2012 MINI COOPER

1 recalls, 96 complaints - 196 TSBs

ELECTRICAL SYSTEM

Defect Description

BMW of North America, LLC (BMW) is recalling certain 2008-2014 MINI Clubman Cooper, Clubman Cooper S, Clubman John Cooper Works, and 2007-2013 MINI Hardtop 2-Door Cooper, Cooper S, and John Cooper Works vehicles sold, or ever registered, in Alaska, Colorado, Connecticut, Delaware, Illinois, Indiana,... Read more

Consequence

An electrical short-circuit can increase the risk of a fire.

Remedy

Dealers will inspect the sunroof drains, interior footwell area, and FRM and, depending upon the results of the inspection, certain components will be replaced. Owner notification letters were mailed May 13, 2024. Owners may contact BMW customer service at 1-866-825-1525.

97,933 vehicles affected

Manufacturer: BMW of North America, LLC

Complaint Statistics

96 total complaints 2 crashes 15 fires 2 injuries

Top Reported Components

Component	Complaints
ENGINE	19
ELECTRICAL SYSTEM	13
AIR BAGS	11
SERVICE BRAKES	7
UNKNOWN OR OTHER	7
FUEL/PROPULSION SYSTEM	4
SEATS	4
EXTERIOR LIGHTING	3
POWER TRAIN	3
AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER	3

Incident date: May 24, 2026

"On Friday afternoon, while driving alone on an open stretch of road at approximately 40 mph, my 2025 Honda Pilot's Collision Mitigation Braking System (CMBS) experienced a catastrophic malfunction and initiated full emergency braking. The brakes locked up aggressively with absolutely no vehicles, p... Read more

1 injured

Incident date: Feb 1, 2023

I have been in need of a repair for the C4B recall for well over a year. My truck is unsafe to drive. No ABS, no traction control, no cruise control. I also cannot use 4wd with this issue. My truck has been undriveable for this time frame.

Incident date: Mar 2, 2025

None of the following recalls have been corrected/ or the update to 2.2, have been completed on my vehicle Recalls are not being done or parts provided. I am being told I have to use an approved service provider and the requires me to drive 350 mile and pay for the labor. 24V865000 (Regen Braking... Read more

Incident date: Dec 4, 2024

The vehicle stalls when driving and breaks suddenly. The dealership said that there was a problem with the fuel pump similar to other recalls but this vin is not included in the recall

Incident date: Aug 16, 2024

The contact owns a 2020 Ford Mustang. The contact stated while driving at an undisclosed speed, the instrument panel became inoperable. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the APIM and FCIM had failed and needed to be replaced and reprogrammed. The vehi... Read more

Incident date: Jan 9, 2024

I see there is a recall related to a fault that may prevent the rearview camera image from booting up and being displayed on the dash for 2017 - 2020 Fits. While relatively uncommon, this also happens on my 2015 Fit. In addition, sometimes the Lane Watch feature shows the backup camera instead of... Read more

Incident date: May 1, 2024

I was driving and I received a drive motor failure. I lost all ability to accelerate and once under 7 mph the car shuddered to a stop. The dash shut down immediately. After exiting the vehicle and locking it, I rendered and the car seemed operational. I drove again to try to return home with the s... Read more

Incident date: Feb 9, 2024

Passenger side airbag error code is displayed on my dash. It is error code B1018 occupant sensor malfunction.

Incident date: May 12, 2023

We have a 09 Toyota Rav4 with a Blizzard Pearl paint that continues to fail. Apparently there were notices sent out in 2022 indicating a recall that would cover these repairs. We were unaware of these notices and continue to experience paint degradation on multiple areas of the car. I have contacte... Read more

Incident date: Nov 9, 2023

The contact owns a 2015 Ford Escape. The contact stated upon entering the rear passenger’s door, the contact became aware that the door failed to securely latch closed. The door-ajar warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was ... Read more

Incident date: Nov 9, 2023

Well this is the second time in a week. “service transmission” comes on the dash and turns vehicle off. Cannot do anything but put in park. Sit for 10 to 15 mins and the vehicle will turn on again. Has no codes for the dealer to check. Will not drive again until its fixed.

Incident date: Feb 23, 2024

Me and my son were traveling on a business road trip from my home in Lincoln, CA to do business at several companies and end up at a customer located in Anaheim, CA. We started on [XXX] in Roseville, CA highway Interstate [XXX] traveling towards Anaheim with stops along the way. We were coming do... Read more

Incident date: Feb 23, 2024

Incident date: Feb 5, 2024

Cluster gauge shuts off in cold weather. This gauge has the odometer and gas gauge.

Incident date: Sep 1, 2023

Front Passenger Seat Headrest deployed from broken plastic that failed and released the headrest while parked and car is off. Concussion risk while driving No inspection yet by dealer or police/insurance No prior warning

Incident date: Sep 1, 2023

I have taken my car to the shop multiple times for brake issue. Brakes smoking and calibers will not release on rear driver side brakes. I took my car to Marmet Tire paid 380 they said it was was brakes and calibers two weeks later same issue I paid 280 for actuator since problem still not fixed. ... Read more

Incident date: Sep 1, 2023

As I was driving on the interstate, 25 or so miles away from, my car started to shake and the service lights appeared on the dashboard. I pulled to the shoulder of the road, and shut it off, i turned it back on and it ran for maybe about 10 more miles until it happened again. This time, I turn it b... Read more

Incident date: Sep 18, 2023

Vehicle had 14,000 miles and tires were rotated by dealership twice, last one 3 weeks ago. Was driving 55 mph and had a sudden complete deflation and stopped immediately. Tire is completely separated. The outer sidewall is completely separated from the rest of the tire. The tire has never had an inj... Read more

Incident date: Jul 6, 2023

The side view mirrors are positioned in a way that completely blocks visibility on the sides of the car, especially when making a left-hand turn. After owing the vehicle for several weeks, I collided with another car when making a left-hand turn. I couldn't see the car when turning until it was too ... Read more

Crash

Incident date: Sep 20, 2023

The contact owns a 2013 Hyundai Elantra. The contact stated while driving 30-35 MPH and making a turn, the steering wheel made an abnormal clicking sound. There was no warning light illuminated. The contact stated that the failure had been recurring while driving. The vehicle was taken to an indepen... Read more

Incident date: May 1, 2023

The contact owns a 2010 Lexus ES350. The contact stated that he had noticed a sticky texture on the dashboard directly in the driver's view. The contact stated that while driving, the sticky texture reflected onto the windshield impairing his vision. The vehicle was taken to a local collision center... Read more

Incident date: Aug 21, 2023

The contact owns a 2020 Ford Explorer. The contact stated while his wife was driving at an undisclosed speed down a steep driveway, upon depressing the brake pedal, the vehicle failed to come to a complete stop. The driver was able to bring the vehicle to a complete stop by shifting into park. The h... Read more

Incident date: Aug 7, 2023

Car has a steering/pull issue. Car will pull to the right when driving on a flat straight road. Steering wheel will tighten up and then the pull starts to occur. Resistance must be applied in order to keep the car on the road. The lane keep safety feature has to be turned completely off or car will ... Read more

Incident date: May 31, 2023

The contact owns a 2020 Ford Escape. The contact stated that upon opening the driver's side, the door fractured. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the spot weld on the driver's side door had fractured from t... Read more

Incident date: May 2, 2022

Footwell module is not working due to rear left blinker is not signaling only the front light does work when turning left.

Incident date: May 2, 2022

Footwell module is not working due to rear left blinker is not signaling only the front light does work when turning left.

Incident date: Jan 10, 2022

Passenger side airbag light on with no one in seat, had it checked, the repair shop stated that there is a seat sensor fault, the code is 93c3(passenger seat occupancy detector). I have done some research on this and it seems that this a common problem, but there hasn't been any recalls by Mini, and... Read more

Incident date: Jan 10, 2022

Incident date: Mar 2, 2022

The failed component is the "Footwell Relay Module" (FRM) which enables communication between the instrument panel in the passenger compartment and the engine control components in the engine compartment. When this component fails the following essential controls become inoperable: emergency flash... Read more

Incident date: Jul 1, 2021

This car was maintained, by Mini and BMW authorized mechanics and only had OEM parts installed and followed management of vehicle as directed by manufacturer, throughout its history. It was always driven and kept in moderate weather conditions, no extreme heat, cold, wet, or speeds. Used almost dail... Read more

Incident date: Jul 1, 2021

Incident date: Sep 8, 2020

MINI COOPER BASE MODEL WITH 90K MILES HAS SEAT BELT AND AIR BAG WARNING LIGHTS ILLUMINATED. WARNING LIGHTS STARTED INTERMITTENTLY GOING ON AND OFF AND NOW STAY ILLUMINATED CONTINOUSLY WHEN IGNITION IS ON. NO VEHICLE ACCIDENTS OR INCIDENTS TO CAUSE THIS PROBLEM.

Incident date: Sep 8, 2020

Incident date: Aug 25, 2020

BOUGHT MINI FROM CARVANA A JANUARY 2020 AND HAVE HAD TOO MANY PROBLEMS. CAR OVERHEATED ON 48, HAD 2 NEW CYLINDERS PUT IN, 2 WEEKS LATER, DUE TO MANY NOTABLE PROBLEMS THIS CAR HAS HAD, ALL COOLANT LEAKED OUT AND WAS QUOTED BY MINI DEALERSHIP $9,000 TO FIX A PROBLEM THAT WAS CAUSED BY A RECALL NOT LIS... Read more

Fire

Incident date: Aug 25, 2020

Fire

Incident date: Aug 25, 2020

Fire

Incident date: Sep 1, 2020

THE PASSENGER AIRBAG WARNING SAFETY LIGHT COMES ON AND STAYS ON WHEN NO-ONE OR SOMEONE IS SITTING IN THE PASSENGER SEAT WITH AND WITHOUT THEIR SEATBELT FASTENED. I SEARCHED ONLINE REGARDING THIS AND FOUND SEVERAL OTHER PEOPLE EXPERIENCING THE SAME ISSUE. SINCE THIS IS POTENTIALLY A SAFETY HAZARD TO ... Read more

Incident date: Dec 23, 2019

MY MOTHER WHO OWNS THIS 2012 MINI COOPER HAS SUDDENLY NOW STARTED HAVING ISSUES WITH HER WATER PUMP LEAKING. I TOOK IT TO THE DEALERSHIP AND WAS TREATED WITH THIS RUDE EMPLOYEE BY CHRISTOPHER GUZMAN WHOM HAD A VERY UNPROFESSIONAL AND NO EMPATHY. VERY SHORT WITH RESPONSES AND SARCASM.KEEP IN MIND MY... Read more

Incident date: Apr 1, 2019

MY DRIVER SIDE BRAKE LIGHT KEEPS MELTING. THE PLASTIC THE THE LIGHT BUILD SCREWS INTO IS ACTUALLY MELTING T THE BRAKE LIGHT BULB. I'VE PAID MINI TO REPAIR THE DAMAGE AND THE SAME ISSUES HAS SURFACED. THE DRIVER'S SIDE BRAKE LIGHT DOES NOT WORK AT ALL.

Incident date: Apr 14, 2019

HANDBRAKE HARNESS NOT ROUTED AS DESIGNED. FROM THE PICTURE YOU CAN SEE THE HARNESS NOT INSIDE THE CLIP. THIS MAKES THE HANDBRAKE HARNESS SHORT FROM POINT TO POINT. WHICH WILL LEAD TO MY REAR PASSENGER SIDE BRAKE ALWAYS ON. AND ALSO, IT WILL CAUSE A SERIOUS SAFETY ISSUE IF I WANT TO USE MY HANDBRA... Read more

Incident date: Apr 14, 2019

Incident date: Feb 24, 2019

PASSENGER OCCUPANCY SENSOR IS MALFUNCTIONING LEADING TO THE PASSENGER AIRBAG BEING DISABLED WHILE IN MOTION. A PERSON SITTING IN THE PASSENGER SEAT TRIGGERS THE AIRBAG SENSOR WARNING AND DISABLING OF THE AIRBAG. WHILE THE PERSON IS SITTING IN THE PASSENGER SEAT, THE WARNING CAN COME ON AND OFF, AND ... Read more

Incident date: Feb 24, 2019

Incident date: Dec 12, 2018

WHILE DRIVING FOR ABOUT 30 MINUTES ON THE HIGHWAY, MY MINI COOPER SHUT OFF COMPLETELY, I WAS ABLE TO PULL ONTO THE SHOULDER AND THAT IS WHEN SMOKE STARTED COMING FROM THE ENGINE, WITHIN 6 MINUTES MY WHOLE ENGINE WAS ENGULFED IN FLAMES, CAR TOTALED. INSURENCE INSPECTORS COULDN'T FIGURE OUT A CAUSE. ... Read more

Fire

Incident date: Dec 12, 2018

Fire

Incident date: Aug 13, 2018

VEHICLE WAS IN MOTION ON A HIGHWAY AND, AFTER GOING OVER SEVERAL POT HOLES, THE ENGINE TEMPERATURE WARNING LIGHT CAME ON. THE ENGINE POWER WAS REDUCED, AND THE ENGINE FAILURE LIGHT ALSO APPEARED. THIS IS WHEN I PULLED OVER INTO THE OFF RAMP, AND THE VEHICLE CAME TO A SPUTTERING STOP. I PLACED THE CA... Read more

Fire

Incident date: Aug 13, 2018

Fire

Incident date: Aug 13, 2018

Fire

Incident date: Aug 13, 2018

Fire

Showing 50 of 96 complaints.

EPA Fuel Economy, 2012 MINI COOPER

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.6L 4-cyl, Automatic (S6) (Front-Wheel Drive)	27.0	35.0	30.0	Premium	$2,550
1.6L 4-cyl, Manual 6-spd (Front-Wheel Drive)	29.0	36.0	32.0	Premium	$2,400

CO2 Emissions: -1.0 g/mile (Minicompact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2012 MINI COOPER

196 manufacturer communications from 88 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE (PWS)	34
110000 ELECTRICAL SYSTEM	34
350000 EQUIPMENT	24
060000 ENGINE AND ENGINE COOLING	23
030000 BRAKES (PWS)	6
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	5
353000 EQUIPMENT:ELECTRICAL	5
200000 WHEELS	4

160000 STRUCTURE

Cavity protection applied to underside of the hood is leaking out onto the wheel arch trim and grille.

110000 ELECTRICAL SYSTEM

MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, m

110000 ELECTRICAL SYSTEM

New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. These new wheel electronics will need to be programmed using the new tool when replaced or when d

200000 WHEELS

350000 EQUIPMENT

220000 SEATS

OC3 SEAT OCCUPANCY MAT - LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES: Component-Specific Limited Warranty Extension For the above-referenced vehicles, MINI USA, a division of BMW of North America, LLC (MINI USA) is extending the li

070000 FUEL SYSTEM, GASOLINE

CLASS ACTION SETTLEMENT: N14 HIGH-PRESSURE FUEL PUMP (HDP) SERVICE BENEFIT CLASS VEHICLES: The MINI vehicle may experience a sudden engine operational failure reduced or loss of power while driving and the malfunction indicator lamp (MIL) m

110000 ELECTRICAL SYSTEM

060000 ENGINE (PWS)

060000 ENGINE AND ENGINE COOLING

"Service Action: Retrofit of the Engine Coolant Temperature Sensor. Internal corrosion could form in the engine coolant temperature sensor. This corrosion leads to internal bridging of the contacts, which can cause an inaccurate engine temp

162300 STRUCTURE:BODY:DOOR

Service Action: Checking or Replacing the Door Sill Trim Strips. The door sill trim strips are deformed and/or peeling up at the corners. CAUSE: Insufficient surface preparation of the door sill.

350000 EQUIPMENT

Service Action: Checking or Replacing the Door Sill Trim Strips. The door sill trim strips are deformed and/or peeling up at the corners. CAUSE: Insufficient surface preparation of the door sill.

356000 EQUIPMENT ADAPTIVE/MOBILITY

Service Action: Checking or Replacing the Door Sill Trim Strips. The door sill trim strips are deformed and/or peeling up at the corners. CAUSE: Insufficient surface preparation of the door sill.

353000 EQUIPMENT:ELECTRICAL

Air Conditioning System Leak Testing. The customer complains of poor or no air conditioning cooling. After further diagnosis, the system is found to be low or empty of a refrigerant charge, but when using an electronic leak detector, no lea

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

110000 ELECTRICAL SYSTEM

N16 ENGINE IGNITION COILS: LIMITED WARRANTY EXTENSION TO 10 YEARS/120000 MILES This Service Information bulletin supersedes SI M01 08 17 dated February 2018.

060000 ENGINE (PWS)

N16 ENGINE IGNITION COILS: LIMITED WARRANTY EXTENSION TO 10 YEARS/120000 MILES This Service Information bulletin supersedes SI M01 08 17 dated February 2018.

350000 EQUIPMENT

OC3 SEAT OCCUPANCY MAT: LIMITED WARRANTY EXTENSION TO 10 YEARS/120.

100000 POWER TRAIN

"MANUAL TRANSMISSION - STIFF DIAGONAL GEARSHIFT LEVER MOVEMENT. The customer may complain of a ""stiff diagonal shift"" (e.g., N-R, R-N, 2-3/3-2 or 4-5/5-4). Also, in some cases, gears cannot be selected, or the selector gear does not go in

060000 ENGINE AND ENGINE COOLING

ENGINE CRANKS, NO START AND/OR ENGINE COOLANT TEMPERATURE FAULTS: NOTE: The engine may also exhibit the same starting behavior as in Situation1.

350000 EQUIPMENT

NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:

118000 ELECTRICAL SYSTEM:SOFTWARE

NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:

100000 POWER TRAIN

AISIN AUTOMATIC TRANSMISISON: RIGHT SIDE OUTPUT SHAFT SEAL REPLACEMENT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Automatic Deactivation of Recirculation Mode. The customer states the recirculation display goes out, even though the recirculation button was switched on. CAUSE The automatic recirculation air deactivation feature was introduced in July 20

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

?OC3 SEAT OCCUPANCY MAT: LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES. This Service Information bulletin supersedes SI 01 11 16 dated December 2016.

118000 ELECTRICAL SYSTEM:SOFTWARE

?OC3 SEAT OCCUPANCY MAT: LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES. This Service Information bulletin supersedes SI 01 11 16 dated December 2016.

060000 ENGINE AND ENGINE COOLING

"Update MINI Water Pump Class Action Settlement: Herremans v. BMW of North America, LLC. MINI USA, a division of BMW of North America, LLC (""MINI USA"") has entered into a nationwide settlement with the plaintiffs in the above referenced c

060000 ENGINE AND ENGINE COOLING

"ENGINE MECHANICAL WATER (COOLANT) PUMP: LIMITED WARRANTY EXTENSION TO 7 YEARS/84,000 MILES. INFORMATION As part of a Class Action Suit Settlement for the vehicles listed above (""Class Vehicles""), MINI USA, a division of BMW of North Amer

110000 ELECTRICAL SYSTEM

"USB DEVICE IS NOT DETECTED BY CHAMP2 HEAD UNIT. Media connected to the USB connector is not recognized by the audio system. Playback of files from the media is not possible. Message displayed on the audio system display: ""Title cannot be

350000 EQUIPMENT

100000 POWER TRAIN

"ENGINE POWER REDUCTION WITH "CLUTCH DAMAGED"" FAULTS STORED This Service Information bulletin supersedes SI M12 06 15 dated July 2015. A drivetrain malfunction check control message is displayed, prompting the customer to contact the deale

110000 ELECTRICAL SYSTEM

FOOTWELL MODULE: LIMITED WARRANTY EXTENSION TO 8 YEARS/125,000 MILES. When performing ISTA/D diagnosis and/or a programming procedure (software update) on an affected vehicle, the Footwell Module could fail. There is a compatibility issue w

110000 ELECTRICAL SYSTEM

Engine Misfire Due to Failed Ignition Coil This Service Information bulletin supersedes SI M12 01 15 dated March 2016.. The Check Engine or Service Engine Soon (MIL) lamp is on with misfire fault(s) stored in the DME. Intermittent performan

116000 ELECTRICAL SYSTEM:IGNITION

121000 EXTERIOR LIGHTING:HEADLIGHTS

Delay in Automatic Driving Light Switching on/off. When driving out of a tunnel or exiting underground parking, the automatic driving light remains switched on for two minutes. Shut-off period varies based on detected situation. This is nor

120000 LIGHTING (PWS)

110000 ELECTRICAL SYSTEM

Bluetooth Connection Failures This Service Information bulletin supersedes SI M84 01 14 dated February 2016.. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

010000 STEERING

N18 engine high pressure fuel pump (hdp): limited warranty extension to 10 years/120,000 miles

070000 FUEL SYSTEM, GASOLINE

N18 engine high pressure fuel pump (hdp): limited warranty extension to 10 years/120,000 miles

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Service Information bulletin supersedes SI M84 01 14 dated November 2014. SUBJECT Bluetooth Connection Failures. There are various connectivity failures with the following devices: z Apple iPhones z Samsung S6 and the S6 Edge. Connect

118000 ELECTRICAL SYSTEM:SOFTWARE

110000 ELECTRICAL SYSTEM

New programming feature: Exclusion of Infotainment Control Units from Programming.

060000 ENGINE (PWS)

Surface Cracks on the Water Pump Drive Pulley. During a repair, service or inspection, the drive pulley on the water pump shows signs of cracking. No part replacement is necessary unless there is another issue found that will be corrected b

350000 EQUIPMENT

"MINI Motorer-Focused Satisfaction (MFS) Program. Based on Motorer feedback, MINI has determined that during the first three years of service, some vehicles may require specific additional service work to be performed. To address this issue

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE AND ENGINE COOLING

The Blower Motor is Faulty. The blower motor does not operate at any fan speed. The blower motor may work intermittently with the blower fan speed operating only on FULL speed. CAUSE The blower motor is faulty and causes the blower resistor

138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

350000 EQUIPMENT

This Service Information bulletin supersedes SI M64 02 15 dated August 2015. SUBJECT The Blower Motor is Faulty. The blower motor does not operate at any fan speed. The blower motor may work intermittently with the blower fan speed operatin

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

350000 EQUIPMENT

NAV Road Map Installation Using USB Stick. The Navigation road map can be installed onto the head unit in the vehicle using a USB stick connected to the USB connector in the center console in the vehicle. 32GB USB stick is necessary Desired

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

110000 ELECTRICAL SYSTEM

MINI: DIFFERENT FAULTS ACTIVATES ENGINE MALFUNCTION AND OIL WARNING. *MA

060000 ENGINE (PWS)

MINI: DIFFERENT FAULTS ACTIVATES ENGINE MALFUNCTION AND OIL WARNING. *MA

110000 ELECTRICAL SYSTEM

MINI: BECAUSE OF THE DME SOFTWARE, AND A DAMAGED CLUTCH, THE DRIVETRAIN MALFUNCTION CHECK MESSAGE APPEAR. *MA

060000 ENGINE (PWS)

MINI: BECAUSE OF THE DME SOFTWARE, AND A DAMAGED CLUTCH, THE DRIVETRAIN MALFUNCTION CHECK MESSAGE APPEAR. *MA

110000 ELECTRICAL SYSTEM

MINI: FAULTY SOFTWARE FOR THE TANK VENTILATION CONTROL DISPLAYS ENGINE THROTTLE REACTION WHEN TEMPERATURE IS HIGH OUTSIDE, AND MORE OBVIOUS IF THE TANK IS ONLY PARTLY FILLED. *MA

060000 ENGINE (PWS)

MINI: FAULTY SOFTWARE FOR THE TANK VENTILATION CONTROL DISPLAYS ENGINE THROTTLE REACTION WHEN TEMPERATURE IS HIGH OUTSIDE, AND MORE OBVIOUS IF THE TANK IS ONLY PARTLY FILLED. *MA

070000 FUEL SYSTEM, GASOLINE

Intermittent Poor Throttle Response at High Ambient Temperatures. The engine throttle response from a stop can intermittently be sluggish when the outside ambient temperatures are higher. Additionally, this can be more noticeable when the f

060000 ENGINE (PWS)

130000 VISIBILITY

Service Action: Replace Both Sun Visors. When opening the sun visor mirror cover, the pivot pins bind. CAUSE The spring tension is too great and weak pivot pins can break.

356000 EQUIPMENT ADAPTIVE/MOBILITY

Service Action: Replace Both Sun Visors. When opening the sun visor mirror cover, the pivot pins bind. CAUSE The spring tension is too great and weak pivot pins can break.

060000 ENGINE (PWS)

MINI: SOME VEHICLES ARE EXPERIENCING SEVERAL ISSUES AS WHEN IDLING POWER IS LOSS, BEFORE ENGINE STARTS, EXTENDED CRANKING, CLUTCH PEDAL FAILS TO RETURN TO DISENGAGED POSITION, A HIGH PITCHED WHINE NOISE FROM LOWER AREA OF ENGINE. MODEL F5

060000 ENGINE (PWS)

MINI: A MECHANICAL FAILURE AND DME SOFTWARE ERROR OF THE VANOS ACTUATORS CAUSE THE ENGINE TO RUN ROUGH WHICH ACTIVATES THE MALFUNCTION WARNING LIGHT. *MA

110000 ELECTRICAL SYSTEM

MINI: DUE TO FAULTY DME SOFTWARE, THE SERVICE ENGINE LIGHTS COMES ON, INCLUDING THE CHECK CONTROL MESSAGE FOR MOTOR FORCE DECREASE. *MA

060000 ENGINE (PWS)

MINI: DUE TO FAULTY DME SOFTWARE, THE SERVICE ENGINE LIGHTS COMES ON, INCLUDING THE CHECK CONTROL MESSAGE FOR MOTOR FORCE DECREASE. *MA

110000 ELECTRICAL SYSTEM

MINI: FAULTY SOFTWARE CAUSES THE CHECK CONTROL AND ENGINE POWER REDUCED LIGHT TO APPEAR. *MA

060000 ENGINE (PWS)

MINI: FAULTY SOFTWARE CAUSES THE CHECK CONTROL AND ENGINE POWER REDUCED LIGHT TO APPEAR. *MA

110000 ELECTRICAL SYSTEM

"CHAMP2: Stored Radio Stations Deleted After Ignition Off. After ignition off, the stored radio stations (AM/FM and Satellite radio) are no longer available in: ? Menu ""PRESETS"" ? Preset buttons on the head unit Hardware error in the CHAM

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

060000 ENGINE (PWS)

MINI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. QUESTIONS AND ANSWERS FOR TIMING CHAIN OF VARIOUS MINI. *PE

190000 TIRES

Valve Stem Replacement with Wheel Electronics. Tire pressure loss after replacement of the RDC/RDCi wheel electronics. Valve stems are not being replaced in conjunction of the RDC/RDCi wheel electronics replacement.

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

200000 WHEELS

060000 ENGINE (PWS)

MINI: SOME VEHICLES ARE CONSUMING ENGINE OIL AND RUNS POORLY, FROM CYLINDER HEAD COVER GASKET AREA AN OIL LEAK FROM ENGINE AND ILLUMINATION OF ENGINE MALFUNCTION LIGHT IS ON. MODEL F56 (COOPER). NO YEARS LISTED. *PE

030000 BRAKES (PWS)

Brake Fluid Maintenance Service: 36-Month Interval. The CBS displays the first brake fluid service as a 36-month interval from the date of production, instead of the appropriate 24-month interval. Only vehicles within the specified producti

350000 EQUIPMENT

Diagnosing Stored Fault Codes to Help Avoid Repeat Repair Visits. Analysis of FASTA data and repeat repair visit reports indicates that there are many fault codes that are stored in the above vehicles, but they are not diagnosed to identify

356000 EQUIPMENT ADAPTIVE/MOBILITY

110000 ELECTRICAL SYSTEM

Engine Misfire Due to Failed Ignition Coil. ? The Check Engine or Service Engine Soon (MIL) lamp is on with misfire fault(s) stored in the DME. ? Intermittent performance or rough running without a relevant DME fault stored The most likely

060000 ENGINE (PWS)

070000 FUEL SYSTEM, GASOLINE

N18:MINI Fuel Additive. INFORMATION Because carbon deposit buildup is related to fuel quality, it is not considered a defect in the vehicle's materials or workmanship. Consequently, the use of MINI Fuel Additive as outlined in this bulletin

110000 ELECTRICAL SYSTEM

"Discharged Battery: Energy Diagnosis Must Be Performed. MINI electrical systems and advancements in vehicle technology have resulted in an increased demand on the vehicle battery. This SI will help the dealer handle ""discharged battery""

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

060000 ENGINE (PWS)

SI M11 01 12February 2015 EngineTechnical Service This Service Information bulletin supersedes SI M11 01 12 dated March 2014. designates changes to this revision SUBJECT N16 and N18 Engine: Engine Oil Leak. The customer states that a small

030000 BRAKES (PWS)

"SI M34 01 13January 2015 BrakesTechnical Service This Service Information bulletin supersedes SI 34 01 13 dated May 2014. designates changes to this revision SUBJECT Erroneous ""Service due"" Message Although Brake Lining Thickness is Abov

350000 EQUIPMENT

"SUBJECT iPhone and iOS 8.x Information. INFORMATION With the release of iOS 8.0, please be aware of the important functional change noted below: Scenario: z The customer leaves the vehicle and turns the phone off. z He or she turns the pho

353000 EQUIPMENT:ELECTRICAL

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

MINI: SOME VEHICLES HAVE TURBOCHARGER NOISE AND A LACK OR LOSS OF PERFORMANCE, DUE TO RESTRICTION OF TURBOCHARGER OIL SUPPLY, RESULTING IN OIL STARVATION AND SEIZING OF TURBOCHARGER ASSEMBLY. MODEL ALL. *PE

061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Dual Mass Flywheel: Diagnosis and Inspection. INFORMATION The following three criteria must to be checked, evaluated and the resulting findings documented on the repair order prior to replacing a dual-mass flywheel as defective: 1. Total ro

100000 POWER TRAIN

021500 SUSPENSION:FRONT:CONTROL ARM

MINI: BETWEEN SPEEDS OF 5MPH AND 30MPH, ON ROUGH ROAD SURFACES AND HIGH TEMPERATURES, A NOISE, LIKE SQUEAKING, IS HEARD FROM FRONT AXLE, DUE TO FRONT AXLE CONTROL ARM HYDRAULIC BEARING. MODEL F55, F56. *PE

110000 ELECTRICAL SYSTEM

N16 Engine: Oil Leak from Cylinder Head Sealing Plug. An oil leak can develop at a sealing plug located in the cylinder head, just below the vacuum pump. The sealing plug was not tightened sufficiently during production.

350000 EQUIPMENT

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

iPhone: Connection Failures with iOS 7. There are various connectivity failures with the iPhone using iOS 7. Some examples are listed below: z Call disconnection z Contact List incomplete z General connection failures Apple software iOS 7 a

350000 EQUIPMENT

MINI Motorer-Focused Satisfaction (MFS) Program. Based on Motorer feedback, MINI has determined that during the first three years of service, some vehicles may require specific additional service work to be performed. MINI USA, a division o

060000 ENGINE (PWS)

MINI: DUE TO ENGINE POSITION MANAGEMENT (EPM) UNFAVORABLE PARAMETERS, IN DME SOFTWARE, VARIOUS CONTROL FAULTS ARE SET AND ENGINE CAN GO INTO POWER MODE, WHILE DISPLAYING DRIVETRAIN MALFUNCTION MESSAGE. MODEL 2011-14 F56 (COOPER, COOPER S)

Showing 100 of 196 bulletins.

NHTSA Safety Investigations, MINI COOPER

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

AQ, Closed , Model Year: 2014

BMW Safety Act Violations

In a Consent Order executed on December 17, 2015, BMW of North America, LLC (BMW NA) admitted that it violated the Safety Act by: failing to conduct a timely recall for Recall No. 15V-450; failing to file certain quarterly recall reports in a timely manner; failing to timely notify vehicle owners of... Read more

AQ, Closed , Model Year: 2014

International Autos, Inc. / Mini Recall

The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell and deliver a new vehicle subject to a recall unless the recall remedy h... Read more

EA, Closed , Model Year: 2002

Loss of power steering assist

The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was ex... panded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included siRead more

EA, Closed , Model Year: 2002

ENGINE COMPARTMENT FIRE

THE OFFICE OF DEFECTS INVESTIGATION (ODI) ANALYZED CONSUMER COMPLAINTS TO BMW OF NORTH AMERICA, LLC (BMW)AND TO ODI THAT ALLEGED FAILURES OF THE ELECTROHYDRAULIC POWER STEERING (EHPS) USED IN MODEL YEAR 2002 THROUGH 2003 MINI COOPER VEHICLES.THE ANALYSIS DETERMINED THAT 43 OF THE 52 (83%) REPORTS WE... Read more

PE, Closed , Model Year: 2002

ENGINE COMPARTMENT FIRE

IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), BMW STATED THAT THE CAUSE OF THE ALLEGED DEFECT IS AN INSUFFICIENT SEAL OF THE GROUND CABLE OF THE POWER STEERING PUMP AT ITS ATTACHMENT TO THE CHASSIS.WATER INGRESS CAN OCCUR AND THE WATER CAN TRAVE... Read more

PE, Closed , Model Year: 2002

AIR BAG WARNING LAMP ILLUMINATION

IN MARCH 2006, BMW REISSUED A SERVICE BULLETIN FIRST ISSUED IN SEPTEMBER 2003, TO MINI DEALERS REGARDING THE REPAIR PROCEDURE FOR IMPROPER WIRE CRIMPS IN APPROXIMATELY 31,500 MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES PRODUCED UP TO JANUARY 2003.THE NEW SERVICE BULLETIN STATES THAT THE WARRANTY C... Read more

DP, Closed , Model Year: 2002

AIR BAG WARNING LAMP ILLUMINATION

ODI HAS GRANTED THE PETITION AND HAS OPENED A PRELIMINARY EVALUATION (PE05-053) ON ILLUMINATION OF AIR BAG WARNING LAMP ON MODEL YEAR 2002 AND 2003 MINI COOPER VEHICLES.

MINI COOPER - All Years Overview

Complete safety history for the MINI COOPER across all model years (2002, 2026).

53 Total Recalls

2,851 Total Complaints

7 Investigations

104 Reported Crashes

155 Reported Fires

1 Reported Deaths

MINI COOPER - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	2	View
2025	3	1	View
2024	0	1	View
2023	0	9	View
2022	0	7	View
2021	2	7	View
2020	2	11	View
2019	2	17	View
2018	0	10	View
2017	3	42	View
2016	1	43	View
2015	6	74	View
2014	7	45	View
2013	1	72	View
2012 (current)	1	96
2011	1	129	View
2010	2	142	View
2009	1	192	View
2008	1	155	View
2007	1	156	View
2006	1	247	View
2005	4	440	View
2004	4	330	View
2003	4	388	View
2002	5	220	View
2001	0	7	View

Other MINI Models

Model	Recalls	Complaints
COOPER S	66	2,180	View
JCW	25	22	View
COOPER S CLUBMAN	21	120	View
COUNTRYMAN	18	147	View
COOPER SE	13	7	View
JCW CLUBMAN	12	5	View
COOPER S CONVERTIBLE	12	180	View
COOPER CONVERTIBLE	11	215	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2012 MINI COOPER

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2012 MINI COOPER

Technical Service Bulletins, 2012 MINI COOPER

Most Affected Components

NHTSA Safety Investigations, MINI COOPER

MINI COOPER - All Years Overview

MINI COOPER - Year by Year

Other MINI Models