FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
88,303 vehicles affected
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
WATER INTRUSION INTO THE KICK PANEL AREAS IN FRONT OF BOTH THE DRIVER AND PASSENGER DOORS CAN CAUSE A CORROSION PATH BETWEEN THE BATTERY FEED AND THE ELECTRICAL GROUND.
Remedy: DEALERS WILL REPLACE THE 25 AMP CIRCUIT BREAKERS WITH 25 AMP FUSES IN THE FUSE BLOCK; REMOVE A TEMPORARY PAPER FUSE-BLOCK COVER; INSTALL A PLASTIC SHIELD OVER THE FUSE BLOCK; REPLACE AND REORIENT THE POWER DOOR LOCK RELAY (IF EQUIPPED); INSPECT THE REMOTE KEYLESS ENTRY MODULE (IF EQUIPPED) FOR SIGNS OF CORROSION, REPLACE IF CORRODED, AND REORIENT IT; AND APPLY ADDITIONAL BODY SEALER IN KEY AREAS.
20,689 vehicles affected
STEERING:LINKAGES
THE STEERING LINKAGE ASSEMBY CONTAINS A RELAY ROD TAPERED-STUD ATTACHMENT NUT THAT WAS NOT TORQUED TO PROPER SPECIFICATIONS.
Remedy: DEALERS WILL REMOVE THE EXISTING CRIMPED NUT AND INSTALL A NEW NUT TORQUED TO SPECIFICATIONS.
8,340 vehicles affected
TIRES:BEAD
THESE TIRES HAVE BEAD DAMAGE WHICH OCCURED DURING TIRE MOUNTING.
Remedy: DEALERS WILL DEMOUNT EACH TIRE AND INSPECT FOR BEAD DAMAGE. IF BEAD DAMAGE IS FOUND, THE TIRE WILL BE REPLACED.
5,773 vehicles affected
CONSUMER INDICATED THAT TRANSMISSION WENT INTO LIMP MODE. WHEN THIS OCCURRED TRANSMISSION SWITCHED OVER TO SECOND GEAR AND STAYED IN THAT GEAR UNTIL VEHICLE WAS TURNED OFF. DEALERSHIP INDICATED THIS WAS CAUSED BY AN ELECTRICAL SYSTEM FUSE FAILURE RECALL 96V180000 WAS ISSUED, BUT THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK
CONSUMER INDICATED THAT TRANSMISSION WENT INTO LIMP MODE. WHEN THIS OCCURRED TRANSMISSION SWITCHED OVER TO SECOND GEAR AND STAYED IN THAT GEAR UNTIL VEHICLE WAS TURNED OFF. DEALERSHIP INDICATED THIS WAS CAUSED BY AN ELECTRICAL SYSTEM FUSE FAILURE RECALL 96V180000 WAS ISSUED, BUT THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK