1991 ISUZU PICKUP TRUCK

2 recalls — 7 complaints — 5 TSBs

EXTERIOR LIGHTING

Defect Description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

61,944 vehicles affected

Manufacturer: PRO-A MOTORS, INC.

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

Defect Description

THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.

Consequence

THE SAFETY BELTS WOULD NOT PROVIDE ADEQUATE PROTECTION TO AN OCCUPANT IN A VEHICLE CRASH.

Remedy

OWNERS SHOULD PROMPTLY CHECK THE CONDITION AND OPERATION OF BOTH FRONT SAFETY BELT BUCKLES AND CAREFULLY INSPECT THE RED RELEASE BUTTON FOR ANY BREAKS OR CRACKS. THEY SHOULD ENSURE THAT BOTH BUCKLES ARE OPERATING PROPERLY BY INSERTING EACH LATCH PLATE INTO ITS BUCKLE, TUGGING ON THE BELT TO MAKE SUR... Read more

88,424 vehicles affected

Manufacturer: ISUZU MOTORS LIMITED

Complaint Statistics

7 total complaints 1 fires

Top Reported Components

Component	Complaints
SEAT BELTS:FRONT:BUCKLE ASSEMBLY	2
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD	1
SUSPENSION:FRONT:SHOCK ABSORBER	1
LATCHES/LOCKS/LINKAGES:HOOD:LATCH	1
LATCHES/LOCKS/LINKAGES:DOORS:LATCH	1
SEAT BELTS:FRONT:RETRACTOR	1

Incident date: Nov 7, 1998

THE CONSUMER HAS BEEN EXPERIENCING PROBLEMS WITH SEAT BELTS. THE SEAT BELTS WON'T RETRACT. THE SEAT BELTS ARE VERY LOOSE. THE MANUFACTURER HAS YET TO BE CONTACTED. *AK

Incident date: Apr 15, 1998

BUTTON TO LOCK DOOR DRIVER'S SIDE; UPON ENTERING TRUCK IF PUSHING THE BUTTON DOWN ON INSIDE TO LOCK DOOR WHEN EXITING THE TRUCK. CONSUMER DOES NOT LIFT THE BUTTON, BUT INSTEAD USES THE DOOR KNOB TO OPEN DOOR. SPRING IN THE DOOR IS BROKEN WHICH CAUSES THE DOOR TO LOCK, MAKING IT UNABLE TO OPEN THE D... Read more

Incident date: Jun 21, 1997

WHILE DRIVING 50 MPH, THE HOOD ON THE VEHICLE SUDDENLY FLEW UP & BROKE THE WINDSHIELD & OBSTRUCTED DRIVER'S VIEW; PULLED OVER & PULLED HOOD DOWN; ARRIVED HOME & NOTICED BOLTS HAD BROKEN IN HALF THAT HELD HOOD DOWN. VEHICLE IS AT BODY SHOP(MECHANC) NOW. *AK

Incident date: Feb 15, 1996

WEAK SHOCK ABSORBERS FAILED, CAUSING FRONT TIRE TO CUP/VIBRATION IN THE STEERING WHEEL. *DSH

Incident date: Jul 3, 1995

ENGINE COMPARTMENT FIRE, UNDER THE HOOD VEHICLE WAS PARKED, WILL PROVIDE MORE INFORMATION. TT

Fire

Incident date: Apr 14, 1995

VEHICLE TAKATA SEAT BELT BUCKLE BOTH DRIVER AND PASSENGER SIDES UNENGAGED. (PE94-085)MODELTK520 &TK521. TT K523. TT

Incident date: Jan 1, 1995

DRIVERS SIDE SEAT BELT DOES NOT LATCH. TT

Technical Service Bulletins — 1991 ISUZU PICKUP TRUCK

5 manufacturer communications from 5 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
980000 UNKNOWN OR OTHER	2
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	1
350000 EQUIPMENT	1
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	1

980000 UNKNOWN OR OTHER

This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The Exchange Program must be used when any Alpine radio or other component covered by this bulletin is repaired under warranty and may als

350000 EQUIPMENT

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

THIS TECHNICAL SERVICE BULLETIN OUTLINES THE DETAILED PROCEDURES FOR THE AIR CONDITIONING SYSTEM CONVERSION / RETROFIT. *TT

980000 UNKNOWN OR OTHER

There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for March 2024 for Isuzu Motors Limited.

NHTSA Safety Investigations — ISUZU PICKUP TRUCK

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

SQ — Open — Model Year: 1994

BRUSH/GRILLE GUARD CAMPAIGN

ADDITION INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE SUBJECT BULLETIN.LOSS OF AN ITEM THIS SIZE WOULD HAVE SAFETY COSEQUENCES.THIS SQ IS OPENED TO LEARN MORE ABOUT THIS ISSUE.

EA — Closed — Model Year: 1984

HEATER CORE FAILURE

There is no summary currently available

ISUZU PICKUP TRUCK — All Years Overview

Complete safety history for the ISUZU PICKUP TRUCK across all model years (1979–1995).

24 Total Recalls

93 Total Complaints

2 Investigations

10 Reported Crashes

1 Reported Fires

1 Reported Deaths

ISUZU PICKUP TRUCK — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
1997	0	1	View
1996	0	1	View
1995	3	13	View
1994	3	22	View
1993	1	7	View
1992	1	9	View
1991 (current)	2	7
1990	2	11	View
1989	1	10	View
1988	1	3	View
1987	0	2	View
1986	0	5	View
1984	0	2	View
1982	3	0	View
1981	3	0	View
1980	2	0	View
1979	1	0	View

Other ISUZU Models

Model	Recalls	Complaints
FTR	82	9	View
NPR HD	64	14	View
NPR	58	66	View
NQR	56	7	View
NRR	55	3	View
RODEO	40	3,314	View
NPR XD	38	1	View
FVR	35	0	View