POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
Defect Description
Chrysler (FCA US LLC) is recalling certain 2012-2013 Fiat 500 vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the cable to detach from the transmission.
Consequence
If the shifter cable detaches from the transmission, the transmission may not shift into the gear selected by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the shifter cable adjuster, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB4.
51,788 vehicles affected
Manufacturer: Chrysler (FCA US LLC)
POWER TRAIN:AUTOMATIC TRANSMISSION
Defect Description
Chrysler (FCA US LLC) is recalling certain 2012-2013 Fiat 500 vehicles equipped with 6-speed automatic transmissions. The shifter cable bushing may fail allowing the cable to detach from the transmission.
Consequence
If the shifter cable detaches from the transmission, the transmission may not shift into the gear selected by the driver. Additionally, despite selecting PARK with the shifter, the vehicle may roll away. These scenarios may increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the shifter cable adjuster, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VB4.
51,788 vehicles affected
Manufacturer: Chrysler (FCA US LLC)
POWER TRAIN:MANUAL TRANSMISSION:FLOOR SHIFT ASSEMBLY
Defect Description
DLT, LLC. is recalling certain CravenSpeed Fiat Short Shifter shafts sold for use in 2011-2019 Fiat 500 vehicles. The Shifter Shaft may have been improperly manufactured with a through hole for the set screw rather than a blind hole, which may lead to the breakage of the Shifter Shaft.
Consequence
If the shifter breaks while the vehicle is in motion, it can increase the risk of a crash.
Remedy
DLT has notified owners, and will provide a complete replacement shifter assembly with an updated shaft, free of charge. The recall began July 24, 2019. Owners may contact DLT customer service at 1-503-505-6886.
740 vehicles affected
Manufacturer: DLT, LLC
POWER TRAIN:MANUAL TRANSMISSION
Defect Description
Chrysler (FCA US LLC) is recalling certain model year 2012-2016 Fiat 500 vehicles manufactured June 21, 2010, through January 12, 2016, equipped with a manual transmission. The clutch diaphragm spring may fracture and fail, causing an inability to switch gears.
Consequence
If the clutch diaphragm spring fails, the driver may not be able to shift gears or the vehicle may lose motive power, increasing the risk of a crash.
Remedy
The remedy for this recall will include the installation of a clutch pedal limiter and a clutch pedal switch. The recall began on November 10, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S34.
39,185 vehicles affected
Manufacturer: Chrysler (FCA US LLC)
POWER TRAIN:AUTOMATIC TRANSMISSION
Defect Description
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Fiat 500 battery electric vehicles manufactured March 8, 2013, to March 7, 2015. The Electric Vehicle Control Unit (EVCU) of the affected vehicles may set a diagnostic trouble code (DTC) that may cause the transmission to unexpectedly
... shift to neutral.Read moreConsequence
If the vehicle unexpectedly shifts to neutral, the loss of drive could increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will reprogram the EVCU, free of charge. The recall began June 19, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R20.
3,851 vehicles affected
Manufacturer: Chrysler (FCA US LLC)
Complaint Statistics
214 total complaints
14 crashes 3 fires 9 injuries
Top Reported Components
| Component | Complaints |
|---|
| POWER TRAIN | 76 |
| ENGINE | 22 |
| UNKNOWN OR OTHER | 18 |
| ELECTRICAL SYSTEM | 16 |
| FUEL/PROPULSION SYSTEM | 12 |
| AIR BAGS | 10 |
| EXTERIOR LIGHTING | 9 |
| STRUCTURE:BODY | 8 |
| SERVICE BRAKES | 7 |
| STEERING | 7 |
Incident date: Oct 18, 2025
While driving 40mph, pressed clutch and the transmission would not shift into gear. Car began to slow in traffic ans I was unable to accelerate as the clutch would not engage a gear. Mamaged to sagely get iff road. No fluid leaks found. Would shift into gear with car off. Gear selection works, not a
... shift cable issue.Read more
Incident date: Jun 23, 2025
In June 2025, while driving my 2013 Fiat Abarth at highway speed, the vehicle suddenly stalled without warning. This happened on one of the hottest days of the year with another person in the car, creating a serious risk of a high-speed collision. The cause was later confirmed by a different Fiat d
... ealership: a port in the intake/PCV system had been left completely uncapped after service at a Fiat dealership in 2024. The mechanic who worked on my car apparently believed this was only a “vent” and not part of the vacuum system — a dangerous misunderstanding that allowed unmetered air into the engine. This disrupted the air/fuel mixture and led directly to the stall. I have written proof from the dealership admitting to the “vent” claim. A competent technician should know the difference between a vent and a vacuum port. Returning a vehicle in this condition is negligence and puts lives at risk. The component is still available for inspection, and I have documentation supporting my claims.Read more
Incident date: Mar 13, 2025
Dear NHTSA Office of Defects Investigation, I am filing this formal complaint to report the sale and interstate delivery of a dangerously defective and noncompliant vehicle sold to me by Arlington Auto Group, located at 3621 Columbia Pike, Arlington, Virginia. On [XXX], I purchased a 2013 Fiat 500
... (VIN: [XXX] ). The vehicle was delivered to my home in Englewood, Colorado on [XXX]. Within 24 hours of taking possession of the car—and having driven fewer than 100 miles—I had the vehicle inspected by a certified mechanic at The Auto Repair Place in Boulder, Colorado. Their findings revealed multiple severe safety hazards, including: Rear brake pads completely worn to metal-on-metal contact Two bolts missing from the rear passenger wheel A destroyed and leaking turbocharger, which increases the risk of engine failure Inoperable tire pressure monitoring system (TPMS) No Virginia safety inspection documentation provided Additionally, the car had been illegally tampered with to bypass emissions systems, including removal of the catalytic converter and installation of sensor bypass wiring, which also violates federal law and emissions standards. This vehicle was represented as safe and legally operable at the time of sale. However, these issues clearly indicate the vehicle poses a substantial risk to public safety and should not have been sold or shipped across state lines. Request for Investigation I respectfully request that NHTSA investigate this matter for violations of federal motor vehicle safety standards (FMVSS) and to determine whether this dealership has a pattern or practice of selling unsafe or defective vehicles. I am prepared to provide: Full mechanic inspection report Purchase contract and shipping records Photos of the damage and mechanical issues Communications with the dealership and lender Thank you for your time and attention to this serious safety matter. Sincerely, [XXX] [XXX] (303) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Read more
Incident date: Mar 13, 2025
Dear NHTSA Office of Defects Investigation, I am filing this formal complaint to report the sale and interstate delivery of a dangerously defective and noncompliant vehicle sold to me by Arlington Auto Group, located at 3621 Columbia Pike, Arlington, Virginia. On [XXX], I purchased a 2013 Fiat 500
... (VIN: [XXX] ). The vehicle was delivered to my home in Englewood, Colorado on [XXX]. Within 24 hours of taking possession of the car—and having driven fewer than 100 miles—I had the vehicle inspected by a certified mechanic at The Auto Repair Place in Boulder, Colorado. Their findings revealed multiple severe safety hazards, including: Rear brake pads completely worn to metal-on-metal contact Two bolts missing from the rear passenger wheel A destroyed and leaking turbocharger, which increases the risk of engine failure Inoperable tire pressure monitoring system (TPMS) No Virginia safety inspection documentation provided Additionally, the car had been illegally tampered with to bypass emissions systems, including removal of the catalytic converter and installation of sensor bypass wiring, which also violates federal law and emissions standards. This vehicle was represented as safe and legally operable at the time of sale. However, these issues clearly indicate the vehicle poses a substantial risk to public safety and should not have been sold or shipped across state lines. Request for Investigation I respectfully request that NHTSA investigate this matter for violations of federal motor vehicle safety standards (FMVSS) and to determine whether this dealership has a pattern or practice of selling unsafe or defective vehicles. I am prepared to provide: Full mechanic inspection report Purchase contract and shipping records Photos of the damage and mechanical issues Communications with the dealership and lender Thank you for your time and attention to this serious safety matter. Sincerely, [XXX] [XXX] (303) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Read more
Incident date: Mar 13, 2025
Dear NHTSA Office of Defects Investigation, I am filing this formal complaint to report the sale and interstate delivery of a dangerously defective and noncompliant vehicle sold to me by Arlington Auto Group, located at 3621 Columbia Pike, Arlington, Virginia. On [XXX], I purchased a 2013 Fiat 500
... (VIN: [XXX] ). The vehicle was delivered to my home in Englewood, Colorado on [XXX]. Within 24 hours of taking possession of the car—and having driven fewer than 100 miles—I had the vehicle inspected by a certified mechanic at The Auto Repair Place in Boulder, Colorado. Their findings revealed multiple severe safety hazards, including: Rear brake pads completely worn to metal-on-metal contact Two bolts missing from the rear passenger wheel A destroyed and leaking turbocharger, which increases the risk of engine failure Inoperable tire pressure monitoring system (TPMS) No Virginia safety inspection documentation provided Additionally, the car had been illegally tampered with to bypass emissions systems, including removal of the catalytic converter and installation of sensor bypass wiring, which also violates federal law and emissions standards. This vehicle was represented as safe and legally operable at the time of sale. However, these issues clearly indicate the vehicle poses a substantial risk to public safety and should not have been sold or shipped across state lines. Request for Investigation I respectfully request that NHTSA investigate this matter for violations of federal motor vehicle safety standards (FMVSS) and to determine whether this dealership has a pattern or practice of selling unsafe or defective vehicles. I am prepared to provide: Full mechanic inspection report Purchase contract and shipping records Photos of the damage and mechanical issues Communications with the dealership and lender Thank you for your time and attention to this serious safety matter. Sincerely, [XXX] [XXX] (303) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Read more
Incident date: Dec 27, 2024
2013 FIAT 500 - Manual Transmission. The clutch cover diaphragm spring on the vehicle has fatigue and/or fracture. A failed clutch cover diaphragm spring has resulted in the inability to disengage the clutch, or shift gears. There is an inability to disengage the clutch, shift gears. It is potential
... ly available for inspection if needed. This occurred while driving at low speed (thank goodness). The car became stuck in place when the failure occurred (obviously a safety concern). The issue has been confirmed by a professional. The component has been inspected by service technician. There were no warnings (lamps, messages, etc.). I believe this failure is described in Recall S34 (NHTSA), and this vehicle should be included in that recall. FIAT disagrees and has denied responsibility. Can you help?Read more
Incident date: Nov 25, 2024
The contact owns a 2013 Fiat 500. The contact received notification of NHTSA Campaign Number: 16V302000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time fo
... r the recall repair. The contact stated while driving approximately 30 MPH, the clutch pedal was depressed; however, the pedal was sticking and failed to respond as designed. The contact was almost involved in a crash due to the failure. The contact stated that the vehicle then started operating as needed after the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage 195,000. VIN tool showed no open recall.Read more
Incident date: Aug 21, 2024
The contact owns a 2013 Fiat 500. The contact stated that while driving at an undisclosed speed, the clutch was depressed; however, the vehicle failed to stop as intended. The contact stated that there was a jingling sound coming from the engine compartment. In addition, the contact stated that whil
... e the clutch was depressed, the vehicle jerked and then rolled forward. The contact stated that several unknown warning lights were illuminated. The contact stated that the hard braking warning light was illuminated. The vehicle was taken to the dealer and the dealer was made aware of the failure. The contact was informed that parts were not available to repair the vehicle. The contact was fearful of driving the vehicle due to the failure. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 16V302000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 90,000. Parts distribution disconnect.Read more
Incident date: Oct 22, 2024
The contact owns a 2013 Fiat 500. The contact stated that while reversing, the vehicle failed to shift into park after stopping. While shifting into gear, the vehicle failed to move after the gear selector was placed in the desired gear. There were no warning lights illuminated. The contact stated t
... hat the failure was related to NHTSA Campaign Number: 19V817000 (Power Train). The contact called a towing company. The tow truck driver was able to re-attach the gear shifter cable, but the failure recurred. While reversing slowly to parallel park, the gear shifter cable detached again. The contact reattached the shifter cable. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 128,300.Read more
Incident date: Jul 4, 2024
The contact's daughter owns a 2013 Fiat 500. The contact stated while the vehicle was parked, the convertible sunroof retractor failed to function as intended. The contact stated that the convertible sunroof failed to close as needed. The vehicle was taken to an independent mechanic where it was dia
... gnosed and determined that the convertible sunroof mechanical system had failed and needed to be replaced. The contact was informed that the convertible sunroof mechanical system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 65,000.Read more
Incident date: Apr 29, 2024
Manual Transaxle Clutch Pedal
Incident date: Oct 12, 2023
The contact owns a 2013 Fiat 500. The contact received notification of NHTSA Campaign Number: 16V302000(Power Train) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufactur
... er exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure causing the clutch to fail. The failure mileage was 103,000. Parts distribution disconnect.Read more
Incident date: Feb 15, 2023
The contact owns a 2013 Fiat 500. The contact stated that upon shifting the vehicle into drive, the RPMs increased, but the vehicle failed to move, and had lost motive power. The contact shifted the vehicle to manual mode, and manually shifted the transmission into first gear and drove the vehicle.
... However, the vehicle would not shift into higher than third gear while in manual mode. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V817000 (Power Train) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 72,000.Read more
Incident date: Sep 1, 2023
The contact owns a 2013 Fiat 500. The contact received notification of NHTSA Campaign Number: 16V302000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds and depressing the accelerator pedal, the RPM failed to exceed 2,5
... 00 RPM. The contact stated that upon applying added pressure to the accelerator pedal, the RPMs increased, but the vehicle failed to accelerate as needed. The contact who is an independent mechanic, determined that the failure was related to the recall. The contact stated that he stopped driving the vehicle due to safety issues. The local dealer was contacted and informed the contact that the part was not available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact only one part per week was being shipped to dealers. The failure mileage was approximately 3,800. Parts distribution disconnect.Read more
Incident date: Jul 18, 2023
The car is difficult to accelerate and makes a loud hum over 50. It wont shift into reverse. It is confirmed that it is a transmission issue and the whole thing has to be replaced. I found on a mechanic's site that there is an open recall S34 however my VIN is not included despite the fact that my c
... ar has the same issue as the recall. The clutch diaphragm spring fails, the driver may not be able to shift gears or the vehicle may lose motive power, increasing the risk of a crash.Read more
Incident date: Jul 18, 2023
The car is difficult to accelerate and makes a loud hum over 50. It wont shift into reverse. It is confirmed that it is a transmission issue and the whole thing has to be replaced. I found on a mechanic's site that there is an open recall S34 however my VIN is not included despite the fact that my c
... ar has the same issue as the recall. The clutch diaphragm spring fails, the driver may not be able to shift gears or the vehicle may lose motive power, increasing the risk of a crash.Read more
Incident date: Jul 18, 2023
The car is difficult to accelerate and makes a loud hum over 50. It wont shift into reverse. It is confirmed that it is a transmission issue and the whole thing has to be replaced. I found on a mechanic's site that there is an open recall S34 however my VIN is not included despite the fact that my c
... ar has the same issue as the recall. The clutch diaphragm spring fails, the driver may not be able to shift gears or the vehicle may lose motive power, increasing the risk of a crash.Read more
Incident date: Sep 8, 2023
On Sept. 5, 2023 I took our Fiat 500 2013 model c in for air condition repair to Winter Haven Fiat service Dept. After I brought it home on Sept. 8th it started making strange noise, so i took it to local auto repair. They advised me that it was a clutch problem. I called Fiat service and they said
... they had good news and bad news. The clutch problem was under recall but they have been unable to get parts. they gave me the number for Fiat customer service and I called. At first I was told parts were available and to take car in for fix. Service dept. again said they couldn't get parts and not to drive car and not to bring it to them until they got parts. I was told to expect parts Oct 1st. then Oct. 13th , Then Oct. 23. Service dept also got these dates of delivery, but parts never came. then when i questioned parts not coming, i was told by case worker that service dept had cancelled my part order. The service dept denies this and since they are vin specific they couldn,t reorder. My caseworker has been unable to answer any questions as to if parts made, being made or if they even will. When i expect answers I am given a new case manager. I have an undriveable car that I need. I was told not to drive it by Fiat service manager as it could totally fail on highway and cause an accident and driving it can cause further damage to clutch.Read more
Incident date: Oct 10, 2023
The contact owns a 2013 Fiat 500 Abarth equipped with a Madness Autoworks Fiat 500 Short Shifter Kit/Adjustable/Madness. The contact stated that while driving approximately 5 MPH and attempting to shift the gear shifter, the vehicle was not responding. The shifter began to move in a circular motion
... making it impossible to drive the vehicle. The contact pushed the vehicle to the side and noticed that the shifter had fractured in half. The contact was able to obtain a different part and replaced the part at the location of the failure. The vehicle had not been taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer had been made aware of the failure and informed the contact that a recall had been issued on the part. The contact was offered the new replacement part. The failure mileage was unknown.Read more
Incident date: Jun 2, 2023
Real main seal leak Valve cover leak Vacuum pump leak Leaks went on to the starter and caused the starter to fail
Incident date: May 24, 2023
While driving down the highway, I noticed my engine began to shake violently and began to make a strong knocking noise. The check engine light then illuminated and started blinking, indicating a serious problem. I immediately attempted to pull over because the car was no longer safe to drive. I wait
... ed a few hours on the side of the road and had the car towed to a mechanic shop. They told me that there was an engine misfire on cylinder 3. They then pointed me toward the dealership. At the dealership, they found that three cylinders had exhaust valves that were burnt out, and needed to be replaced. What component or system failed or malfunctioned, and is it available for inspection upon request? - The exhaust valves of cylinders 1, 2, and 3. I have photos of what the valves looked like, but may not be able to retrieve the defective valves. I can retrieve an invoice as soon as I receive it. How was your safety or the safety of others put at risk? - Immediately once the issue started, it was no longer safe to continue driving on the highway. If I had continued to drive, it could have started a fire, or the engine could have stopped working, meaning that I would be stranded in the middle of the highway. Has the problem been reproduced or confirmed by a dealer or independent service center? - Yes. The dealership has determined the exhaust valves were at fault. The same dealership also had another vehicle with the same issue in the shop at the same time mine was in the shop. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - Yes, the dealership has inspected the part. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - There were no prior warning signs to this issue besides a slightly higher idle than usual. Immediately when the issue happened, the check engine light illuminated and started blinking.Read more
Incident date: Feb 1, 2023
The clutch pedal sticks to the floor and won't let me shift gears. There is a recall already but for some reason my car is not included the no.16v302000 please help if possible to get my car added to this recall thanks [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5
... U.S.C. 552(B)(6).Read more
Incident date: Aug 15, 2022
The contact owns a 2013 Fiat 500. The contact received notification of NHTSA Campaign Number: 16V302000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amou
... nt of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. The contact stated that they would like to withdraw this complaint because the part it due to arrive soon.Read more
Incident date: Nov 19, 2022
I stepped out of my car and shut my door by accident with my keys still in the car and all the doors locked on my car and locked me out. This is not a normal thing. My keys, my phone, and my purse were all in the car I am very thankful a child was not in there locked in. It was very cold out and rai
... ning. I had to use Walgreens office phone and they were not supposed to allow that but did thankfully. The police came and got me in my car. Ever since my car locked me out my door handles do not work. I have to leave my passenger window down at all times to get in my car. It rains in my car and on my passenger seat. I use the passenger window so I am not sitting in a wet seat so I just crawl through the passenger side after I stick my hand in the hole where the window should be to open my door and actually get in my usually wet car. I was sitting in Walgreens parking lot car was off and keys in seat. Please let me know if you need a police report. I have to locate the officer and get him to send me the report then upload it. He got me back in my carRead more
Incident date: Dec 2, 2022
In 2019 my 2013 500e wouldn't start/take a charge. I towed it to the dealer and after more than a month and $2250 they replaced the PIM module and HV battery pack. Fast forward to 2022 and I received the SERVICE ELECTRIC VEHICLE SYSTEM error. I drove the car to the dealer. They are claiming the fai
... lure is the HV battery cooling system is leaking coolant in to the battery itself and the only repair is full replacement. They are also claiming the battery is not under any warranty at this time. Any thoughts or advice on next steps would be appreciated. I cannot believe the HV battery would need to be replaced twice in 3 years.Read more
Incident date: Jun 2, 2022
shift cables & bushings failed causing inability to shift gears.
Incident date: May 19, 2022
Car break shift lock stuck in park with various different elements illuminating on the dash. Must manually override break shift lock to put car in neutral, start the car, and put it in drive or reverse. Will no go over 40 mph. Power steering will unexpectedly go out in addition to fuel cut off, ABS,
... and electronic stability control also stopping. Have had brake light switch replaced for temporary fix, and replaced the battery. Has passed multiple 20 point inspections with no visible damage. The same problem has reoccurred and the fiat mechanics only idea is to replace the entire shifter column and see if any other codes are appearing.Read more
Incident date: May 19, 2022
Car break shift lock stuck in park with various different elements illuminating on the dash. Must manually override break shift lock to put car in neutral, start the car, and put it in drive or reverse. Will no go over 40 mph. Power steering will unexpectedly go out in addition to fuel cut off, ABS,
... and electronic stability control also stopping. Have had brake light switch replaced for temporary fix, and replaced the battery. Has passed multiple 20 point inspections with no visible damage. The same problem has reoccurred and the fiat mechanics only idea is to replace the entire shifter column and see if any other codes are appearing.Read more
Incident date: May 19, 2022
Car break shift lock stuck in park with various different elements illuminating on the dash. Must manually override break shift lock to put car in neutral, start the car, and put it in drive or reverse. Will no go over 40 mph. Power steering will unexpectedly go out in addition to fuel cut off, ABS,
... and electronic stability control also stopping. Have had brake light switch replaced for temporary fix, and replaced the battery. Has passed multiple 20 point inspections with no visible damage. The same problem has reoccurred and the fiat mechanics only idea is to replace the entire shifter column and see if any other codes are appearing.Read more
Incident date: Jun 3, 2022
MELTING DASKBOARD, FIRST TIME COVERED BY ORIGINAL MANUFACTURERS WARRANTY. We extended the vehicle warranty with the dealer and specifically asked if the prior problem was covered and they answered in the affirmative. We then renewed vehicle warranty with the dealer again. THE PROBLEM HAPPENED AGA
... IN, AND THEY DENIED COVERAGE. SINCE THIS IS THE FACE OF THE DASHBOARD AND NOT THE TOP WE ARE CONCERNED THAT THE AIR BAG WILL NOT PROPERLY DEPLOY FOR THE PASSENGER. PART NOT COVERED ESTIMATE FOR PART IS $377.OO Labor charges unknownRead more
Incident date: Apr 14, 2022
Head light will not turn off . Drains the battery. Once fuse is removed the lights will then sut off only. This was since l purchase vehicle at dealership and hidden from me. Not told of problem . They hide it by removing the fuses.
Incident date: Feb 15, 2022
The contact owns a 2013 Fiat 500. The contact stated while reversing out of a parking space, he attempted to shift into drive; however, the gear shifter failed to move. There were no warning lights illuminated. Upon researching the failure online, the contact was able to reset the gear shifter by de
... pressing an unknown button. The contact was then able to move the gear shifter into drive position; however, the vehicle failed to respond. The vehicle remained at the scene. Upon further investigation online, the contact disconnected the battery of the vehicle, purchased the shifter cable bushing adjuster from the local dealer and replaced the part himself. The contact was then able to drive the vehicle. The manufacturer was notified of the failure and informed the contact that the dealer needed to send a diagnostic report indicating that the failure was related to NHTSA Campaign Number: 19V817000 (Power Train). The manufacturer would then determine whether they would assist as the VIN was not included. The vehicle was not diagnosed or repaired. The failure mileage was approximately 133,000.Read more
Incident date: Jan 1, 2020
When putting gasoline at the gas pump, pump clicks off constantly. Makes you think the tank is full when it is not, Have to pump very slow. takes 10-15 mins to fill up and have to know how many gallons are needed.
Incident date: Mar 4, 2019
Ed Payne Chrysler Dodge Jeep RAM 2101 E Expressway 83, Weslaco, TX 78599 +1 956-272-1902 For the past years, I have complained to the car dealer I take my vehicle into that there is an issue with the fuel tank. I have been told that other Fiat car owners have had the same issues as I. Issues, the 2
... 013 - 2014 Fait Sport 500, tank issue, when filling up the tank, the tank does not fill up normal. When filling up the gas take, the gas handle stops every 10 sec, I have to keep clicking on the gas pump handle every 10 sec. To keep the flow of gas to fill the gas tank up. I was told by the car dealer that the issue was the gas tank on the Fait, not the gas pump machine. When adding a new gas tank to the vehicle, the problem stop, and the owners were able to fill the gas tank without any issues. I keep having headlights, blinkers, stop lights burn out all the time. I believe there's an issue with the wiring in the Fait Sport 500.Read more
Incident date: Mar 4, 2019
Ed Payne Chrysler Dodge Jeep RAM 2101 E Expressway 83, Weslaco, TX 78599 +1 956-272-1902 For the past years, I have complained to the car dealer I take my vehicle into that there is an issue with the fuel tank. I have been told that other Fiat car owners have had the same issues as I. Issues, the 2
... 013 - 2014 Fait Sport 500, tank issue, when filling up the tank, the tank does not fill up normal. When filling up the gas take, the gas handle stops every 10 sec, I have to keep clicking on the gas pump handle every 10 sec. To keep the flow of gas to fill the gas tank up. I was told by the car dealer that the issue was the gas tank on the Fait, not the gas pump machine. When adding a new gas tank to the vehicle, the problem stop, and the owners were able to fill the gas tank without any issues. I keep having headlights, blinkers, stop lights burn out all the time. I believe there's an issue with the wiring in the Fait Sport 500.Read more
Incident date: Mar 4, 2019
Ed Payne Chrysler Dodge Jeep RAM 2101 E Expressway 83, Weslaco, TX 78599 +1 956-272-1902 For the past years, I have complained to the car dealer I take my vehicle into that there is an issue with the fuel tank. I have been told that other Fiat car owners have had the same issues as I. Issues, the 2
... 013 - 2014 Fait Sport 500, tank issue, when filling up the tank, the tank does not fill up normal. When filling up the gas take, the gas handle stops every 10 sec, I have to keep clicking on the gas pump handle every 10 sec. To keep the flow of gas to fill the gas tank up. I was told by the car dealer that the issue was the gas tank on the Fait, not the gas pump machine. When adding a new gas tank to the vehicle, the problem stop, and the owners were able to fill the gas tank without any issues. I keep having headlights, blinkers, stop lights burn out all the time. I believe there's an issue with the wiring in the Fait Sport 500.Read more
Incident date: Sep 20, 2021
The airbag warning light comes on intermittently with nothing on the passenger seat and a message that says "airbag service required" also appears intermittently. Dealership was unable to diagnose ("never seen this issue before"}, escalated to STAR (STAR case 101975980). STAR could not diagnose and
... requested that the tech perform a teardown to try to figure out what was wrong. The dealership wanted to do this at my expense ($360 just to perform the tear down. Actual repair cost unknown.) I do not feel that a customer should have to cover the cost for a manufacturer to find out what is wrong with their vehicle when the error is something that they are not familiar with and cannot diagnose and was not caused by the owner, especially when it is related to safety equipment and the proper functioning of that equipment.Read more
Incident date: Aug 17, 2021
When driving at 60mph, the vehicle lost power and would not accelerate. I do not know why this happened. I was endangered due to the inability to control the speed of my car in traffic. I have recognized a recall that I am going to pursue with a dealer. There was no warning lights on. Oil level
... was good. Engine temperature was in the OK zone.Read more
Incident date: Jan 13, 2021
VEHICLE WAS ACTING A LITTLE STRANGE ON A TRIP TO THE STORE. I SAW SMOKE COMING FROM UNDER THE HOOD WHEN I PULLED INTO THE PARKING SPOT. UPON THIS HAPPENING THE CAR WOULD NOT GO BACK INTO GEAR. HAD IT TOWED TO A DEALERSHIP AND WAS INFORMED OF THE S34 RECALL ON THE CLUTCH. THE SPRING HAD FAILED CAU
... SING THE CLUTCH TO FAIL. THE RECALL FIX WAS COMPLETED AND WHEN I PICKED MY CAR UP I NOTICED IT WAS VERY HARD TO SHIFT INTO GEARS-BUT THOUGHT IT WAS DUE TO THE NEW CLUTCH. I WENT TO THE STORE AND WHEN I WENT TO LEAVE IT GRINDED SO LOUD WHEN I PUT IT IN REVERSE. I WAITED SO I COULD PULL FORWARD INSTEAD. I TOOK IT BACK TO THE DEALERSHIP AND WAS TOLD THAT MY TRANSMISSION WAS GOING OUT BUT WAS INSTRUCTED ON HOW TO JUST PUSH IT INTO GEAR THROUGH THE GRINDING UNTIL I COULD GET A NEW TRANSMISSION. THAT THE RECALL HAD NOTHING TO DO WITH THE TRANSMISSION ISSUE. I FOUND THIS ABSOLUTELY UNACCEPTABLE AND OPENED A CASE WITH FIAT-WHO IS STILL TRYING TO TELL ME THAT THE TWO ISSUES HAVE NOTHING TO DO WITH EACH OTHER. I AM ATTACHING DOCUMENTATION I HAVE FOUND THAT SHOWS FCA STATING THAT THE RECALL CAN CAUSE EXCESSIVE CLUTCH TRAVEL AND THAT OVER TIME CAUSE DAMAGE TO THE TRANSMISSION-LIMITING A DRIVER'S ABILITY TO CHANGE GEARS!!!!! I AM GETTING NOWHERE WITH THEM AND BASICALLY HAVE A HUNK OF METAL NOW.Read more
Incident date: Dec 1, 2020
TL* THE CONTACT OWNS A 2013 FIAT 500. THE CONTACT STATED WHILE DRIVING 50 MPH, SHE WAS UNABLE SHIFT GEARS. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT PARKED ON THE SIDE OF THE ROAD. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO A FRIEND'S RESIDENCE. THE VEHICLE WAS THE
... N TOWED TO SOUTH MIAMI ALFA ROMEO FIAT (17220 S DIXIE HWY, MIAMI, FL 33157, (305) 305-3428) WHO WAS MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED NOR REPAIRED YET. THE VEHICLE WAS TOWED TO HER RESIDENCE. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 16V302000 (POWER TRAIN) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.Read more
Incident date: Dec 30, 2020
TL* THE CONTACT OWNS A 2013 FIAT 500. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITH SEVERAL UNKNOWN WARNING LIGHTS FLICKERING ON THE INSTRUMENT PANEL. THE CONTACT HAD THE VEHICLE TOWED TO HIS RESIDENCE WHERE AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE. THE CONT
... ACT WAS INFORMED THAT THE PCM AND ECM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS LIKE NHTSA CAMPAIGN NUMBER: 15V291000 (POWERTRAIN). THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 81,200.Read more
Incident date: Feb 3, 2020
DEALRS ARE AWARE OF THE FUEL TANK ISSUES, IT REFUSE TO FILL THE TANK THE NORMAL WAY. YOU HAVE TO KEEP PUMPING EVER SECOND UNTIL THE FULE TANK IS FULL. DEAL ADVICE TO CORRCT THE ISSUE, THE FUL TANK WAS BE REPLACE A $1000 ? VALUE. I REPORTED THE ISSUE AUG 8,2020 CASE # 76990681 TO THE FCA/MOPAR 800-85
... 3-1403. NOTHING HAS BEEN CORRECTED ON THE ISSUE, IM STILL HAVING PROBLEMS FUELING MY CAR WITH GAS. ELECTRIC ISSUE AS WELL, FRONT AND REAR LIGHT BUBBLE KEEP BURING OUT. DEALER NAME ED PAYNE2101 E EXPRESSWAY 83, WESLACO, TX 78599 (956) 272-1902Read more
Incident date: Feb 3, 2020
DEALRS ARE AWARE OF THE FUEL TANK ISSUES, IT REFUSE TO FILL THE TANK THE NORMAL WAY. YOU HAVE TO KEEP PUMPING EVER SECOND UNTIL THE FULE TANK IS FULL. DEAL ADVICE TO CORRCT THE ISSUE, THE FUL TANK WAS BE REPLACE A $1000 ? VALUE. I REPORTED THE ISSUE AUG 8,2020 CASE # 76990681 TO THE FCA/MOPAR 800-85
... 3-1403. NOTHING HAS BEEN CORRECTED ON THE ISSUE, IM STILL HAVING PROBLEMS FUELING MY CAR WITH GAS. ELECTRIC ISSUE AS WELL, FRONT AND REAR LIGHT BUBBLE KEEP BURING OUT. DEALER NAME ED PAYNE2101 E EXPRESSWAY 83, WESLACO, TX 78599 (956) 272-1902Read more
Incident date: Oct 31, 2020
CLUTCH PETAL TRANMISSION NOISE WHEN SHIFTING INDICATING DAMAGE IT MAY BE THE SAME PART THAT WAS RECALLED BUT I PURCHASED THE VEHICLE AFTER RECALL PERIOD CLOSED FOR WORK DONE ON VEHICLE. I NEED TO KNOW IS THERE ANY TYPE OF EXTENSION OR WAIVER THAT CAN BE GIVEN TO FIX ISSUE.
Incident date: Oct 1, 2020
HAVING THE SAME ISSUE WITH DIFFICULTY SHIFTING INCLUDED IN FCA RECALL 16V302000. AS WITH MANY OTHER COMPLAINTS FILED WITH THE NHTSA, FCA AND THE DEALERSHIP ARE DENYING MY VIN IS COVERED IN THE RECALL, BUT I HAVE A 2013 MANUAL TRANSMISSION FIAT 500, AND THE RECALL INCLUDES 2012-2016 MODEL YEARS. TH
... E CABLE HAS NOT BROKEN YET, BUT I AM HAVING GREAT DIFFICULTY GETTING THE CAR TO SHIFT INTO 1ST AND REVERSE. THE RECALL SPECIFICALLY SAYS THIS IS A SAFETY ISSUE INCREASING THE RISK OF CRASH IF THE CABLE BREAKS WHILE OPERATING THE CAR, BUT FCA IS CLEARLY NO COVERING UNDER RECALL ALL OF THE VEHICLES EXPERIENCING THIS PROBLEM. SO, AN OTHERWISE PERFECTLY MAINTAINED CAR IS NOW LEAVING ME QUESTIONING IT'S SAFETY. THANKS FIAT FOR NOT ACCEPTING RESPONSIBILITY FOR ALL THE VEHICLES WITH THIS PROBLEM!Read more
Incident date: Oct 5, 2020
CEL ALERT: P0071 OBD II ERROR AMBIENT AIR TEMPERATURE. THE FORUMS ARE FULL OF PEOPLE TRYING TO FIND OUT HOW TO FIX THIS. THERE IS A FAULTY THERMOSTAT IN THE PASSENGER SIDE MIRROR THAT REQUIRES THE ENTIRE MIRROR TO BE ( $117 FROM AUTO ZONE ) A 25 THERMOSTAT IS THE ONLY THING THAT SHOULD ACTUALLY NEED
... REPLACEMENTRead more
Incident date: Oct 5, 2020
CEL ALERT: P0071 OBD II ERROR AMBIENT AIR TEMPERATURE. THE FORUMS ARE FULL OF PEOPLE TRYING TO FIND OUT HOW TO FIX THIS. THERE IS A FAULTY THERMOSTAT IN THE PASSENGER SIDE MIRROR THAT REQUIRES THE ENTIRE MIRROR TO BE ( $117 FROM AUTO ZONE ) A 25 THERMOSTAT IS THE ONLY THING THAT SHOULD ACTUALLY NEED
... REPLACEMENTRead more
Incident date: Oct 5, 2020
CEL ALERT: P0071 OBD II ERROR AMBIENT AIR TEMPERATURE. THE FORUMS ARE FULL OF PEOPLE TRYING TO FIND OUT HOW TO FIX THIS. THERE IS A FAULTY THERMOSTAT IN THE PASSENGER SIDE MIRROR THAT REQUIRES THE ENTIRE MIRROR TO BE ( $117 FROM AUTO ZONE ) A 25 THERMOSTAT IS THE ONLY THING THAT SHOULD ACTUALLY NEED
... REPLACEMENTRead more
Incident date: Sep 11, 2020
THE WIRE HARNESS GOING TO THE TRUNK LID IS DEFECTIVE. THE WIRES BREAK AND THE DEALER REPAIRS THE BREAKS WITH A SPLICE WHICH DOESN'T LAST. I BROUGHT THE CAR TO THE DEALER FOR THIS DEFECT IN 2017. THEY PERFORMED THE FACTORY REPAIR PER THE SERVICE MANAGER CHARLIE THIBAULT. I EXPRESSED CONCERNS FOR
... THE REPAIR SINCE IT WAS SOMETHING I COULD HAVE PERFORMED. HE SAID IF THE REPAIR FAILS THEY WILL REVIEW AND DECIDE IF IT WILL BE COVERED IN THE FUTURE. THE REPAIR FAILED IN 2020, LESS THAN 20,000 MILES SINCE THE ORIGINAL REPAIR. THE CAR IS NOT DRIVEN IN THE WINTER AND IT IS STORED IN THE GARAGE SO THIS IS NOT DUE TO HARSH CONDITIONS. I CONTACTED FIAT CHRYSLER AUTOMOBILES (FCA) TO SEEK THEIR ASSISTANCE. THEY SUGGESTED REQUESTING A SERVICE APPOINTMENT TO GET THE DEALERSHIP INVOLVED. I DID THIS AND FCA REFUSED TO PAY FOR THE REPAIR. THEY SAID THE REPAIR HAS A 2 YEAR WARRANTY. WIRING HARNESSES SHOULD NOT FAIL EVERY 2 YEARS. LOOKING AT THE FIAT FORUMS THIS APPEARS TO BE A COMMON DEFECT WITH THIS VEHICLE. THE DEFECT CAN RESULT IN A SURCHARGEABLE OFFENSE IN MA OR AN ACCIDENT DUE TO THE LIGHTS NOT WORKING OR POSSIBLY A FIRE WHEN THE HARNESS BREAKS. THE ATTACHED PICTURES SHOW THE ORIGINAL DEFECT, THE NEW DEFECT, THE UNTAPED REPAIR WHEN IT FAILED A SECOND TIME, THE POOR REPAIR WITH WIRES NOT SEALED AFTER FIRST REPAIR. FIAT CHRYSLER SHOULD HAVE A RECALL FOR THIS ISSUE AND BE FORCED TO MAKE A PERMANENT REPAIR FOR THIS PROBLEM THAT WILL LAST THE LIFE OF THE CAR.Read more
Incident date: Aug 30, 2020
THE CAR HAS HAD THE RECALL SAFETY RECALL S34 / NHTSA 16V-302 <BR/>MANUAL TRANSAXLE CLUTCH PEDAL PERFORMED BACK AT 30,000 MI. CLEARLY DOSENT FIX THE PRESSURE PLATE ISSUE, AS I'M AN SURE THIS IS WHAT HAPPENED WHEN I WAS GETTING TIRES INSTALLED AND THE STATE INSPECTION AT A NTB SHOP. WHEN YOU HIT THE P
... EDAL THE CLITCH DOES NOT DISENGAGE, MEANING THE CLUTCH IS ALWAYS ENGAGED AND YOU CANNOT SHIFT GEARS. I PERSONALLY INSPECTED THE CLUTCH SYSTEM FROM THE PEDAL TO THE CLUTCH ARM AND CAN SEE THE CLUTCH DISENGAGEMENT ARM MOVING WHICH LEADS ME TO BELIEVE THAT THE PRESSURE PLATE SPRING IS BROKEN. I HAVE TRIED TO CONTACT THE LOCAL DEALER HERE IN ROANOME, VA TO NO AVAIL. SOUNDS LIKE I WILL BE DOING THE CLUTCH AND RELATED PARTS MYSELF, SO I FIGURED I WOULD GET MY COMPLAINT IN INCASE SOMEONE WANTS TO INSPECT PARTS AS THEY GET REMOVED. THE VEHICLE HAD THIS FAILURE WHILE MOVING SLOWLY IN A SHOP TO BE PUT ON A LIFT TO HAVE TIRES INSTALLED. NO PHOTOS YET, BUT WILL BE GETTING THEM SOON.Read more
Showing 50 of 214 complaints.