1992 DODGE RAM 1500

1 recalls, 0 complaints - 5 TSBs

PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE

Defect Description

THE PARKING BRAKE CABLE SPRINGS ARE TOO LONG, WHICH CAN CAUSE FULL COMPRESSION OF THE RETURN SPRING BEFORE FULL ENGAGEMENT OF THE BRAKE PADS TO THE DRUM WHEN THE PARKING BRAKE IS APPLIED. THE AMOUNT OF FORCE APPLIED BETWEEN THE PADS AND THE DRUM MAY ALSO DECREASE WITH REAR PAD WEAR AND SUCH DETERIOR... Read more

Consequence

THE PARKING BRAKE MAY NOT BE FULLY ENGAGED WHEN THEVEHICLE OPERATOR HAS APPLIED THE PARKING BRAKE LEVER. THIS COULD RESULT INUNINTENDED VEHICLE ROLLAWAY.

Remedy

REPLACE THE DEFECTIVE PARKING BRAKE CABLE WITH A CABLE ASSEMBLY THAT HAS THE PROPER LENGTH SPRING.

800 vehicles affected

Manufacturer: CHRYSLER CORPORATION

No complaints found for this vehicle.

Technical Service Bulletins, 1992 DODGE RAM 1500

5 manufacturer communications from 2 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	2
060000 ENGINE AND ENGINE COOLING	1
114000 ELECTRICAL SYSTEM:WIRING	1
160000 STRUCTURE	1

160000 STRUCTURE

Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom and/or

114000 ELECTRICAL SYSTEM:WIRING

350000 EQUIPMENT

NHTSA Safety Investigations, DODGE RAM 1500

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

AQ, Closed , Model Year: 2006

Chrysler's execution of 13V-528 & 529

RMD opened this audit query (AQ) investigation in order to better understand and evaluate Chrysler's process(es) for timely and efficient execution of its safety recall campaigns, including its oversight and management of its parts division Mopar.Prior to opening this investigation, RMD had raised c... Read more

PE, Closed , Model Year: 2005

Rear Differential Failure

On December 16, 2014, Chrysler Group LLC submitted a Safety Recall Report to NHTSA describing a defect in the rear differential of approximately 256,956 model year (MY) 2005 Dodge Ram 1500 pickup trucks (NHTSA Recall No. 14V-796, Chrysler Recall No. P77).Chrysler's letter states that: 1) some of the... Read more

PE, Closed , Model Year: 2009

Rear Differential Failure

In a letter dated October 2, 2012, Chrysler Group LLC (Chrysler) submitted a Defect Information Report (DIR) to NHTSA identifying a safety defect in approximately 48,058 vehicles built with an axle pinion nut that can loosen, which could result in lock-up of the rear axle and/or separation of the re... ar drive shaft from the rear axle (NHTSA Recall No. 12V-474).The vehicles involved in this recall are model year (MY) 2009 and MY 2010 Dodge Ram 1500 (46,677) and Dodge Dakota (1,381) vehicles manufactured between July 1, 2009 and November 30, 2009 built with 9.25? rear axles built at Chrysler?s Detroit Axle Assembly Plant.Chrysler stated it determined during this time frame there were instances of 9.25? axles built with rear axle pinion nuts that were missing the adhesive patch.The remedy for these vehicles is to install a pinion nut retainer.In a review of data in its complaint database and data submitted by Chrysler, the Office of Defects Investigation (ODI) identified 194 reports (including 3 crash reports) of rear axle lock up and/or drive shaft separation outside of the scope of recall 12V-474.In a letter dated February 5, 2013, Chrysler submitted a second DIR to NHTSA identifying another safety defect in approximately 278,150 vehicles built with 9.25? rear axles and outside of the scope of recall 12V-474 that could also result in lock-up of the rear axle and/or rear drive separation (NHTSARecall No. 13V-038).Chrysler stated that analysis of field return parts from this vehicle population, undersized pinion splines were found as the likely factor contributing to the loosening of the pinion nut.The vehicles involved in this recall are:266,091 MY 2009?2012 Dodge Ram 1500 vehicles manufactured from 2/28/09 through 6/30/09 and 12/1/09 through 10/20/11 (including 183,421 MY 2009-2010 subject vehicles); 8,475 MY 2009?2010 Dodge Dakota vehicles manufactured from 2/18/07 through 6/30/09 and 12/1/09 through 7/9/10; 2,346 MY 2009 Chrysler Aspen vehicles manufactured from 1/19/07 through 12/18/08; and 1,238 MY 2009 Dodge Durango vehicles manufactured from 1/17/07 through 12/18/08.The remedy for these vehicles is the same as for 12V-474.The failure counts in this resume are for the subject MY 2009-2010 Dodge Ram 1500 vehicles only.The recalled vehicle counts are based on current estimates from Chrysler and may differ from estimates in the original DIR's.This Preliminary Evaluation is closed.The ODI report cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10489593,10489091,10488952,10485174,10485096,10484596,10484490,10483394,10483370,10482853,10482816,10482438,10479806,10479352,10478724,10477460,10477354,10476923,10476691,10475939,10475241,10475158,10473147,10472488,10470655,10470516,10470231,10470152,10469969,10469548,10469435,10468759,10468024,10467819,10467805,10467683,10467196,10466630,10464240,10448778,10445208,10443542,10439902,10375394,10362531,10353440Read more

PE, Closed , Model Year: 2000

2000-2001 DODGE RAM PICKUP HOOD LATCH

THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE ... Read more

DP, Closed , Model Year: 1994

SEAT BACK FAILURE

ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STAN... Read more

PE, Closed , Model Year: 2002

REAR AXLE FAILURE

SEE ATTACHED REPORT.

PE, Closed , Model Year: 2001

REAR SAFETY BELT ANCHORAGE DISENGAGEMENT

ALLEGE THAT BOTH REAR INBOARD SAFETY BELT ANCHORAGES WERE FOUND TO LACK PROPER ATTACHMENTS.

EA, Closed , Model Year: 1994

HEADLIGHT CIRCUIT

THE HEADLAMP SWITCH IN THE SUBJECT VEHICLES CAN OVER-HEAT AND FAIL RESULTING IN LOSS OF HEAD LAMPS AND POSSIBLY OTHER LIGHTS.DAIMLERCHRYSLER CONDUCTED A SERIES OF TESTS AND DETERMINED THAT THE 3500 SERIES IS PRONE TO GENERATING HEAD LAMP SWITCH TEMPERATURES IN EXCESS OF THE SWITCH LUBRICANT THRESHOL... Read more

PE, Closed , Model Year: 1994

ALLEGED FAILURE OF STEERING PITMAN SHAFT

STEERING BOX OUTPUT (PITMAN) SHAFT BREAKAGE RESULTING IN LOSS OF CONTROL.

DODGE RAM 1500 - All Years Overview

Complete safety history for the DODGE RAM 1500 across all model years (1992, 2012).

83 Total Recalls

15,455 Total Complaints

9 Investigations

1,139 Reported Crashes

344 Reported Fires

44 Reported Deaths

DODGE RAM 1500 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2014	0	1	View
2012	7	978	View
2011	4	989	View
2010	4	0	View
2009	2	884	View
2008	8	720	View
2007	7	701	View
2006	12	1,080	View
2005	7	1,629	View
2004	8	1,367	View
2003	5	1,362	View
2002	6	1,004	View
2001	3	1,370	View
2000	3	641	View
1999	1	769	View
1998	1	645	View
1997	1	468	View
1996	1	407	View
1995	1	273	View
1994	1	148	View
1993	0	7	View
1992 (current)	1	0
1991	0	8	View

Other DODGE Models

Model	Recalls	Complaints
DURANGO	234	19,190	View
CARAVAN	213	14,304	View
GRAND CARAVAN	203	18,754	View
CHARGER	200	8,152	View
RAM	176	5,521	View
DAKOTA	153	9,250	View
CHALLENGER	102	2,357	View
STRATUS	94	3,621	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health