2003 MITSUBISHI FUSO FH210

8 recalls — 0 complaints — 50 TSBs

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

MITSUBISHI FUSO TRUCK OF AMERICA (MFTA) IS RECALLING 156 HALOGEN SEALED BEAM HIGH BEAM HEADLAMP ASSEMBLIES SOLD BETWEEN OCTOBER 24, 2007 AND DECEMBER 2, 2008 FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN MITSUBISHI FUSO TRUCKS. THESE LAMPS FAIL TO CONFORM TO THE SAE STANDARDS OR RECOMMENDED PRACTICE... Read more

Consequence

THE PURPOSE OF THIS STANDARD IS TO REDUCE DEATHS AND INJURIES FROM MOTOR VEHICLE CRASHES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.

Remedy

MFTA WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 15, 2009. OWNERS MAY CONTACT MFTA AT 1-856-467-4500.

156 vehicles affected

Manufacturer: MITSUBISHI FUSO TRUCK OF AMERICA, INC.

POWER TRAIN:AUTOMATIC TRANSMISSION

Defect Description

MITSUBISHI FUSO IS RECALLING 15,549 MY 1999-2004 FE639, FE649, AND FG639 TRUCKS; MY 2001-2004 FE640, AND MY 2003-2004 FH210 TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS. NORMAL HEAT EMANATING FROM THE EXHAUST PIPE MAY CAUSE THE AUTOMATIC TRANSMISSION SHIFT LINKAGE TO DEFORM. THE EFFORT REQUIRED TO... Read more

Consequence

THE SHIFT CONTROL LEVER MAY BECOME INOPERATIVE, OR THE PHYSICAL SHIFT LEVER POSITION ON THE SHIFT LEVER HOUSING GEAR INDICATOR MAY NOT MATCH THE ACTUAL GEAR SELECTION AT THE TRANSMISSION.

Remedy

DEALERS WILL INSTALL A MODIFIED AUTOMATIC TRANSMISSION SHIFT CONTROL LEVER ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 6, 2008. OWNERS MAY CONTACT MITSUBISHI FUSO AT 1-856-467-4500.

15,549 vehicles affected

Manufacturer: MITSUBISHI FUSO TRUCK OF AMERICA, INC.

ENGINE AND ENGINE COOLING

Defect Description

ON CERTAIN MEDIUM DUTY TRUCKS, THE CYLINDER HEAD IDLER GEAR SHAFT BOLT MAY HAVE BEEN INSUFFICIENTLY TIGHTENED DURING INITIAL ASSEMBLY. CONTINUED OPERATION IN THIS CONDITION COULD CAUSE THE BOLT TO LOOSEN, RESULTING IN ABNORMAL NOISE FROM IMPROPER GEAR ALIGNMENT.

Consequence

THE BOLT COULD BREAK, CAUSING THE ENGINE TO STALL AND NOT RESTART, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL CHECK THE IDLER SHAFT BOLT. IF THE BOLT CANNOT BE REMOVED BY HAND, A MODIFIED IDLER SHAFT BOLT WILL BE INSTALLED. IF THE BOLT IS LOOSE ENOUGH TO BE REMOVED BY HAND, A NEW IDLER GEAR, IDLER SHAFT, AND A MODIFIED IDLER SHAFT BOLT WILL BE INSTALLED. THE RECALL BEGAN ON DECEMBER 20, 2005... Read more

1,848 vehicles affected

Manufacturer: MITSUBISHI FUSO TRUCK OF AMERICA, INC.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT

Defect Description

ON CERTAIN MEDIUM DUTY TRUCKS, RUST BUILD-UP ON THE AUTOMATIC TRANSMISSION (A/T) SHIFT LINKAGE MAY CAUSE THE LINKAGE TO BIND. RUST BUILD-UP IS ACCELERATED IN GEOGRAPHIC LOCATIONS THAT ARE SITUATED NEAR LARGE BODIES OF SALT WATER, OR IN REGIONS WITH HEAVY SNOW/ICE MELTING COMPOUND USAGE IN WINTER MO... Read more

Consequence

THE EFFORT REQUIRED TO OPERATE THE A/T SHIFT CONTROL LEVER MAY INCREASE IF THE LINKAGE BINDS DUE TO RUST BUILD-UP. THE SHIFT CONTROL LEVER MAY BECOME INOPERATIVE, OR THE PHYSICAL SHIFT LEVER POSITION ON THE SHIFT LEVER HOUSING GEAR INDICATOR MAY NOT MATCH THE ACTUAL GEAR SELECTION AT THE TRANSMISSI... Read more

Remedy

DEALERS WILL INSTALL A MODIFIED A/T SHIFT CONTROL LEVER ASSEMBLY. THE RECALL BEGAN ON SEPTEMBER 26, 2005. OWNERS MAY CONTACT MITSUBISHI FUSO AT 1-856-467-4500.

15,549 vehicles affected

Manufacturer: MITSUBISHI FUSO TRUCK OF AMERICA, INC.

ENGINE AND ENGINE COOLING

Defect Description

ON CERTAIN MEDIUM DUTY TRUCKS, THE REAR ENGINE SUPPORT BRACKET IS COMPOSED OF MATERIALS OF INSUFFICIENT STRENGTH. NORMAL VEHICLE VIBRATIONS MAY CAUSE THE BRACKET TO CRACK.

Consequence

IF THE VEHICLE IS CONTINUALLY OPERATED IN THIS CONDITION, THE BRACKET MAY BREAK APART, CAUSING THE TRANSMISSION TO DROP OUT OF ALIGNMENT WITH THE DRIVE TRAIN.

Remedy

DEALERS WILL INSTALL A MODIFIED REAR ENGINE SUPPORT BRACKET. THE RECALL BEGAN ON SEPTEMBER 26, 2005. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-856-467-4500.

15,307 vehicles affected

Manufacturer: MITSUBISHI FUSO TRUCK OF AMERICA, INC.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

Defect Description

ON CERTAIN TRUCKS, THE RUBBER PORTION OF THE FUEL INJECTION PIPE CLAMPS COULD DETERIORATE. NORMAL VEHICLE OPERATION COULD CAUSE THE DETERIORATED CLAMP TO LOOSEN AND DRIP.

Consequence

IF THIS CONDITION OCCURS IN THE AREA OF THE FUEL INJECTION PUMP, THE ENGINE STARTER COULD SHORT CIRCUIT IF THE CLAMP DROPS ONTO THE STARTER TERMINAL. THIS COULD PREVENT THE ENGINE FROM STARTING. EXCESSIVE HEAT FROM THE SHORT CIRCUIT COULD CAUSE A FIRE.

Remedy

DEALERS WILL REMOVE EACH CLAMP AND INSPECT FOR RUBBER DETERIORATION AND WILL REPLACE THE CLAMP IF THE RUBBER DETERIORATION IS EVIDENT. DEALERS WILL REPLACE THE ATTACHING HARDWARE AND APPLY ADHESIVE TO PREVENT THE BOLTS/NUTS FROM LOOSENING AND INSPECT FOR A RUBBER CAP ON THE STARTER MOTOR'S TERMINAL... Read more

3,674 vehicles affected

Manufacturer: MITSUBISHI FUSO TRUCK OF AMERICA, INC.

SUSPENSION:FRONT:HUB

Defect Description

ON CERTAIN TRUCKS TRUCKS EQUIPPED WITH AN F040T FRONT AXLE. THE FRONT WHEEL HUB OUTER BEARING LOCK NUT MAY HAVE BEEN IMPROPERLY TIGHTENED DURING ASSEMBLY, AND AN INSUFFICIENT AMOUNT OF GREASE MAY HAVE BEEN APPLIED TO THE OUTER BEARING.

Consequence

THESE CONDITIONS COULD RESULT IN THE OUTER BEARING GENERATING EXCESSIVE HEAT AND/OR BREAKING, CAUSING THE VEHICLE TO BECOME DISABLED. THE EXCESSIVE HEAT COULD CAUSE A FIRE.

Remedy

DEALERS WILL INSPECT THE INNER AND OUTER FRONT WHEEL HUB BEARINGS, AND REPLACE ANY BEARING WITH SIGNS OF DAMAGE. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-856-467-4500.

2,537 vehicles affected

Manufacturer: MITSUBISHI FUSO TRUCK OF AMERICA, INC.

SUSPENSION:FRONT:WHEEL BEARING

Defect Description

ON CERTAIN MEDIUM DUTY TRUCKS, THE FRONT HUB OUTER WHEEL BEARING MAY BECOME DAMAGED DUE TO IMPROPER LUBRICATION.

Consequence

THIS COULD CAUSE SMOKE FROM THE AREA OF THE FRONT WHEEL HUB, OR THE VEHICLE COULD BECOME INOPERABLE DUE TO BEARING SEIZURE, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL INSPECT THE WHEEL HUB BEARINGS, AND IF THE BEARINGS SHOW A SIGN OF DAMAGE OR BREAKAGE, WILL REPLACE THE BEARING WITH A NEW ONE. OWNER NOTIFICATION BEGAN AUGUST 20, 2003. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-877-711-0707.

1,913 vehicles affected

Manufacturer: MITSUBISHI FUSO TRK, AMER

No complaints found for this vehicle.

Technical Service Bulletins — 2003 MITSUBISHI FUSO FH210

50 manufacturer communications from 20 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	6
100000 POWER TRAIN	6
110000 ELECTRICAL SYSTEM	4
350000 EQUIPMENT	4
070000 FUEL SYSTEM, GASOLINE	4
160000 STRUCTURE	4
200000 WHEELS	3
060000 ENGINE AND ENGINE COOLING	3

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross veh

160000 STRUCTURE

This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 2nd quarterly technician quiz for 2023.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Technical Service Bulletin was sent to dealers to provide instructions and Material Safety Data Sheets for Biosol 100 use.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Technical Information Notice was sent to dealers reminding them of the importance of customer satisfaction.

110000 ELECTRICAL SYSTEM

Tech Talk is a service newsletter that was sent out to dealers. It covers various topics and reviews the previous months publications.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Tech Talk is a service newsletter that was sent out to dealers. It covers various topics and reviews the previous months publications.

160000 STRUCTURE

This Technical Information Notice was sent to dealers informing that MMNA has recently received information from Mitsubishi Motors Corporation (MMC) about the effects of the Waterborne (WB) paint process on Mitsubishi vehicles.

350000 EQUIPMENT

160000 STRUCTURE

This Technical Service Bulletin informs dealers they may find a stain or cloudy spot on the body panels after removing the transportation film.due to improper installation of the film.This TSB instructs the dealers of the repair procedure f

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

100000 POWER TRAIN

SUBJECT: AISIN Transmission Repeat Failure Diagnosis Process MODELS: FE639, FE640, FE649, FG639, FH210, FE83D, FE84D, and FE85D DESCRIPTION: This process must be followed for any AISIN transmission assembly that fails during the 12

200000 WHEELS