2002 MITSUBISHI MONTERO SPORT

0 recalls — 63 complaints — 77 TSBs

No recalls found for this vehicle.

Complaint Statistics

63 total complaints 14 crashes 14 injuries 1 deaths

Top Reported Components

Component	Complaints
AIR BAGS:FRONTAL	8
STRUCTURE:BODY	4
ELECTRICAL SYSTEM	4
AIR BAGS	3
SERVICE BRAKES	3
ELECTRICAL SYSTEM:HORN	2
TIRES	2
ENGINE AND ENGINE COOLING	2
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL	2
ENGINE AND ENGINE COOLING:ENGINE	2

Incident date: Aug 18, 2022

I checked and there's several recalls on the vehicle and I purchase it last year from the dealership and I never received anything about the recalls and now my vehicle doesn't want to start it lock me out.

Incident date: Aug 18, 2022

Incident date: Aug 2, 2021

I have a 2002 Mitsibishi Montero Sport.I was driving home from work, and all the sudden i couldn't steer. I had no steering, Lost power to vehicle and battery light came on. Wasnt sure what happened, looked under the hood and noticed belts were off. Went and got new ones and noticed when trying to p... Read more

Incident date: Jun 22, 2018

DRIVE MODE SELECTOR WILL NOT MOVE FROM THE AWD POSITION.

Incident date: Mar 27, 2017

THE HOOD FLEW UP WHEN SAFETY LATCH FAILED TO HOLD IT,, PLUS BRAKE LINE TROUBLES AS WELL AS GAS TANK FILL PIPE ALL RUSTED OUT,, HOOD WAS ON HIGHWAY AT ABOUT 30MPH AN WRAPPED ARROUND WINDSHIELD,,

Incident date: Mar 27, 2017

THE HOOD FLEW UP WHEN SAFETY LATCH FAILED TO HOLD IT,, PLUS BRAKE LINE TROUBLES AS WELL AS GAS TANK FILL PIPE ALL RUSTED OUT,, HOOD WAS ON HIGHWAY AT ABOUT 30MPH AN WRAPPED ARROUND WINDSHIELD,,

Incident date: Mar 27, 2017

THE HOOD FLEW UP WHEN SAFETY LATCH FAILED TO HOLD IT,, PLUS BRAKE LINE TROUBLES AS WELL AS GAS TANK FILL PIPE ALL RUSTED OUT,, HOOD WAS ON HIGHWAY AT ABOUT 30MPH AN WRAPPED ARROUND WINDSHIELD,,

Incident date: Mar 31, 2017

MY MECHANIC SAID THAT THE HYDRAULIC BRAKE BOOSTER HAS BEEN MANUFACTURED IMPROPERLY WHICH RESULTED IN LEAKAGE OF THE PRESSURIZED NITRGEN GAS FROM INSIDE THE ACCUMULATOR. THE LOSS OF THIS GAS PRESSURE RESULTED IN AN ABNORMAL NOISE FROM THE LEFT SIDE OF THE DASH PANEL WHEN THE BRAKES ARE APPLIED AND CA... Read more

Incident date: Nov 17, 2016

MY MITSUBISHI MONTERO LIMITED STARTED MAKING A STRANGE NOISE FROM UNDER THE DASH WHILE DRIVING. ONE DAY WHILE DRIVING WHEN I APPLIED THE BRAKE THE PEDAL WENT ALL THE WAY TO THE FLOOR. I DID SOME RESEARCH AND FOUND A RECALL FOR THE BRAKE HYDRAULIC BOOSTER FOR THIS VEHICLE BUT MY VIN NUMBER IS NOT SHO... Read more

Incident date: Mar 5, 2017

BOTH HEAD LIGHT BEAMS SOMETIMES DISAPPEAR WHEN SWITCHING TO HIGH BEAM WHILE DRIVING LEAVING YOU DRIVING IN THE DARK WITHOUT ANY LIGHTS.

Incident date: Sep 20, 2015

TL* THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. WHEN THE STEERING WHEEL WAS TURNED LEFT OR RIGHT AT A CERTAIN ANGLE, THE HORN OF THE VEHICLE ACTIVATED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT AN UNKNOWN MODULE RELATED TO THE AIR BAG AND A RELA... Read more

Incident date: Sep 20, 2015

Incident date: Oct 30, 2014

FRAME AND UNDERCARRIAGE ROT/RUST. WAS TOLD BY ONE SHOP ABOUT IN 2013 THAT I HAD ALOT OF RUST ON THE FRAME WHEN THEY REPLACED MY RUSTED BRAKE LINES.. THIS WEEK IN OCTOBER 2014 I HAD TO REPLACE A RUSTY FILL PIPE FOR MY GAS AND THE MECHANIC TOLD ME THAT I HAD MAJOR RUST ON THE FRAME AND UNDERCARRIAGE ... Read more

Incident date: Nov 30, 2013

BROUGHT 2002 MONTERO SPORT FOR INSPECTION INSPECTOR TOLD ME THE REAR FRAME AND UNDERCARRIAGE WAS ROTTEN VEHICLE WAS NOT TO BE DRIVEN. WHAT DO I DO WITH VEHICLE NOW THAT I JUST PAID IT OFF AND I CANT DRIVE? *TR

Incident date: Jan 19, 2012

2002 MITSUBISHI MONTERO SPORT; THE CAR HORN/ALARM GOES OFF USUALLY WHEN A DROP OF TEMPERATURE OCCURS IN THE MIDDLE OF THE NIGHT. TO FIX ... HAS SOMETHING TO DO WITH A SHORT IN THE ELECTRICAL OF THE AIR BAG AND THE STEERING WHEEL COLUMN. VERY EXPENSIVE FOR A MECHANIC, OVER $1200. I HAVE TO UNHOOK MY... Read more

Incident date: Jan 19, 2012

Incident date: Jul 5, 2013

THE REAR VIEW MIRROR CHANGES AUTOMATICALLY TO NIGHT VISION YOU CAN NOT CHANGE IT BACK. IT VERY DIFFICULT TO SEE CARS BEHIND YOU WITH THE WAY IT CHANGES AND HOW CLOSE THEY ARE TO YOU. MY DAUGHTER BACKED INTO SOMEONE BECAUSE SHE COULD NOT TELL THEY WERE BEHIND HER. I HAVE HAD PROBLEMS WITH THIS ALSO. ... Read more

Crash

Incident date: May 3, 2013

TL* THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. THE CONTACT STATED THAT DURING A ROUTINE INSPECTION, THE CONTACT WAS ADVISED THAT THE FRAME WAS ROTTING AND THERE WERE TWENTY TWO INCH-LONG FRACTURES FOUND IN THE FRAME. A DEALER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRE... Read more

Incident date: Aug 22, 2011

2002 MITSUBISHI MONTERO SPORT. THE HORN SOUNDS FOR NO REASON, WHEN THE TEMPERATURE DROPS BELOW 55DEGREES. I MUST REMOVE THE FUSE TO SILENCE IT. IT IS STATE REQUIRED SAFETY EQUIPMENT. I CONTACTED THE LANCASTER, PA MITSUBISHI DEALER BUT THEY WON'T REPLY. THE PROBLEM STARTED IN THE WINTER WHEN THE... Read more

Incident date: Aug 22, 2011

Incident date: Nov 9, 2010

TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. WHILE THE VEHICLE WAS STOPPED, ANOTHER VEHICLE REAR ENDED IT AND PUSHED IT INTO THREE OTHER VEHICLES. THE FRONT PASSENGER AIR BAG PARTIALLY DEPLOYED BUT THE DRIVER SIDE FRONT AIR BAG DID NOT DEPLOY AT ALL. THE CONTACT SUSTAINED MULTIPLE INJURIES. ... Read more

Crash 1 injured

Incident date: Aug 7, 2010

TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. THE CONTACT NOTICED A FUEL LEAK WHILE SHE WAS ADDING FUEL TO THE VEHICLE. SHE TOOK THE VEHICLE TO A MECHANIC WHO DIAGNOSED THE FAILURE AS THE FUEL STORAGE TANK. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VIN WASN'T INCLUDED IN... Read more

Incident date: Nov 14, 2009

I WAS IN AN AUTO ACCIDENT AND HIT A CAR IN IT'S SIDE. I WAS GOING APPROXIMATELY 30 MPH. THE VEHICLE ALSO ROLLED ON IT'S LEFT SIDE AFTER IMPACT. I WAS THE ONLY FRONT PASSENGER. MY AIRBAG NEVER DEPLOYED. MY HEAD ENDED UP HITTING THE STEERING WHEEL. *TR

Crash 1 injured

Incident date: Feb 26, 2010

I HAVE HAD SEVERAL TIMES TO TAKE MY CAR TO A SERVICE CENTER TO HAVE MY BRAKES CHECKED AND/OR REPLACED. I HAVE A 2002 MITSUBISHI MONTERO SPORT LX THAT HAVE GIVEN ME DISCOMFORT WHEN HAVING TO STOP WHEN TRAVELING AT SPEED ABOVE 45 MPH. I HAVE BEEN TOLD THAT THE NUMBER OF TIME I HAVE REPLACE MY BRAKES... Read more

Incident date: Feb 22, 2010

TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. HE STATED THAT WHILE DRIVING 60 MPH WHEN IT WAS RAINING AND THE WIPERS WERE ON, THE LEFT SIDE WINDSHIELD WIPER EXTENDED OFF OF THE WINDSHIELD BUT IT WAS STILL ATTACHED TO THE WIPER MOTOR. HE NOTICED THAT THE WIPER WAS ALSO SLIGHTLY DETACHED FROM T... Read more

Incident date: Nov 24, 2007

HORN BUTTON WHEN THE ACCESSORY SOCKET IS IN USE OR NOT IN USE,THE HORN CONTINUES TO BLOW WHEN THE BUTTON IS RELEASED. THEREFORE THE FUSE TO THE HORN MUST BE DISCONNECTED AT ALL TIMES. I HAD IT PUT ON A DIAGNOSTIC MACHINE AND IN ORDER TO HAVE THIS FIXED IT WILL COST $1300 BECAUSE THE PROBLEM HAS TO D... Read more

Incident date: Mar 30, 2008

I WAS A PASSENGER IN A 2002 MITSUBISHI MONTERO AND WE WERE HIT HEAD ON DOING 40+ ON THE HIGHWAY. NEITHER FRONT AIRBAG DEPLOYED. I FRACTURED MY HUMOROUS REQUIRING SURGERY FOR THE INSTALLATION OF HARDWARE TO MEND THE BONE. *TR

Crash 1 injured

Incident date: May 4, 2006

MY HUSBAND AND I WERE IN A SUV ROLLOVER ACCIDENT IN MAY 4, 2006. OUR VEHICLE WAS REAR-ENDED BY ANOTHER SUV AND ULTIMATELY INVOLVED FOUR (4) VEHICLES TOTAL. THE AIRBAGS IN OUR VEHICLE DID NOT DEPLOY AND MY HUSBAND DIED LATER FROM COMPLICATIONS INDUCED BY INTERNAL BLEEDING. *TR

Crash 2 injured 1 deaths

Incident date: Nov 5, 2007

TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. DURING AN OIL CHANGE, FIRESTONE FOUND A LEAK IN THE GASKET AND VALVE. THE MECHANIC BELIEVED THE FLOW ENGINE VALVE CAUSED THE LEAK. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER. THERE HAD BEEN NO FAILURE TO DATE. THE PURCHASE DATE AND CURRENT ... Read more

Incident date: Sep 12, 2007

TL*THE CONTACT OWNS A 2002 MITSUBISHI MONTERO SPORT. WHILE DRIVING 35 MPH, THE CONTACT'S WIFE REAR ENDED ANOTHER VEHICLE. THE FRONT AIR BAGS FAILED TO DEPLOY. THE SEAT BELT DID NOT RETRACT AND SHE LUNGED FORWARD INTO THE STEERING WHEEL. HIS WIFE SUSTAINED MINOR INJURIES TO HER ARM, FACE, AND CHE... Read more

Crash 1 injured

Incident date: Feb 10, 2007

MY FAMILY AND I WERE INVOLVED IN A FOUR-CAR PILE UP. WE REAR-ENDED A 4RUNNER AT 45 MPH AND THE FRONT AIR BAGS NEVER DEPLOYED. HUSBAND HAS SEVERE BACK TROUBLE AND I SUFFER NECK AND SHOULDER PAIN. *NM

Crash 2 injured

Incident date: Feb 4, 2007

DURING COLD WEATHER (APPROXIMATELY 20 DEGREES C AND BELOW) THE HORN STARTS BLOWING AND WON'T TURN OFF UNLESS THE BATTERY IS DISCONNECTED OR THE CAR INTERIOR HAS WARMED UP. THE ONLY WAY I HAVE TO PREVENT THE HORN FROM COMING ON IS TO KEEP THE HORN/AIR/BAG ASSEMBLY WARM. I WRAP AN ELECTRIC BLANKET A... Read more

Incident date: Oct 30, 2006

DT*: THE CONTACT STATED WHILE DRIVING 40 MPH, THE VEHICLE WAS INVOLVED IN A FRONT IMPACT CRASH, AND THE AIRBAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SEAT BELT, BUT MINOR INJURIES WERE SUSTAINED TO THE BACK AND NECK. THERE WAS EXTENSIVE DAMAGE TO THE FRONT OF THE VEHICLE. THE POLICE WERE ON T... Read more

Crash 1 injured

Incident date: Nov 21, 2006

RETAINING BOLTS ON THE DRIVER'S SIDE FRONT BRAKE CALIPER FELL OUT. WHEN BRAKES WERE APPLIED AT HIGHWAY SPEED, THE CALIPER ROTATED AND STRUCK THE INSIDE OF THE WHEEL. THE WHEEL CRACKED, CAUSING THE FRONT TIRE TO GO FLAT. THIS IS THE SECOND TIME SINCE I HAVE OWNED THE VEHICLE THAT THE BRAKE CALIPER... Read more

Incident date: Oct 13, 2006

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS AT NIGHT WITH THE HEADLIGHTS ILLUMINATED, THE HEADLIGHTS INTERMITTENTLY FAILED TO ILLUMINATE WITHOUT WARNING. AFTER SEVERAL ATTEMPTS OF TURNING THE HEADLIGHT SWITCH ON AND OFF, THE HEADLIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS INSPECTED BY A ... Read more

Incident date: Jul 12, 2006

I HAD A BAD 02 SENSOR REPLACED ON MY 2002 MITSUBISHI MONTERO SPORT IN JUNE 2006. A MONTH LATER ANOTHER 02 SENSOR NEEDED TO BE REPLACED. TOTAL EXPENSE WAS $600+. *JB

Incident date: Oct 17, 2005

HARD KNOCKING NOISE AND OIL LAMP ON IMMEDIATELY AFTER OIL HAS BEEN CHANGED. CHECKED OIL, DIP STICK SHOWED NO OIL IN ENGINE. TOOK BACK TO MECHANIC WHO PERFORMED AN OIL PUMP PRESSURE TEST, DIAGNOSED WITH NO OIL PRESSURE RECOMMENDED TAKE TO DEALERSHIP. DEALERSHIP CLAIMS PROBLEM DUE TO LACK OF OIL CH... Read more

Incident date: May 30, 2005

DT: THE WINDSHIELD WIPER ARM WOULD STICK ON DRIVER'S SIDE OF THE WINDSHIELD, AND THEN IT WOULD COME BACK. THIS HAPPENED 5 OR 6 TIMES, THEN THE WINDSHIELD WIPER ARM GOT STUCK OVER THE WINDSHIELD MOLDING. WHEN THE CONSUMER GOT OUT OF VEHICLE TO ADJUST THE PROBLEM HE NOTICED IT WAS LOOSE FROM THE B... Read more

Incident date: Jan 17, 2005

ONE DAY SEAT BELT LIGHT STOPPED FUNCTIONING WHEN SEAT BELT NOT SECURED. WORKS WHEN CAR IS STARTED, FLASHES AS NORMAL, BUT WHEN YOU UNDO THE BELT, YOU GET NO WARNING LIGHT ON DASH. TOOK TO THE DEALERSHIP WHO KEPT TRUCK FOR TWO DAYS ONLY TO CALL ME BACK AND ADVISE FUNCTIONING AS DESIGNED. CALLED MITSU... Read more

Incident date: Dec 3, 2003

WHILE DRIVING WITH VEHICLE IS AT FULL CAPACITY IT SHUTTERS. TRANSMISSION VIBRATES, AND THEN TAKE OFF, IS VERY SLUGGISH. VEHICLE WAS TAKEN REPAIR SHOP FOUR TIMES. HOWEVER, THE PROBLEM WAS NOT RESOLVED. *AK

Incident date: May 25, 2004

AT ALL TIMES EMERGENCY PARKING BRAKE LIGHT STAYS ON. THE DEALER CLAIMS THAT ALTHOUGH THE LIGHT IS ON EMERGENCY BRAKES ARE WORKING.*AK

Incident date: Feb 18, 2004

SAME PROBLEM AS WITH THE COMPLAINT LISTED BELOW. I BLAMED MY MECHANIC AND NEARLY SUED HIM FOR FAILURE TO PROPERLY MAINTAIN MY SUV. RESEARCH HAS PROVEN THIS TO BE NOT AN ISOLATED INCIDENT. CONSUMER COMPLAINT: ODI CASE NUMBER: 10054255 COMPONENT: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL DE... Read more

Incident date: Apr 1, 2004

+BRAKE PADS MUST BE CHANGED BECAUSE OF PREMATURE WEAR. MILEAGE: 17,000.IF THE TRUCK IS STOPPED, AND YOU PRESS THE ACCELERATOR, YOU FEEL LIKE IT WOULD STALL, BUT IT KEEPS GOING.*AK

Incident date: Apr 1, 2004

+BRAKE PADS MUST BE CHANGED BECAUSE OF PREMATURE WEAR. MILEAGE: 17,000.IF THE TRUCK IS STOPPED, AND YOU PRESS THE ACCELERATOR, YOU FEEL LIKE IT WOULD STALL, BUT IT KEEPS GOING.*AK

Incident date: Jan 2, 2004

DEALERSHIP SAID THERE IS SLUDGE IN ENGINE DUE TO "LACK OF PROPER MAINTENANCE". WE'VE HAD THE OIL CHANGED ACCORDING TO THE MANUAL BUT BELIEVE THAT THE OIL PAN IS POSITIONED WRONG AS THE DEALERSHIPS TOLD US THAT ABOUT 1/4 INCH TO 1/2 INCH IS ALWAYS LEFT IN THE BOTTOM OF THE OIL PAN WHEN YOU CHANGE TH... Read more

Incident date: Jan 2, 2004

WHILE MAKING A RIGHT TURN THE TRUCK FAILED TO RESPOND. THE DEALER SERVICED THE TRANSFER CASE BOX. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM

PROBLEMS WITH VEHICLE LOSING POWER AND CUTTING OFF.*MR VEHICLE RUNS ROUGH WHEN DRIVING UPHILL. VEHICLE STALLED. *TS

Incident date: Sep 28, 2003

AIR BAG DID NOT DEPLOY.

Crash 1 injured

Incident date: May 19, 2003

AT ONLY 15 MILES PER HOUR, OUR MITSUBISHI MONTERO SPORT ROLLED OVER AND THE CAR WAS TOTALLED.*AK

Crash

Showing 50 of 63 complaints.

Technical Service Bulletins — 2002 MITSUBISHI MONTERO SPORT

77 manufacturer communications from 46 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
070000 FUEL SYSTEM, GASOLINE	7
980000 UNKNOWN OR OTHER	6
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	5
350000 EQUIPMENT	5
100000 POWER TRAIN	5
020000 SUSPENSION	4
160000 STRUCTURE	4
061000 ENGINE AND ENGINE COOLING:ENGINE	4

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023.

160000 STRUCTURE

This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross veh

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 2nd quarterly technician quiz for 2023.

980000 UNKNOWN OR OTHER

This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.

120000 EXTERIOR LIGHTING

350000 EQUIPMENT