2016 FORD EXPLORER POLICE INTERCEPT
0 recalls, 29 complaints - 68 TSBs
No recalls found for this vehicle.
Complaint Statistics
29 total complaints
Top Reported Components
| Component | Complaints |
|---|---|
| UNKNOWN OR OTHER | 12 |
| STRUCTURE:BODY | 5 |
| ENGINE | 4 |
| POWER TRAIN | 2 |
| ELECTRICAL SYSTEM | 2 |
| FUEL/PROPULSION SYSTEM | 1 |
| SEATS | 1 |
| STEERING | 1 |
| ENGINE AND ENGINE COOLING | 1 |
ENGINE AND ENGINE COOLING
Mar 26, 2024
Incident date: Mar 26, 2024
The contact owns a 2013 Ford Explorer. The contact stated that anti-freeze was leaking from the vehicle. While driving at unknown speeds, the message that the engine was overheating was displayed. The vehicle was taken to an independent mechanic, who replaced the water pump. The contact called the l... Read more
POWER TRAIN
Sep 10, 2020
Incident date: Aug 23, 2020
TL* THE CONTACT OWNS A 2016 FORD EXPLORER POLICE INTERCEPTOR. THE CONTACT STATED WHILE DRIVING 35 MPH, THE VEHICLE DOWNSHIFTED INDEPENDENTLY WITH THE RPMS INCREASING RAPIDLY. THE CONTACT STATED HE WAS UNAWARE IF THERE WAS ANY WARNING LIGHT ILLUMINATED. THE CONTACT STATED PULLED OVER TO THE SIDE OF T... Read more
STRUCTURE:BODY
Apr 12, 2019
Incident date: Mar 1, 2019
THE DRIVER AND PASSENGER "A" AND "B" PILLARS ARE COMING OFF.
STRUCTURE:BODY
Apr 12, 2019
Incident date: Mar 1, 2019
THE PLASTIC PIECES ON THE "A" PILLAR ARE COMING OFF
STRUCTURE:BODY
Apr 12, 2019
Incident date: Mar 1, 2019
THE PLASTIC PIECES ON THE "A" AND "B" PILLAR, DRIVER AND PASSENGER SIDE ARE COMING OFF.
STEERING
Jan 12, 2019
Incident date: Jan 10, 2019
I STARTED MY VEHICLE AND PUT IN DRIVE MY STEERING WHEEL WAS LOCKED IN ONE POSITION I WAS UNABLE TO TURN THE WHEEL LEFT OR RIGHT I STARTED GETTING SEVERAL LIGHTS ON MY DASH FROM HILL START ASSIST, SERVICE ADVANCETRAC, STEERING ASSIST FAULT. I WAS UNABLE TO TURN MY VEHICLE & HAD TO BACK IN THROUGH THE... Read more
ELECTRICAL SYSTEM
Jan 12, 2019
Incident date: Jan 10, 2019
I STARTED MY VEHICLE AND PUT IN DRIVE MY STEERING WHEEL WAS LOCKED IN ONE POSITION I WAS UNABLE TO TURN THE WHEEL LEFT OR RIGHT I STARTED GETTING SEVERAL LIGHTS ON MY DASH FROM HILL START ASSIST, SERVICE ADVANCETRAC, STEERING ASSIST FAULT. I WAS UNABLE TO TURN MY VEHICLE & HAD TO BACK IN THROUGH THE... Read more
SEATS
Oct 16, 2018
Incident date: Jul 1, 2017
THE SEAT MANUAL TILT LEVER FOR THE DRIVER SIT IS BUSTED. IT LOCKS AND DOES NOT ALLOW ADJUSTMENT. THE LOCAL DEALERSHIP SAID IT WAS NOT COVERED UNDER WARRANTY. THE COST TO REPLACE THE UNIT WAS EXTREME. WE HAVE HAD THREE 2016 EXPLORERS POLICE PACKAGE FALL VICTIM TO THE SAME ISSUE. THE ISSUE BEGAN ABOUT... Read more
FUEL/PROPULSION SYSTEM
Aug 21, 2018
Incident date: Jul 16, 2018
FUEL PUMP ASSEMBLY, SENDING UNIT. FUEL GAUGE STOPPED WORKING. VEHICLE HAD 38,000 MILES ON IT. DEALER CHARGED 600.00 PLUS TO FIX, NOT COVERED UNDER RECALL OR WARRANTY.
ELECTRICAL SYSTEM
Aug 21, 2018
Incident date: Jul 16, 2018
FUEL PUMP ASSEMBLY, SENDING UNIT. FUEL GAUGE STOPPED WORKING. VEHICLE HAD 38,000 MILES ON IT. DEALER CHARGED 600.00 PLUS TO FIX, NOT COVERED UNDER RECALL OR WARRANTY.
ENGINE
Jun 21, 2018
Incident date: Jun 17, 2018
TWO POLICE OFFICERS WERE PATROLLING IN A CITY ENVIRONMENT TOGETHER IN A 2016 FORD INTERCEPTOR UTILITY AND HAD SYMPTOMS OF CARBON MONOXIDE POISONING. THIS VEHICLE PREVIOUSLY HAD ALL CARBON MONOXIDE RELATED FORD RECALL WORK COMPLETED. THE OFFICERS' SYMPTOMS INCLUDED HEADACHE, DIZZINESS, SHORTNESS OF B... Read more
POWER TRAIN
Oct 16, 2017
Incident date: Aug 24, 2017
WHILE DRIVING THE EXPLORER ON THE DASHBOARD, A WARNING THAT INCLUDED THE WORD 'TERRAIN' FLASHED ONCE OR TWICE. THE REVERSE GEAR WAS DISCOVERED TO HAVE FAILED COMPLETELY UPON ATTEMPTING TO PARALLEL PARK.. *BF THE CONSUMER STATED THE TRANSMISSION FAILED. THE MANUFACTURER OFFERED TO REIMBURSE A PO... Read more
UNKNOWN OR OTHER
Oct 16, 2017
Incident date: Aug 24, 2017
WHILE DRIVING THE EXPLORER ON THE DASHBOARD, A WARNING THAT INCLUDED THE WORD 'TERRAIN' FLASHED ONCE OR TWICE. THE REVERSE GEAR WAS DISCOVERED TO HAVE FAILED COMPLETELY UPON ATTEMPTING TO PARALLEL PARK.. *BF THE CONSUMER STATED THE TRANSMISSION FAILED. THE MANUFACTURER OFFERED TO REIMBURSE A PO... Read more
ENGINE
Sep 13, 2017
Incident date: Sep 12, 2017
LAW ENFORCEMENT VEHICLE RECEIVING HIGH CARBON MONOXIDE LEVEL READINGS (10+ PARTS PER MILLION) IN PASSENGER CABIN UPON HARD ACCELERATION (FROM COMPLETE STOP TO 100+ MPH) WITH THE AIR CONDITIONING SYSTEM ON WITH THE RECIRCULATION FUNCTION ACTIVATED.
UNKNOWN OR OTHER
Sep 13, 2017
Incident date: Sep 12, 2017
LAW ENFORCEMENT VEHICLE RECEIVING HIGH CARBON MONOXIDE LEVEL READINGS (10+ PARTS PER MILLION) IN PASSENGER CABIN UPON HARD ACCELERATION (FROM COMPLETE STOP TO 100+ MPH) WITH THE AIR CONDITIONING SYSTEM ON WITH THE RECIRCULATION FUNCTION ACTIVATED.
UNKNOWN OR OTHER
Aug 3, 2017
Incident date: Jul 25, 2017
LAW ENFORCEMENT VEHICLE RECEIVING HIGH CARBON MONOXIDE LEVEL READINGS (10+ PARTS PER MILLION) IN PASSENGER CABIN UPON HARD ACCELERATION (FROM COMPLETE STOP TO 100+ MPH) WITH THE AIR CONDITIONING SYSTEM ON WITH THE RECIRCULATION FUNCTION ACTIVATED. NA6-067
UNKNOWN OR OTHER
Aug 3, 2017
Incident date: Jul 25, 2017
LAW ENFORCEMENT VEHICLE RECEIVING HIGH CARBON MONOXIDE LEVEL READINGS (10+ PARTS PER MILLION) IN PASSENGER CABIN UPON HARD ACCELERATION (FROM COMPLETE STOP TO 100+ MPH) WITH THE AIR CONDITIONING SYSTEM ON WITH THE RECIRCULATION FUNCTION ACTIVATED. 090
UNKNOWN OR OTHER
Aug 3, 2017
Incident date: Jul 25, 2017
LAW ENFORCEMENT VEHICLE RECEIVING HIGH CARBON MONOXIDE LEVEL READINGS (10+ PARTS PER MILLION) IN PASSENGER CABIN UPON HARD ACCELERATION (FROM COMPLETE STOP TO 100+ MPH) WITH THE AIR CONDITIONING SYSTEM ON WITH THE RECIRCULATION FUNCTION ACTIVATED. 541
UNKNOWN OR OTHER
Aug 3, 2017
Incident date: Jul 25, 2017
LAW ENFORCEMENT VEHICLE RECEIVING HIGH CARBON MONOXIDE LEVEL READINGS (10+ PARTS PER MILLION) IN PASSENGER CABIN UPON HARD ACCELERATION (FROM COMPLETE STOP TO 100+ MPH) WITH THE AIR CONDITIONING SYSTEM ON WITH THE RECIRCULATION FUNCTION ACTIVATED.
UNKNOWN OR OTHER
Aug 3, 2017
Incident date: Jul 25, 2017
LAW ENFORCEMENT VEHICLE RECEIVING HIGH CARBON MONOXIDE LEVEL READINGS (10+ PARTS PER MILLION) IN PASSENGER CABIN UPON HARD ACCELERATION (FROM COMPLETE STOP TO 100+ MPH) WITH THE AIR CONDITIONING SYSTEM ON WITH THE RECIRCULATION FUNCTION ACTIVATED. 052
UNKNOWN OR OTHER
Aug 3, 2017
Incident date: Jul 25, 2017
LAW ENFORCEMENT VEHICLE RECEIVING HIGH CARBON MONOXIDE LEVEL READINGS (10+ PARTS PER MILLION) IN PASSENGER CABIN UPON HARD ACCELERATION (FROM COMPLETE STOP TO 100+ MPH) WITH THE AIR CONDITIONING SYSTEM ON WITH THE RECIRCULATION FUNCTION ACTIVATED. 704
UNKNOWN OR OTHER
Aug 3, 2017
Incident date: Jul 25, 2017
LAW ENFORCEMENT VEHICLE RECEIVING HIGH CARBON MONOXIDE LEVEL READINGS (10+ PARTS PER MILLION) IN PASSENGER CABIN UPON HARD ACCELERATION (FROM COMPLETE STOP TO 100+ MPH) WITH THE AIR CONDITIONING SYSTEM ON WITH THE RECIRCULATION FUNCTION ACTIVATED. 534
UNKNOWN OR OTHER
Jul 31, 2017
Incident date: Jul 28, 2017
THE VEHICLE HAD CO IN THE INTERIOR AS HIGH AS 30 PPM. UNIT WAS PLACED OUT OF SERVICE DUE TO THE ABOVE CONDITIONS AND OFFICER HEADACHES.
ENGINE
Jul 31, 2017
Incident date: Jul 28, 2017
THE VEHICLE HAD CO IN THE INTERIOR AS HIGH AS 30 PPM. UNIT WAS PLACED OUT OF SERVICE DUE TO THE ABOVE CONDITIONS AND OFFICER HEADACHES.
STRUCTURE:BODY
Jul 31, 2017
Incident date: Jul 28, 2017
THE VEHICLE HAD CO IN THE INTERIOR AS HIGH AS 30 PPM. UNIT WAS PLACED OUT OF SERVICE DUE TO THE ABOVE CONDITIONS AND OFFICER HEADACHES.
UNKNOWN OR OTHER
Jul 31, 2017
Incident date: Jul 28, 2017
THE VEHICLE HAS 12-15 PPM OF CO IN THE INTERIOR WHILE IN OPERATION. THE VEHICLE WAS PLACED OUT OF SERVICE AFTER TESTING.
ENGINE
Jul 31, 2017
Incident date: Jul 28, 2017
THE VEHICLE HAS 12-15 PPM OF CO IN THE INTERIOR WHILE IN OPERATION. THE VEHICLE WAS PLACED OUT OF SERVICE AFTER TESTING.
STRUCTURE:BODY
Jul 31, 2017
Incident date: Jul 28, 2017
THE VEHICLE HAS 12-15 PPM OF CO IN THE INTERIOR WHILE IN OPERATION. THE VEHICLE WAS PLACED OUT OF SERVICE AFTER TESTING.
UNKNOWN OR OTHER
Jun 1, 2017
Incident date: Jun 1, 2017
ODOR OF FRESH GAS NOT EXHAUST COMING FROM VEHICLE WHETHER IT IS RUNNING OR NOT. IT CAN BE SMELLED POSSIBLY COMING FROM THE VENTS WHEN AIR CONDITIONING IS ON AND ALSO AFTER VEHICLE SITS OVER NIGHT. LOCAL FORD DEALERSHIP SUPPOSEDLY RAN A "SMOKE" TEST TO CHECK FOR GAS LEAKING COULD NOT FIND ONE. THERE ... Read more
Technical Service Bulletins, 2016 FORD EXPLORER POLICE INTERCEPT
68 manufacturer communications from 40 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 110000 ELECTRICAL SYSTEM | 7 |
| 060000 ENGINE AND ENGINE COOLING | 7 |
| 350000 EQUIPMENT | 6 |
| 160000 STRUCTURE | 5 |
| 020000 SUSPENSION | 5 |
| 100000 POWER TRAIN | 5 |
| 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 3 |
| 220000 SEATS | 3 |
SSM 52335
Mar 6, 2024
060000 ENGINE AND ENGINE COOLING
For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbocharg
SSM 52314
Mar 1, 2024
100000 POWER TRAIN
During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the tim
23L06
Feb 19, 2024
150000 SEAT BELTS
Certain 2013-2019 Model Year Explorer Police Interceptor Vehicles - Owner Guide Update
SSM 51536
Apr 4, 2023
160000 STRUCTURE
For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification numbe
SSM 51291
Jan 10, 2023
131000 VISIBILITY:WINDSHIELD
Some 2013-2019 Police Interceptor Utility vehicles, equipped with spotlights, require left and/or right windshield applique/moulding modification if these parts are replaced. Spotlight mounting holes are not present on new replacement winds
21N01 S2
Aug 31, 2022
110000 ELECTRICAL SYSTEM
Certain 2016-2018 Model Year Explorer Vehicles High-Speed Cooling Fan Motor Relay; Reason for supplement: Vehicles Covered by this Program: all open / unrepaired vehicles from 21B05 (Police Interceptor Utility Vehicles) have been added to
TSB 22-2287
Jul 19, 2022
100000 POWER TRAIN
Some 2015-2019 MKC and 2016-2019 Explorer vehicles equipped with a 2.3L engine may exhibit a vibration/rough idle when the vehicle is in drive (D) or reverse (R). The vehicle may also exhibit a lack of engine revolutions per minute (RPM), l
SSM 50861
Jun 16, 2022
100000 POWER TRAIN
Some 2015-2016 vehicles equipped with 6F50/6F55 transmission and built on 2-Nov-2015 and through 1-Feb-2016 may exhibit no reverse, 3rd and 5th gear with diagnostic trouble codes (DTCs) P0715,P0717,P0756 and/or P2701. This may be caused by
SSM 50804
May 24, 2022
110000 ELECTRICAL SYSTEM
Some 2013-2023 Ford or Lincoln vehicles with modems activated through FordPass or LincolnWay may experience 12 volt battery drain symptoms when the customer uses non-Ford/Lincoln phone applications as an alternate channel to access vehicle
TSB 22-2104
Mar 21, 2022
350000 EQUIPMENT
This article supersedes TSB 21-2236 to update the models and year affected. Some 2013-2018 C-Max, 2013-2020 Fusion/MKZ, 2013-2022 Escape, 2015-2018 Focus, 2015-2019 MKC, 2015-2022 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2
TSB 22-2104
Mar 21, 2022
220000 SEATS
This article supersedes TSB 21-2236 to update the models and year affected. Some 2013-2018 C-Max, 2013-2020 Fusion/MKZ, 2013-2022 Escape, 2015-2018 Focus, 2015-2019 MKC, 2015-2022 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2
TSB 22-2104
Mar 21, 2022
354000 EQUIPMENT:MECHANICAL
This article supersedes TSB 21-2236 to update the models and year affected. Some 2013-2018 C-Max, 2013-2020 Fusion/MKZ, 2013-2022 Escape, 2015-2018 Focus, 2015-2019 MKC, 2015-2022 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2
SSM 50395
Jan 14, 2022
012000 STEERING:STEERING WHEEL /HANDLE BAR:HAND HEATER/COOLER
Some 2016 Explorer vehicles equipped with factory remote start (on the key fob) may exhibit erratic operation of the climate control seats and/or heated steering wheel during a remote start event. Examples of this may include: cooled seats
SSM 50395
Jan 14, 2022
118000 ELECTRICAL SYSTEM:SOFTWARE
Some 2016 Explorer vehicles equipped with factory remote start (on the key fob) may exhibit erratic operation of the climate control seats and/or heated steering wheel during a remote start event. Examples of this may include: cooled seats
SSM 50395
Jan 14, 2022
350000 EQUIPMENT
Some 2016 Explorer vehicles equipped with factory remote start (on the key fob) may exhibit erratic operation of the climate control seats and/or heated steering wheel during a remote start event. Examples of this may include: cooled seats
SSM 50395
Jan 14, 2022
221700 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
Some 2016 Explorer vehicles equipped with factory remote start (on the key fob) may exhibit erratic operation of the climate control seats and/or heated steering wheel during a remote start event. Examples of this may include: cooled seats
SSM 50379
Jan 7, 2022
134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY
Some 2011-2022 Explorer and 2020-2022 Aviator vehicles may experience an inoperative roof opening panel motor. If diagnostics lead to a motor replacement, visually inspect the original motor for signs of water intrusion. If found, determine
SSM 50097
Sep 9, 2021
115000 ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM
Some 2016-2017 Ford and Lincoln vehicles with a new body control module (BCM) installed may exhibit a programming error when using IDS versions 122.03 through 123.01 stating 'Data Corrupt' or 'Configuration Failed, would you like to retry?'
SSM 50097
Sep 9, 2021
110000 ELECTRICAL SYSTEM
Some 2016-2017 Ford and Lincoln vehicles with a new body control module (BCM) installed may exhibit a programming error when using IDS versions 122.03 through 123.01 stating 'Data Corrupt' or 'Configuration Failed, would you like to retry?'
SSM 50067
Aug 27, 2021
110000 ELECTRICAL SYSTEM
Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing th
SSM 50059
Aug 19, 2021
119430 ELECTRICAL SYSTEM:PROPULSION SYSTEM:CHARGING:MODULE:ONBOARD (OBCM)
Some 2016-2017 Ford and Lincoln vehicles with a new Body Control Module (BCM) installed may exhibit a programming error using IDS v122.03 and newer stating "Data Corrupt" or Configuration Failed, would you like to retry?. A temporary work
21B05
Aug 19, 2021
060000 ENGINE AND ENGINE COOLING
After extended idling, the high-speed cooling fan relay may fail in some of the affected vehicles. A failure will cause the fan to either continuously run or never turn on. A continuously running fan will increase the temperature of the rel
SSM 50059
Aug 19, 2021
115000 ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM
Some 2016-2017 Ford and Lincoln vehicles with a new Body Control Module (BCM) installed may exhibit a programming error using IDS v122.03 and newer stating "Data Corrupt" or Configuration Failed, would you like to retry?. A temporary work
TSB 21-2236
Jul 22, 2021
220000 SEATS
Some 2013-2018 C-Max, 2013-2020 Fusion/MKZ, 2013-2021 Escape, 2015-2018 Focus, 2015-2019 MKC, 2015-2021 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2021 F-Super Duty, 2018-2021 EcoSport/Expedition, 2019-2021 Ranger/Nautilus,
SSM 49821
May 24, 2021
060000 ENGINE AND ENGINE COOLING
Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing th
SSM 49821
May 24, 2021
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing th
21B14-S1
Mar 19, 2021
020000 SUSPENSION
Certain 2013 through 2017 Model Year Explorer and Police Interceptor Utility Vehicles that are Registered or Sold in Certain States/Provinces; Rear Toe Link Ball Joint Inspection This program is a proactive investigation by Ford Motor Comp
21B14
Mar 8, 2021
020000 SUSPENSION
Certain 2013 through 2017 Model Year Explorer and Police Interceptor Utility Vehicles that are Registered or Sold in Certain States/Provinces Rear Toe Link Ball Joint Inspection This program is a proactive investigation by Ford Motor Comp
TSB 20-2271
Dec 10, 2020
060000 ENGINE AND ENGINE COOLING
Some 2015-2019 MKC and 2016-2019 Explorer vehicles equipped with a 2.3L engine may exhibit a vibration/rough idle when the vehicle is in DRIVE or REVERSE. The vehicle may also exhibit a lack of engine revolutions per minute (RPM), lack of a
TSB 20-2271
Dec 10, 2020
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
Some 2015-2019 MKC and 2016-2019 Explorer vehicles equipped with a 2.3L engine may exhibit a vibration/rough idle when the vehicle is in DRIVE or REVERSE. The vehicle may also exhibit a lack of engine revolutions per minute (RPM), lack of a
SSM 49210
Sep 25, 2020
060000 ENGINE AND ENGINE COOLING
Some 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Although oil may collect on the turbocharger, it is very rare fo
19M01 S1
Jul 23, 2020
060000 ENGINE AND ENGINE COOLING
Certain 2013-2019 Model Year Police Interceptor Utility Vehicles Equipped with a 3.7L Engine Catalytic Converter Extended Coverage This program extends the warranty coverage of the catalytic converters to 11 years of service or 120,000 mil
TSB 20-2233
Jul 13, 2020
160000 STRUCTURE
This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint wi
SSM 48908
Jun 17, 2020
350000 EQUIPMENT
Some 2016-2020 Ford and Lincoln vehicles equipped with a SYNC 3 Touchscreen may experience the volume control unresponsive from the Front Control Interface Module (FCIM) and steering volume controls when using Apple Car Play. When the Apple
SSM 48908
Jun 17, 2020
110000 ELECTRICAL SYSTEM
Some 2016-2020 Ford and Lincoln vehicles equipped with a SYNC 3 Touchscreen may experience the volume control unresponsive from the Front Control Interface Module (FCIM) and steering volume controls when using Apple Car Play. When the Apple
SSM 48876
Jun 5, 2020
350000 EQUIPMENT
For 2013-2019 Ford Explorer vehicles that require rear wheel knuckle and bushing assembly repairs, dealers are advised to follow Workshop Manual (WSM) Procedures and use service parts recommended by Ford only. Ford has received reports of t
SSM 48876
Jun 5, 2020
022000 SUSPENSION:REAR
For 2013-2019 Ford Explorer vehicles that require rear wheel knuckle and bushing assembly repairs, dealers are advised to follow Workshop Manual (WSM) Procedures and use service parts recommended by Ford only. Ford has received reports of t
SSM 48876
Jun 5, 2020
200000 WHEELS
For 2013-2019 Ford Explorer vehicles that require rear wheel knuckle and bushing assembly repairs, dealers are advised to follow Workshop Manual (WSM) Procedures and use service parts recommended by Ford only. Ford has received reports of t
SSM 48876
Jun 5, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
For 2013-2019 Ford Explorer vehicles that require rear wheel knuckle and bushing assembly repairs, dealers are advised to follow Workshop Manual (WSM) Procedures and use service parts recommended by Ford only. Ford has received reports of t
TSB 20-2171
May 18, 2020
161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
Some 2013-2018 C-Max, 2013-2020 Escape/Fusion/MKZ, 2015-2018 Focus,2015-2019 MKC, 2015-2020 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2020 F-Super Duty, 2018-2020 EcoSport/Expedition, 2019-2020 Ranger/Nautilus vehicles may
TSB 20-2171
May 18, 2020
220000 SEATS
Some 2013-2018 C-Max, 2013-2020 Escape/Fusion/MKZ, 2015-2018 Focus,2015-2019 MKC, 2015-2020 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2020 F-Super Duty, 2018-2020 EcoSport/Expedition, 2019-2020 Ranger/Nautilus vehicles may
SSM 48821
May 14, 2020
200000 WHEELS
For 2013-2019 Ford Explorer vehicles that require rear wheel knuckle and bushing assembly repairs, dealers are advised to follow Workshop Manual (WSM) Procedures and use service parts recommended by Ford only. Ford has received reports of t
TSB 20-2154
May 7, 2020
162900 STRUCTURE:BODY:ROOF AND PILLARS
Some 2016-2019 Explorer vehicles may exhibit roof rail covers that become loose or partially detached. This may be caused by a lack of retention of the clips securing the roof rail covers. To correct the condition, follow the Service Proced
18B19-S1
Oct 31, 2018
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Certain 2013-2017 Model Year Police Interceptor Utility Vehicles - Exhaust Odor and Carbon Monoxide Complaints. Certain 2017 Model Year Continental Livery Vehicles - Exterior Door Handle Replacement
18B19-S1
Oct 31, 2018
162300 STRUCTURE:BODY:DOOR
Certain 2013-2017 Model Year Police Interceptor Utility Vehicles - Exhaust Odor and Carbon Monoxide Complaints. Certain 2017 Model Year Continental Livery Vehicles - Exterior Door Handle Replacement
17B25-S5
Sep 26, 2018
060000 ENGINE AND ENGINE COOLING
Certain 2013-2017 Model Year Police Interceptor Utility Vehicles - Exhaust Odor and Carbon Monoxide Complaints
17G01-S2
Aug 10, 2018
020000 SUSPENSION
Certain 2013-2017 Model Year Police Interceptor Utility Vehicles - Rear Suspension Toe Link Replacement
17G01-S1
Jan 31, 2018
020000 SUSPENSION
Certain 2013-2016 Model Year Police Interceptor Utility Vehicles - Rear Suspension Toe Link Replacement
17G01-S1
Jan 31, 2018
020000 SUSPENSION
Certain 2013-2016 Model Year Police Interceptor Utility Vehicles - Rear Suspension Toe Link Replacement
17G01-S1
Jan 31, 2018
022000 SUSPENSION:REAR
Certain 2013-2016 Model Year Police Interceptor Utility Vehicles - Rear Suspension Toe Link Replacement
17B25-S4
Nov 13, 2017
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Certain 2013-2017 Model Year Police Interceptor Utility Vehicles - Exhaust Odor and Carbon Monoxide Complaints
17N04
Nov 7, 2017
350000 EQUIPMENT
Certain 2014-2015 Explorer and 2014-2016 Police Interceptor Utility Vehicles - Front Door Trim Panel Repair
17N04
Nov 7, 2017
160000 STRUCTURE
Certain 2014-2015 Explorer and 2014-2016 Police Interceptor Utility Vehicles - Front Door Trim Panel Repair
17B25-S3
Oct 25, 2017
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Certain 2013-2017 Model Year Police Interceptor Utility Vehicles - Exhaust Odor and Carbon Monoxide Complaints
17M06
Oct 2, 2017
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Certain 2014 Model Year Police Interceptor Sedan and 2014-2016 Model Year Police Interceptor Utility Vehicles - Canister Purge Valve Leaks
16B10
Apr 5, 2016
110000 ELECTRICAL SYSTEM
In some of the affected vehicles, the front control/display interface module (FCDIM) may have been unintentionally programmed for the European market instead of the North American market
TSB160001
Feb 5, 2016
074000 FUEL/PROPULSION SYSTEM (PWS)
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C
TSB160001
Feb 5, 2016
060000 ENGINE (PWS)
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C
TSB160001
Feb 5, 2016
350000 EQUIPMENT
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C
TSB160001
Feb 5, 2016
160000 STRUCTURE
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C
TSB160001
Feb 5, 2016
140000 AIR BAGS
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C
TSB160001
Feb 5, 2016
100000 POWER TRAIN
49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C
LTR3756
Feb 5, 2016
074000 FUEL/PROPULSION SYSTEM (PWS)
49 CFR Part 579.5 Monthly Communications - January 2016
LTR3756
Feb 5, 2016
060000 ENGINE (PWS)
49 CFR Part 579.5 Monthly Communications - January 2016
LTR3756
Feb 5, 2016
160000 STRUCTURE
49 CFR Part 579.5 Monthly Communications - January 2016
LTR3756
Feb 5, 2016
140000 AIR BAGS
49 CFR Part 579.5 Monthly Communications - January 2016
LTR3756
Feb 5, 2016
110000 ELECTRICAL SYSTEM
49 CFR Part 579.5 Monthly Communications - January 2016
LTR3756
Feb 5, 2016
100000 POWER TRAIN
49 CFR Part 579.5 Monthly Communications - January 2016
FORD EXPLORER POLICE INTERCEPT - All Years Overview
Complete safety history for the FORD EXPLORER POLICE INTERCEPT across all model years (2017, 2021).
5
Total Recalls
51
Total Complaints
0
Investigations
1
Reported Crashes
0
Reported Fires
0
Reported Deaths