1999 MITSUBISHI ECLIPSE SPYDER

2 recalls, 11 complaints - 58 TSBs

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS COND... Read more

Consequence

IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Remedy

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

222 vehicles affected

Manufacturer: AIRTEX PRODUCTS

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Remedy

DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED T... Read more

567,432 vehicles affected

Manufacturer: MITSUBISHI AMERICA

Complaint Statistics

11 total complaints

Top Reported Components

Component	Complaints
POWER TRAIN:AUTOMATIC TRANSMISSION	4
ENGINE AND ENGINE COOLING:ENGINE	3
POWER TRAIN:CLUTCH ASSEMBLY	1
VISIBILITY:SUN/MOON ROOF ASSEMBLY	1
WHEELS	1
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT	1

Incident date: Aug 1, 2008

TRANSMISSION STICKING BETWEEN 40-60 MILES PER HOUR AT 3000 RPMS AND HAS A PROBLEM SHIFTING DOWN CAUSING THE "SERVICE ENGINE SOON" LIGHT TO COME ON. THE PROBLEM HAPPENS ON THE SAME 2 ROADS IN THE SAME EXACT SPOT. I HAD THE PULSE GENERATORS IN THE TRANSMISSION REPLACED AND ONE WEEK LATER IT WAS DOIN... Read more

Incident date: Sep 12, 2006

I PURCHASED A 1999 MITSUBISHI ECLIPSE SPYDER CONVERTIBLE 6-15-06. AFTER DRIVING THE CAR 3 MONTHS THE "SERVICE ENGINE SOON" LIGHT CAME ON. I WAS OUT OF TOWN SO TOOK TO NEAREST CAR REPAIR STATION. THEY RESET LIGHT & RCVD CODE P1750. WHEN I RTND HOME I TOOK IT IN FOR SERVICE & TO RESET THE CHECK ENGI... Read more

Incident date: Jul 15, 2006

I PURCHASED A USED 1999 MITSUBISHI ECLIPSE SPYDER IN AUG 2006. THE FIRST TIME I DROVE IT THE SERVICE ENGINE SOON LIGHT CAME ON. I TOOK TO A SHOP, THEY FOUND NOTHING WRONG & RESET THE BUTTON. WHEN I RETURNED HOME THE SES LIGHT WAS ON AGAIN & I TOOK TO TRANSMISSION SHOP TO SEE WHY?THEY FOUND NOTHIN... Read more

Incident date: Mar 7, 2005

LOWER BALL JOINTS. *JB

Incident date: Jul 1, 2005

NORMAL DRIVING CONDITIONS ON 1999 ECLIPSE GS SPYDER HAVE LEAD TO THE BENDING OF RIMS ON 2 OUR OF 4 WHEELS. EXCESSIVE VIBRATION AND UNABLE TO PASS PA STATE INSPECTION. WHEELS WILL NEED TO BE REPLACED IN ORDER TO MAINTAIN "LEGAL" REGISTRATION IN PA STATE.

Incident date: Feb 14, 2005

I WENT OUT TO START MY 1999 ECLIPSE SPYDER AND THE DRIVE BELT CAME OFF. TOOK THE CAR TO A DEALER WAS INFORMED THAT THE HARMONIC BALANCER HAD BROKEN OFF. *JB

Incident date: Aug 3, 2003

CONVERTIBLE TOP LINKS BENT, REAR WINDOW STITCHING FAILURE. TOP WILL NOT GO DOWN DUE TO PREVIOUS. JUST HAPPENED OVERNIGHT. ONE DAY IT WASN'T THERE, THE NEXT THE LINKS WERE BENT. DEALER STATES THIS IS JUST NORMAL WEAR & TEAR AND THE LINKS BENT ARE THE MOST COMMON PROBLEM WITH THIS TOP. *AK

Incident date: Aug 20, 2003

MAIN BEARING FAILURE @ 65,000 MILES. DEALERSHIP WOULD NOT REPLACE, OR REPAIR. THIS IS A COMMON PROBLEM WITH THIS MODEL. I AM ON MY 2ND MOTOR WITH THE SAME PROBLEM.*AK

Incident date: Nov 1, 2001

INITIAL FAILURE OF TRANSMISSION RESULTED IN TOW ON MAJOR HIGHWAY; REPLACEMENT FAILURE RESULTED IN TOW ON MAJOR HIGHWAY; STILL NO RESOLUTION TO PROBLEM. *AK

Incident date: Aug 28, 2001

CRANKSHAFT PULLEY FAILED BECAUSE INNER AND OUTER RINGS SEPARATED. DEALERSHIP CONTACTED AND REPORTED THAT THEY ARE SEEING THIS ON A FREQUENT BASES. MECHANIC AND DEALERSHIP AGEE THAT INSUFFENCIENT GLUE USED TO SEAL RINGS TOGETHER.

WHILE DRIVING THE CLUTCH BROKE INTO PIECES/DISINTEGRATED, THERE WERE NO SIGNS OF A PROBLEM WITH THE CLUTCH. NLM

Technical Service Bulletins, 1999 MITSUBISHI ECLIPSE SPYDER

58 manufacturer communications from 31 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
100000 POWER TRAIN	5
070000 FUEL SYSTEM, GASOLINE	5
350000 EQUIPMENT	4
200000 WHEELS	3
060000 ENGINE AND ENGINE COOLING	3
110000 ELECTRICAL SYSTEM	3
020000 SUSPENSION	2
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM	2

980000 UNKNOWN OR OTHER

This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.

120000 EXTERIOR LIGHTING

350000 EQUIPMENT