 NISSAN XTERRA. WHILE DRIVING 55 MPH, THE ENGINE STALLED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 145,000.

Incident date: Nov 24, 2017

TL* THE CONTACT OWNS A 2004 NISSAN XTERRA. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED WHILE DRIVING. THE CONTACT HAD TO USE EXTRA STRENGTH JUST TO TURN THE STEERING WHEEL. IN ADDITION, THE ABS AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE... Read more

Incident date: May 22, 2018

2004 XTERRA HAD BEEN LOW ON RADIATOR FLUID AND NEEDED TOPPING UP EACH WEEK, THEN EACH DAY. AFTER FILLING WITH WATER AND COOLANT NIGHT BEFORE CAR BEGAN TO OVERHEAT ON HWY. CAR SAT IN SUN ALL DAY, THEN OVERHEATED IN TRAFFIC. HAD TOWED TO WORK ON IT. REPLACED SPLIT RADIATOR HOSE WHERE DRIPPING O... Read more

Incident date: May 22, 2018

Incident date: Jul 7, 2017

STEERING IS SLOPPY. STEERING WHEEL HAS EXCESSIVE PLAY. THERE IS A LOT ON THIS TOPIC ACROSS THE INTERNET FORUMS.

Incident date: Sep 9, 2016

I TOOK MY VECHICLE TO ACE AUTO AND HE CLAIM HE FIXED IT GAVE ME A LIST THE SECOND TIME BUT NOT THE FIRST TIME IT SAT THERE FOR A YEAR THAN I GOT IT OUT FOR 2 MONTHS BACK IN AGAIN ITS GOES REAL SLOW BACK FIRES NOW AND STERRING WHEEL LOCKED ONE DAY NOW ITS ACTING LIKE IT DONT HAVE POWER TO IT.EVERYTIM... Read more

Incident date: Sep 9, 2016

Incident date: Sep 11, 2016

ON 9/11/2016, WHILE ATTEMPTING TO PARK MY 2004 NISSAN XTERRA, THERE WAS A TERRIBLE ACCIDENT. I PULLED IN FRONT OF A MAECHANICS BAY AT FIRESTONE IN NEWPORT NEWS, VA. WHILE PARKING MY SUV, WITH MY FOOT FIRMLY ON THE BRAKE, THE SUV RAPIDLY ACCELATRED AND DROVE THROUGH THE BUILDING AND BADLY INJURED A... Read more

Crash 2 injured

Incident date: Sep 11, 2016

Crash 2 injured

Incident date: Sep 5, 2016

I WAS DRIVE MY NISSAN XTERRA IN IN HIGHWAY AND MY CAR START TO SHAKE AND WITH IN 15 MINUTE 3 LUG NUT OUT OF 6 CAME OUT AND OTHER THREE ABOUT TO LOOSE. IT WAS SCARY. I ANYHOW APPROACHED TO CAR REPAIR SHOP AND LEARNED THAT MY FRONT WHEEL BEARING GONE BAD. I JUST FOUND THAT NISSAN XTERRA 2012 HAS R... Read more

Incident date: Jun 12, 2016

JUNE 12 2016 AT THE TRI-PAR IN SLINGER, WI I WAS FILLING UP THE GAS TANK, WHEN GAS BEGAN SPILLING OUT OF THE VEHICLE'S WHEEL WELL. I IMMEDIATELY STOPPED IT AFTER I NOTICED IT. THE STATION ALONG WITH THE SLINGER FIRE DEPARTMENT ESTIMATED A GALLON WAS SPILT. IT APPEARS THE GAS TANK NECK HAS RUSTED OUT... Read more

Incident date: Jun 12, 2016

Incident date: Jun 1, 2015

STEERING BINDS WHEN COMING TO COMPLETE LEFT TURN, WILL NOT RETURN WHEN MOVING FORWRD UNLESS MANUALLY ASSISTED, NOW STEERING GEAR STARTING TO LEAK.

Incident date: Nov 18, 2015

I SMELL GAS INSIDE THE CAR, I TOOK IT TO A SHOP AND THEY TOLD ME THE GAS TANK IS ALL RUSTED ON TOP, CAUSING THE GAS TO SPILL OUT. SPEAKING WITH NISSAN THEY SAID THIS IS PART OF WEAR AND TEAR OF THE VEHICLE, WHICH I DO NOT AGREE WITH.

Incident date: Aug 7, 2015

THE LOWER RADIATOR SUPPORT BAR FOR MY NISSAN XTERRA HAS RUSTED OUT. THIS CAUSES THE MAIN RADIATOR TO SINK WHICH HAS SINCE HIT THE MAIN FAN. ONLY REPLACEMENT IS TO REPLACE THE ENTIRE RADIATOR BRACE. AS A MAIN STRUCTURE COMPONENT OF THE VEHICLE THIS SHOULD NOT BE RUSTING OUT.

Incident date: Jul 1, 2014

PASSENGER SIDE REAR LEAF SPRING BROKE WHILE DRIVING ON THE FREEWAY, ALMOST PUNCTURING GAS TANK ACCORDING TO THE MECHANIC. THE DRIVER'S SIDE REAR LEAF SPRING BROKE WHILE DRIVING ON CITY STREETS. I WAS ADVISED BY MY MECHANIC THAT THIS WAS DEFINITELY AN ITEM THAT SHOULD NOT HAVE FAILED AND IT IS MOST L... Read more

Incident date: Jan 13, 2015

I HAVE HAD TO REPLACE MY STARTER 3 TIMES IN 4 YEARS. I HAVE ALL OF THE RECEIPTS TO SHOW ALSO. I HAVE ALSO HAD TO REPLACE MY RADIATOR BECAUSE OF A CRACK NEAR THE CAP. I HAD A HOSE THAT GOES THROUGH MY DASH WITH THE HOT WATER EXPLODE ON ME AND BURN MY HAND PRETTY BAD. MY RADIATOR SEEMS TO EVAPORATE CO... Read more

1 injured

Incident date: Jan 13, 2015

1 injured

Incident date: Oct 14, 2011

I HAVE REPLACED MY STARTER 3 TIMES. MY BRAKE LIGHTS HAVE A SHORT OR FAULTY WIRING I'M SURE BECAUSE WE HAVE REPLACED THE BULBS SEVERAL TIMES. I HAVE GOTTEN TICKETS BECAUSE OF THIS AS A RESULT I HAVE A EXPIRED BRAKE TAG I CANT GET A NEW ONE BECAUSE THE WIRING WILL COST TO MUCH. MY UV JOINT BROKE WHILE... Read more

Incident date: Oct 14, 2011

Incident date: Feb 23, 2015

VEHICLE OVERHEATED WHILE DRIVING DOWN THE HIGHWAY. UPON INSPECTION, AN APPROXIMATELY 4IN CRACK WAS NOTICED ON THE TOP OF THE RADIATOR, PASSENGER SIDE, NEAR THE THERMOSTAT. REPLACEMENT OF THE RADIATOR WAS REQUIRED.

Incident date: Feb 23, 2015

Incident date: Jan 16, 2015

TL* THE CONTACT OWNS A 2004 NISSAN XTERRA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE SERVICE WHEN THE MECHANIC DIAGNOSED THAT THE LEAF SPRING WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE ... Read more

Incident date: Sep 10, 2014

I'M SURPRISED WITH ALL THE COMPLAINTS ABOUT THE FUEL TANKS RUSTING OUT THAT THERE HAS NOT BEEN A RECALL. ARE THEY WAITING FOR ONE TO BLOW UP OR CATCH FIRE. THE O RING LEAKS VAPOR AND GAS ON FILL UPS BECAUSE THAT AREA IS ALL RUSTED. EITHER THEY HAVE TO USE BETTER COATINGS OR HIDE THAT AREA FROM THE ... Read more

Incident date: Sep 19, 2013

TL* THE CONTACT OWNS A 2004 NISSAN XTERRA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, SHE CRASHED INTO A CONCRETE WALL. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE NECK, BACK AND A CONCUSSION. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL FROM THE SCENE AND A ... Read more

Crash 1 injured

Incident date: Jul 17, 2013

VEHICLE HAS TIGHT STEERING. BARELY ABLE TO TURN WHEEL WHILE NOT MOVING. INDEPENDENT GARAGE CHECKED STEERING, FOUND CORROSION IN STEERING LINKAGE AND NOTIFIED ME OF RECALL. WHEN CONTACTED NISSAN DEALER CLAIMS THAT RECALL DOES NOT COVER THIS VEHICLE. CALLED NISSAN CUSTOMER SERVICE NUMBER WHO ALSO DEN... Read more

Incident date: Aug 10, 2013

FLANGE AROUND THE FUEL SENDING UNIT IS CORRODED AND FUMES ARE ESCAPING FROM THE GAS TANK EVERY TIME I FUEL UP MY VEHICLE. MANY XTERRAS HAVE THIS ISSUE. I BELIEVE IT SHOULD BE A RECALL. *TR

Showing 50 of 110 complaints.

Technical Service Bulletins, 2004 NISSAN XTERRA

69 manufacturer communications from 42 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	6
200000 WHEELS	5
350000 EQUIPMENT	5
010000 STEERING	4
020000 SUSPENSION	4
130000 VISIBILITY	3
030000 BRAKES (PWS)	3
160000 STRUCTURE	2

010000 STEERING

DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

110000 ELECTRICAL SYSTEM

12 VOLT BATTERY TESTING FOR IN-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations ar

110000 ELECTRICAL SYSTEM

SILICONE-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone-based lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal

110000 ELECTRICAL SYSTEM

VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

110000 ELECTRICAL SYSTEM

INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.

130000 VISIBILITY

WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

160000 STRUCTURE

REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

130000 VISIBILITY

REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

160000 STRUCTURE

WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

010000 STEERING

DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

200000 WHEELS

WHEEL BEARING COLLISION DAMAGE This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

020000 SUSPENSION

STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

020000 SUSPENSION

STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

072120 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP:MOUNTING PLATE/FLANGE

VOLUNTARY SERVICE CAMPAIGN FRONT DIFFERENTIAL SIDE FLANGE MOUNTING BOLT Service Campaign ID # P4134 is no longer active. i?? Repair orders opened after this bulletina??s published date are no longer eligible for reimbursement under Cam

350000 EQUIPMENT

100000 POWER TRAIN

350000 EQUIPMENT

BALL JOINT AXIAL END PLAY PROCEDURE SERVICE INFORMATION When working on the front suspension, use the updated service information in this bulletin along with the Electronic Service Manual (ESM). The updated information in this bulletin

021000 SUSPENSION:FRONT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

IF YOU CONFIRM A refrigerant leak at a refrigerant pipe/hose joint location. ACTIONS 1. Inspect the metal surfaces of the pipe/hose joint for damage or contamination. NOTE: Do not replace a refrigerant pipe, hose, or other A/C compon

356000 EQUIPMENT ADAPTIVE/MOBILITY

260000 FORWARD COLLISION AVOIDANCE

SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement "Certification Label" or "VIN Plate / Label" may be needed. These items may be available from Nissan by request if certain criteria are met. Th

355100 EQUIPMENT:OTHER:LABELS

130000 VISIBILITY

SERVICE INFORMATION Windshield "foreign material" that is on the surface of the glass in some cases can be cleaned off with a very particular type and grade of steel wool. * Most any foreign material on the surface of the Windshield c

280000 BACK OVER PREVENTION

SERVICE INFORMATION This bulletin has compiled Tire Pressure Monitor System (TPMS) and Low Tire Pressure Warning System (LTPWS) information for: - Basic diagnosing of TPMS/LTPWS systems - Radio frequency interference causing a "No Da

270000 LANE DEPARTURE

030000 BRAKES (PWS)

200000 WHEELS

140000 AIR BAGS

SERVICE INFORMATION Changes or modifications to the front seat assembly trim materials may affect the proper operation of the Front Seat-Mounted Side-Impact Supplemental Air Bags and Passenger Occupant Classification Sensor and could resul

350000 EQUIPMENT

280000 BACK OVER PREVENTION

140000 AIR BAGS

SERVICE INFORMATION Information necessary to service the Supplemental Restraint System (SRS) safely is included in the "RESTRAINTS" section of the Electronic Service Manual (ESM) for each vehicle. IMPORTANT: Turn the ignition switch OFF

350000 EQUIPMENT

141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

NISSAN: SRS PRECAUTIONS DURING SERVICE;IMPROPER MAINTENANCE, INCLUDING INCORRECT REMOVAL AND INSTALLATION OF THE SRS, CAN LEAD TO A SERIOUS INJURY OR DEATH CAUSED BY UNINTENTIONAL ACTIVATION OF THE SRS ON ALL NISSAN MODELS WITH THE SRS SYS

120000 EXTERIOR LIGHTING

NISSAN: EXTERIOR LAMP FOGGING. OCCASIONALLY WATER IS NOTICED IN THE EXTERIOR LAMPS. THIS IS GENERALLY NOT DUE TO A DEFECT. ALL CURRENT EXTERIOR LAMP ASSEMBLIES ARE VENTED TO THE ATMOSPHERE (NOT SEALED). THIS IS NECESSARY TO ALLOW FOR E

121000 EXTERIOR LIGHTING:HEADLIGHTS

121100 EXTERIOR LIGHTING:HEADLIGHTS:CONCEALMENT DEVICES

122000 EXTERIOR LIGHTING:FOG LIGHTS

123000 EXTERIOR LIGHTING:TAIL LIGHTS

200000 WHEELS

Nissan Original Equipment or Genuine Accessory Alloy wheels, along with their finish coating (clear, chrome, titanium, etc.), are specifically developed to achieve Nissan design and performance standards. These Original Equipment or Genuin

350000 EQUIPMENT

010000 STEERING

SERVICE INFORMATION - This bulletin is to assist you in responding to customer questions about brake operation, and provides diagnostic and repair information for each item listed, if any should occur. - Most brake incidents fall into

200000 WHEELS

If YOU CONFIRM: A vehicle needs to have the brake rotors resurfaced (front or rear). ACTION: Use the ProCut PFM Series on-car brake lathe to perform brake rotor resurfacing and follow the tips listed in this bulletin. - The ProCut P

010000 STEERING

030000 BRAKES (PWS)

200000 WHEELS

020000 SUSPENSION

030000 BRAKES (PWS)

110000 ELECTRICAL SYSTEM

As part of an enhanced emissions test for Inspection & Maintenance (I/M), some States may require the System Readiness Test (SRT) status be checked. - The SRT is used to indicate whether the engine control module (ECM) has completed sel

170000 LATCHES/LOCKS/LINKAGES

NISSAN: LOCK/UNLOCK REQUEST BUTTON ON OUTSIDE HANDLE DOES NOT RESPOND. *JS

020000 SUSPENSION

SERVICE INFORMATION This bulletin provides information to identify: - A leaking strut or a shock absorber that qualifies for replacement under warranty. - A strut or shock absorber that has slight oil seepage, a condition wh

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

NISSAN: ECM REPLACEMENT PROCEDURES WITH CONSULT III PLUS. APPLIES TO ALL 2004 AND LATER (DOES NOT APPLY TO LEAF/EV) VEHICLES. *JS

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

NISSAN: TIRE PRESSURE MONITORING SYSTEM (TPMS) WARNING LIGHT ON/FLASHING. NO MODELS OR MODEL YEARS LISTED. *PE UPDATED ON 08-11-2011. *KB

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

NISSAN: VENT CONTROL VALVE REPLACEMENT. WHEN REPLACING THE EVAP CANISTER VENT CONTROL VALVE FOR REASON: USE THE ONE LISTED ON PAGE 2; FOR VENT CONTROL VALVE REPLACEMENT PROCEDURE, REFER TO THE APPROPRIATE SECTION OF THE ELECTRONIC SERVICE

353000 EQUIPMENT:ELECTRICAL

NISSAN: THE PROPELLER SHAFT U JOINT (JOURNAL/JOURNAL BEARINGS) IS THE SOURCE OF NOISE AND/OR VIBRATION ON AN APPLIED VEHICLE. DIAGNOSE BY EVALUATING THE U JOINT WITH THE PROPELLER SHAFT REMOVED. REPLACE THE U JOINT (JOURNAL/JOURNAL BEARI

021600 SUSPENSION:FRONT:WHEEL BEARING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

111100 ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

NISSAN: THE 12 VOLT BATTERY IS AN IMPORTANT PART OF THE VEHICLE ELECTRICAL SYSTEM AND IS REQUIRED TO STAY CONNECTED WHEN THE ENGINE IS RUNNING. TO PREVENT DAMAGE TO VEHICLE ELECTRONIC COMPONENTS FOLLOW THE INSTRUCTIONS/CAUTIONS. NO MOD

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

110000 ELECTRICAL SYSTEM

220000 SEATS

SEAT BACK BOARD REMOVAL/INSTALLATION. *NJ

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

NISSAN; SPECIAL AUTOMATIC TRANSMISSION FLUID REQUIREMENT. 2004 TO CURRENT NISSAN VEHICLES. *NJ

120000 EXTERIOR LIGHTING

EXTERIOR LAMP FOGGING. *KB

061000 ENGINE AND ENGINE COOLING:ENGINE

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE U1000 OR U1010 STORED IN ENGINE CONTROL UNIT. *AK

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

NO A/T UPSHIFT AFTER HILL WITH ASCD (AUTOMATIC SPEED CONTROL DEVICE) ON. *TT

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ANTILOCK BRAKING SYSTEM (ABS) LIGHT ON AND / OR DIAGNOSTIC TROUBLE CODE FOR ABS WHEEL SPEED SENSOR. *TT

135000 VISIBILITY:REARVIEW MIRRORS/DEVICES

AUTO-DIMMING ELECTROCHROMIC (EC) MIRROR DIAGNOSIS. *TT

105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

FRONT DIFFERENTIAL SIDE MOUNTING BOLT SERVICE CAMPAIGN. *NM SERVICE CAMPAIGN BULLETIN DATED SEPTEMBER 1, 2004. *TT

021220 SUSPENSION:FRONT:SPRINGS:TORSION BAR

TORSION BAR SPRING CAUTION. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SUPERCHARGER NOISE AT IDLE AND LACK OF POWER. *TT

NHTSA Safety Investigations, NISSAN XTERRA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2001

BRAKE ROTOR WARPAGE

MR. KENT JONES OF KERNERSVILLE, NC, SUBMITTED A PETITION TO NHTSA BY E-MAIL DATED JULY 1, 2003, REQUESTING NHTSA TO INVESTIGATE THE BRAKE ROTORS ON MY 2002 NISSAN XTERRA VEHICLES.THE PETITIONER ALLEGED THAT THE BRAKE ROTORS IN THESE VEHICLES WERE DEFECTIVE BECAUSE THE ROTORS OVERHEAT AND WARP FROM N... Read more

EA, Closed , Model Year: 2002

DRIVER'S AIR BAG SYSTEM FAILURE

IN ITS LETTER DATED FEBRUARY 21, 2003 TO NHTSA, NISSAN STATED THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 27,385 MY 2002 NISSAN XTERRA VEHICLES PRODUCED FROM 6/12/01 (START OF PRODUCTION) TO 11/1/01 AS WELL AS APPROXIMATELY 37,177 MY 2002 NISSAN ALTIMA VEHICLES PRODUCED FROM 6/13/01 (START... Read more

PE, Closed , Model Year: 2002

DRIVER'S AIR BAG SYSTEM MALFUNCTION

NISSAN XTERRA - All Years Overview

Complete safety history for the NISSAN XTERRA across all model years (1999, 2012).

59 Total Recalls

4,199 Total Complaints

3 Investigations

164 Reported Crashes

56 Reported Fires

5 Reported Deaths

NISSAN XTERRA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2015	0	15	View
2014	0	15	View
2013	0	7	View
2012	2	17	View
2011	2	27	View
2010	6	58	View
2009	5	26	View
2008	8	174	View
2007	2	770	View
2006	5	1,034	View
2005	6	1,175	View
2004 (current)	3	110
2003	3	97	View
2002	6	214	View
2001	5	197	View
2000	5	258	View
1999	1	0	View

Other NISSAN Models

Model	Recalls	Complaints
LEAF	526	1,374	View
ROGUE	457	9,808	View
SENTRA	291	8,185	View
PATHFINDER	267	10,167	View
VERSA	224	4,473	View
FRONTIER	219	4,441	View
TITAN	208	4,415	View
ALTIMA	183	20,085	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2004 NISSAN XTERRA

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2004 NISSAN XTERRA

Most Affected Components

NHTSA Safety Investigations, NISSAN XTERRA

NISSAN XTERRA - All Years Overview

NISSAN XTERRA - Year by Year

Other NISSAN Models