2019 HYUNDAI IONIQ HYBRID
1 recalls — 30 complaints — 102 TSBs
19V720000 Oct 9, 2019
WHEELS:LUGS/NUTS/BOLTS/STUDS
Defect Description
Hyundai Motor America (Hyundai) is recalling certain 2019 Ioniq Hybrid and 2020 Elantra vehicles. The right-side rear wheel lug nuts may have been insufficiently tightened, allowing the wheel to detach from the vehicle.
Consequence
A wheel detaching from the vehicle increases the risk of a crash.
Remedy
Hyundai will notify owners, and dealers will inspect and, if necessary, tighten the lug nuts, free of charge. The recall began November 15, 2019. Owners may contact Hyundai customer service at 1-800-251-0871. Hyundai's number for this recall is 184.
Complaint Statistics
30 total complaints
7 crashes 3 fires 9 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| ENGINE | 4 |
| FUEL/PROPULSION SYSTEM | 4 |
| VEHICLE SPEED CONTROL | 3 |
| SERVICE BRAKES | 3 |
| POWER TRAIN | 3 |
| ELECTRICAL SYSTEM | 2 |
| FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL | 1 |
| FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING | 1 |
| FORWARD COLLISION AVOIDANCE: WARNINGS | 1 |
| UNKNOWN OR OTHER | 1 |
FUEL/PROPULSION SYSTEM
Jan 30, 2026
Incident date: Jan 15, 2026
While driving vehicle it flashed warning to check battery and power was severely reduced, limited to about 25 mph. Battery and EV warning triangle appeared. Then within less then a minute it brought up additional warning to "Stop Vehicle and Check Power Supply" and power was further reduced to less ... Read more
LANE DEPARTURE: BLIND SPOT DETECTION
Jan 30, 2026
Incident date: Jan 15, 2026
The system lost its ability to audibly warn me of various conditions that were a risk to everybody in the car. Examples of alerts we could not here were: blind spot collision warning, cross traffic while backing up, driver attention alert when hands are not on the steering wheel, and audible blinker... Read more
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
Jan 30, 2026
Incident date: Jan 15, 2026
The system lost its ability to audibly warn me of various conditions that were a risk to everybody in the car. Examples of alerts we could not here were: blind spot collision warning, cross traffic while backing up, driver attention alert when hands are not on the steering wheel, and audible blinker... Read more
ENGINE
Oct 13, 2025
Incident date: Oct 12, 2025
Lifter and camshaft failed
VEHICLE SPEED CONTROL
Oct 13, 2025
Incident date: Oct 12, 2025
What component or system failed or malfunctioned, and is it available for inspection upon request? Braking and acceleration control, yes How was your safety or the safety of others put at risk? The car continued to move/accelerate after depressing the brake pedal, and upon applying additional force ... Read more
EXTERIOR LIGHTING
Oct 12, 2025
Incident date: Oct 3, 2025
Kept getting a Check Headlamp System See Manual for a couple days then the headlight went out
VEHICLE SPEED CONTROL
Oct 12, 2025
Incident date: Oct 3, 2025
While attempting to park and depressing the brake the car made a sudden acceleration without input and hard braking did not slow the car. The car then impacted the curb. On another occasion while stopped at a red light the car began to move forward while the break was depressed. Pressing the break w... Read more
Crash
SERVICE BRAKES
Aug 9, 2025
Incident date: Aug 5, 2025
Brake assist, ESC alerts on vehicle. Sat in the dealer service shop for 3 days and said to have been fixed. Still with same issue
BACK OVER PREVENTION: WARNINGS
Aug 25, 2023
Incident date: May 24, 2023
My engine light came on, I took it to the service center where I purchase the vehicle. They state it is a evaporative emission canister purge pump. They state the part is on back order due to many vehicles having the same faulty part. I contacted GMC, they state the part is not available at this t... Read more
FUEL/PROPULSION SYSTEM
Aug 25, 2023
Incident date: May 24, 2023
My engine light came on, I took it to the service center where I purchase the vehicle. They state it is a evaporative emission canister purge pump. They state the part is on back order due to many vehicles having the same faulty part. I contacted GMC, they state the part is not available at this t... Read more
VISIBILITY/WIPER
Jul 31, 2023
Incident date: Jul 24, 2023
While in park at a drive thru we heard a loud bang. The rear windshield shattered. No foreign objects could be located and people around the vehicle did not witness anything hitting the car. Contents of the car were searched and no reason for the window to shatter was found.
STEERING
Jul 31, 2023
Incident date: Jul 24, 2023
Steering sticks consistently when going around curves, usually around the 10 and 2 areas. Vehicle steering has to be manually forced back to midline. Occurs more frequently the longer the drive and usually at speeds only over 30mph.
FUEL/PROPULSION SYSTEM
Jul 31, 2023
Incident date: Jul 24, 2023
What component of system failed or malfunctioned? Sudden deceleration, not sure what system this is a part of. Is it available for inspection upon request? No, I don't know what is causing the problem so have not been able to have the specific system looked at. How was your safety or the safety of... Read more
POWER TRAIN
May 15, 2023
Incident date: May 15, 2023
2019: cooling temperature sensor failed. Brought to ford dealership and paid $5000 for new computer and sensors. 2023: radiator overheated with no warning and messed up engine. Now radiator won’t hold fluid and continues to get over heat warning. Brought to Ford dealer and they said the engine n... Read more
ELECTRICAL SYSTEM
Apr 14, 2023
Incident date: Apr 11, 2023
I have owned the vehicle since October 2022, currently ~4,400 miles. During second week of ownership, backup camera was blank upon startup and placing vehicle into reverse. A system reboot solved the issue, but several reboots have been required in subsequent months. Common that audio doesn't initia... Read more
POWER TRAIN
Mar 20, 2023
Incident date: Feb 26, 2023
The contact owns a 2015 Honda Civic. The contact stated that while driving at an undisclosed speed, the vehicle experienced unintended acceleration with the ABS and air bag warning lights illuminated. Additionally, the transmission was slipping while coming to a stop. The vehicle was taken to the de... Read more
SERVICE BRAKES
Mar 20, 2023
Incident date: Feb 26, 2023
Service abs system light is on as well as service electronic braking system. My truck no longer has antilock brakes. Cruise control does not work. Dealers do not have parts available to fix the issue. This is a very common and well documented issue with these trucks. This was an intermittent prob... Read more
VEHICLE SPEED CONTROL:THROTTLE
Dec 15, 2022
Incident date: Dec 14, 2022
The contact owns a 2019 Hyundai Ioniq. The contact stated that while attempting to park into her son's parking pad, the vehicle independently accelerated reverse while in the reverse(R) position. The vehicle initially hit a gutter on the side of the house; as the vehicle continued to accelerate, the... Read more
Crash
1 injured
POWER TRAIN
Dec 15, 2022
Incident date: Dec 14, 2022
The contact owns a 2019 Hyundai Ioniq. The contact stated that while attempting to park into her son's parking pad, the vehicle independently accelerated reverse while in the reverse(R) position. The vehicle initially hit a gutter on the side of the house; as the vehicle continued to accelerate, the... Read more
Crash
1 injured
ELECTRICAL SYSTEM
Dec 15, 2022
Incident date: Dec 14, 2022
The contact owns a 2019 Hyundai Ioniq. The contact stated that while attempting to park into her son's parking pad, the vehicle independently accelerated reverse while in the reverse(R) position. The vehicle initially hit a gutter on the side of the house; as the vehicle continued to accelerate, the... Read more
Crash
1 injured
UNKNOWN OR OTHER
Jun 23, 2022
Incident date: Jun 20, 2022
One morning, my father turned on the car. It was still in Park. He and my mom heard a noise, as if my dad was pushing on the gas pedal, but he was not. They turned off the car, turned it on again, and everything seemed fine. After driving for a bit, my father was back home and parking the car. Beca... Read more
Crash
Fire
2 injured
SERVICE BRAKES
Jun 23, 2022
Incident date: Jun 20, 2022
One morning, my father turned on the car. It was still in Park. He and my mom heard a noise, as if my dad was pushing on the gas pedal, but he was not. They turned off the car, turned it on again, and everything seemed fine. After driving for a bit, my father was back home and parking the car. Beca... Read more
Crash
Fire
2 injured
VEHICLE SPEED CONTROL
Jun 23, 2022
Incident date: Jun 20, 2022
One morning, my father turned on the car. It was still in Park. He and my mom heard a noise, as if my dad was pushing on the gas pedal, but he was not. They turned off the car, turned it on again, and everything seemed fine. After driving for a bit, my father was back home and parking the car. Beca... Read more
Crash
Fire
2 injured
FORWARD COLLISION AVOIDANCE: WARNINGS
Mar 23, 2022
Incident date: Nov 13, 2021
07/13/19 Car experienced uncontrolled breaking while traveling at 70 mph on President George Bush Tollway, Texas. All dashboard lights came on and only went off when car turned off then on. 09/26/21 Car experienced uncontrolled breaking while traveling at 70 mph on I-75 in Georgia. All dashboar... Read more
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Mar 23, 2022
Incident date: Nov 13, 2021
07/13/19 Car experienced uncontrolled breaking while traveling at 70 mph on President George Bush Tollway, Texas. All dashboard lights came on and only went off when car turned off then on. 09/26/21 Car experienced uncontrolled breaking while traveling at 70 mph on I-75 in Georgia. All dashboar... Read more
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Mar 23, 2022
Incident date: Nov 13, 2021
07/13/19 Car experienced uncontrolled breaking while traveling at 70 mph on President George Bush Tollway, Texas. All dashboard lights came on and only went off when car turned off then on. 09/26/21 Car experienced uncontrolled breaking while traveling at 70 mph on I-75 in Georgia. All dashboar... Read more
ENGINE
Dec 14, 2021
Incident date: Dec 10, 2021
I am not sure who to report this to, but NHTSA and Hyundai corporate office both report the car as having no recalls. The local dealership says it has 3, 2 for computer errors (my car currently has a computer error). When I asked the main Hyundai support people about this, they stated local dealersh... Read more
ENGINE
May 1, 2020
Incident date: Apr 21, 2020
RECALL WORK WAS PERFORMED TO FIX ANY POSSIBLE OVERHEATING ISSUES. A MONTH LATER I NOTICE ME HEATER NOT WORKING AND THEN IT STARTS OVER HEATING AND SMOKING FROM THE BACK, I TAKE IT IN AND THEY CLAIM THAT IT'S JUST A BUBBLE IN THE RADIATOR. ON 04/21/2020 ABOUT A MONTH LATER WITHOUT ANY WARNING LIGHTS ... Read more
ENGINE
Mar 3, 2019
Incident date: Mar 3, 2019
FOR THE SECOND COLD MORNING THIS YEAR MY IONIQ STALLED. I WAS PARKED IN MY DRIVEWAY. TEMPERATURE WAS -3F, I PRESS THE POWER BUTTON, CAR TRIED TO START AND STALLED THREE TIMES IN A ROW THEN GOT A CHECK HYBRID SYSTEM WARNING MESSAGE. I TURNED THE CAR OFF THEN ON AGAIN AND IT STARTED TO STALL, I DEPRE... Read more
FUEL/PROPULSION SYSTEM
Mar 3, 2019
Incident date: Mar 3, 2019
FOR THE SECOND COLD MORNING THIS YEAR MY IONIQ STALLED. I WAS PARKED IN MY DRIVEWAY. TEMPERATURE WAS -3F, I PRESS THE POWER BUTTON, CAR TRIED TO START AND STALLED THREE TIMES IN A ROW THEN GOT A CHECK HYBRID SYSTEM WARNING MESSAGE. I TURNED THE CAR OFF THEN ON AGAIN AND IT STARTED TO STALL, I DEPRE... Read more
NHTSA Safety Ratings — 2019 HYUNDAI IONIQ HYBRID
2019 Hyundai Ioniq Hybrid 4 DR FWD
| Category | Rating |
|---|---|
| Rollover Risk | 0.0% |
Safety Technology
| Feature | Status |
|---|---|
| Electronic Stability Control | Standard |
| Forward Collision Warning | Optional |
| Lane Departure Warning | Optional |
Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.
Technical Service Bulletins — 2019 HYUNDAI IONIQ HYBRID
102 manufacturer communications from 62 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 110000 ELECTRICAL SYSTEM | 19 |
| 350000 EQUIPMENT | 14 |
| 060000 ENGINE AND ENGINE COOLING | 11 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 9 |
| 010000 STEERING | 8 |
| 130000 VISIBILITY | 3 |
| 100000 POWER TRAIN | 3 |
| 060000 ENGINE (PWS) | 3 |
24-BD-001H
Feb 14, 2024
130000 VISIBILITY
This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming
24-BD-001H
Feb 14, 2024
130000 VISIBILITY/WIPER (PWS)
This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming
23-EM-005H
Oct 13, 2023
060000 ENGINE AND ENGINE COOLING
This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
23-01-072H
Sep 7, 2023
100000 POWER TRAIN
This bulletin provides the procedure to update the Hybrid Control Unit (HCU) / Low DC/DC Converter (LDC) software logic to eliminate internal P-DTCs (that are not viewable) in certain 2019-2021MY IONIQ Hybrid (AE HEV) and 2021MY IONIQ Plug-
23-01-072H
Sep 7, 2023
118000 ELECTRICAL SYSTEM:SOFTWARE
This bulletin provides the procedure to update the Hybrid Control Unit (HCU) / Low DC/DC Converter (LDC) software logic to eliminate internal P-DTCs (that are not viewable) in certain 2019-2021MY IONIQ Hybrid (AE HEV) and 2021MY IONIQ Plug-
23-BE-007H
Jul 17, 2023
110000 ELECTRICAL SYSTEM
This Service Information bulletin provides information on how to update the Apple Carplay software from Hyundaia??s Navigation Updates page. The current version of Google Maps has 10 times the data transmission compared to the previous vers
23-BE-007H
Jul 17, 2023
353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE
This Service Information bulletin provides information on how to update the Apple Carplay software from Hyundaia??s Navigation Updates page. The current version of Google Maps has 10 times the data transmission compared to the previous vers
23-BD-007H
Apr 24, 2023
162000 STRUCTURE:BODY
Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom
23-BR-001H
Apr 7, 2023
050000 PARKING BRAKE
When servicing any of the specified vehicles below with the corresponding DTCs, C2416, a??Motor Short or Open a?? LH (EPB)a?? or C2417 a??Motor Short or Open a?? RH (EPB)a??, follow the step-by-step procedures in this bulletin.
23-BD-002H
Jan 30, 2023
130000 VISIBILITY
This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th
22-EM-010H
Jul 28, 2022
060000 ENGINE AND ENGINE COOLING
Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
22-GI-006H
Jul 14, 2022
190000 TIRES
Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale
218/231 amend
Jun 3, 2022
010000 STEERING
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
22-HC-001H
May 18, 2022
060000 ENGINE AND ENGINE COOLING
If you are servicing an applicable model with Hybrid Drive Motor (Traction Motor) improper operation or any DTC listed in the related shop manual, Motor Control System, refer to the shop manual for diagnosis. If the diagnosis indicates a fa
22-HC-001H
May 18, 2022
110000 ELECTRICAL SYSTEM
If you are servicing an applicable model with Hybrid Drive Motor (Traction Motor) improper operation or any DTC listed in the related shop manual, Motor Control System, refer to the shop manual for diagnosis. If the diagnosis indicates a fa
22-ST-005H
Apr 8, 2022
010000 STEERING
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
22-ST-005H
Apr 8, 2022
010000 STEERING
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
21-ST-003H
Oct 1, 2021
010000 STEERING
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing
21-BR-004H
Apr 9, 2021
050000 PARKING BRAKE
This bulletin describes the procedure to update the EPB (Electronic Parking Brake) ECU to revise the logic of setting DTC C2416, a??Motor Short or Open a?? LH (EPB)a?? or C2417 a??Motor Short or Open a?? RH (EPB)a?? from vibrations while dr
21-EM-004H
Mar 30, 2021
060000 ENGINE AND ENGINE COOLING
This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps
21-EM-004H
Mar 30, 2021
350000 EQUIPMENT
This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps
21-BR-002H
Mar 23, 2021
350000 EQUIPMENT
This bulletin provides best practice recommendations when performing brake service procedures.
21-BR-002H
Mar 23, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
This bulletin provides best practice recommendations when performing brake service procedures.
21-BR-002H
Mar 23, 2021
030000 BRAKES (PWS)
This bulletin provides best practice recommendations when performing brake service procedures.
21-EM-003H
Mar 10, 2021
060000 ENGINE AND ENGINE COOLING
This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
21-EM-003H
Mar 10, 2021
350000 EQUIPMENT
This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
20-01-049H
Dec 16, 2020
060000 ENGINE AND ENGINE COOLING
This bulletin provides information related to the Engine Control Module (ECM) software update for OBD communication test logic, and for DTC P0128 a??Coolant thermostat - Coolant temp Below thermostat regulating Temperaturea??. There are no
20-FL-012H
Dec 16, 2020
060000 ENGINE AND ENGINE COOLING
This bulletin provides information related to the Engine Control Module (ECM) software logic update for DTC P0128 a??Coolant thermostat - Coolant temp Below thermostat regulating Temperaturea??. There is no drivability issue with this DTC.
20-FL-012H
Dec 16, 2020
350000 EQUIPMENT
This bulletin provides information related to the Engine Control Module (ECM) software logic update for DTC P0128 a??Coolant thermostat - Coolant temp Below thermostat regulating Temperaturea??. There is no drivability issue with this DTC.
20-BR-002H
Nov 30, 2020
030000 BRAKES (PWS)
This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.
20-SS-004H
Nov 19, 2020
190000 TIRES
This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For
20-SS-004H
Nov 19, 2020
200000 WHEELS
This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For
20-01-039H
Oct 9, 2020
110000 ELECTRICAL SYSTEM
This bulletin provides information and procedures for collecting OBD a??In Use Monitor Performance Ratioa?? (IUMPR) data on certain 2019-2021MY vehicles at California dealers. This reporting is mandated by CARB (California Air Resources Boa
20-01-039H
Oct 9, 2020
350000 EQUIPMENT
This bulletin provides information and procedures for collecting OBD a??In Use Monitor Performance Ratioa?? (IUMPR) data on certain 2019-2021MY vehicles at California dealers. This reporting is mandated by CARB (California Air Resources Boa
20-ST-001H-2
Sep 9, 2020
010000 STEERING
This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
20-ST-001H-2
Sep 9, 2020
350000 EQUIPMENT
This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
20-ST-003H-1
Sep 9, 2020
010000 STEERING
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft assembly.
20-ST-003H-1
Sep 9, 2020
350000 EQUIPMENT
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft assembly.
20-ST-003H-1
Sep 9, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft assembly.
20-ST-001H-1
Aug 10, 2020
012000 STEERING:COLUMN
This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
20-ST-001H-1
Aug 10, 2020
110000 ELECTRICAL SYSTEM
This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
20-ST-001H-1
Aug 10, 2020
018100 STEERING:AUTOMATED/ADAPTIVE STEERING:MOTOR/ACTUATOR
This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
20-ST-003H
Aug 10, 2020
012000 STEERING:COLUMN
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft assembly.
20-ST-003H
Aug 10, 2020
110000 ELECTRICAL SYSTEM
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft assembly.
20-ST-003H
Aug 10, 2020
016000 STEERING:ELECTRIC POWER ASSIST SYSTEM
Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft assembly.
20-BD-014H
Jul 14, 2020
120000 EXTERIOR LIGHTING
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the la
20-BD-014H
Jul 14, 2020
350000 EQUIPMENT
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the la
20-BD-014H
Jul 14, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the la
20-SS-002H(1)
May 6, 2020
190000 TIRES
This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.
20-SS-002H(1)
May 6, 2020
200000 WHEELS
This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.
20-BD-007H-1
May 1, 2020
350000 EQUIPMENT
This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.
20-EE-003H
Apr 23, 2020
110000 ELECTRICAL SYSTEM
This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days.
20-EE-003H
Apr 23, 2020
350000 EQUIPMENT
This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days.
20-AT-016H
Apr 17, 2020
100000 POWER TRAIN
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
20-AT-016H
Apr 17, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
20-AT-016H
Apr 17, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
20-FL-002H
Apr 13, 2020
060000 ENGINE AND ENGINE COOLING
Certain Ioniq hybrid 2017-2019 vehicles may experience check engine light a??ONa?? with the following DTC stored: DTC P0456 - Evaporative System (EVAP) - Very Small Leak This bulletin provides instructions to install an Air Filter Kit and
20-FL-002H
Apr 13, 2020
350000 EQUIPMENT
Certain Ioniq hybrid 2017-2019 vehicles may experience check engine light a??ONa?? with the following DTC stored: DTC P0456 - Evaporative System (EVAP) - Very Small Leak This bulletin provides instructions to install an Air Filter Kit and
20-FL-002H
Apr 13, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Certain Ioniq hybrid 2017-2019 vehicles may experience check engine light a??ONa?? with the following DTC stored: DTC P0456 - Evaporative System (EVAP) - Very Small Leak This bulletin provides instructions to install an Air Filter Kit and
20-HA-001H
Mar 30, 2020
042100 SERVICE BRAKES, AIR:SUPPLY:COMPRESSOR
This bulletin provides additional service diagnostic information and repair procedures related to electric A/C compressors equipped in hybrid electric vehicles, plug-in hybrid electric vehicles, and electric vehicles.
20-BD-007H
Mar 23, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.
20-EE-002H(1)
Mar 18, 2020
110000 ELECTRICAL SYSTEM
This bulletin describes the mandatory procedure to submit battery test data electronically for battery warranty claims by running the GDS Battery Claim App. The App must be run right after an incident battery is removed from the vehicle or
20-BR-001H
Feb 12, 2020
030000 SERVICE BRAKES, HYDRAULIC
This bulletin describes the procedure to properly bleed the brakes on Sonata HEV/PHEV (LF) and Ioniq EV/HEV/PHEV (AE) vehicles. This procedure applies when any air is introduced into the Active Hydraulic Boost (AHB) system, which consists o
20-SS-001H
Feb 5, 2020
020000 SUSPENSION
This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years.
20-BE-001H
Jan 16, 2020
110000 ELECTRICAL SYSTEM
This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. This bullet
20-ST-001H
Jan 3, 2020
010000 STEERING
This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
19-01-042H
Dec 17, 2019
350000 EQUIPMENT
This bulletin provides information and procedures for collecting OBD ?In Use Monitor Performance Ratio? (IUMPR) data on certain 2019-2020MY vehicles at California dealers. This reporting is mandated by CARB (California Air Resources Board).
19-01-036H
Nov 7, 2019
110000 ELECTRICAL SYSTEM
Certain vehicles may incur dash warning light(s) On with DTC(s) stored including either of the following DTC: ? U1116 - Lost Communication With Motor Electronics Coolant Pump (C-CAN) ? U1118 - Lost Communication With Hybrid/EV Battery Ele
Campaign T4G Dea
Nov 7, 2019
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
Hyundai is conducting a Service Campaign to inspect the Electric Water Pump (EWP) assembly.
19-BE-011H-1
Nov 4, 2019
270000 LANE DEPARTURE
The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects v
19-BE-011H-1
Nov 4, 2019
280000 BACK OVER PREVENTION
The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects v
19-01-030H
Oct 28, 2019
060000 ENGINE AND ENGINE COOLING
"Certain 2017-2019 vehicles may experience check engine light ??A?A?ON??A?A? with the following DTC stored: DTC P0456 - Evaporative System (EVAP) - Very Small LeakThese conditions primarily occur in the California coastal areas that are su
Campaign T4C Dea
Oct 28, 2019
060000 ENGINE AND ENGINE COOLING
Hyundai is conducting a Service Campaign to install a new Air Filter Kit with an updated filter to help prevent DTC P0456 on certain 2017-2019 Ioniq (AE) HEV vehicles.
19-01-030H
Oct 28, 2019
110000 ELECTRICAL SYSTEM
Certain 2017-2019 vehicles may experience check engine light ?ON? with the following DTC stored: ? DTC P0456 - Evaporative System (EVAP) - Very Small LeakThese conditions primarily occur in the California coastal areas that are subject to
19-01-030H
Oct 28, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
Certain 2017-2019 vehicles may experience check engine light ?ON? with the following DTC stored: ? DTC P0456 - Evaporative System (EVAP) - Very Small LeakThese conditions primarily occur in the California coastal areas that are subject to
19-01-030H
Oct 28, 2019
060000 ENGINE (PWS)
Certain 2017-2019 vehicles may experience check engine light ?ON? with the following DTC stored: ? DTC P0456 - Evaporative System (EVAP) - Very Small LeakThese conditions primarily occur in the California coastal areas that are subject to
Campaign T4C Dea
Oct 28, 2019
350000 EQUIPMENT
Hyundai is conducting a Service Campaign to install a new Air Filter Kit with an updated filter to help prevent DTC P0456 on certain 2017-2019 Ioniq (AE) HEV vehicles.
Campaign T4C Dea
Oct 28, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
Hyundai is conducting a Service Campaign to install a new Air Filter Kit with an updated filter to help prevent DTC P0456 on certain 2017-2019 Ioniq (AE) HEV vehicles.
Campaign T4C Dea
Oct 28, 2019
060000 ENGINE (PWS)
Hyundai is conducting a Service Campaign to install a new Air Filter Kit with an updated filter to help prevent DTC P0456 on certain 2017-2019 Ioniq (AE) HEV vehicles.
19-GI-006H
Oct 14, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and m
19-01-023H
Aug 13, 2019
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This bulletin provides information related to a BMS (Battery Management System) software update to the diagnostic logic for DTC P1B77 ? ?High Voltage Battery Precharging Fault?.
Campaign T3U Dea
Aug 13, 2019
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This service campaign provides information related to a BMS software update to the diagnostic logic for DTC P1B77 ? ?High Voltage Battery Pre-charging Fault?.
Campaign T3U Dea
Aug 13, 2019
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service campaign provides information related to a BMS software update to the diagnostic logic for DTC P1B77 ? ?High Voltage Battery Pre-charging Fault?.
19-EE-001H-1
Jul 10, 2019
110000 ELECTRICAL SYSTEM
This bulletin provides information on how to return a Hyundai HEV/PHEV/EV/Fuel Cell Lithium Battery for proper disposal and safe environmental recycling using Hyundai?s authorized vendor Kinsbursky Brothers Intl. (KBI).
19-EE-001H-1
Jul 10, 2019
350000 EQUIPMENT
This bulletin provides information on how to return a Hyundai HEV/PHEV/EV/Fuel Cell Lithium Battery for proper disposal and safe environmental recycling using Hyundai?s authorized vendor Kinsbursky Brothers Intl. (KBI).
19-BE-009H
May 16, 2019
260000 FORWARD COLLISION AVOIDANCE
This bulletin provides information for troubleshooting of the Blind-Spot Collision Warning (BCW/BSD) system whenever it exhibits Diagnostic Trouble Code (DTC) C120B/D or C160A.
19-BE-009H
May 16, 2019
270000 LANE DEPARTURE
This bulletin provides information for troubleshooting of the Blind-Spot Collision Warning (BCW/BSD) system whenever it exhibits Diagnostic Trouble Code (DTC) C120B/D or C160A.
19-EE-003H
Apr 23, 2019
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The following summarizes the service procedures for Lithium Battery replacement:
19-ST-001H
Apr 22, 2019
010000 STEERING
This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
19-HA-001H
Apr 19, 2019
060000 ENGINE AND ENGINE COOLING
This bulletin provides additional service diagnostic information and repair procedures related to electric A/C compressors equipped in hybrid electric vehicles, plug-in hybrid electric vehicles, and electric vehicles.
19-HA-001H
Apr 19, 2019
060000 ENGINE (PWS)
This bulletin provides additional service diagnostic information and repair procedures related to electric A/C compressors equipped in hybrid electric vehicles, plug-in hybrid electric vehicles, and electric vehicles.
19-FL-003H
Apr 15, 2019
100000 POWER TRAIN
This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Once the VIN has been programmed to the ECM/PCM, it cannot b
19-FL-003H
Apr 15, 2019
110000 ELECTRICAL SYSTEM
This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Once the VIN has been programmed to the ECM/PCM, it cannot b
19-BE-004H
Mar 13, 2019
130000 VISIBILITY
This bulletin provides information on the serviceable parts for the outside mirror assembly. When diagnosing and repairing the outside mirror, do not replace the entire assembly. Refer to page 2 of this TSB for replacement of individual par
19-BE-004H
Mar 13, 2019
135000 VISIBILITY:REARVIEW MIRRORS/DEVICES
This bulletin provides information on the serviceable parts for the outside mirror assembly. When diagnosing and repairing the outside mirror, do not replace the entire assembly. Refer to page 2 of this TSB for replacement of individual par
19-BE-003H
Feb 12, 2019
110000 ELECTRICAL SYSTEM
Some vehicles equipped with the wireless charging pad may experience a no charging condition. This bulletin provides information of how to diagnose the no charging condition.
5NP-M7Z5K-02
Jan 30, 2019
110000 ELECTRICAL SYSTEM
This bulletin provides information on how to return a Hyundai HEV/PHEV/EV/Fuel Cell Lithium Battery for proper disposal and safe environmental recycling using Hyundai?s authorized vendor Kinsbursky Brothers Inc. (KBI).
5NP-Q5X4W-01
Dec 20, 2018
110000 ELECTRICAL SYSTEM
Hyundai Motor America is conducting a Service Campaign to update the ECM software on certain Dealer Stock 2019 Model Year Ioniq Hybrid and Plug-In vehicles. Service Campaign T3P provides a procedure to update the ECM software.
5NP-U5H2S-01
Dec 20, 2018
110000 ELECTRICAL SYSTEM
This bulletin provides information related to an ECM (Engine Control Module) ECU software update for OBD (On Board Diagnostics) logic improvement. The Freeze Frame Data has been updated for multiple DTC.
5NP-B6S5Q-01
Dec 6, 2018
110000 ELECTRICAL SYSTEM
This bulletin provides the procedures for calibrating Ioniq Hybrid sensors using GDS whenever the components listed below are replaced or the DTC listed are stored.
Showing 100 of 102 bulletins.
HYUNDAI IONIQ HYBRID — All Years Overview
Complete safety history for the HYUNDAI IONIQ HYBRID across all model years (2017–2019).
6
Total Recalls
193
Total Complaints
0
Investigations
21
Reported Crashes
9
Reported Fires
0
Reported Deaths