2008 MINI COOPER S Recalls, Complaints & Safety

The contact owns a 2008 Mini Cooper S. The contact stated that the check engine warning light was illuminated. Additionally, the windows would roll down independently and the sunroof would fail to close completely. The vehicle was taken to AutoZone, where it was diagnosed that the failure was related to the braking system; however, the contact stated that new brake hardware had been installed on the vehicle. The contact related the failures to NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted, but no assistance was provided. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 111,000. VIN tool confirms parts not available.

The contact owns a 2008 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT SENSOR HAS FAILED. THE FRONT PASSENGER AIR BAG IS NOT ACTIVATE IN A CRASH WHEN THE SEAT IS OCCUPIED. RECALLS ACTIVE FOR THIS EXACT ISSUE FOR THE SAME MAKE IN OTHER YEARS AND MODELS ARE CURRENTLY RECALLED HOWEVER OTHERS ARE EXCLUDED.

TO THE BEST OF MY KNOWLEDGE THE AIRBAG SYSTEM IS OFF LINE. THE PASSENGER AIRBAGS DO NOT TURN ON WHEN A PASSENGER IS SEATED. THE PASSENGER AIRBAG INDICATOR LIGHT SHOWS THAT IT IS NOT TURNING ON WITH OR WITHOUT A PASSENGER. ALSO THE DRIVERS SIDE AIRBAG INDICATOR LIGHT COMES ON THE DASHBOARD AND THE TACHOMETER WHEN I START THE VEHICLE. THIS PROBLEM BEGAN WHILE THE VEHICLE WAS PARKED AND STATIONARY.

TIMING CHAIN JUMPED OUT OF TIMING AND CAUSED BENT VALVES.

WARNING MESSAGE FOR SEAT BELT TENSION/AIR BAG MALFUNCTION AND BOTH LIGHTS ARE ON. THE VEHICLE HAS 40+ THOUSAND MILES ON IT, I AM A SECOND OWNER. THIS PROBLEM JUST STARTED ON MAY 29, 2020. NO ACCIDENTS FOR THIS VEHICLE. COST FOR REPAIR IS OVER $2000 AND SO FAR THERE'S ONLY RECALLS FOR 2008 CONVERTIBLE WHICH I TOTALLY DON'T UNDERSTAND. THIS LOOKS TO BE AN ONGOING PROBLEM WITH THE MINI AND NEEDS TO BE ADDRESSED DUE TO THE AIR BAGS BEING AFFECTED. I CURRENTLY HAVE NO PHOTOS BUT CAN READILY SUPPLY PHOTOS UPON REQUEST. THE SEAT BELT LIGHT/AIR BAG EMBLEM SHOWS ON THE DASH SCREEN WHEN ENTERING THE KEY WHILE STATIONARY, NO ONE IS SITTING IN THE PASSENGER SEAT WHEN THIS HAPPENS AND DOES NOT GO AWAY WHEN OCCUPIED. *TR

MY CAR CAUGHT FIRE WHILE DRIVING. I HAD BEEN DRIVING FOR ABOUT AN HOUR ON THE HIGHWAY. THERE WAS NO WARNING. NO CEL OR ERRORS ON THE DASH DISPLAY. CAR WAS RUNNING NORMALLY. I NOTICED SOME SMOKE. AFTER PULLING TO THE SIDE OF THE ROAD FLAMES STARTED COMING FROM UNDER THE HOOD. THE CAR WAS STILL RUNNING NORMALLY. I SHUT OFF THE MOTOR AND GOT OUT. BYSTANDERS EMPTIED AN EXTINGUISHER THROUGH THE FRONT GRILLE BUT WITHIN MINUTES THE ENTIRE VEHICLE WAS ENGULFED. CAR WAS ALMOST COMPLETELY DESTROYED. FIRE BURNED THROUGH THE FIREWALL AND CONSUMED THE INTERIOR.

Fire

MY CAR CAUGHT FIRE WHILE DRIVING. I HAD BEEN DRIVING FOR ABOUT AN HOUR ON THE HIGHWAY. THERE WAS NO WARNING. NO CEL OR ERRORS ON THE DASH DISPLAY. CAR WAS RUNNING NORMALLY. I NOTICED SOME SMOKE. AFTER PULLING TO THE SIDE OF THE ROAD FLAMES STARTED COMING FROM UNDER THE HOOD. THE CAR WAS STILL RUNNING NORMALLY. I SHUT OFF THE MOTOR AND GOT OUT. BYSTANDERS EMPTIED AN EXTINGUISHER THROUGH THE FRONT GRILLE BUT WITHIN MINUTES THE ENTIRE VEHICLE WAS ENGULFED. CAR WAS ALMOST COMPLETELY DESTROYED. FIRE BURNED THROUGH THE FIREWALL AND CONSUMED THE INTERIOR.

Fire

MY CAR CAUGHT FIRE WHILE DRIVING. I HAD BEEN DRIVING FOR ABOUT AN HOUR ON THE HIGHWAY. THERE WAS NO WARNING. NO CEL OR ERRORS ON THE DASH DISPLAY. CAR WAS RUNNING NORMALLY. I NOTICED SOME SMOKE. AFTER PULLING TO THE SIDE OF THE ROAD FLAMES STARTED COMING FROM UNDER THE HOOD. THE CAR WAS STILL RUNNING NORMALLY. I SHUT OFF THE MOTOR AND GOT OUT. BYSTANDERS EMPTIED AN EXTINGUISHER THROUGH THE FRONT GRILLE BUT WITHIN MINUTES THE ENTIRE VEHICLE WAS ENGULFED. CAR WAS ALMOST COMPLETELY DESTROYED. FIRE BURNED THROUGH THE FIREWALL AND CONSUMED THE INTERIOR.

Fire

PASSENGER SIDE AIRBAG SEAT MAT IS DEFECTIVE. JUST STOPPED WORKING. COST TO REPLACE IS OVER $2000. SO, THE WARNING LIGHT FOR DEFECTIVE AIRBAG SENSOR REMAINS ON.

AT 32000 MILES AN OIL LEAK WAS NOTED ON THE GARAGE FLOOR. THE FOREIGN CAR REPAIR SHOP TROUBLESHOT THE LEAK. FINAL OUTCOME: REPLACE SUPERCHARGER ASSEMBLY, VACUUM BRAKE BOOSTER PUMP AND INTAKE MANIFOLD GASKET. TOTAL COST $3,014.78 FOR A VEHICLE THAT HAS A TRADE-IN VALUE OF LESS THAN $5,000. THE FOREIGN CAR EXPERT WAS AMAZED THAT THE TURBO HAD TO BE REPLACED WITH SUCH LOW MILEAGE.

WHILE DRIVING AT HIGHWAY SPEED ON I-71 N & N. BROADWAY EXIT IN COLUMBUS, OHIO ON MARCH 1, 2019 THE TIMING CHAIN BROKE AND CAUSED COMPLETE ENGINE FAILURE AND BENT ALL VALVES AND CYLINDER HEAD AND VALVES RESULTING IN $8821.97 IN DAMAGE TO MY ENGINE. THE CAUSE OF THE TIMING CHAIN FAILURE IS DUE TO THE PRINCE/PSA ENGINE DESIGN AND MANUFACTURING DEFECT ADMITTED TO IN THE CLASS ACTION LAWSUIT KNOW AS JOSHUA SKEEN AND LAURIE FREEMAN V. BMW OF NORTH AMERICA, L.LC. UNITED STATES DISTRICT COURT DISTRICT OF NEW JERSEY CIV. NO. 2:13-CV-1531-WHW-CLW. BMW DECLINED TO REPLACE MY ENGINE UNDER THE EXTENDED WARRANTY AGREED TO IN THE SETTLEMENT AGREEMENT OF THE ABOVE CITED ACTION. ALL AFFECTED VEHICLES SHOULD HAVE BEEN RECALLED AND MY ENGINE FAILURE COULD HAVE EASILY CAUSED LOSS OF LIFE. MY VEHICLE IS ONE OF THE CLASS VEHICLES, R56 N14 ENGINE PRODUCED BETWEEN 2006 THRU 2010. THIS IS A PRODUCT LIABILITY SAFETY CLAIM THAT IS NOT SUBJECT TO ANY STATUTORY/WARRANTY TIME LIMITATION. ALL CLASS VEHICLES SHOULD BE RECALLED DUE TO THE LOSS OF LIFE AND SAFETY RISKS. DO NOT WAIT FOR LOSS OF LIFE TO ENFORCE THE LIABILITY OF BMW FOR THEIR FAILURE TO SELF REPORT THE DESIGN DEFECT AND FAILURE TO VOLUNTARILY RECALL ALL AFFECTED VEHICLES.

TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING 60 MPH, THE TIMING CHAIN FRACTURED, CAUSING A COMPLETE ENGINE FAILURE. ALL THE VALVES AND CYLINDER HEADS WERE BENT. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SHOULDER EVEN AFTER THE VEHICLE LOST ALL POWER. THE VEHICLE WAS TOWED TO THE DEALER (MIDWESTERN AUTO GROUP, 6335 PERIMETER LOOP RD, DUBLIN, OH 43017, (614) 889-2571 WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED AT A COST OF OVER $8,000. THE CONTACT NOTIFIED THE MANUFACTURER AND WAS PROVIDED A CLAIM NUMBER. THE MANUFACTURER DID NOT ASSIST WITH THE WARRANTY OR RECALL,S BUT OFFERED TO PAY $2,000 TOWARDS THE REPAIR COST. THE OFFER WAS GOOD FOR SIX MONTHS. THE FAILURE MILEAGE WAS 70,674.

MY MINI COOPER HAS A TIMING CHAIN PROBLEM IT RATTLES UPON STARTING AND I HAVEN'T DRIVEN IT .....I JUST FOUND OUT ABOUT THIS RECALL

THE VEHICLE LOST POWER WHILE DRIVING ON THE HIGHWAY AND A MINI DEALERSHIP HAS CONFIRMED THAT THE TIMING CHAIN IS THE PROBLEM ALONG WITH THE VALVES (POSSIBLY CAUSED BY THE TIMING BEING OFF). MULTIPLE CONVERSATIONS WITH MINI CUSTOMER RELATIONS HAVE GOTTEN NO WHERE AND THE MANUFACTURER REFUSES TO TAKE RESPONSIBILITY FOR THE KNOWN ISSUES WITH THE TIMING CHAIN IN THIS VEHICLE. DESPITE A CLASS ACTION LAWSUIT SPECIFICALLY ABOUT THE TIMING CHAIN, NO RECALL HAS BEEN ISSUED AND THE MANUFACTURER REFUSES TO ASSIST CUSTOMERS WITH NECESSARY REPAIRS TO THIS DEFECTIVE PART (AND OTHER DAMAGE CAUSED BY THE DEFECT). THESE TIMING CHAIN ISSUES ARE NOT ONLY AN UNDUE BURDEN ON THE CONSUMER, THEY CAN BE POTENTIALLY FATAL IF A TIMING CHAIN FAILS AT AN UNFORTUNATE MOMENT. MINI NEEDS TO ISSUE A RECALL.

WHILE TRAVELING ON I-10 IN TALLAHASSEE, FL AT HIGHWAY SPEED OF 70 MPH THE CAR SUDDENLY LOST POWER. BEING I THE CENTER LANE OF EIGHT (FOUR EACH DIRECTION) IT WAS ALMOST IMPOSSIBLE TO GET OUT OF TRAFFIC. SEVERAL VEHICLES MADE ABRUPT MANEUVERS TO AVOID A CRASH. ALSO AS I GOT OUT OF THE VEHICLE WAS NEARLY STRUCK BY OTHER CARS. I LATER FOUND OUT THIS WAS DUE TO A FAILED TIMING CHAIN WITH NUMEROUS COMPLAINTS AND NO RECALL. THERE WAS ALSO A CLASS ACTION SETTLEMENT AND STILL NO RECALL. THIS COULD HAVE WELL BEEN A FATAL INCIDENT.

AS SOON AS CAR BEGINS TO MOVE THE DSC ERROR APPEARS AND THE DSC NO LONGER WORKS. I HAVE BEEN TOLD THAT THE SZL MODULE THAT CONTROLS THIS HAS FAILED AND APPARENTLY DOES THIS WITH OTHER MINI'S AS WELL.

CAR TAKES A WHILE TO "WARM UP" HOWEVER AFTER A VERY SHORT DRIVE THE HOOD IS HOT TO THE TOUCH. IT ALSO SMELLS HOT. I LOOKED ON LINE AND SEEN SEVERAL COMPLAINTS AND THERE IS ACTUALLY AN AFTER MARKET 'DEFLECTOR' TO CHANNEL HEAT FROM THE HOOD. I HAVE NOTICED THE PLASTIC HOOD SCOOP IS DEFORMED FROM HEAT. I FEEL IT IS A MATTER OF TIME BEFORE A FIRE OR OTHER REACTION, E.G., HEAT CAUSES ANOTHER PART TO FAIL AND CAR WONT STOP, ACCELERATE OR OTHER CAUSING A CRASH. I ALSO NOTICED THE HEADLIGHT WIRING TO BE FRAYED AS IF IT HAS BEEN HOT.

TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING VARIOUS SPEEDS, SPECIFICALLY WHEN ATTEMPTING TO TURN THE VEHICLE, THE POWER STEERING SUDDENLY FAILED AND CAUSED STEERING CONTROL TO BECOME DIFFICULT. THE CONTACT STATED THAT THE POWER STEERING PUMP WOULD OVERHEAT, WHICH CAUSED THE CONTACT TO PARK THE VEHICLE UNTIL IT COOLED IN ORDER FOR THE POWER STEERING TO FUNCTION CORRECTLY. THE CONTACT CALLED MINI OF KENNESAW (2275 BARRETT LAKES BLVD, KENNESAW, GA 30144; 678-496-9565) WHO ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT COVERED UNDER THE EXTENDED WARRANTY OR A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

SEAT BELT WARNING LIGHT COMES ON WHEN STARTING CAR. CALLED LOCAL MINI DEALERSHIP AND WAS TOLD THERE WAS AN "EXTENDED WARRANTY" FOR SEAT MAT SENSOR.

MY CAR HAS 114,000 MILE ON IT. THE HIGH PRESSURE FUEL PUMP WAS REPLACED PER RECALL. THE ENGINE HAS FAILED WITH BAD INJECTORS, CYLINDERS AND RINGS. MECHANIC SAID THIS FAILURE IS PERVASIVE IN 2002 TO 2008 MODELS DO TO POOR DESIGN. THE COST TO REPAIR IS TOO HIGH.

I WAS IN A BAD CAR ACCIDENT IN WHICH MY CAR WAS REAR ENDED. I WAS IN THE VERY MOST RIGHT HAND LANE ON THE HIGHWAY, AT A STOP IN STOP AND GO TRAFFIC. THE VEHICLE BEHIND ME DID NOT STOP, HITTING ME AT APPROXIMATELY 75 MPH. AS A RESULT, MY CAR SPUN OUT TO THE RIGHT AND HIT THE GUARD RAIL ON THE SIDE OF THE HIGHWAY HEAD ON. THE CAR THEN BOUNCED OFF OF THE GUARD RAIL, AND SPUN ABOUT 180 DEGREES TO THE LEFT, WHERE THE REAR END OF THE CAR THEN HIT THE SAME GUARD RAIL AND FINALLY STOPPED. WHEN THE CAR CRASHED INTO THE GUARD RAIL HEAD ON, THE AIR BAG DID NOT DEPLOY AND I HIT MY HEAD AND MY CHEST AGAINST THE STEERING WHEEL. I SUSTAINED A FRACTURE IN MY T2 VERTEBRAE AND BAD CHEST BRUISING.

Crash 1 injured

AIRBAG PASSENGER SIDE LIGHT ON W ONLY 25000 MILES ON IT, MECHANIC TOLD ME IT'S A SHORT IN THE WIRING CAUSED BY SUNROOF SLICING INTO IT. SAID HE COULD FIX IT BUT HEADLINER HAS TO COME DOWN AND HE DOESN'T DO THAT KIND OF WORK. CONTACTED MINI USA AND WAS TOLD IT'S OUT OF WARRANTY AND DEALER PROB WON'T FIX IT WITHOUT CHARGE. WHEN SOMEONE GETS KILLED OR MAMED, MAYBE THEY'LL RECALL. COST TO REPAIR ABOUT $5K...

TL* THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V657000 (ENGINE AND ENGINE COOLING), BUT THE REPAIR WAS NOT COMPLETED BEFORE THE CONTACT OWNED THE VEHICLE. IN ADDITION, THE CONTACT EXPERIENCED A FAILURE CONCERNING NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHO PROVIDED AN OIL CHANGE AND CLEARED A DTC. THE CONTACT LATER EXPERIENCED EXTREME SMOKE EMITTING ON THE OUTSIDE OF THE VEHICLE TO THE INSIDE OF THE VEHICLE. THE VEHICLE WAS COASTED OVER TO THE SIDE OF THE ROAD AND TOWED TO A REPAIR SHOP. THE MECHANIC DIAGNOSED THAT THE WATER PUMP LEAKED, THE ENGINE OVER HEATED, THE CYLINDER HEAD WAS WARPED, AND THE OIL FILTER HOUSING GASKET WAS LEAKY. THE MECHANIC DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE CONTACT WAS UNCERTAIN IF THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

Fire

THE TURBO OIL FEED LINE IS INHERENTLY FLAWED AND PREMATURELY FAILS BECAUSE OF A BAD DESIGN. THIS FAILURE CAUSES HOT OIL TO LEAK ALL OVER A HOT TURBO. I WAS LUCKY ENOUGH TO NOT HAVE MY ENGINE CATCH FIRE WITH THE FAILED O-RING ON MINE. I WAS DRIVING ON THE HIGHWAY WHEN LARGE CLOUDS OF SMOKE BEGIN TO FLOW FROM THE ENGINE COMPARTMENT. I WAS FORCED TO PULL OVER AND GET TOWED HOME. I WAS OUT OF WARRANTY BUT STILL VERY LOW MILEAGE (48K) WHEN MINE FAILED. *TR

PRISTINE CONDITION, LOW MILEAGE, DEALER SERVICED MINI COOPER S (OWNED SINCE NEW) BEGAN EXHIBITING A RATTLING NOISE FROM ENGINE AT 34K MILES. DEALER DIAGNOSED IT AS A TIMING CHAIN DEFECT AND TIMING CHAIN TENSIONER DEFECT. THIS IS A KNOWN ENGINE DEFECT. REFERENCE CLASS ACTION SUIT AND SETTLEMENT 338403. THIS SETTLEMENT BY BMW/MINI USA COVERS THIS FLAW AND BMW/MINI KNOWS THAT VEHICLES PRODUCED WITHIN THE 2007-2010 TIMEFRAME HAVE THIS FLAW. THIS FLAW CAN RESULT IN CATASTROPHIC ENGINE FAILURE. IN MY CASE, IT WAS NOISY UNDER ACCELERATION, AND WAS INTO THE DEALER FOR SERVICE WITHIN DAYS OF FIRST ISSUE. THIS IS A KNOWN FLAW. HOWEVER, BMW/MINI SETTLED THE CLASS ACTION LAWSUIT AND SET ASIDE MILLIONS OF DOLLARS FOR CLAIMS....BUT THOSE CLAIMS MUST BE FILED BY 7/1/16. I DID NOT HAVE THE ISSUE BEFORE THAT DATE, I HAD IT HAPPEN IN SEPTEMBER 2016 - TWO MONTHS LATER. I HAVE REQUESTED SOME ACCOMMODATION FROM BMW/MINI, HOWEVER THEY ARE REFUSING TO PARTICIPATE AT ANY LEVEL, EVEN THOUGH THEY KNOW THIS WAS A FLAWED PART AND COULD HAVE CAUSED SIGNIFICANT DAMAGE. I AM NOT EXPECTING FULL REIMBURSEMENT, BUT IF THEY KNOW THE CAR HAS A MAJOR FLAW, THEY SHOULD HAVE SOME COVERAGE IN PLACE FOR ANY OF THESE VEHICLES WITH THE FLAW. THUS FAR THE REGIONAL SERVICE MANAGER AND MINI USA HAVE INDICATED BECAUSE THIS HAPPENED AFTER 7/1/16 THEY WILL NOT ACCOMMODATE.

FUEL SMELL STARTED TO GET STRONGER IN THE CABIN AND OUTSIDE OF THE VEHICLE, BUT DID NOT SEE ANY LEAKS ON THE FLOOR TILL TODAY. I ALSO NOTICE THE GREEN TEMPERATURE NOTIFICATION COME ON TODAY. I HAD MY OIL CHANGED AT THE BMW/MINI DEALER IN ONTARIO LAST MONTH.

STARTING AROUND 65,000 MILES PASSENGER AIRBAG SENSOR APPEARED ON THE DASHBOARD WHEN CAR WOULD BE TURNED ON AND WOULD REMAIN ON WHILE DRIVING EVEN THOUGH NO ONE WAS IN THE PASSENGER SEAT. HAD IT CHECKED BY LOCAL MINI WORKSHOP AND THEY SAID IT WAS DUE TO THE DEFECTIVE PASSENGER AIRBAG MAT IN 2001-2008 MODELS. THEY LOOKED UP MY CAR FOR RECALL USING MY VIN AND MY CAR WAS NOT INCLUDED, THOUGH THE 2008 COOPER S CONVERTIBLE THAT USES THE SAME EXACT PART WAS INCLUDED. THIS MAKES ABSOLUTELY NO SENSE WHATSOEVER. THIS IS A SAFETY RECALL!! ALL MODELS SHOULD BE INCLUDED SINCE ALL MODELS HAVE THE PROBLEM!! IT IS COMPLETELY ABSURD THAT MINI WOULD PICK AND CHOOSE WHICH OF THEIR CUSTOMER'S LIVES THEY WANT TO SAVE. I AM BEING QUOTED BETWEEN $700 AND $1200 TO GET THIS ISSUE FIXED. MINI SHOULD FOOT THAT BILL; THEY INSTALLED A DEFECTIVE PART THAT IS CRUCIAL IN THE SAFETY OF THEIR CUSTOMERS AND THEY NEED TO OWN UP TO IT.

TIMING CHAIN AND TIMING CHAIN TENSIONER BROKEN AND DAMAGED THE ENGINE AT MILE 48544 - 48552

TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING VARIOUS SPEEDS, THE FRONT PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEAT OCCUPANCY MAT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

TAKATA RECALL: MY 2008 MINI COOPER S HARDTOP BEGAN EXPERIENCING ISSUES WITH THE "PASSENGER AIR BAG OFF" LIGHT STAYING LITE WHETHER OR NOT A PASSENGER IS IN THE CAR. ON APRIL 28, 2016, I TOOK MY CAR TO A MINI COOPER DEALERSHIP TO HAVE THE ISSUE DIAGNOSED (AT A COST OF $53.95). THE DIAGNOSIS STATES "FAULT PASSENGER SIDE SEAT MAT SENSOR" (INVOICE COPY ATTACHED). I DON'T UNDERSTAND WHY MY VEHICLE THAT MEETS THE CRITERIA FOR THE APRIL 2015 AIR-BAG RECALL EXCEPT IT IS A HARDTOP INSTEAD OF A CONVERTIBLE IS NOT INCLUDED IN THE RECALL. TO FIX THIS ITEM WILL BE OVER 1300. MY CAR ONLY HAS 14,000 MILES ON IT. DUE TO THE COST, AT THIS POINT I DO NOT PLAN ON HAVING IT FIXED AND WILL SAY MY PRAYERS EVERY TIME I TRAVEL WITH A PASSENGER IN THE VEHICLE.

TL* THE CONTACT OWNED A 2008 MINI COOPER S. WHILE DRIVING APPROXIMATELY 70 MPH, AN ABNORMAL NOISE WAS HEARD AND THE CONTACT NOTICED THICK, GREY SMOKE COMING FROM THE FRONT OF THE VEHICLE. THE OIL WARNING LIGHT ILLUMINATED. THE CONTACT OPENED THE HOOD AND NOTICED FLAMES IN THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT AND A FIRE REPORT WERE FILED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS TOWED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,777.

Fire

I OWN A 2008 MINI COOPER S AND IT HAS 62000 MILES ON IT. AS MANY OTHER MINI OWNERS, I HAVE " RATTLE NOISE" ISSUE WHEN COLD START AND POPPED UP "ENGINE OIL PRESSURE TOO LOW" WARNING YESTERDAY WHEN DROVE HOME ON CITY STREET. THIS VEHICLE HAS HAD THE TIMING CHAIN TENSIONER/GUIDE CHANGED ONCE BEFORE AT 18,942 BY A MINI DEALER.

THE SEAT OCCUPANCY SENSOR MALFUNCTIONS. THE PASSENGER SIDE AIRBAG MAY NOT DEPLOY EVEN IF THE PASSENGER SIDE SEAT IS OCCUPIED. THE AIRBAG LIGHT SOMETIMES STAYS ON, WHILE SOMETIMES GOES AWAY. MINI HAS RECALLED SEVERAL CARS FOR SEAT OCCUPANCY SENSOR MAT FAULT BUT MY CAR ISN'T ON THE LIST. THE LIGHT STAYS ON WHEN VEHICLE IS STATIONARY AND ALSO WHILE RUNNING. I'M UNABLE TO USE THE PASSENGER SEAT FOR SAFETY CONCERN. THE AIRBAG LIGHT GOES AWAY ON ITS OWN AS WELL BUT TURNS BACK ON WITHIN A FEW MILES.

PASSENGERS AIR BAG APPEARS OFF WHEN SOMEONE ARE SEAT. THIS EVOLVE A SERIOUS SAFETY ISSUE IN CASE OF ACCIDENT.

DRIVERS FOOT WELL GETS SO HOT THAT YOU CAN NOT TOUCH THE PLASTIC BY THE ACCELERATOR AND YOUR FOOT STARTS COOKING AFTER 20 MINUTES OR SO.

AIR BAG WARNING LIGHT ON. PASSENGER AIRBAG OFF DESPITE SOMEONE SITTING IN THAT SEAT

ENGINE RATTLE UPON STARTUP. NEXT THING I KNOW IS THE TIMING CHAIN GUIDES BROKE AND THE VALVES BENT. THOUSANDS IN REPAIR AND MINI WON'T COVER A THING.

AS MANY OTHERS HAVE POSTED HERE, MY ENGINE BEGAN RATTLING LOUDLY WHEN I WOULD START IT UP. TO ALLEVIATE THIS, I WOULD TOP OFF THE OIL AND GET FREQUENT OIL CHANGES, IN FACT, MORE OFTEN THAN MINI/BMW SUGGESTED IT SHOULD GET AN OIL CHANGE. THIS WOULD USUALLY TAKE CARE OF THE RATTLE. ONE NIGHT, THE ENGINE RATTLE KEPT INCREASING AND SUDDENLY THE CAR STOPPED IN THE MIDDLE OF A BUSY STREET JUST 20 FEET FROM RAILROAD TRACKS WITHOUT ANY WARNING LIGHTS OR INDICATIONS WHATSOEVER. I HAD IT TOWED TO A NEARBY MECHANICS SHOP I TRUST (NOT THE DEALERSHIP). THE TIMING CHAIN HAD BROKEN AND BENT THE VALVES AND I'M IN THE PROCESS OF HAVING A NEW ENGINE PUT IN (WITH THE SAME FAULTY TIMING CHAIN) TO THE TUNE OF $6,500. I CALLED MINI/BMW USA BECAUSE MY MECHANIC SAID HE'S SEEN THIS PROBLEM FREQUENTLY IN MY MODEL. MINI SAID THEY WOULD NOT DO ANYTHING FOR ME UNLESS THE CAR WAS DIAGNOSED BY THE MINI DEALERSHIP, AND EVEN THEN THERE WOULD BE NO GUARANTEE THEY WOULD COVER ANYTHING BECAUSE OF "MY VEHICLE'S AGE." MINI/BMW USA WOULDN'T EVEN ACKNOWLEDGE THAT THERE HAVE BEEN FREQUENT REPORTS OF TIMING TENSIONER/CHAINS HAVING PROBLEMS. I'M EVEN MORE SURPRISED HOW FREQUENT THIS PROBLEM IS NOW THAT I'M LOOKING ON THE NHTSA WEBSITE. THIS NEEDS TO BE A RECALL AND SOMETHING THAT MINI/BMW SHOULD COVER AND RESPOND TO, SINCE THERE HAVE BEEN SEVERAL CLASS ACTION LAWSUITS AGAINST THE COMPANY BECAUSE OF THIS.

AIR BAG WARNING WITH THE FAULT CODE 93C3 WHICH HAS CAUSED A RECALL OF 91 THOUSAND VEHICLES... MY MINI S IS NOT A RECALL CAR. (ON THE SAME GRID AS THE RECALLED MINI'S...SAME OEM REPAIR PARTS) MINI USA REPRESENTATIVE [JAMIE] SUGGESTED I REMOVE THE AIR BAG AND PUT A SIGN UP IN THE DASH INDICATING 'NO AIR BAG" IF I DID NOT WANT TO PAY THE $1500.00+ IN REPAIIR COST... AND THAT WILL ALLOW ME TO PASS THE STATE INSPECTION.

I BOUGHT THIS CAR USED WITH 86,100 MILES ON IT. WHEN DRIVING WITHIN THE FIRST 500 MILES, THE AIRBAG LIGHT AND SEAT BELT RESTRAINT SYSTEM INDICATED ON MY DASH (BOTH THE TACHOMETER AND THE SPEEDOMETER). AN ALERT FOR THE AIRBAG APPEARS AS AN ICON ON THE TACHOMETER. I TOOK THE CAR TO THE DEALERSHIP WHO INDICATED THE AUTO GOT WET WHICH CAUSED THE AIR BAG MODULE TO FAIL, WHICH NOW NEEDS REPLACEMENT AT A RIDICULOUSLY HIGH COST.

AFTER MINI/BMW REPAIRED THE TIMING CHAIN TENSIONER AND THE TIMING CHAIN, MY TURBO OIL SUPPLY LINE DEVELOPED A SIGNIFICANT LEAK (WITHIN A WEEK/ WITHIN 200 MILES OF MINI SERVICE) CAUSING SMOKE TO ESCAPE FROM THE BONNET, OIL TO COVER THE FRONT ENGINE/TURBO/EXHAUST. OIL NOW PUDDLES BENEATH THE CAR WHEN PARKED. THE CAR HAS 89,XXX MILES. I FIRST NOTICED THE SMELL OF BURNING OIL WHEN DRIVING ACROSS TOWN AT A SPEED OF 40MPH. WHEN PARKING THE VEHICLE, UPON IDLE THE SMOKE BILLOWED FROM THE BONNET OF THE CAR. ACCORDING TO MINI FORUMS, THIS PROBLEM OF A FAILED O-RING IN THE TURBO OIL SUPPLY LINE IS A KNOWN PROBLEM RESULTING IN NUMEROUS FAILURES THAT CAN LEAD TO CATASTROHIC DAMAGE TO THE TURBO, CATALYTIC CONVERTER, AND ENGINE.

THE MILEAGE ON THE VEHICLE 16600MILES. THE WARNING LIGHT FOR THE FRONT PASSENGER AIRBAG GOES ON INTERMITTENTLY. THE LIGHT FOR THE FRONT PASSENGER AIRBAG ILLUMINATES "OFF". TOOK TO DEALERSHIP AND FOUND THE PASSENGER SEAT MAT FAULTY. STARTED FLICKERING WHILE DRIVING BUT NOW THE LIGHT IS ON CONSTANTLY WHEN START CAR AND DRIVING. I HAVE READ THAT THERE IS A RECALL FOR THIS PROBLEM FOR VEHICLES MANUFACTURED UP TO JULY 2008. MY MINI S SHOWS A PRODUCTION DATE 8/01/08. I HAD THIS CAR BUILT TO MY SPECIFICATION IN JULY 2008. I HAVE PAID FOR THE PART BECAUSE I BELIEVE THIS IS FOR THE SAFETY FOR WHOM EVER RIDES WITH ME BUT THE PART IS ON BACKORDER AND WE ARE WAITING FOR IT TO ARRIVE FROM GERMANY. BMW/MINI HAVE NOT RESOLVED THE ISSUE IF IT IS STILL HAPPENING. THE COST TO REPAIR IS APPROX.$ 2153.00. IF I WAIT TILL I GET A RECALL AND THERE IS A FATALITY.....? IF AT A LATER DATE A RECALL IS MADE FOR MY VEHICLE CAN I GET THE FULL COST REIMBURSED?

WHEN STARTING CAR, I GET A GRINDING, RATTLING NOISE FROM THE ENGINE. I HAVE BEEN TOLD THIS IS THE CHAIN TENSIONER ON THE CAR