2004 DODGE SPRINTER
0 recalls, 45 complaints - 40 TSBs
No recalls found for this vehicle.
Complaint Statistics
45 total complaints
1 fires
Top Reported Components
| Component | Complaints |
|---|---|
| TIRES:VALVE | 6 |
| TIRES | 4 |
| POWER TRAIN:AUTOMATIC TRANSMISSION | 4 |
| ENGINE AND ENGINE COOLING:ENGINE | 4 |
| STRUCTURE:BODY | 2 |
| SERVICE BRAKES, HYDRAULIC | 2 |
| ENGINE | 2 |
| ELECTRICAL SYSTEM | 2 |
| ENGINE AND ENGINE COOLING:ENGINE:DIESEL | 2 |
| FUEL/PROPULSION SYSTEM | 1 |
FUEL/PROPULSION SYSTEM
Feb 4, 2020
Incident date: Dec 12, 2019
UPON COMPLETION OF THE T21 RECALL, THE CHECK ENGINE LIGHT (ERROR CODE U0423) CAME ON. THE INSTRUMENT CLUSTER LIGHT CONTINUED TO ILLUMINATE AFTER THE VEHICLE'S IGNITION WAS OFF, DRAINING THE BATTERY.
ENGINE
Jul 5, 2018
Incident date: Jun 12, 2018
TL* THE CONTACT OWNS A 2004 DODGE SPRINTER. THE CONTACT STATED THAT THE VEHICLE CONSISTENTLY MISFIRED. THE DODGE MANUFACTURER INCLUDED THE VEHICLE IN ITS T21 EMISSIONS RECALL FOR THE ENGINE CONTROL UNIT; HOWEVER, THE TOOLS, AN AVAILABLE TECHNICIAN, AND THE PART WAS NOT AVAILABLE TO SCHEDULE THE REPA... Read more
UNKNOWN OR OTHER
Nov 29, 2017
Incident date: Nov 29, 2017
I USED YOUR ONLINE VIN CHECKER TO SEE IF MY CAR HAS A RECALL AND IT SAID NO RECALLS, AND REQUEST INVALID BUT I KNOW I ENTERED THE CORRECT VIN AND YOU GAVE ME MY VEHICLE YEAR AND MODEL INFORMATION.
TIRES
Mar 2, 2015
Incident date: Feb 28, 2015
FOUR P225/75R15XL SCORPION STR TIRES PURCHASED & INSTALLED 8-5-10 AT EVANS TIRE &SERVICE CENTER 1530 GARNET AVE. SAN DIEGO CA 92109 ONTO 2004 DODGE SPRINTER 2500, MILEAGE 28274. ON 2-28-2015 MILEAGE APPROX.43125MI. : PASSERBY REPORTED LEFT REAR TIRE APPEARED VERY LOW ON AIR; DRIVER IMMEDIATE... Read more
STRUCTURE:BODY
Jul 13, 2014
Incident date: Oct 2, 2006
THE SLIDING DOOR WHICH IS THE ONLY EGRESS FOR PASSENGERS IN THE BACK OF THE VAN WILL NOT OPEN. I HAVE HAD IT FIXED 4 TIMES AND IT CONTINUOUSLY FAILS. I HAVE TALKED TO OTHER SPRINTER OWNERS AND THEY HAVE THE SAME PROBLEM. SHOULD THERE BE AN INCIDENT THAT REQUIRED THE QUICK EVACUATION OF THE VAN BY... Read more
ENGINE
Nov 9, 2012
Incident date: Apr 2, 2012
DRIVING AT FREEWAY SPEED THE VEHICLE LOSSES POWER AND THE SPEED DECREASES TO ABOUT 40 MPH. I CAN PULL OVER AND TURN OF THE MOTOR FOR ABOUT 10 SECONDS AND START UP AND THE VEHICLE WILL RESET AND RUN FINE UNTIL IT DOES IT AGAIN RANDOMLY. THIS IS VERY DANGEROUS ESPECIALLY WHEN YOU ARE IN THE LEFT HAND... Read more
SERVICE BRAKES, HYDRAULIC
Feb 25, 2010
Incident date: Feb 25, 2010
2004 DODGE SPRINTER - THE BRAKING SYSTEM STIFFENS UP (POWER BRAKE) IF I PUSH THE PEDAL HARD ESPECIALLY WHEN I BACK UP THE VEHICLE. IT'S LIKE THE BOOSTER HAS FROZEN SOLID AND THE BRAKE PEDAL CAN'T TRAVEL ALL THE WAY DOWN. IF I LET THE VEHICLE SIT FOR A WHILE (1 HR) IT WILL GET BACK TO NORMAL. THIS IS... Read more
EQUIPMENT
Oct 22, 2009
Incident date: Jul 10, 2005
IN MAY OF 2005 I PURCHASED A NEW DODGE (MERCEDES BENZ) SPRINTER 2500 PASSENGER VAN. WITHIN THE FIRST 3 MONTHS AND 7,500 MILES OF DATE OF PURCHASE THE VEHICLE BEGAN TO SHOW SIGNS OF PREMATURE RUSTING AND LEAKAGE OVER THE ENTIRE VEHICLE. I PURSUED REMEDY THRU ALL AUTHORIZED SPRINTER DEALERSHIPS ADHER... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Oct 22, 2009
Incident date: Jul 10, 2005
IN MAY OF 2005 I PURCHASED A NEW DODGE (MERCEDES BENZ) SPRINTER 2500 PASSENGER VAN. WITHIN THE FIRST 3 MONTHS AND 7,500 MILES OF DATE OF PURCHASE THE VEHICLE BEGAN TO SHOW SIGNS OF PREMATURE RUSTING AND LEAKAGE OVER THE ENTIRE VEHICLE. I PURSUED REMEDY THRU ALL AUTHORIZED SPRINTER DEALERSHIPS ADHER... Read more
STRUCTURE:BODY
Oct 22, 2009
Incident date: Jul 10, 2005
IN MAY OF 2005 I PURCHASED A NEW DODGE (MERCEDES BENZ) SPRINTER 2500 PASSENGER VAN. WITHIN THE FIRST 3 MONTHS AND 7,500 MILES OF DATE OF PURCHASE THE VEHICLE BEGAN TO SHOW SIGNS OF PREMATURE RUSTING AND LEAKAGE OVER THE ENTIRE VEHICLE. I PURSUED REMEDY THRU ALL AUTHORIZED SPRINTER DEALERSHIPS ADHER... Read more
INTERIOR LIGHTING
Sep 22, 2009
Incident date: Aug 20, 2009
THERE IS A SAFETY RECALL ID # 07V299000 - INTERIOR LIGHTING ON THE MAKE AND MODEL OF MY VEHICLE AND MY VEHICLE HAS THE SAME SYMPTOMS YET IS NOT PART OF THE RECALL. DODGE HAS ORDERED THE PARTS TO BE REPLACED AND IS CHARGING $277.67. PLEASE LET ME KNOW HOW TO CORRECT THIS ISSUE. *TR
ELECTRICAL SYSTEM
Sep 22, 2009
Incident date: Aug 20, 2009
THERE IS A SAFETY RECALL ID # 07V299000 - INTERIOR LIGHTING ON THE MAKE AND MODEL OF MY VEHICLE AND MY VEHICLE HAS THE SAME SYMPTOMS YET IS NOT PART OF THE RECALL. DODGE HAS ORDERED THE PARTS TO BE REPLACED AND IS CHARGING $277.67. PLEASE LET ME KNOW HOW TO CORRECT THIS ISSUE. *TR
WHEELS
Jul 5, 2009
Incident date: Jul 1, 2009
ORIGINAL EQUIPMENT STEEL WHEEL ON 2004 DODGE SPRINTER BROKE ALONG "SPOKES". THIS COULD BE A LIFE THREATENING CONDITION AT HIGHWAY SPEEDS OR IN A LOADED VAN. I NOTICED A NOISE COMING FROM THE WHEEL AND TOOK IT TO A SHOP WHERE THEY COULD FIND NOTHING WRONG BECAUSE THE CRACKS IN THE WHEEL ARE VERY DI... Read more
EXTERIOR LIGHTING:BRAKE LIGHTS
Nov 18, 2008
Incident date: Nov 18, 2006
TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. WITHIN TWO MONTHS OF PURCHASING THE VEHICLE, THE REAR BRAKE LIGHTS FAILED. THE CONTACT HAD TO CONSTANTLY TAKE THE VEHICLE TO THE DEALER FOR REPAIR. THE MANUFACTURER WAS NOTIFIED, BUT THERE WAS NO RESOLUTION. A BLOWN TAIL LIGHT FUSE WAS REPAIRED, BUT IT ... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Nov 18, 2008
Incident date: Nov 18, 2006
TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. WITHIN TWO MONTHS OF PURCHASING THE VEHICLE, THE REAR BRAKE LIGHTS FAILED. THE CONTACT HAD TO CONSTANTLY TAKE THE VEHICLE TO THE DEALER FOR REPAIR. THE MANUFACTURER WAS NOTIFIED, BUT THERE WAS NO RESOLUTION. A BLOWN TAIL LIGHT FUSE WAS REPAIRED, BUT IT ... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
Nov 12, 2008
Incident date: Jun 15, 2008
TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. THE CONTACT DISCOVERED OIL ON HIS DRIVEWAY. THE VEHICLE WAS TAKEN TO A DEALER AND THEY STATED THAT THERE WAS A LEAKING PLUG ON THE TRANSMISSION THAT RELEASED THE OIL ONTO THE DRIVEWAY. THE CURRENT MILEAGE WAS 17,000 AND FAILURE MILEAGE WAS 15,000.
POWER TRAIN:AUTOMATIC TRANSMISSION
Nov 12, 2008
Incident date: Jan 11, 2008
TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. THE CONTACT DISCOVERED OIL ON HIS DRIVEWAY. THE VEHICLE WAS TAKEN TO A DEALER AND THEY STATED THAT THERE WAS A LEAKING PLUG ON THE TRANSMISSION THAT RELEASED THE OIL ONTO THE DRIVEWAY. THE CURRENT MILEAGE WAS 52,000 AND FAILURE MILEAGE WAS 35,000.
ENGINE AND ENGINE COOLING:ENGINE
Jun 18, 2008
Incident date: Jun 14, 2008
WHILE TRAVELING ON I-70 FROM FREDERICK TO CUMBERLAND IN 2004 DODGE SPRINTER PLEASURE-WAY RV, NOTICED A REVVING IN THE ENGINE. GOING UP FIRST STEEP MOUNTAIN, THE ENGINE DROPPED 10 MPH FROM 65 TO 55. DROVE THROUGH HAGERSTOWN AND GOT ON I-68 TO CUMBERLAND. GOING UP THAT MOUNTAIN, THE RV LOST POWER I... Read more
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
May 31, 2008
Incident date: May 31, 2008
THERE IS CURRENTLY A COMPLAINT FOR THE 2500 DODGE SPRINTERS, FOR VALVE STEM FAILURE. WHAT ABOUT THE 3500? I'VE HAD THREE VALVE STEM FAILURES SO FAR AND NO RECOURSE. WHY IS THE 2500 DIFFERENT THAN THE 3,500? TWO HAPPENED ON THE HIGHWAY AND ONE JUST LET GO WHILE PARKED. LUCKILY TWO WERE ON THE REAR DU... Read more
ENGINE AND ENGINE COOLING:ENGINE
Apr 24, 2008
Incident date: May 10, 2006
ENGINE STALLS INTERMITTENTLY, WITH OR WITHOUT A/C. CAN HAPPEN AT ANY TIME AFTER START UP AND AT ANY SPEED WITHOUT WARNING. SOMETIMES CAN HAPPEN AFTER VEHICLE GOES OVER A BUMP (EVEN SMALL ONES), DURING TURNS, MOVING OFF FROM A TRAFFIC LIGHT. THIS IS HIGHLY DANGEROUS. DEALER DID INSTALL KIT TO PREVENT... Read more
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
Dec 27, 2007
Incident date: Nov 21, 2006
TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. WHILE DRIVING 65 MPH, THE VEHICLE SPEED DECREASED DRAMATICALLY. THE ENGINE WARNING LIGHT ILLUMINATED AFTER THE VEHICLE DECREASED IN SPEED. HE TOOK THE VEHICLE TO THE DEALER ON NINE OCCASIONS AND THEY REPLACED THE ERG VALVE, TURBO MANIFOLD, AND THE TURBO R... Read more
STEERING:RACK AND PINION
Jun 8, 2007
Incident date: Jun 8, 2007
RACK AND PINION WAS REPLACED AFTER LEAKAGE OCCURED AT 27000 MILES. IT IS LEAKING AGAIN BUT NOT COVERED UNDER DRIVE TRAIN WARRENTY AND DODGE REFUSES TO REPLACE IT. HOWEVER IF THIS IS A REOCCURING PROBLEM YOU SHOULD INSIST THAT DODGE MODIFY THE DESIGN AND EFFECT A RECALL.
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Jun 8, 2007
Incident date: Jan 30, 2007
FAN PULLEY DISLODGES AND TEARS UP THE FRONT ACCESSORIES. DURING EXTENSIVE TRAVELS I HAVE FOUND DOZENS OF SPRINTERS HAVING HAD THE SAME PROBLEM. I THINK THAT THE DESIGN OR MATERIALS THAT MAKE UP THE PULLEY ARE FLAWED AND YOU SHOULD INVESTIGATE. I FURTHER BELIEVE THE DESCREPENCY BASED ON CONVERSAT... Read more
ENGINE AND ENGINE COOLING:ENGINE
Apr 4, 2007
Incident date: Apr 3, 2007
TL*THE CONTACT OWNS A 2004 DODGE SPRINTER. WHILE DRIVING 65 MPH WITH CRUISE CONTROL ACTIVATED, THE VEHICLE SHUT DOWN WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER AND IT WAS TOWED TO THE DEALER. THE VEHICLE IS BEING DIAGNOSED BY THE DEALER AT THIS TIME. THE CURRENT AND FAILURE MILEAGE WER... Read more
TIRES:VALVE
Apr 4, 2007
Incident date: Apr 3, 2007
WHILE PARKED IN MY DRIVEWAY MY 04 3500 DODGE SPRINTER RIGHT REAR OUTSIDE TIRE SUDDENLY DEFLATED. THE VALVE STEM CORE HAD SEPARATED FROM THE RUBBER, CAUSING THE TIRE TO SUDDENLY DEFLATE. DODGE CLAIMS MY TRUCK IS NOT COVERED UNDER THE VALVE STEM RECALL. THIS IS THE 3RD. VALVE STEM TO FAIL. *AK
TIRES:VALVE
Apr 4, 2007
Incident date: Aug 27, 2006
WHILE PARKED IN MY DRIVEWAY TIRES INFLATED TO 60 PSI MAXIMUM 65 PSI, LEFT FRONT TIRE SUDDENLY DEFLATED. THE VALVE STEM CORE SEPARATED FROM THE RUBBER CAUSING THE TIRE TO DEFLATE. THE VALVE STEM WAS REPLACED.THIS IS ON A 04 3500 DODGE SPRINTER AND IS NOT COVERED UNDER THE VALVE STEM RECALL ACCORDI... Read more
TIRES:VALVE
Apr 3, 2007
Incident date: Mar 27, 2007
WHILE PARKED IN A STORE PARKING LOT WITH TIRES INFLATED TO 60 PSI (MAX 65 PSI) INSIDE LEFT REAR TIRE ON A 04 3500 DODGE SPRINTER SUDDENLY WENT FLAT, THE VALVE STEM CORE SEPARATED FROM THE RUBBER CAUSING THE TIRE TO LOSE AIR. *JB
VISIBILITY:WINDSHIELD
Mar 19, 2007
Incident date: Jan 1, 2006
WE OWN TWO DODGE SPRINTERS 2500. YEARS 2004 AND 2006. WE HAVE OWNED BOTH FOR A LITTLE MORE THAN A YEAR. WE HAVE BROKEN SIX WINSHIELDS. WE HAVE LOOKED FOR STRONGER WINDSHIELDS NONE ARE MADE.{ PER PPG} WE HAVE HAD INSTALLS DONE BY FACTORY AND PRIVATE. THE WINDOW FAMES HAVE BEEN INSPECTED FOR DEFECTS... Read more
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Feb 2, 2007
Incident date: Jun 17, 2006
THE CRANK SHAFT DAMPER PULLY & R & R TIMING CHAIN BROKE, RENDERING THE VEHICLE IMMOBILE. PARTS WERE REPLACED AND 2 MONTHS LATER, THE SAME THING HAPPENED. *JB
TIRES:VALVE
Oct 27, 2006
Incident date: Oct 25, 2006
I OWN A 2004 SPRINTER VIN # WD1PD443745XXXXXX WITH CONTINENTAL TIRES. I HAVE HAD 3 VALVE STEMS SEPARATE WITH THE CORE COMING COMPLETELY OUT WITH LESS THAN 40,000 MILES. WHEN I HAD THE OTHERS (3 PLUS THE SPARE) REPLACED 2 OF THEM ALSO CAME APART. *NM
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Sep 8, 2006
Incident date: Sep 8, 2006
DT*: THE CONTACT STATED THE VEHICLE WAS CONSTRUCTED WITHOUT A TAILPIPE, CAUSING THE VEHICLE INTERIOR TO BECOME COVERED WITH DIESEL EXHAUST SOOT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER RESEARCHED THE MANUFACTURING SPECIFICATIONS OF THE VEHICLE AND CONFIRMED THAT THE LACK OF A T... Read more
ENGINE AND ENGINE COOLING:ENGINE
Mar 6, 2006
Incident date: Mar 6, 2006
DT*: THE CONTACT STATED AT ANY SPEED THE VEHICLE STALLED, INTERMITTENTLY. THE VEHICLE MUST BE STOPPED AND TURNED OFF BEFORE THE VEHICLE WOULD RESTART. THE DEALERSHIP HAS REPLACED THE COMPUTER, EGR VALVE, FUSE BLOCK, AND FUEL RELAY SWITCH. THESE EFFORTS HAVE NOT REPAIRED THE PROBLEM.
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Dec 20, 2005
Incident date: Jul 15, 2005
DT: THE CONTACT STATED 2004 SPRINTER 2500 DRAINED THE BATTERY AND NEEDED TO BE RECHARGED ABOUT EVERY THREE WEEKS. THE DEALERSHIP STATED THERE WAS A TSB , BUT THEY REFUSED TO FIX IT. *AK
TIRES:VALVE
Oct 26, 2005
Incident date: Oct 18, 2005
DT CONTACT'S VEHICLE LOST TWO BACK TIRES BECAUSE OF THE TIRE STEMS. THIS IS A DUALLY VEHICLE. THE REAR INNER TIRES BLEW OUT. THE DEALER CAN NOT GET REPLACEMENT TIRES. THE DEALER DID AN EXAMINATION OF THE TIRES, AND THEY DETERMINED THAT THE VALVE STEMS SPLIT OPEN. HAD ALL SIX VALVE STEMS REPLACED.... Read more
STRUCTURE
Sep 2, 2005
Incident date: Jan 1, 1901
2004 SPRINTER VANS HAD PROBLEMS WITH CARBON DIOXIDE GETTING INSIDE OF THE VEHICLE.***NO ANSWER REQUIRED***. *MR *NM
ELECTRICAL SYSTEM
Aug 22, 2005
Incident date: Aug 1, 2005
2004 DODGE SPRINTER FUEL HOSE DISCONNECTED WHICH CAUSED THE ENGINE TO STOP OPERATING WHILE IN MOTION.*MR THERE WAS ALSO A WIRING ISSUE WHICH CAUSED THE BATTERY TO DRAIN AND THE ENGINE FAULT LIGHT WAS ILLUMINATED DUE TO THE LOOSE CONNECTION IN THE FUEL TANK. *TT
FUEL SYSTEM, OTHER
Aug 22, 2005
Incident date: Aug 1, 2005
2004 DODGE SPRINTER FUEL HOSE DISCONNECTED WHICH CAUSED THE ENGINE TO STOP OPERATING WHILE IN MOTION.*MR THERE WAS ALSO A WIRING ISSUE WHICH CAUSED THE BATTERY TO DRAIN AND THE ENGINE FAULT LIGHT WAS ILLUMINATED DUE TO THE LOOSE CONNECTION IN THE FUEL TANK. *TT
SERVICE BRAKES, HYDRAULIC
Mar 29, 2005
Incident date: Dec 13, 2004
SINCE PURCHASING THE VEHICLE THERE HAS BEEN A CONTINUOUS GRINDING AND VIBRATION WITH THE BRAKES, WHICH HAS IMPERFECTLY THE VEHICLE'S PERFORMANCE. CONSUMER TOOK VEHICLE TO DEALER FOR SERVICE, AND THE BRAKE PADS WERE REPLACED TWICE. HOWEVER, PROBLEM RECURRED. *AK REPLACED 4 ROTORS IN APRIL 2005 A... Read more
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Mar 8, 2005
Incident date: Mar 8, 2005
DRIVER NOTICED SMOKE COMING FROM UNDERNEATH THE VEHICLE WHILE PARKED. DRIVER TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE PROBLEM COULD NOT DUPLICATED. *AK
Fire
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Jan 10, 2005
Incident date: Jan 9, 2005
WHILE DRIVING AT HIGHWAY SPEED OR GREATER VEHICLE CUTS OFF WITHOUT WARNING, CAUSING THE VEHICLE TO LOSE POWER. OWNER HAS TAKEN THE VEHICLE TO THE DEALERS ON SEVERAL OCCASIONS. HOWEVER, DEALERSHIP WAS UNABLE TO DIAGNOSE THE PROBLEM. *AK....WHILE DRIVING ON I-5 IN CALIFORNIA, JUST AFTER PASSING A LAR... Read more
TIRES
Oct 28, 2004
Incident date: Sep 28, 2004
TIRES LOSING AIR PRESSURE EVERYDAY. *AK PE04066_CAT
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
Oct 28, 2004
Incident date: Oct 22, 2004
DRIVER SIDE MIRROR WON'T ADJUST HIGH ENOUGH TO BE ABLE TO SEE CARS BEHIND VEHICLE. CHRYSLER'S ANSWER IS THAT IT IS OPERATING AS DESIGNED AND NOT COVERED UNDER WARRANTY. *AK
TIRES
Oct 6, 2004
Incident date: Sep 8, 2004
WHILE DRIVING 35 MPH FRONT DRIVER SIDE TIRE DEFLATTED. CONSUMER PULLED OVER AND CHANGED THE TIRE. DEALERSHIP WAS NOTIFED, BUT DID NOT RESOLVE THE PROBLEM. MICHELIN, 225/75R16.*AK PE04066_CAT
TIRES
Aug 20, 2004
Incident date: Aug 8, 2004
VALVE STEM FAILED ON RIGHT REAR TIRE. TIRE DEFLATED RAPIDLY WHILE PARKED. 6100 MILES ON VEHICLE. DODGE SPRINTER 2500, 158 WHEELBASE AIRSTREAM CONVERSION RV.*AK PE04066_CAT
TIRES:VALVE
Aug 20, 2004
Incident date: Aug 8, 2004
VALVE STEM FAILED ON RIGHT REAR TIRE. TIRE DEFLATED RAPIDLY WHILE PARKED. 6100 MILES ON VEHICLE. DODGE SPRINTER 2500, 158 WHEELBASE AIRSTREAM CONVERSION RV.*AK PE04066_CAT
Technical Service Bulletins, 2004 DODGE SPRINTER
40 manufacturer communications from 30 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 160000 STRUCTURE | 7 |
| 350000 EQUIPMENT | 6 |
| 060000 ENGINE AND ENGINE COOLING | 6 |
| 103000 POWER TRAIN:AUTOMATIC TRANSMISSION | 3 |
| 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL | 2 |
| 116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER | 2 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 2 |
| 061000 ENGINE AND ENGINE COOLING:ENGINE | 2 |
T21
Jun 3, 2021
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Emissions Recall T21 Reprogram Engine Control Unit
T21
Mar 12, 2021
060000 ENGINE AND ENGINE COOLING
Emissions Recall T21 Reprogram Engine Control Unit
9004275
Jul 22, 2020
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi
9004275
Jul 22, 2020
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi
T21 Rev3
May 21, 2020
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Emissions Recall T21 Reprogram Engine Control Unit
T21 Rev3
May 21, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Emissions Recall T21 Reprogram Engine Control Unit
23-015-20
Apr 30, 2020
160000 STRUCTURE
Disinfectant Solution Recommended for COVID-19
23-015-20
Apr 30, 2020
350000 EQUIPMENT
Disinfectant Solution Recommended for COVID-19
08-049-20
Apr 22, 2020
350000 EQUIPMENT
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece
08-049-20
Apr 22, 2020
110000 ELECTRICAL SYSTEM
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece
3100619
Nov 20, 2019
160000 STRUCTURE
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100619
Nov 20, 2019
350000 EQUIPMENT
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100519
Nov 20, 2019
160000 STRUCTURE
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100319
Nov 20, 2019
160000 STRUCTURE
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-006-19
Nov 20, 2019
160000 STRUCTURE
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
31-003-19
Nov 20, 2019
350000 EQUIPMENT
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Nov 20, 2019
160000 STRUCTURE
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-005-19
Nov 20, 2019
350000 EQUIPMENT
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
68332810
Sep 7, 2016
060000 ENGINE AND ENGINE COOLING
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. C
R2118796A
Feb 26, 2016
060000 ENGINE AND ENGINE COOLING
Valve Body. These may cause over drive cycling.
9003215
Feb 12, 2015
060000 ENGINE AND ENGINE COOLING
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a
9003215
Feb 12, 2015
060000 ENGINE AND ENGINE COOLING
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a
9002849
Sep 3, 2014
350000 EQUIPMENT
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacemen
9002849
Sep 3, 2014
160000 STRUCTURE
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacemen
9002519
Mar 20, 2013
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
0711
May 1, 2007
022520 SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
REAR AXLE REPAIR VS. REPLACE PROCEDURE CHANGE. *KB
1400107
Jan 26, 2007
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
BIO-DIESEL B5 FUEL. *KB
0803006
Aug 25, 2006
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
0900606
Jun 17, 2006
061000 ENGINE AND ENGINE COOLING:ENGINE
NEW CRANKSHAFT AND CENTER BOLT DESIGN. *TT
0900306
Feb 25, 2006
061000 ENGINE AND ENGINE COOLING:ENGINE
CRANKSHAFT REPLACEMENT POLICY CHANGE AND MAIN BEARING PART NUMBER INFORMATION. *TT
1100305
Nov 10, 2005
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
TURBOCHARGER, CHANGE AIR COOLER, AND EXHAUST GAS RECIRCULATION SYSTEMS DIAGNOSIS ON OM647 ENGINES. *NM
2401305
Aug 4, 2005
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
2100205
May 7, 2005
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
TRANSMISSION FLUID MAY BE WICKING IN THE RIGHT FRONT CORNER OF THE TRANSMISSION OIL PAN AREA. *EH
2100705
Mar 9, 2005
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
AUTOMATIC TRANSMISSION SHIFTING CONCERNS. 2001-2005 DODGE SPRINTER. *SC
0801505
Mar 2, 2005
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
1400204
Nov 1, 2004
073100 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
COMMON RAIL FUEL INJECTION DIAGNOSIS. *TT THIS BULLETIN SUPERSEDES BULLETIN 14-002-04, DATED SETPEMBER 28, 2004. *TT
10182004
Oct 18, 2004
090000 FUEL SYSTEM, OTHER
FUEL SYSTEM CODES UPDATED. *EH
10182004
Oct 18, 2004
060000 ENGINE AND ENGINE COOLING
UPDATED GRAPHIC FOR HIGH PRESSURE PUMP REMOVAL AND INSTALLATION. *EH
44
Oct 1, 2004
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
CUSTOMER SATISFACTION NOTIFICATION D44 - EGR VALVE. THIS COULD CAUSE LIMITED ENGINE OUTPUT AND VEHICLE SPEED AS WELL AS ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL). ALSO INCLUDE THE 2004 FREIGHTLINER SPRINTER. *TT
0300204
May 4, 2004
106000 POWER TRAIN:AXLE ASSEMBLY
RINGING SOUND COMING FROM PROPELLER SHAFT WHEN TRANSMISSION IS SHIFTED FROM DRIVE TO REVERSE OR REVERSE TO DRIVE. *TT
DODGE SPRINTER - All Years Overview
Complete safety history for the DODGE SPRINTER across all model years (2005, 2007).
14
Total Recalls
115
Total Complaints
0
Investigations
0
Reported Crashes
1
Reported Fires
0
Reported Deaths