2003 CHEVROLET TRAILBLAZER
8 recalls, 1,160 complaints - 793 TSBs
05V198000 May 5, 2005
EXTERIOR LIGHTING:TURN SIGNAL
Defect Description
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence
THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1... Read more
04V527000 Nov 1, 2004
EXTERIOR LIGHTING:BRAKE LIGHTS
Defect Description
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence
AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
04V046000 Feb 4, 2004
VISIBILITY:WINDSHIELD WIPER/WASHER
Defect Description
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER... Read more
Consequence
DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-... Read more
03V250000 Jul 15, 2003
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Defect Description
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE... Read more
Consequence
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CON... Read more
03V151000 Apr 23, 2003
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Defect Description
CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH A LEFT-FRONT BRAKE PIPE WITH A CIRCUMFERENTIAL SCORE AT A RANDOM LOCATION ALONG THE LENGTH OF THE PIPE AS THE RESULT OF THE MANUFACTURING PROCESS. IF THE BRAKE PIPE PARTIALLY OR FULLY FRACTURED, BRAKE PEDAL TRAVEL WOULD IMMEDIATELY INCREASE AND FRONT B... Read more
Consequence
IF BRAKING PERFORMANCE IS REDUCED, A CRASH COULD OCCUR.
Remedy
DEALERS WILL REPLACE THE LEFT-FRONT BRAKE PIPE. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-... Read more
03V075000 Mar 6, 2003
POWER TRAIN:AUTOMATIC TRANSMISSION
Defect Description
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN AD... Read more
Consequence
THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.
Remedy
DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020... Read more
03V051000 Feb 14, 2003
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Defect Description
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence
THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy
DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-... Read more
02V222000 Aug 9, 2002
AIR BAGS:FRONTAL
Defect Description
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CON... Read more
Complaint Statistics
1,160 total complaints
84 crashes 24 fires 86 injuries 3 deaths
Top Reported Components
| Component | Complaints |
|---|---|
| ELECTRICAL SYSTEM | 169 |
| ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | 82 |
| FUEL SYSTEM, GASOLINE | 56 |
| FUEL/PROPULSION SYSTEM | 55 |
| AIR BAGS | 45 |
| POWER TRAIN:AUTOMATIC TRANSMISSION | 38 |
| EXTERIOR LIGHTING | 36 |
| POWER TRAIN | 34 |
| FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY | 26 |
| EXTERIOR LIGHTING:BRAKE LIGHTS | 23 |
ENGINE
Mar 1, 2023
Incident date: Feb 27, 2023
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving 50 MPH, the vehicle lost motive power and stalled. The contact stated that the check engine warning light was illuminated. The contact was able to restart the vehicle and continue driving to his destination. The conta... Read more
VISIBILITY
Mar 1, 2023
Incident date: Feb 27, 2023
The contact owns a 2018 Subaru Impreza. The contact received notification of NHTSA Campaign Number: 22V624000 (Visibility) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of tim... Read more
ENGINE
Mar 1, 2023
Incident date: Feb 27, 2023
My fusion is experiencing a coolant leak in the engine. After research, I have found it is a KNOWN problem by ford, that several people are experiencing. They are refusing to issue and recalls or cover any repair costs associated with the issue.
POWER TRAIN
Jan 12, 2022
Incident date: Jan 9, 2022
While driving my Trailblazer in A4WD on slippery road conditions, I went to pulled out of a parking lot and there was a loud sound like my whole front end fell out and the front end completely locked up. Almost causing an accident. I had to dial back to 2HI quickly to unlock to front end. There was ... Read more
ELECTRICAL SYSTEM
Mar 16, 2021
Incident date: Mar 1, 2021
WIRE HARNESS COATING FALLING APART ALMOST CAUGHT MY TRUCK ON FIRE GOT PICTURES AND IT TRIGGERS THE BRAKE LIGHT TO STAY ON
Fire
EXTERIOR LIGHTING
Mar 16, 2021
Incident date: Mar 1, 2021
WIRE HARNESS COATING FALLING APART ALMOST CAUGHT MY TRUCK ON FIRE GOT PICTURES AND IT TRIGGERS THE BRAKE LIGHT TO STAY ON
Fire
SERVICE BRAKES
Mar 16, 2021
Incident date: Mar 1, 2021
WIRE HARNESS COATING FALLING APART ALMOST CAUGHT MY TRUCK ON FIRE GOT PICTURES AND IT TRIGGERS THE BRAKE LIGHT TO STAY ON
Fire
STRUCTURE:BODY
Jan 31, 2021
Incident date: Oct 2, 2020
SEE ATTACHED COMPLAINT TO GENERAL MOTORS. I HAVE ADDITIONAL DOCUMENTS WHERE OTHERS HAVE HAD THE SAME PROBLEMS WITH THERE SIMILAR YEAR TRAILBLAZERS.
SUSPENSION
Jan 31, 2021
Incident date: Oct 2, 2020
SEE ATTACHED COMPLAINT TO GENERAL MOTORS. I HAVE ADDITIONAL DOCUMENTS WHERE OTHERS HAVE HAD THE SAME PROBLEMS WITH THERE SIMILAR YEAR TRAILBLAZERS.
FUEL/PROPULSION SYSTEM
Dec 3, 2020
Incident date: Sep 4, 2020
IT'S LEAKING GAS FROM LINES ON TOP OF GAS TANK MECHANIC CHECK IT OUT I JUST CAN'T AFFORD IT I'M DISABLED ON FIXED INCOME RAISING MY GRANDSON
FUEL/PROPULSION SYSTEM
May 12, 2020
Incident date: Oct 1, 2018
IN 2018 WE WERE HAVING A FUEL PRESSURE ISSUE AND DISCOVERED THAT THE ICV HAD CRACKED AROUND THE GAS TANK. WHEN I RESEARCHED THE ISSUE I FOUND THERE WAS A SPECIAL COVERAGE WARRANTY FOR THE ISSUE AND CALLED THE NEAREST CHEVY DEALERSHIP. THEY TOLD ME THAT THE COVERAGE HAD EXPIRED A MONTH EARLIER AND T... Read more
SEATS
Apr 29, 2020
Incident date: Apr 27, 2020
MY DRIVER SEAT CAUGHT FIRE WENT TO OPEN THE DOOR TO FIND A HOLE IN MY DRIVER SEAT AND THE ROOF TOP BURNT AS WELL. I ALSO HAD A NEW FUEL PUMP PUT IN DUE TO IT LEAKING GAS AFTER PUT IT. IT CONTINUES TO LEAK.
Fire
FUEL/PROPULSION SYSTEM
Apr 29, 2020
Incident date: Apr 27, 2020
MY DRIVER SEAT CAUGHT FIRE WENT TO OPEN THE DOOR TO FIND A HOLE IN MY DRIVER SEAT AND THE ROOF TOP BURNT AS WELL. I ALSO HAD A NEW FUEL PUMP PUT IN DUE TO IT LEAKING GAS AFTER PUT IT. IT CONTINUES TO LEAK.
Fire
SUSPENSION
Apr 13, 2020
Incident date: Apr 6, 2020
FRAME FAILED DRIVER'S SIDE REAR. CAUSING UNSAFE DRIVE CONDITION. FORWARD TO REVERSE GRINDING CAUSED BY SEPARATION OF FRAME.
SEATS
Apr 13, 2020
Incident date: Apr 6, 2020
FRAME FAILED DRIVER'S SIDE REAR. CAUSING UNSAFE DRIVE CONDITION. FORWARD TO REVERSE GRINDING CAUSED BY SEPARATION OF FRAME.
AIR BAGS
Apr 8, 2020
Incident date: Apr 2, 2020
NOTHING HAS HAPPENING YET TRYING TO GET THE RECALLS FIXED HAVE NO IDEA HOW TO GO ABOUT IT SO STARTED HERE, PLEASE TELL ME IF NOT ALLOWED OR WHERE I CAN GET THE INFORMATION
ELECTRICAL SYSTEM
Apr 8, 2020
Incident date: Apr 2, 2020
NOTHING HAS HAPPENING YET TRYING TO GET THE RECALLS FIXED HAVE NO IDEA HOW TO GO ABOUT IT SO STARTED HERE, PLEASE TELL ME IF NOT ALLOWED OR WHERE I CAN GET THE INFORMATION
SERVICE BRAKES
Apr 8, 2020
Incident date: Apr 2, 2020
NOTHING HAS HAPPENING YET TRYING TO GET THE RECALLS FIXED HAVE NO IDEA HOW TO GO ABOUT IT SO STARTED HERE, PLEASE TELL ME IF NOT ALLOWED OR WHERE I CAN GET THE INFORMATION
FUEL/PROPULSION SYSTEM
Mar 28, 2020
Incident date: Jan 9, 2020
CHEVROLET SHOULD DO A CURRENT RECALL MY 2003 TRAILBLAZER HAS LEAK NEEDS TO BE FIXED
SEATS
Aug 28, 2019
Incident date: Aug 22, 2019
TAKATA RECALL I HAVE A 2003 CHEVROLET TRAILBLAZER AND MY SUV WAS PARKED IN THE YARD AND I WENT TO GO TO THE STORE AND OPENED MY DOOR AND FOUND THE TRUCK WAS FULL OF SMOKE! MY DRIVER SEAT HAD CAUGHT ON FIRE JUST SITTING THERE. NOT EVEN CRANKED! IT DESTROYED THE SEAT AND THE TOP OF THE SUV AND THE ROO... Read more
Fire
ELECTRICAL SYSTEM
Aug 28, 2019
Incident date: Aug 22, 2019
TAKATA RECALL I HAVE A 2003 CHEVROLET TRAILBLAZER AND MY SUV WAS PARKED IN THE YARD AND I WENT TO GO TO THE STORE AND OPENED MY DOOR AND FOUND THE TRUCK WAS FULL OF SMOKE! MY DRIVER SEAT HAD CAUGHT ON FIRE JUST SITTING THERE. NOT EVEN CRANKED! IT DESTROYED THE SEAT AND THE TOP OF THE SUV AND THE ROO... Read more
Fire
SUSPENSION
Aug 20, 2019
Incident date: Jul 1, 2019
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHILE DRIVING VARIOUS SPEEDS, THE FRONT END OF THE VEHICLE VIBRATED. THE VIBRATION WAS MORE PRONOUNCED WHILE THE ENGINE WAS IDLING. ALSO, WHILE ASCENDING UP A HILL, THE VEHICLE WOULD NOT PROPERLY ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT M... Read more
ENGINE
Aug 20, 2019
Incident date: Jul 1, 2019
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHILE DRIVING VARIOUS SPEEDS, THE FRONT END OF THE VEHICLE VIBRATED. THE VIBRATION WAS MORE PRONOUNCED WHILE THE ENGINE WAS IDLING. ALSO, WHILE ASCENDING UP A HILL, THE VEHICLE WOULD NOT PROPERLY ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT M... Read more
POWER TRAIN
Aug 20, 2019
Incident date: Jul 1, 2019
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHILE DRIVING VARIOUS SPEEDS, THE FRONT END OF THE VEHICLE VIBRATED. THE VIBRATION WAS MORE PRONOUNCED WHILE THE ENGINE WAS IDLING. ALSO, WHILE ASCENDING UP A HILL, THE VEHICLE WOULD NOT PROPERLY ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT M... Read more
ELECTRICAL SYSTEM
Jul 24, 2019
Incident date: Apr 1, 2019
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHEN THE VEHICLE WAS STARTED, THE INSTRUMENT PANEL GAUGES OPERATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH AND INSTRUMENT CLUSTER FAILED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED O... Read more
FUEL/PROPULSION SYSTEM
Jun 1, 2019
Incident date: Oct 5, 2018
TAKATA RECALL YES I WAS SMELLING FUEL COMING FROM THE INSIDE OF THE CAB OF MY VEHICLE EVERY MORNING WELL STARTING IT UP AND IT WOULD REMAIN SO I LOOKED INTO IT AND IT WAS ON A RECALL BUT THEY TOLD ME THAT THE RECALL HAD EXPIRED AND THERE'S NOTHING THEY COULD DO ABOUT IT I DON'T THINK SOMETHING AS SE... Read more
EXTERIOR LIGHTING
Feb 20, 2019
Incident date: Sep 14, 2018
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHILE THE CONTACT WAS DRIVING AT DUSK, THE HEADLIGHTS WENT OUT WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE CONTACT CALLED SONS CHEVROLET (3615 MANCHESTER EXPY, COLUMBUS, GA 31909, (706) 322-8888), BUT NO ASSISTANCE WAS PROVIDED... Read more
FUEL/PROPULSION SYSTEM
Jan 30, 2019
Incident date: Jan 21, 2019
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. THE CONTACT STATED THERE WAS A STRONG ODOR OF FUEL INSIDE AND OUTSIDE THE VEHICLE. RELIABLE CHEVROLET (3655 S CAMPBELL AVE, SPRINGFIELD, MO 65807, (417) 708-8088) WAS CONTACTED AND INFORMED THE CONTACT THAT THE FAILURE WAS NOT COVERED. THE VEHICLE W... Read more
VEHICLE SPEED CONTROL
Jan 8, 2019
Incident date: Jan 1, 2019
THE INSTRUMENT CLUSTER HAS QUIT WORKING
ELECTRICAL SYSTEM
Jan 8, 2019
Incident date: Jan 1, 2019
THE INSTRUMENT CLUSTER HAS QUIT WORKING
EXTERIOR LIGHTING:BRAKE LIGHTS
Dec 3, 2018
Incident date: Nov 19, 2018
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHILE DRIVING, THE CONTACT WAS PULLED OVER BY A STATE TROOPER AND INFORMED THAT THE REAR BRAKE LIGHTS WERE NOT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED, BUT THE RESULTS WERE UNKNOWN. THE VEHICLE WAS NOT REPAIRED.... Read more
FUEL/PROPULSION SYSTEM
Oct 11, 2018
Incident date: Oct 8, 2018
GAS SMELL
ELECTRICAL SYSTEM
Sep 21, 2018
Incident date: Sep 15, 2018
I HAVE A HEAVY FUEL RUNOFF , FROM MY FUEL TANK. EVEN IF THE ENGINE IS ONLY RAN FOR A MINUTE. ALSO, MY HEADLIGHTS GO OUT WHENEVER THEY FEEL LIKE DOING SO,WHILE DRIVING
FUEL/PROPULSION SYSTEM
Sep 21, 2018
Incident date: Sep 15, 2018
I HAVE A HEAVY FUEL RUNOFF , FROM MY FUEL TANK. EVEN IF THE ENGINE IS ONLY RAN FOR A MINUTE. ALSO, MY HEADLIGHTS GO OUT WHENEVER THEY FEEL LIKE DOING SO,WHILE DRIVING
ELECTRICAL SYSTEM
Jul 2, 2018
Incident date: Jul 1, 2018
MY DAUGHTER WAS DRIVING LOCALLY YESTERDAY 7/1/18 AND MAKING A RIGHT HAND TURN AT A SLOW SPEED. SHE LOST CONTROL AND COLLIDED WITH ANOTHER VEHICLE IN ONCOMING TRAFFIC. SHE WAS INJURED. THE CARS BRAKE LIGHTS HAD JUST GONE OUT AND THE BLOWER IS GOING ON AND OFF. I ASSUME THIS IS AN ELECTRICAL PROBLEM F... Read more
Crash
1 injured
SERVICE BRAKES
Jul 2, 2018
Incident date: Jul 1, 2018
MY DAUGHTER WAS DRIVING LOCALLY YESTERDAY 7/1/18 AND MAKING A RIGHT HAND TURN AT A SLOW SPEED. SHE LOST CONTROL AND COLLIDED WITH ANOTHER VEHICLE IN ONCOMING TRAFFIC. SHE WAS INJURED. THE CARS BRAKE LIGHTS HAD JUST GONE OUT AND THE BLOWER IS GOING ON AND OFF. I ASSUME THIS IS AN ELECTRICAL PROBLEM F... Read more
Crash
1 injured
ELECTRONIC STABILITY CONTROL (ESC)
Jul 2, 2018
Incident date: Jul 1, 2018
MY DAUGHTER WAS DRIVING LOCALLY YESTERDAY 7/1/18 AND MAKING A RIGHT HAND TURN AT A SLOW SPEED. SHE LOST CONTROL AND COLLIDED WITH ANOTHER VEHICLE IN ONCOMING TRAFFIC. SHE WAS INJURED. THE CARS BRAKE LIGHTS HAD JUST GONE OUT AND THE BLOWER IS GOING ON AND OFF. I ASSUME THIS IS AN ELECTRICAL PROBLEM F... Read more
Crash
1 injured
ENGINE
Jun 12, 2018
Incident date: May 18, 2018
OVERHEATING, REPLACED WATER PUMP THERMOSTAT CLUTCH FAN, RADIATOR IS GOOD, FUEL VALVE AND CLUTCH FAN ALL NEW, STILL OVERHEATING WHEN IT'S HOT OR CITY DRIVING WITH STOP AND GO. MECHANIC REPORTS HE CANNOT FIND ANYTHING CAUSING IT. FOUND INFO ON 2004 PCM CLUTCH FAN SETTING BUT, NOT 2003
EXTERIOR LIGHTING
Apr 2, 2018
Incident date: Apr 1, 2013
THE LIGHTS MELT THE HARNESSES IN THE FRONT LIGHTS FREQUENTLY. MORE THAN 2 TIMES A YEAR THE TAIL LIGHT NEEF CONSTANT REPLACEMENT FROM FAULTY WIRING. THE WIRES ARE NOT BIG ENOUGB TO HANDLE THE LOAD. IT HAPPENS AT ANY TIME IT WANTS DOESNT MATTER IF ITS SITTING IN PARK OR DRIVING.
Fire
ELECTRICAL SYSTEM
Apr 2, 2018
Incident date: Apr 1, 2013
THE LIGHTS MELT THE HARNESSES IN THE FRONT LIGHTS FREQUENTLY. MORE THAN 2 TIMES A YEAR THE TAIL LIGHT NEEF CONSTANT REPLACEMENT FROM FAULTY WIRING. THE WIRES ARE NOT BIG ENOUGB TO HANDLE THE LOAD. IT HAPPENS AT ANY TIME IT WANTS DOESNT MATTER IF ITS SITTING IN PARK OR DRIVING.
Fire
ELECTRICAL SYSTEM
Mar 17, 2018
Incident date: Mar 17, 2018
2003 CHEVY TRAIL BLAZER, AT ENGINE START UP, DASH LIGHTS AND GAUGES DO NOT COME ON, TURN KEY OFF AND BACK ON, DASH PANEL (CLUSTER) STILL DOES NOT FUNCTION. TEST DROVE TO SEE IF DASH WOULD COME ON, IT DID NOT. PARKED TBLAZER, TRIED STARTING AGAIN, STILL NOTING. DID THIS PROCEDURE 5 TIMES AND STILL DA... Read more
ELECTRICAL SYSTEM
Mar 11, 2018
Incident date: Mar 11, 2018
FOR THE LAST 3 YEARS, EVERY PART OF MY INSTRUMENT PANEL SEEMS TO WORK INTERMITTENTLY. AT TIMES WHILE DRIVING, THE SPEEDOMETER WILL SHOW ME DOING 40 MPH OVER MY ACTUAL SPEED, OR WILL SHOW ME DOING 120 WHILE I AM SITTING STILL. THE OIL PRESSURE WILL SOMETIMES SHOW THAT THERE IS NO PRESSURE AT ALL, O... Read more
FUEL/PROPULSION SYSTEM
Mar 7, 2018
Incident date: Mar 6, 2018
I JUST PURCHASED A 2003 TRAILBLAZER AND AFTER A DRIVE WHEN TURN OFF SMELLS REALLY BAD LIKE GASOLINE IS LEAKING
UNKNOWN OR OTHER
Jan 19, 2018
Incident date: Jan 18, 2017
ALMOST ALL THE GAUGES ON MY INTSTRUMET CLUSTER HAVE FAILED. SPEEDOMETER 1ST, OIL PRESSURE GAUGE NEXT, AND NOW MY FUEL GAUGE HAS FAILED. MANY COMPLAINTS FROM CHEVY OWNERS RE: SAME ISSUE. NO RESPONSE YET FROM CHEVY.
STRUCTURE:FRAME AND MEMBERS
Dec 1, 2017
Incident date: Oct 17, 2017
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE FRAME WAS EXPERIENCING DECAY. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED OF ROTTEN AREAS ON THE FRAME. THERE WERE NO WARNING INDICATORS ILLUMINATED. PRIOR TO THE DIAGNOSIS, T... Read more
STRUCTURE:BODY
Dec 1, 2017
Incident date: Oct 17, 2017
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE FRAME WAS EXPERIENCING DECAY. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED OF ROTTEN AREAS ON THE FRAME. THERE WERE NO WARNING INDICATORS ILLUMINATED. PRIOR TO THE DIAGNOSIS, T... Read more
ELECTRICAL SYSTEM
Nov 26, 2017
Incident date: Sep 4, 2017
MULTIPLE GAUGES ON THE INSTRUMENT PANEL ARE MALFUNCTIONING. THE TACHOMETER IS READING 5,000 RPM WHEN THE VEHICLE WAS IN PARK, AND 7,000 RPM WHEN GOING 15 MPH. WHEN I TURN THE CAR OFF THE GAUGE SITS AT 2,000. THE SPEEDOMETER IS CLICKING UP (NOT A SMOOTH TRANSITION TO THE CORRECT SPEED). AND IT SHOWIN... Read more
VEHICLE SPEED CONTROL
Nov 26, 2017
Incident date: Sep 4, 2017
MULTIPLE GAUGES ON THE INSTRUMENT PANEL ARE MALFUNCTIONING. THE TACHOMETER IS READING 5,000 RPM WHEN THE VEHICLE WAS IN PARK, AND 7,000 RPM WHEN GOING 15 MPH. WHEN I TURN THE CAR OFF THE GAUGE SITS AT 2,000. THE SPEEDOMETER IS CLICKING UP (NOT A SMOOTH TRANSITION TO THE CORRECT SPEED). AND IT SHOWIN... Read more
POWER TRAIN
Oct 18, 2017
Incident date: Oct 10, 2017
FLASHER MODULE, TRANSMISSION LEAK EVENING AFTER REPLACEMENT, UPPER CONTROL ARMS GOES OUT AFTER REPLACEMENT.
EXTERIOR LIGHTING
Oct 18, 2017
Incident date: Oct 10, 2017
FLASHER MODULE, TRANSMISSION LEAK EVENING AFTER REPLACEMENT, UPPER CONTROL ARMS GOES OUT AFTER REPLACEMENT.
Showing 50 of 1,160 complaints.
Technical Service Bulletins, 2003 CHEVROLET TRAILBLAZER
793 manufacturer communications from 599 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 84 |
| 110000 ELECTRICAL SYSTEM | 71 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 60 |
| 061000 ENGINE AND ENGINE COOLING:ENGINE | 45 |
| 060000 ENGINE AND ENGINE COOLING | 44 |
| 060000 ENGINE (PWS) | 30 |
| 353000 EQUIPMENT:ELECTRICAL | 28 |
| 100000 POWER TRAIN | 24 |
10-08-45-001H
Mar 28, 2024
110000 ELECTRICAL SYSTEM
This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
06-06-01-019C
Mar 14, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin advises the technician of possible location of an internal coolant leak from a specific cylinder head and location.
16-NA-383
Mar 13, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
22-NA-074
Feb 22, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
18-NA-099
Jan 16, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PI1394B
Jan 12, 2024
100000 POWER TRAIN
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PI1394B
Jan 12, 2024
060000 ENGINE AND ENGINE COOLING
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
02-08-42-001J
Jan 12, 2024
120000 EXTERIOR LIGHTING
This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
PIP5601B
Jan 12, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di
23-NA-219
Dec 12, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
23-NA-219
Dec 12, 2023
350000 EQUIPMENT
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
17-NA-170
Oct 6, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
PIT5099G
Sep 26, 2023
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
10-00-89-006J
Sep 26, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
07-08-49-020R
Sep 21, 2023
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
350000 EQUIPMENT
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
23-NA-153
Sep 1, 2023
100000 POWER TRAIN
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
23-NA-153
Sep 1, 2023
060000 ENGINE AND ENGINE COOLING
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
18-NA-073
Aug 24, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
PIP5628G
Aug 10, 2023
060000 ENGINE (PWS)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
PIP5358C
Jul 18, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
17-NA-170
Apr 27, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
19-NA-219
Apr 24, 2023
060000 ENGINE AND ENGINE COOLING
This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
PIP5628F
Apr 24, 2023
061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
19-NA-219
Mar 23, 2023
060000 ENGINE AND ENGINE COOLING
This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
22-NA-009
Mar 17, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
17-NA-073
Feb 21, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
01-08-42-001O
Feb 15, 2023
120000 EXTERIOR LIGHTING
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
PIP5628E
Feb 10, 2023
353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
09-00-89-008F
Dec 21, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
PIP5540J
Dec 15, 2022
138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
21-NA-124
Dec 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
PIT3271N
Nov 29, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271N
Nov 29, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
22-NA-074
Nov 9, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-205
Oct 19, 2022
110000 ELECTRICAL SYSTEM
This service bulletin provides information on Module Harvesting.
PIT3033B
Oct 18, 2022
061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR
This Preliminary Information communication provides information to the technician that the Cam gear alignment can be incorrect after replacing the HVAC mode actuator.
PIT3033B
Oct 18, 2022
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician that the Cam gear alignment can be incorrect after replacing the HVAC mode actuator.
10-00-89-006I
Oct 7, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
PIC5453D
Sep 30, 2022
980000 UNKNOWN OR OTHER
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
22-NA-195
Sep 28, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.
06-00-89-031H
Sep 16, 2022
100000 POWER TRAIN
This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.
06-00-89-031H
Sep 16, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.
22-NA-009
Sep 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIP5640A
Sep 1, 2022
100000 POWER TRAIN
This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an
22-NA-181
Sep 1, 2022
100000 POWER TRAIN
This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.
20-NA-065
Aug 15, 2022
060000 ENGINE AND ENGINE COOLING
This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.
22-NA-009
Jun 15, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIT5099F
Jun 13, 2022
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
PIP5358B
May 31, 2022
160000 STRUCTURE
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
18-NA-099
May 16, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
12-00-89-003B
May 2, 2022
060000 ENGINE (PWS)
This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
12-00-89-003B
May 2, 2022
353000 EQUIPMENT:ELECTRICAL
This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
22-NA-074
Mar 31, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-009
Mar 22, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIT3271M
Mar 7, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271M
Mar 7, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271L
Feb 3, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271L
Feb 3, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIP4723F
Jan 14, 2022
070000 FUEL SYSTEM, GASOLINE
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and
PIP4723F
Jan 14, 2022
030000 SERVICE BRAKES, HYDRAULIC
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and
22NA009
Jan 11, 2022
061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
000090002L
Jan 4, 2022
199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
This service bulletin provides information for accurate tire pressures that ensure the safe handling and appropriate ride characteristics of GM cars and trucks.
PIP5628E
Dec 14, 2021
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
PIT3099U
Aug 11, 2021
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician
010842001N
Jun 21, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
010842001N
Jun 21, 2021
350000 EQUIPMENT
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
010842001N
Jun 21, 2021
120000 EXTERIOR LIGHTING
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
21NA124
May 25, 2021
071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
21NA124
May 25, 2021
110000 ELECTRICAL SYSTEM
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
100089006H
May 17, 2021
350000 EQUIPMENT
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
PIP5358A
May 12, 2021
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
PIP5358A
May 12, 2021
160000 STRUCTURE
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
PIP5640A
Apr 12, 2021
200000 WHEELS
This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an
18NA099
Mar 30, 2021
350000 EQUIPMENT
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PIP5163E
Mar 30, 2021
070000 FUEL SYSTEM, GASOLINE
This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
PIP5540G
Mar 22, 2021
061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
PIP5725A
Mar 19, 2021
350000 EQUIPMENT
This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in
PIT3271K
Nov 11, 2020
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271K
Nov 11, 2020
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIP5628C
Oct 8, 2020
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
18NA099
Aug 5, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PIT5099E
Jul 27, 2020
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
PIP5226D
Jul 27, 2020
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is
PIP5226D
Jul 27, 2020
060000 ENGINE (PWS)
This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is
PIC5453D
Jul 22, 2020
355100 EQUIPMENT:OTHER:LABELS
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
PIC5453D
Jul 22, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
PIC5453C
Jun 5, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
PIP5628B
May 21, 2020
060000 ENGINE (PWS)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
070849020Q
May 20, 2020
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
PIT3116B
May 13, 2020
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
This Preliminary information communicates information to Clean the throttle body if the engine stalls at idle when the A/C comes on.
PIP5725
May 8, 2020
070000 FUEL SYSTEM, GASOLINE
This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in
19NA219
Feb 28, 2020
350000 EQUIPMENT
This diagnostic tip provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
19NA219
Feb 28, 2020
060000 ENGINE (PWS)
This diagnostic tip provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
PIT3099T
Feb 4, 2020
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician
PIP4723D
Jan 31, 2020
110000 ELECTRICAL SYSTEM
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and
PIP5540F
Jan 14, 2020
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
16NA383
Jan 2, 2020
073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
16NA383
Jan 2, 2020
350000 EQUIPMENT
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
Showing 100 of 793 bulletins.
NHTSA Safety Investigations, CHEVROLET TRAILBLAZER
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE12003
Opened: Feb 9, 2012 , Closed: Jun 11, 2012
Driver's Master Power Window Switch
The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 w... Read more
PE07013
Opened: Mar 12, 2007 , Closed: Jul 10, 2007
FUEL PUMP MODULE LEAKS GASOLINE
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ... Read more
PE04032
Opened: Apr 6, 2004 , Closed: Aug 3, 2004
BRAKE LAMP FAILURE
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON MODEL YEAR (MY) 2002-04 CHEVROLET TRAILBLAZER VEHICLES.GM REPORTS THAT OTHER VEHICLES SHARING THIS PLATFORM AND BRAKE LAMP DESIGN ARE THE MY 2002-2004 CHEVROLET TRAILBLAZER EXT; GMC ENVOY, XL, XUV; OLDSMOBILE BRAVADA AND 2004 BUI... Read more
EA04002
Opened: Jan 6, 2004 , Closed: Feb 10, 2004
WINDSHIELD WIPER FAILURE
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE ... Read more
PE04001
Opened: Jan 5, 2004 , Closed: May 7, 2004
FUEL SPILLAGE DURING REFUELING
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDE... Read more
PE03042
Opened: Sep 17, 2003 , Closed: Jan 6, 2004
WINDSHIELD WIPER FAILURE
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH ... Read more
PE02093
Opened: Dec 17, 2002 , Closed: Apr 9, 2003
2002 TRAILBLAZER/ENVOY FUEL TANK LEAKS
SEE ATTACHED REPORT.
PE02036
Opened: Mar 18, 2002 , Closed: Oct 3, 2002
PINCHER/CHAFED WIRING
CHEVROLET TRAILBLAZER - All Years Overview
Complete safety history for the CHEVROLET TRAILBLAZER across all model years (2002, 2022).
43
Total Recalls
9,364
Total Complaints
8
Investigations
525
Reported Crashes
342
Reported Fires
44
Reported Deaths
CHEVROLET TRAILBLAZER - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2026 | 0 | 11 | View |
| 2025 | 0 | 36 | View |
| 2024 | 0 | 50 | View |
| 2023 | 0 | 91 | View |
| 2022 | 1 | 173 | View |
| 2021 | 4 | 280 | View |
| 2014 | 0 | 2 | View |
| 2009 | 0 | 37 | View |
| 2008 | 0 | 263 | View |
| 2007 | 5 | 965 | View |
| 2006 | 8 | 1,441 | View |
| 2005 | 2 | 1,905 | View |
| 2004 | 2 | 1,302 | View |
| 2003 (current) | 8 | 1,160 | |
| 2002 | 13 | 1,573 | View |
| 2001 | 0 | 29 | View |
| 2000 | 0 | 32 | View |
| 1999 | 0 | 7 | View |