2020 MINI COOPER S
2 recalls, 8 complaints - 128 TSBs
20V283000 May 20, 2020
AIR BAGS
Defect Description
BMW of North America, LLC (BMW) is recalling certain 2020 X1 xDrive28i, X1 sDrive28i, X2 xDrive28i and X2 sDrive28i, 2020 MINI Clubman Cooper S All4, 2021 MINI Hardtop 2 Door (Cooper, Cooper S, John Cooper Works and Cooper S E) and MINI Hardtop 4 Door (Cooper and Cooper S) vehicles. Due to a proble... Read more
Consequence
If the safety systems do not deploy as intended in a roll over crash, it may increase the risk of injury.
Remedy
BMW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began July 17, 2020. Owners may contact BMW customer service at 1-800-525-7417 or MINI customer service at 1-866-825-1525.
19V634000 Aug 28, 2019
STRUCTURE
Defect Description
BMW of North America, LLC (BMW) is recalling certain 2020 MINI Hardtop 2-Door Cooper, Cooper S, and JCW vehicles. The rear side trim panels may have been assembled without a crash pad. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) num... Read more
Consequence
Without a crash pad, rear seat passengers would have an increased risk of injury in the event of a side impact crash.
Remedy
MINI will notify owners, and MINI dealers will install crash pads, free of charge. The recall began October 11, 2019. Owners may contact MINI customer service at 1-866-825-1525.
Complaint Statistics
8 total complaints
Top Reported Components
| Component | Complaints |
|---|---|
| ELECTRICAL SYSTEM | 2 |
| VISIBILITY/WIPER | 1 |
| ENGINE | 1 |
| WHEELS | 1 |
| AIR BAGS | 1 |
| EXTERIOR LIGHTING | 1 |
| BACK OVER PREVENTION: SENSING SYSTEM: CAMERA | 1 |
ELECTRICAL SYSTEM
Jun 25, 2025
Incident date: Jun 18, 2025
First Incident [XXX], in Columbia SC driving in parking lot On Post, approx 10pm, blocking traffic. Car shut down and MMI disappeared. After approximately 20-30 minutes car started, still no screen. I was able to drive it. Next day, Rebooted per Google, took to dealership who said I should make sure... Read more
EXTERIOR LIGHTING
Jun 25, 2025
Incident date: Jun 18, 2025
Auto high beam turns off and on on dark country road repeatedly with no other cars or light present . This means I lose highbeams when needed the most for animals in road. Also, the system goes from low beam into high beam when a car approaches in opposite lane blinding them. In short , is danger... Read more
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Jun 25, 2025
Incident date: Jun 18, 2025
Backup camera was previously recalled. Polestar released version 3.6.4 and claimed it fixed the issue. However, it’s the same, if not worse, than before. “Camera currently unavailable” error message still displays upwards of 50% of the time after putting the car into reverse.
AIR BAGS
Mar 13, 2025
Incident date: Feb 13, 2025
The contact owns a 2021 Toyota Rav4 Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The ... Read more
WHEELS
Mar 18, 2021
Incident date: Feb 23, 2021
THE TIRES ON THIS VEHICLE HAVE BLOWN OUT 3 TIMES IN THE 9 MONTHS WE HAVE OWNED THIS CAR. ANOTHER TIRE (A FOURTH INCIDENT) HAD A BUBBLE THAT WAS REPLACED BEFORE IT BLEW OUT. ALL INCIDENTS WERE SEPARATE TIMES. THE DEALER AND BMW WILL DO NOTHING. ALL BLOW OUTS WERE ON THE HIGHWAY TRAVELING ABOUT 60 MPH... Read more
ELECTRICAL SYSTEM
Jun 23, 2020
Incident date: Jun 23, 2020
DURING A RAIN SHOWER, DROVE AT ABOUT 15MPH INTO ROUGHLY 4" OF WATER GATHERED ON THE SHOULDER OF AN ACCESS ROAD ADJACENT TO THE HIGHWAY AND THE ENGINE STALLED. WOULD NOT RESTART. PUDDLE OF WATER WAS NOT HIGH ENOUGH TO BREACH THE CABIN - RUNNING BOARDS WERE STILL ABOVE WATER AND THE CURB ADJACENT TO ... Read more
ENGINE
Jun 23, 2020
Incident date: Jun 23, 2020
DURING A RAIN SHOWER, DROVE AT ABOUT 15MPH INTO ROUGHLY 4" OF WATER GATHERED ON THE SHOULDER OF AN ACCESS ROAD ADJACENT TO THE HIGHWAY AND THE ENGINE STALLED. WOULD NOT RESTART. PUDDLE OF WATER WAS NOT HIGH ENOUGH TO BREACH THE CABIN - RUNNING BOARDS WERE STILL ABOVE WATER AND THE CURB ADJACENT TO ... Read more
VISIBILITY/WIPER
Dec 19, 2019
Incident date: Dec 16, 2019
WHEN SITTING IN DRIVERS SEAT ( I AM 5FT. 1 IN TALL) AND THE CONVERTIBLE TOP IS OPEN, I CAN NOT SEE THROUGH THE REAR VIEW MIRA BECAUSE THE CONVERTIBLE TOP FOLDED IS BLOCKING MY VISION. MY SEAT IS AT HIGHEST POSITION. JUST AS POINT OF REFERENCE I HAD A 2012 MINI CONV. AND THIS WAS NOT A PROBLEM. B... Read more
Technical Service Bulletins, 2020 MINI COOPER S
128 manufacturer communications from 56 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 110000 ELECTRICAL SYSTEM | 23 |
| 350000 EQUIPMENT | 18 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 14 |
| 060000 ENGINE AND ENGINE COOLING | 11 |
| 060000 ENGINE (PWS) | 6 |
| 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER | 5 |
| 162300 STRUCTURE:BODY:DOOR | 4 |
| 010000 STEERING | 3 |
M310424
Mar 4, 2024
020000 SUSPENSION
During inspection and/or diagnosis there is noticeable dirt/grease buildup on the axles near the inner and/or outer CV boots.
M610607
Oct 25, 2023
110000 ELECTRICAL SYSTEM
MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, m
M110323
Aug 1, 2023
346000 COMMUNICATION:MANUFACTURER TELEMATICS
?BMW AG has issued a Delivery Stop: REPLACE CHARGE AIR LINE.
M540123
Aug 1, 2023
162900 STRUCTURE:BODY:ROOF AND PILLARS
?The panoramic roof sunblind does not close, or jams while closing.
M510123
May 1, 2023
162000 STRUCTURE:BODY
Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
M510123
May 1, 2023
162500 STRUCTURE:BODY:TAILGATE
Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
M610123
Mar 1, 2023
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Oscillations in the electric drive can occur. As a result, the 12 V positive battery cable may rub against the battery box cover.
M610223
Mar 1, 2023
110000 ELECTRICAL SYSTEM
The buttons on the gear selector switch (GWS) do not work, or the function indicator lighting has failed.
M610223
Mar 1, 2023
120000 EXTERIOR LIGHTING
The buttons on the gear selector switch (GWS) do not work, or the function indicator lighting has failed.
M840322
Mar 1, 2023
110000 ELECTRICAL SYSTEM
The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via Voice over LTE (VoLTE) function. For this purpose, the SIM card must perform an IMS r
M630122
Feb 1, 2023
110000 ELECTRICAL SYSTEM
Ambient lighting changes color after the vehicle goes to sleep.
M630122
Feb 1, 2023
120000 EXTERIOR LIGHTING
Ambient lighting changes color after the vehicle goes to sleep.
M220122
Nov 1, 2022
060000 ENGINE AND ENGINE COOLING
During a vehicle inspection and/or while addressing a customer's concern, the engine stabilizer bar/link appears to be worn.
M540122
Nov 1, 2022
160000 STRUCTURE
It is possible that the guide stem (aka rotational axis) on the wind deflector can break, upon removal and or during installation.
M610820
Nov 1, 2022
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
During the service life of the vehicle, the high-voltage battery may unexpectedly not provide power to the vehicle.
M840322
Sep 1, 2022
353000 EQUIPMENT:ELECTRICAL
Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, MINI Assistance and emergency call voice) can no longer be used regionally in the US
SIM330122
May 1, 2022
010000 STEERING
The following complaints may be noticed while slow maneuvering with a steering input of 80-100% (at or near full lock, e.g., parking lot maneuvers) or accelerating with a medium to large steering angle: Humming or creaking noises from the r
SIM640122
May 1, 2022
060000 ENGINE AND ENGINE COOLING
Mist formation on the windscreen inner surface may occur at departure or after MSA (automaticstart/stop). Acoustic abnormality in the area of the recirculated air flap (recirculation flap closing and opening several times). The above may oc
SIM610321
Apr 1, 2022
162300 STRUCTURE:BODY:DOOR
The Check Control message "Door open" appears in the instrument cluster (Kombi) even though all vehicle doors are securely closed and locked.
M340317
Feb 1, 2022
356000 EQUIPMENT ADAPTIVE/MOBILITY
Vehicles with total mileage below approx. 12,500 may experience premature wear of the left rear brakes. In some cases, there also may be visible damage due to thermal overload.
M340317
Feb 1, 2022
030000 BRAKES (PWS)
Vehicles with total mileage below approx. 12,500 may experience premature wear of the left rear brakes. In some cases, there also may be visible damage due to thermal overload.
M120121
Dec 1, 2021
070000 FUEL SYSTEM, GASOLINE
In situations when the fuel tank vent line becomes blocked, the on-board diagnosis (OBD) may not detect the blockage.
M120121
Dec 1, 2021
350000 EQUIPMENT
In situations when the fuel tank vent line becomes blocked, the on-board diagnosis (OBD) may not detect the blockage.
M230121
Dec 1, 2021
100000 POWER TRAIN
When the vehicle is on a lift and wheels are manually spun, a clanking noise is heard from the transmission area.
M230121
Dec 1, 2021
200000 WHEELS
When the vehicle is on a lift and wheels are manually spun, a clanking noise is heard from the transmission area.
M360119
Dec 1, 2021
110000 ELECTRICAL SYSTEM
New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. These new wheel electronics will need to be programmed using the new tool when replaced or when d
M360119
Dec 1, 2021
200000 WHEELS
New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. These new wheel electronics will need to be programmed using the new tool when replaced or when d
M360119
Dec 1, 2021
350000 EQUIPMENT
New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. These new wheel electronics will need to be programmed using the new tool when replaced or when d
M610321
Dec 1, 2021
110000 ELECTRICAL SYSTEM
Any or all of the following CCM ID code 14/15/16/17 door open appear in the instrument cluster when the door is properly closed and locked. The locking operation of the door is not affected by the incorrect display.
M610321
Dec 1, 2021
162300 STRUCTURE:BODY:DOOR
Any or all of the following CCM ID code 14/15/16/17 door open appear in the instrument cluster when the door is properly closed and locked. The locking operation of the door is not affected by the incorrect display.
M610321
Dec 1, 2021
170000 LATCHES/LOCKS/LINKAGES
Any or all of the following CCM ID code 14/15/16/17 door open appear in the instrument cluster when the door is properly closed and locked. The locking operation of the door is not affected by the incorrect display.
M610321
Dec 1, 2021
171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Any or all of the following CCM ID code 14/15/16/17 door open appear in the instrument cluster when the door is properly closed and locked. The locking operation of the door is not affected by the incorrect display.
M640221
Sep 1, 2021
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
Different air temperatures are felt from left to right out of the front fresh air grilles (air vents).
M640221
Sep 1, 2021
110000 ELECTRICAL SYSTEM
Different air temperatures are felt from left to right out of the front fresh air grilles (air vents).
M651015
Sep 1, 2021
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
The Headunit High (HU-H), also called NBT came in vehicles with option 609. This uses map North America NEXT. The Headunit High 2 (HU-H2), also called NBT-EVO, superseded the NBT HU and came in vehicles with option code 609. This uses map N
M640221
Jul 1, 2021
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Different air temperatures are felt from left to right out of the front fresh air grilles (air vent). The following fault code is saved in the IHKA (integrated automatic heating/air conditioning system) control unit: 801189 - Engine mixed a
M310115
Jun 1, 2021
010000 STEERING
A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle
M310115
Jun 1, 2021
350000 EQUIPMENT
A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle
M310115
Jun 1, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
A groaning and/or squeaking noise from the front axle occurs when turning at low speeds or idle
M220117
May 1, 2021
020000 SUSPENSION
Creaking Noise When Cornering: A creaking noise is heard from the front end of the vehicle while cornering (predominantly left turns)
M410221
May 1, 2021
162300 STRUCTURE:BODY:DOOR
SERVICE ACTION 0041080200: MINI F54 RIGHT FRONT DOOR: Due to a fault in the press shop, there may be a crack in the inner door panel of the front right door in the area of the window frame.
M660121
Apr 1, 2021
110000 ELECTRICAL SYSTEM
ACTIVE CRUISE CONTROL (ACC) CANNOT BE ACTIVATED: After the recent software update, the cruise control cannot be activated.
M660121
Apr 1, 2021
185000 VEHICLE SPEED CONTROL:CRUISE CONTROL
ACTIVE CRUISE CONTROL (ACC) CANNOT BE ACTIVATED: After the recent software update, the cruise control cannot be activated.
M660121
Apr 1, 2021
350000 EQUIPMENT
ACTIVE CRUISE CONTROL (ACC) CANNOT BE ACTIVATED: After the recent software update, the cruise control cannot be activated.
M660121
Apr 1, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
ACTIVE CRUISE CONTROL (ACC) CANNOT BE ACTIVATED: After the recent software update, the cruise control cannot be activated.
M660121
Apr 1, 2021
118000 ELECTRICAL SYSTEM:SOFTWARE
ACTIVE CRUISE CONTROL (ACC) CANNOT BE ACTIVATED: After the recent software update, the cruise control cannot be activated.
M660121
Apr 1, 2021
263010 FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL:SOFTWARE
ACTIVE CRUISE CONTROL (ACC) CANNOT BE ACTIVATED: After the recent software update, the cruise control cannot be activated.
M610121
Mar 1, 2021
060000 ENGINE AND ENGINE COOLING
CLICKING NOISE IN VEHICLE INTERIOR DURING CHARGING: Clicking noise from the interior passenger side footwell when the vehicle is being charged, with the air conditioning running at the same time.
M610121
Mar 1, 2021
280000 BACK OVER PREVENTION
CLICKING NOISE IN VEHICLE INTERIOR DURING CHARGING: Clicking noise from the interior passenger side footwell when the vehicle is being charged, with the air conditioning running at the same time.
M610820
Mar 1, 2021
100000 POWER TRAIN
REPLACING THE CELL MODULE OF HIGHVOLTAGE BATTERY: During the service life of the vehicle, the high-voltage battery may unexpectedly not provide power to the vehicle.
M610820
Mar 1, 2021
110000 ELECTRICAL SYSTEM
REPLACING THE CELL MODULE OF HIGHVOLTAGE BATTERY: During the service life of the vehicle, the high-voltage battery may unexpectedly not provide power to the vehicle.
M610820
Dec 1, 2020
110000 ELECTRICAL SYSTEM
?REPLACING THE CELL MODULE OF HIGH VOLTAGE BATTERY: During the service life of the vehicle, the high-voltage battery may unexpectedly not provide power to the vehicle. The high-voltage battery cells may not have been produced according to s
M610820
Dec 1, 2020
350000 EQUIPMENT
?REPLACING THE CELL MODULE OF HIGH VOLTAGE BATTERY: During the service life of the vehicle, the high-voltage battery may unexpectedly not provide power to the vehicle. The high-voltage battery cells may not have been produced according to s
M610820
Dec 1, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
?REPLACING THE CELL MODULE OF HIGH VOLTAGE BATTERY: During the service life of the vehicle, the high-voltage battery may unexpectedly not provide power to the vehicle. The high-voltage battery cells may not have been produced according to s
M610820
Dec 1, 2020
110000 ELECTRICAL SYSTEM
?REPLACING THE CELL MODULE OF HIGHVOLTAGE BATTERY: During the service life of the vehicle, the high-voltage battery may unexpectedly not provide power to the vehicle. The high-voltage battery cells may not have been produced according to sp
M520119
Nov 1, 2020
220000 SEATS
NOISE DURING FORWARD / BACK SEAT ADJUSTMENT OVER THE ENTIRE LENGTH OF TRAVEL: A loud screeching noise can be heard from the front driver's or passenger's seat during forward/back seat adjustment.
M520119
Nov 1, 2020
350000 EQUIPMENT
NOISE DURING FORWARD / BACK SEAT ADJUSTMENT OVER THE ENTIRE LENGTH OF TRAVEL: A loud screeching noise can be heard from the front driver's or passenger's seat during forward/back seat adjustment.
M110420
Oct 1, 2020
071110 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
SERVICE ACTION - MOUNTING THE OIL FILLER CAP CORRECTLY: The oil filler cap may not be mounted correctly. The cap was not installed correctly during assembly.
M110420
Oct 1, 2020
350000 EQUIPMENT
SERVICE ACTION - MOUNTING THE OIL FILLER CAP CORRECTLY: The oil filler cap may not be mounted correctly. The cap was not installed correctly during assembly.
M510220
Oct 1, 2020
162500 STRUCTURE:BODY:TAILGATE
SERVICE ACTION - F60 TAILGATE HANDLE STRIP: The incorrect tailgate handle strip may have been installed during production.
M510220
Oct 1, 2020
350000 EQUIPMENT
SERVICE ACTION - F60 TAILGATE HANDLE STRIP: The incorrect tailgate handle strip may have been installed during production.
M510220
Oct 1, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
SERVICE ACTION - F60 TAILGATE HANDLE STRIP: The incorrect tailgate handle strip may have been installed during production.
M640120
Oct 1, 2020
350000 EQUIPMENT
BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Prior to turning off the A/C, the system was functional and coolin
M640120
Oct 1, 2020
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Prior to turning off the A/C, the system was functional and coolin
M640120
Oct 1, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Prior to turning off the A/C, the system was functional and coolin
M640220
Oct 1, 2020
161000 STRUCTURE:FRAME AND MEMBERS
CONDENSATION FROM AIR CONDITIONING LEAKS INTO PASSENGER FOOTWELL: Condensation from the air conditioning systems evaporator drips, below the instrument panel, into the passenger's footwell. During assembly, the cover of the fresh air intake
M640220
Oct 1, 2020
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
CONDENSATION FROM AIR CONDITIONING LEAKS INTO PASSENGER FOOTWELL: Condensation from the air conditioning systems evaporator drips, below the instrument panel, into the passenger's footwell. During assembly, the cover of the fresh air intake
M110420
Oct 1, 2020
060000 ENGINE AND ENGINE COOLING
SERVICE ACTION - MOUNTING THE OIL FILLER CAP CORRECTLY: The oil filler cap may not be mounted correctly. The cap was not installed correctly during assembly.
M510220
Oct 1, 2020
162510 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
SERVICE ACTION - F60 TAILGATE HANDLE STRIP: The incorrect tailgate handle strip may have been installed during production.
M640120
Oct 1, 2020
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Prior to turning off the A/C, the system was functional and coolin
M640220
Oct 1, 2020
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
CONDENSATION FROM AIR CONDITIONING LEAKS INTO PASSENGER FOOTWELL: Condensation from the air conditioning systems evaporator drips, below the instrument panel, into the passenger's footwell. During assembly, the cover of the fresh air intake
M340120
Sep 1, 2020
251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
SERVICE ACTION - PROGRAM THE BODY DOMAIN CONTROL (BDC) UNIT: Aftermarket scan tools cannot read fault codes in the Dynamic Stability Control (DSC) unit via the On Board Diagnostic (OBD) socket. The DSC data is not processed correctly in the
M340120
Sep 1, 2020
160000 STRUCTURE
SERVICE ACTION - PROGRAM THE BODY DOMAIN CONTROL (BDC) UNIT: Aftermarket scan tools cannot read fault codes in the Dynamic Stability Control (DSC) unit via the On Board Diagnostic (OBD) socket. The DSC data is not processed correctly in the
M610520
Sep 1, 2020
110000 ELECTRICAL SYSTEM
MINI TURBOCORD PORTABLE EV 120V/240V CHARGER: The MINI-approved accessory TurboCord will not charge the vehicle.
M010520
Aug 1, 2020
060000 ENGINE AND ENGINE COOLING
B46M ENVIRONMENTAL AIR CATALYST SENSOR - LTD WTY EXT TO 15 YEARS/150,000 MILES: Component/Issue-Specific Limited Warranty Extension For the eligible vehicles, MINI USA, a division of BMW of North America, LLC ("MINI USA") is extending the l
M340120
Aug 1, 2020
115000 ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM
SERVICE ACTION - PROGRAM THE BODY DOMAIN CONTROL (BDC) UNIT: Aftermarket scan tools cannot read fault codes in the Dynamic Stability Control (DSC) unit via the On Board Diagnostic (OBD) socket. The DSC data is not processed correctly in the
M410120
Aug 1, 2020
160000 STRUCTURE
CRACKING NOISE FROM A-PILLAR: When driving over rough road surfaces, a cracking noise can be heard from either or both lower A-Pillars near the bottom corners of the windshield. Interference between 2 sheet metal panels.
M610420
Aug 1, 2020
110000 ELECTRICAL SYSTEM
DELIVERY STOP - HIGH-VOLTAGE BATTERY: Please do not charge the vehicle high-voltage battery until further notice. There may be a potential issue in the welding process of the HV-modules.
M010520
Jul 1, 2020
350000 EQUIPMENT
B46M ENVIRONMENTAL AIR CATALYST SENSOR - LTD WTY EXT TO 15 YEARS/150,000 MILES: Component/Issue-Specific Limited Warranty Extension For the eligible vehicles, MINI USA, a division of BMW of North America, LLC ("MINI USA") is extending the l
M010520
Jul 1, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
B46M ENVIRONMENTAL AIR CATALYST SENSOR - LTD WTY EXT TO 15 YEARS/150,000 MILES: Component/Issue-Specific Limited Warranty Extension For the eligible vehicles, MINI USA, a division of BMW of North America, LLC ("MINI USA") is extending the l
M010520
Jul 1, 2020
060000 ENGINE (PWS)
B46M ENVIRONMENTAL AIR CATALYST SENSOR - LTD WTY EXT TO 15 YEARS/150,000 MILES: Component/Issue-Specific Limited Warranty Extension For the eligible vehicles, MINI USA, a division of BMW of North America, LLC ("MINI USA") is extending the l
M160220
Jul 1, 2020
070000 FUEL SYSTEM, GASOLINE
NOISES FROM THE FUEL TANK AT IDLE: While driving slowly with low RPM or while idling, a faint knocking or fluttering noise can be heard from inside the fuel tank when the tank is full. The customer may describe this noise as a "helicopter n
M620318
Jul 1, 2020
110000 ELECTRICAL SYSTEM
BLACK SPOT IN THE CENTRAL INFORMATION DISPLAY: A small black spot remains on the Central Information Display's (CID) illuminated screen which does not go away after a key cycle or sleep mode. Dead pixels in the Liquid Crystal Display (LCD)
M620318
Jul 1, 2020
350000 EQUIPMENT
BLACK SPOT IN THE CENTRAL INFORMATION DISPLAY: A small black spot remains on the Central Information Display's (CID) illuminated screen which does not go away after a key cycle or sleep mode. Dead pixels in the Liquid Crystal Display (LCD)
M620318
Jul 1, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
BLACK SPOT IN THE CENTRAL INFORMATION DISPLAY: A small black spot remains on the Central Information Display's (CID) illuminated screen which does not go away after a key cycle or sleep mode. Dead pixels in the Liquid Crystal Display (LCD)
M660220
Jul 1, 2020
110000 ELECTRICAL SYSTEM
KAFAS (CAMERA-BASED DRIVER ASSISTANCE SYSTEMS) LIMITATIONS: KAFAS camera-based assistance system (without radar) is not operating up to customer expectations. Customers can report system errors such as: Vehicle equipped with camera-based AC
M660220
Jul 1, 2020
350000 EQUIPMENT
KAFAS (CAMERA-BASED DRIVER ASSISTANCE SYSTEMS) LIMITATIONS: KAFAS camera-based assistance system (without radar) is not operating up to customer expectations. Customers can report system errors such as: Vehicle equipped with camera-based AC
M660220
Jul 1, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
KAFAS (CAMERA-BASED DRIVER ASSISTANCE SYSTEMS) LIMITATIONS: KAFAS camera-based assistance system (without radar) is not operating up to customer expectations. Customers can report system errors such as: Vehicle equipped with camera-based AC
M660220
Jul 1, 2020
030000 BRAKES (PWS)
KAFAS (CAMERA-BASED DRIVER ASSISTANCE SYSTEMS) LIMITATIONS: KAFAS camera-based assistance system (without radar) is not operating up to customer expectations. Customers can report system errors such as: Vehicle equipped with camera-based AC
M130120
May 1, 2020
060000 ENGINE AND ENGINE COOLING
TANK VENTILATION AND MIXTURE CONTROL FAULTS STORED IN THE DME: The Engine Malfunction Warning is illuminated and one or more of the following faults are stored in the DME. All models: FC 191C02 - Fuel tank ventilation system 2nd discharge p
M130120
May 1, 2020
070000 FUEL SYSTEM, GASOLINE
TANK VENTILATION AND MIXTURE CONTROL FAULTS STORED IN THE DME: The Engine Malfunction Warning is illuminated and one or more of the following faults are stored in the DME. All models: FC 191C02 - Fuel tank ventilation system 2nd discharge p
M130120
May 1, 2020
100000 POWER TRAIN
TANK VENTILATION AND MIXTURE CONTROL FAULTS STORED IN THE DME: The Engine Malfunction Warning is illuminated and one or more of the following faults are stored in the DME. All models: FC 191C02 - Fuel tank ventilation system 2nd discharge p
M110320
Apr 1, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
DELIVERY STOP: BMW AG has issued a Delivery Stop (effective March 13 2020) on a small number of Model Year 2020 MINI vehicles that were produced between February 4 2020 and February 13 2020. Due to a possible production issue the cylinder h
M110320
Apr 1, 2020
060000 ENGINE (PWS)
DELIVERY STOP: BMW AG has issued a Delivery Stop (effective March 13 2020) on a small number of Model Year 2020 MINI vehicles that were produced between February 4 2020 and February 13 2020. Due to a possible production issue the cylinder h
M120120
Apr 1, 2020
060000 ENGINE AND ENGINE COOLING
MIL LIGHT ILLUMINATED AT LOW AMBIENT TEMPERATURES: This Service Information Bulletin (Revision #1) replaces SI B12 01 20 dated February 2020. After engine start the malfunction indicator lamp (MIL) and Check Control message (ID 29) "Engine
M120120
Apr 1, 2020
350000 EQUIPMENT
MIL LIGHT ILLUMINATED AT LOW AMBIENT TEMPERATURES: This Service Information Bulletin (Revision #1) replaces SI B12 01 20 dated February 2020. After engine start the malfunction indicator lamp (MIL) and Check Control message (ID 29) "Engine
M120320
Apr 1, 2020
110000 ELECTRICAL SYSTEM
SERVICE ACTION: PROGRAM CONTROL UNITS (EME): The software of the electrical machine electronics is faulty. This causes the scan tool to read out only the fault memory that was stored first so that any further faults are not displayed.
M120320
Apr 1, 2020
350000 EQUIPMENT
SERVICE ACTION: PROGRAM CONTROL UNITS (EME): The software of the electrical machine electronics is faulty. This causes the scan tool to read out only the fault memory that was stored first so that any further faults are not displayed.
M120420
Apr 1, 2020
060000 ENGINE AND ENGINE COOLING
SERVICE ACTION: PROGRAM THE DIGITAL MOTOR ELECTRONICS (DME) - B36C: In certain situations the exhaust valve seat inserts may become overheated when using low quality fuel. If overheated the valve seat insert may become distorted and wear at
M120420
Apr 1, 2020
350000 EQUIPMENT
SERVICE ACTION: PROGRAM THE DIGITAL MOTOR ELECTRONICS (DME) - B36C: In certain situations the exhaust valve seat inserts may become overheated when using low quality fuel. If overheated the valve seat insert may become distorted and wear at
Showing 100 of 128 bulletins.
NHTSA Safety Investigations, MINI COOPER S
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
EA08020
Opened: Aug 29, 2008 , Closed: Jan 2, 2009
EXHAUST PIPE BURNS
BMW WILL CONDUCT A SAFETY RECALL (08V-657) ON 28,450 MINI COOPER S VEHICLES MANUFACTURED FROM NOVEMBER 18, 2006 THROUGH JULY 8, 2008.DEALERS WILL INSTALL MODIFIED EXHAUST PIPE TIPS THAT DO NOT EXTEND BEYOND THE REAR BUMPER.THE TWO EXHAUST PIPE TIPS OF THE SUBJECT VEHICLES EXIT THE UNDERSIDE OF THE V... Read more
PE08031
Opened: Apr 28, 2008 , Closed: Aug 29, 2008
EXHAUST PIPE BURNS
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION BASED ON THREE CONSUMER REPORTS.THE COMPLAINANTS REPORTED BEING BURNED ON THEIR LEGS BY THE HOT EXHAUST PIPE TIP WHILE THEY WERE REMOVING CARGO ITEMS FROM THE REAR HATCH AREA OF THEIR VEHICLES.THE MINI COOPER S MODEL HAS DUAL EXHAUS... Read more
MINI COOPER S - All Years Overview
Complete safety history for the MINI COOPER S across all model years (2002, 2025).
50
Total Recalls
2,184
Total Complaints
2
Investigations
57
Reported Crashes
152
Reported Fires
4
Reported Deaths
MINI COOPER S - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2025 | 2 | 6 | View |
| 2024 | 0 | 2 | View |
| 2022 | 0 | 1 | View |
| 2021 | 2 | 0 | View |
| 2020 (current) | 2 | 8 | |
| 2019 | 1 | 7 | View |
| 2017 | 3 | 8 | View |
| 2016 | 3 | 10 | View |
| 2015 | 4 | 20 | View |
| 2014 | 4 | 17 | View |
| 2013 | 1 | 32 | View |
| 2012 | 2 | 30 | View |
| 2011 | 3 | 46 | View |
| 2010 | 4 | 78 | View |
| 2009 | 3 | 151 | View |
| 2008 | 4 | 197 | View |
| 2007 | 4 | 300 | View |
| 2006 | 1 | 243 | View |
| 2005 | 2 | 383 | View |
| 2004 | 2 | 279 | View |
| 2003 | 2 | 258 | View |
| 2002 | 1 | 105 | View |