2006 MACK CV
5 recalls, 0 complaints - 47 TSBs
07V497000 Oct 23, 2007
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN... Read more
Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT MACK TRUCKS AT 1-800-528-6586.
07V360000 Aug 15, 2007
PARKING BRAKE
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.
Consequence
THIS COULD DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.
Remedy
MACK IS WORKING WITH BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 10, 2008. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000 OR MACK AT 1-800-528-6586.
07V361000 Aug 15, 2007
SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH PARKER SINGLE CHECK VALVES (SCV) PROVIDED BY BENDIX. THE DEFECT EXISTS IN THE PARKER SCV THAT CONNECTS WITH THE SUPPLY PORT OF THE SR-7 SPRING BRAKE MODULATING VALVE. AFTER PROLONGED USE OF THE PARKER SCV, THE VALVE BODY RETAINER MAY BECOME EXCESSIVELY WORN AND EVE... Read more
Consequence
THIS CONDITION CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON. THESE CONDITIONS CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY, BRAKE DRAG, OR IN THE CASE OF LOSS OF PRIMARY CIRCUIT, INABILITY TO MODULA... Read more
Remedy
MACK IS WORKING WITH BENDIX TO REPLACE THE PARKER SINGLE CHECK VALVE. THE RECALL BEGAN ON JANUARY 9, 2008. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000 OR MACK AT 1-800-528-6586.
06V319000 Aug 29, 2006
SERVICE BRAKES, AIR
Defect Description
CERTAIN TRUCKS EQUIPPED WITH A FRONT GLAD HAND OPTION FAIL TO COMPLY WITH THE PERFORMANCE CRITERIA REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, 'AIR BRAKE SYSTEMS.'
Consequence
THE PURPOSE OF THIS STANDARD IS TO INSURE SAFE BRAKING PERFORMANCE UNDER NORMAL AND EMERGENCY CONDITIONS.
Remedy
DEALERS WILL REPLACE THE SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2006. OWNERS MAY CONTACT MACK TRUCK AT 1-800-528-6586.
05V349000 Jul 28, 2005
STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT
Defect Description
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE PITMAN ARM TO THE STEERING GEAR MAY NOT BE TIGHTENED PROPERLY.
Consequence
THIS MAY AFFECT THE PERFORMANCE OF THE STEERING, WHICH MAY RESULT IN A CRASH.
Remedy
DEALERS WILL CHECK THE TORQUE ON THE BOLT THAT ATTACHES THE PITMAN ARM TO STEERING GEAR AND TIGHTEN THE BOLT PROPERLY. THE RECALL BEAGN AUGUST 18, 2005. OWNERS CONTACT MACK AT 1-800-2528-6586.
No complaints found for this vehicle.
Technical Service Bulletins, 2006 MACK CV
47 manufacturer communications from 35 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 060000 ENGINE AND ENGINE COOLING | 12 |
| 110000 ELECTRICAL SYSTEM | 7 |
| 100000 POWER TRAIN | 5 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 3 |
| 180000 VEHICLE SPEED CONTROL | 2 |
| 980000 UNKNOWN OR OTHER | 2 |
| 161000 STRUCTURE:FRAME AND MEMBERS | 2 |
| 020000 SUSPENSION | 2 |
M-465-001 202311
Nov 7, 2023
100000 POWER TRAIN
TSB: Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family carriers. The new HD shaft went into production on January 23rd, 2023 for 2.54 - 3.50 axle ratios and April 1st, 2023 for 3.56 - 3.
M728-005A 202308
Aug 14, 2023
020000 SUSPENSION
TSB: Barksdale Leveling Valve, Leak Test
KC-614-Ver4
May 24, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
CBR: eWarranty To UCHP Labor Code ( SCC Code ) Crossover, Conversion Information For Use With Campaigns ( FI, PI ) And Recalls ( EC, SC ), Location On Trucks Dealer Portal ( TDP )
KC-750
Jun 28, 2022
060000 ENGINE AND ENGINE COOLING
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting.
KC-745
Jun 22, 2022
100000 POWER TRAIN
Automated Manual Transmission ( AMT ) I-Shift / mDRIVE - Ribbon Harness Replacement - Speed Sensor Bolts, Possible Fault Codes P1058 - 21 Or MID 130 PID 161 FMI 1
KC-2112
Jun 21, 2022
110000 ELECTRICAL SYSTEM
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2112
Jun 21, 2022
100000 POWER TRAIN
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2112
Jun 21, 2022
060000 ENGINE AND ENGINE COOLING
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2143
Jun 21, 2022
180000 VEHICLE SPEED CONTROL
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP).
KC-2171
May 26, 2022
060000 ENGINE AND ENGINE COOLING
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-2165
May 26, 2022
060000 ENGINE AND ENGINE COOLING
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2158
May 26, 2022
060000 ENGINE AND ENGINE COOLING
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2131
May 26, 2022
060000 ENGINE AND ENGINE COOLING
USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E
KC-2116
May 26, 2022
060000 ENGINE AND ENGINE COOLING
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-714
May 25, 2022
060000 ENGINE AND ENGINE COOLING
Mack Chassis - Diagnostic Trouble Codes ( DTC's ) - P020113, P020213, P020313, P020413, P020513, P020613, Cylinders 1 Through 6 Injector A Open Circuit
KC-698
May 24, 2022
060000 ENGINE AND ENGINE COOLING
Mack Chassis - Diesel Exhaust Fluid ( DEF ) System Cleaning/Flush After DEF Pump Failure Or System Contamination
KC-699
May 24, 2022
110000 ELECTRICAL SYSTEM
Mack Chassis - Bendix Vendor Configuration Program ( VCP ) Software Download Information
KC-686
May 20, 2022
180000 VEHICLE SPEED CONTROL
(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)
KC-686
May 20, 2022
251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)
KC-663
May 18, 2022
060000 ENGINE AND ENGINE COOLING
Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet - US07 Emissions
KC-653
May 17, 2022
060000 ENGINE AND ENGINE COOLING
Low Oil Pressure Diagnostic Process For 11 Liter Engines
KC-648
May 17, 2022
980000 UNKNOWN OR OTHER
Mack - PTO Pump Speed Calculator
KC-648
May 17, 2022
100000 POWER TRAIN
Mack - PTO Pump Speed Calculator
KC-2172
May 16, 2022
110000 ELECTRICAL SYSTEM
No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
KC-2172
May 16, 2022
980000 UNKNOWN OR OTHER
No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
KC-2170
May 16, 2022
020000 SUSPENSION
Electronically Controlled Suspension (ECS) Losing Air Pressure
KC-2169
May 16, 2022
110000 ELECTRICAL SYSTEM
Low Voltage Disconnect (LVD), Function Description
KC-2161
May 13, 2022
060000 ENGINE AND ENGINE COOLING
DEF Pump Cycling periodically Hours After Key Off
KC-627
May 9, 2022
350000 EQUIPMENT
Premium Tech Tool ( PTT ) Training Materials And Support Tools
KC-626
May 9, 2022
100000 POWER TRAIN
Mack Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, mDrive ), Premium Tech Tool ( PTT ) Gearbox Calibration Failure; Gearbox Calibration Operation Stops And Fails At 33% When Run With Transmission Removed
KC-692
Oct 11, 2021
120000 EXTERIOR LIGHTING
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
KC-692
Oct 11, 2021
120100 EXTERIOR LIGHTING:LIGHTING CONTROL MODULE
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
KC-692
Oct 11, 2021
110000 ELECTRICAL SYSTEM
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
K72614548
Feb 28, 2018
110000 ELECTRICAL SYSTEM
Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K04342327
Feb 27, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K01050303
Feb 27, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Diagnostic Trouble Code ( DTC ) P0471 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K58557784
Feb 20, 2018
110000 ELECTRICAL SYSTEM
Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS ); Possible Rough / Uneven Idle - OBD15 Chassis
K58557784
Feb 20, 2018
070000 FUEL SYSTEM, GASOLINE
Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS ); Possible Rough / Uneven Idle - OBD15 Chassis
FSB-711-006
May 1, 2011
161000 STRUCTURE:FRAME AND MEMBERS
MACK TRUCKS: LEFT SIDE FRAME BRACKET MAY CRACK. *RM
FSB-711-006
May 1, 2011
061000 ENGINE AND ENGINE COOLING:ENGINE
MACK TRUCKS: LEFT SIDE FRAME BRACKET MAY CRACK. *RM
FSB-214-024
Jan 1, 2011
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
MACK TRUCKS: THERE IS REVISED MOUNTING HARDWARE FOR THE EXHAUST MANIFOLD AND TURBOCHARGER. *RM
FSB-851-007
Sep 1, 2010
220100 SEATS:BARRIERS
MACK TRUCK: REAR TRIM PANEL WEAR PLATE, INSTALLATION. MODEL CHASSIS EQUIPPED WITH HIGH BACK OR MID BACK SEATS, THE SEAT BACK CAN RUB AND WEAR THROUGH THE REAR TRIM PANEL. DOES NOT APPLY TO CHASSIS EQUIPPED WITH SEARS BRAD SEATS. MODELS C
FSB-851-007
Sep 1, 2010
220000 SEATS
MACK TRUCK: REAR TRIM PANEL WEAR PLATE, INSTALLATION. MODEL CHASSIS EQUIPPED WITH HIGH BACK OR MID BACK SEATS, THE SEAT BACK CAN RUB AND WEAR THROUGH THE REAR TRIM PANEL. DOES NOT APPLY TO CHASSIS EQUIPPED WITH SEARS BRAD SEATS. MODELS C
SB-121037
Oct 28, 2008
160000 STRUCTURE
MACK TRUCKS: CRACKS IN LOWER FRAME FLANGE. ON CERTAIN CV AND RD MODEL CHASSIS EQUIPPED WITH CONSTANT SECTION FRAME RAILS, CRACKS MAY DEVELOP IN THE LOWER FRAME FLANGE IN THE AREA OF THE STEERING GEAR. *PE
SB-121037
Oct 28, 2008
161000 STRUCTURE:FRAME AND MEMBERS
MACK TRUCKS: CRACKS IN LOWER FRAME FLANGE. ON CERTAIN CV AND RD MODEL CHASSIS EQUIPPED WITH CONSTANT SECTION FRAME RAILS, CRACKS MAY DEVELOP IN THE LOWER FRAME FLANGE IN THE AREA OF THE STEERING GEAR. *PE
SB-121037
Oct 28, 2008
162000 STRUCTURE:BODY
MACK TRUCKS: CRACKS IN LOWER FRAME FLANGE. ON CERTAIN CV AND RD MODEL CHASSIS EQUIPPED WITH CONSTANT SECTION FRAME RAILS, CRACKS MAY DEVELOP IN THE LOWER FRAME FLANGE IN THE AREA OF THE STEERING GEAR. *PE
607
Apr 26, 2006
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
MISSING CABLE BOOT ON POSITIVE BATTERY TERMINAL. MACK CL, CV AND CTP MODEL CHASSIS. *TT
MACK CV - All Years Overview
Complete safety history for the MACK CV across all model years (1998, 2008).
46
Total Recalls
5
Total Complaints
0
Investigations
3
Reported Crashes
4
Reported Fires
1
Reported Deaths