2007 MACK CH
3 recalls, 0 complaints - 64 TSBs
07V401000 Sep 5, 2007
FUEL SYSTEM, DIESEL
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH ASET AC MODEL ENGINES, THE ENGINE AS CONFIGURED WITH AN EXTERNAL EXHAUST GAS RECIRCULATION SYSTEM MAKES SERVICING THE FUEL INJECTION LINES DIFFICULT WHEN USING TRADITIONAL TOOLS. THEREFORE, IT IS POSSIBLE FOR FUEL LEAKS TO DEVELOP WHEN REMOVING AND INSTALLING THE FU... Read more
Consequence
A LEAK IN THE FUEL INJECTION LINE MAY SPRAY FUEL ON THE HOT SURFACES OF THE EXHAUST GAS RECIRCULATION SYSTEM, WHICH COULD RESULT IN AN ENGINE FIRE.
Remedy
DEALERS WILL REPLACE THE FUEL INJECTION LINES FREE OF CHARGE. NOTE: THIS RECALL SUPERSEDES A PREVIOUS CAMPAIGN CONDUCTED IN 2006 (PLEASE SEE 06V392). THE RECALL BEGAN ON SEPTEMBER 11, 2007, WITH SUBSEQUENT MAILINGS EVERY SIX WEEKS UNTIL APRIL 2008. OWNERS MAY CONTACT MACK AT 800-528-6586.
07V159000 Apr 13, 2007
FUEL SYSTEM, DIESEL
Defect Description
CERTAIN TRUCKS WERE RECALLED FOR THE INSTALLATION OF SLEEVES ON THE FUEL INJECTION LINE AS REQUIRED BY SAFETY RECALL SC0317 (NHTSA RECALL NO. 06V392). THERE IS A POSSIBILITY THAT THE NEW SLEEVES MAY CHAFE THE FUEL INJECTION LINE.
Consequence
THIS COULD COMPROMISE THE FUEL INJECTION LINE OVER TIME WHICH COULD POSSIBLY RESULT IN AN ENGINE FIRE.
Remedy
DEALERS WILL REMOVE THE PROTECTIVE SLEEVES ON ALL FUEL INJECTION LINES FREE OF CHARGE. THIS RECALL BEGAN ON APRIL 19, 2007. OWNERS MAY CONTACT MACK TRUCKS AT 1-800-528-6586.
06V392000 Oct 13, 2006
FUEL SYSTEM, DIESEL
Defect Description
ON CERTAIN TRUCKS, A LEAK IN THE ASET AC FUEL INJECTION LINE MAY SPRAY FUEL ON THE EXHAUST GAS RECIRCULATION PIPES THAT CARRY HOT EXHAUST GASES .
Consequence
THIS COULD POTENTIALLY RESULT IN AN ENGINE FIRE.
Remedy
MACK HAS ISSUED A STOP WORK ON THIS CAMPAIGN UNDER FURTHER NOTICE (2-22-2007). THE REMEDY DOES NOT ADEQUATELY ADDRESS THE ISSUE ON ALL VEHICLES. MACK WILL RE-RELEASE THE RECALL IN THE NEAR FUTURE. (PLEASE SEE NHTSA NO. 07V159/MACK RECALL NO. SCO323 FOR VEHICLES THAT HAVE HAD THIS REPAIR ALREADY P... Read more
No complaints found for this vehicle.
Technical Service Bulletins, 2007 MACK CH
64 manufacturer communications from 47 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 060000 ENGINE AND ENGINE COOLING | 16 |
| 100000 POWER TRAIN | 9 |
| 110000 ELECTRICAL SYSTEM | 8 |
| 980000 UNKNOWN OR OTHER | 4 |
| 350000 EQUIPMENT | 3 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 3 |
| 020000 SUSPENSION | 2 |
| 180000 VEHICLE SPEED CONTROL | 2 |
CBR-202 202402
Feb 16, 2024
100000 POWER TRAIN
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
M-465-001 202311
Nov 7, 2023
100000 POWER TRAIN
TSB: Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family carriers. The new HD shaft went into production on January 23rd, 2023 for 2.54 - 3.50 axle ratios and April 1st, 2023 for 3.56 - 3.
M728-005A 202308
Aug 14, 2023
020000 SUSPENSION
TSB: Barksdale Leveling Valve, Leak Test
KC-614-Ver4
May 24, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
CBR: eWarranty To UCHP Labor Code ( SCC Code ) Crossover, Conversion Information For Use With Campaigns ( FI, PI ) And Recalls ( EC, SC ), Location On Trucks Dealer Portal ( TDP )
KC-474-Ver5
May 2, 2023
100000 POWER TRAIN
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
KC-395
Feb 8, 2023
110000 ELECTRICAL SYSTEM
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
M-265-002
Sep 22, 2022
060000 ENGINE AND ENGINE COOLING
TSB-Charge Air Cooler t-clamp install.
M-263-003
Aug 18, 2022
060000 ENGINE AND ENGINE COOLING
2009 Document reformatted to be published as a TSB in Impact. Fan Drive Belt Replacement MP7 Engine
M-258-006
Aug 18, 2022
060000 ENGINE AND ENGINE COOLING
2009 Document reformatted to be published as a TSB in Impact. DRV Air Line Service Kit
M-811-001
Aug 6, 2022
353000 EQUIPMENT:ELECTRICAL
2009 Document reformatted to be published as a TSB in Impact. Day cab Conversion Closure Panel
M-811-001
Aug 6, 2022
160000 STRUCTURE
2009 Document reformatted to be published as a TSB in Impact. Day cab Conversion Closure Panel
M-811-001
Aug 6, 2022
980000 UNKNOWN OR OTHER
2009 Document reformatted to be published as a TSB in Impact. Day cab Conversion Closure Panel
M-811-001
Aug 6, 2022
163200 STRUCTURE:INTERIOR PANELS:DOOR
2009 Document reformatted to be published as a TSB in Impact. Day cab Conversion Closure Panel
KC-750
Jun 28, 2022
060000 ENGINE AND ENGINE COOLING
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting.
KC-745
Jun 22, 2022
100000 POWER TRAIN
Automated Manual Transmission ( AMT ) I-Shift / mDRIVE - Ribbon Harness Replacement - Speed Sensor Bolts, Possible Fault Codes P1058 - 21 Or MID 130 PID 161 FMI 1
KC-2112
Jun 21, 2022
110000 ELECTRICAL SYSTEM
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2112
Jun 21, 2022
100000 POWER TRAIN
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2112
Jun 21, 2022
060000 ENGINE AND ENGINE COOLING
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2143
Jun 21, 2022
180000 VEHICLE SPEED CONTROL
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP).
KC-405
Jun 21, 2022
100000 POWER TRAIN
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation -
KC-2131
May 26, 2022
060000 ENGINE AND ENGINE COOLING
USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E
KC-2171
May 26, 2022
060000 ENGINE AND ENGINE COOLING
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-2165
May 26, 2022
060000 ENGINE AND ENGINE COOLING
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2158
May 26, 2022
060000 ENGINE AND ENGINE COOLING
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2116
May 26, 2022
060000 ENGINE AND ENGINE COOLING
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-714
May 25, 2022
060000 ENGINE AND ENGINE COOLING
Mack Chassis - Diagnostic Trouble Codes ( DTC's ) - P020113, P020213, P020313, P020413, P020513, P020613, Cylinders 1 Through 6 Injector A Open Circuit
KC-698
May 24, 2022
060000 ENGINE AND ENGINE COOLING
Mack Chassis - Diesel Exhaust Fluid ( DEF ) System Cleaning/Flush After DEF Pump Failure Or System Contamination
KC-699
May 24, 2022
110000 ELECTRICAL SYSTEM
Mack Chassis - Bendix Vendor Configuration Program ( VCP ) Software Download Information
KC-686
May 20, 2022
251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)
KC-686
May 20, 2022
180000 VEHICLE SPEED CONTROL
(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)
KC-663
May 18, 2022
060000 ENGINE AND ENGINE COOLING
Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet - US07 Emissions
KC-648
May 17, 2022
980000 UNKNOWN OR OTHER
Mack - PTO Pump Speed Calculator
KC-648
May 17, 2022
100000 POWER TRAIN
Mack - PTO Pump Speed Calculator
KC-653
May 17, 2022
060000 ENGINE AND ENGINE COOLING
Low Oil Pressure Diagnostic Process For 11 Liter Engines
KC-2169
May 16, 2022
110000 ELECTRICAL SYSTEM
Low Voltage Disconnect (LVD), Function Description
KC-2170
May 16, 2022
020000 SUSPENSION
Electronically Controlled Suspension (ECS) Losing Air Pressure
KC-2172
May 16, 2022
110000 ELECTRICAL SYSTEM
No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
KC-2172
May 16, 2022
980000 UNKNOWN OR OTHER
No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
KC-2161
May 13, 2022
060000 ENGINE AND ENGINE COOLING
DEF Pump Cycling periodically Hours After Key Off
KC-626
May 9, 2022
100000 POWER TRAIN
Mack Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, mDrive ), Premium Tech Tool ( PTT ) Gearbox Calibration Failure; Gearbox Calibration Operation Stops And Fails At 33% When Run With Transmission Removed
KC-627
May 9, 2022
350000 EQUIPMENT
Premium Tech Tool ( PTT ) Training Materials And Support Tools
KC-593
Apr 21, 2022
350000 EQUIPMENT
V-MAC - ABS Malfunction Lamp On - ( Eaton ABS Active Code 17-10 / Arvin Meritor Wabco Active Code 7-4 )
KC-593
Apr 21, 2022
040000 SERVICE BRAKES, AIR
V-MAC - ABS Malfunction Lamp On - ( Eaton ABS Active Code 17-10 / Arvin Meritor Wabco Active Code 7-4 )
KC-525
Feb 21, 2022
060000 ENGINE AND ENGINE COOLING
US07 / US10 D13 Turbocharger Gasket - Low Power, Poor Regen Performance
KC-525
Feb 21, 2022
102500 POWER TRAIN:MANUAL TRANSMISSION:SEALS/GASKETS
US07 / US10 D13 Turbocharger Gasket - Low Power, Poor Regen Performance
KC-692
Oct 11, 2021
120100 EXTERIOR LIGHTING:LIGHTING CONTROL MODULE
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
KC-692
Oct 11, 2021
120000 EXTERIOR LIGHTING
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
KC-692
Oct 11, 2021
110000 ELECTRICAL SYSTEM
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
S7496
May 6, 2020
060000 ENGINE (PWS)
Reman Engine Label Replacement
S7496
May 6, 2020
355100 EQUIPMENT:OTHER:LABELS
Reman Engine Label Replacement
K31822325
Dec 18, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
Mack Chassis - Differential Carrier Models CRD 125 And CRD 150 - New Differential Axle Seal Installation Tool; New Tool Required For New Input And Output Seal Installation
K31822325
Dec 18, 2019
350000 EQUIPMENT
Mack Chassis - Differential Carrier Models CRD 125 And CRD 150 - New Differential Axle Seal Installation Tool; New Tool Required For New Input And Output Seal Installation
K31822325
Dec 18, 2019
100000 POWER TRAIN
Mack Chassis - Differential Carrier Models CRD 125 And CRD 150 - New Differential Axle Seal Installation Tool; New Tool Required For New Input And Output Seal Installation
K72614548
Feb 28, 2018
110000 ELECTRICAL SYSTEM
Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K01050303
Feb 27, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Diagnostic Trouble Code ( DTC ) P0471 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K04342327
Feb 27, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K58557784
Feb 20, 2018
110000 ELECTRICAL SYSTEM
Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS ); Possible Rough / Uneven Idle - OBD15 Chassis
K58557784
Feb 20, 2018
070000 FUEL SYSTEM, GASOLINE
Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS ); Possible Rough / Uneven Idle - OBD15 Chassis
FSB-437-001
Sep 1, 2011
103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
MACK TRUCK: THE EASY INSTALLATION OF ALLISON TRANSMISSION AND PREVENTING BINDING OF TORQUE CONVERTER PILOT DURING THERMAL EXPANSION CYCLE OF NORMAL OPERATION BY USING HIGH TEMPERATURE MOLYBDENUM DISULFIDE GREASE. *PE
FSB-491-029
Sep 1, 2011
980000 UNKNOWN OR OTHER
MACK TRUCKS: THERE ARE CRACKS IN A STEEL OIL TUBE THAT CAN LEAD TO LEAKING. *RM UPDATED 2/21/12. *PE
FSB-461-001
Feb 1, 2011
022520 SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
MACK TRUCKS: REAR AXLE HOUSING REPLACEMENT. *RM
FSB-214-024
Jan 1, 2011
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
MACK TRUCKS: THERE IS REVISED MOUNTING HARDWARE FOR THE EXHAUST MANIFOLD AND TURBOCHARGER. *RM
FSB-851-007
Sep 1, 2010
220000 SEATS
MACK TRUCK: REAR TRIM PANEL WEAR PLATE, INSTALLATION. MODEL CHASSIS EQUIPPED WITH HIGH BACK OR MID BACK SEATS, THE SEAT BACK CAN RUB AND WEAR THROUGH THE REAR TRIM PANEL. DOES NOT APPLY TO CHASSIS EQUIPPED WITH SEARS BRAD SEATS. MODELS C
FSB-851-007
Sep 1, 2010
220100 SEATS:BARRIERS
MACK TRUCK: REAR TRIM PANEL WEAR PLATE, INSTALLATION. MODEL CHASSIS EQUIPPED WITH HIGH BACK OR MID BACK SEATS, THE SEAT BACK CAN RUB AND WEAR THROUGH THE REAR TRIM PANEL. DOES NOT APPLY TO CHASSIS EQUIPPED WITH SEARS BRAD SEATS. MODELS C
NHTSA Safety Investigations, MACK CH
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE02094
Opened: Dec 11, 2002 , Closed: May 30, 2003
INTEGRAL HUB AND BEARING ASSEMBLY
THE COMPANIES INVOLVED IN THIS MATTER ARE: SKF (HUB MFR), ARVINMERITOR (FRONT AXLE MFR), AND MACK (MANUFACTURER OF CLASS VIIITRACTOR/TRUCKS).SKF IDENTIFIED MANUFACTURING DEFECTS FOR SPECIFIC BUILD DATES ON FRONT AXLE HUB AND BEARINGS (WHEEL BEARINGS) SUPPLIED TO ARVINMERITOR.AS A RESULT, ARVINMERITO... Read more
MACK CH - All Years Overview
Complete safety history for the MACK CH across all model years (1987, 2007).
91
Total Recalls
8
Total Complaints
1
Investigations
2
Reported Crashes
1
Reported Fires
12
Reported Deaths
MACK CH - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2007 (current) | 3 | 0 | |
| 2006 | 2 | 0 | View |
| 2005 | 3 | 0 | View |
| 2004 | 5 | 0 | View |
| 2003 | 7 | 0 | View |
| 2002 | 6 | 2 | View |
| 2001 | 5 | 0 | View |
| 2000 | 7 | 0 | View |
| 1999 | 7 | 0 | View |
| 1998 | 3 | 0 | View |
| 1997 | 2 | 1 | View |
| 1996 | 3 | 1 | View |
| 1995 | 2 | 0 | View |
| 1994 | 1 | 1 | View |
| 1993 | 5 | 0 | View |
| 1992 | 6 | 1 | View |
| 1991 | 5 | 0 | View |
| 1990 | 5 | 0 | View |
| 1989 | 7 | 0 | View |
| 1988 | 6 | 0 | View |
| 1987 | 1 | 0 | View |