2002 CHEVROLET PRIZM

1 recalls, 20 complaints - 357 TSBs

SUSPENSION

Defect Description

RIDE CONTROL IS RECALLING CERTAIN FRONT STRUT MOUNTS BRANDED AS GABRIEL RIDE CONTROL OR ARVINMERITOR, P/NOS. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE ... Read more

Consequence

THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.

Remedy

RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.

12,657 vehicles affected

Manufacturer: RIDE CONTROL, LLC

Complaint Statistics

20 total complaints 2 crashes

Top Reported Components

Component	Complaints
STEERING	2
ENGINE AND ENGINE COOLING	2
LATCHES/LOCKS/LINKAGES	2
EXTERIOR LIGHTING:HEADLIGHTS	1
ELECTRICAL SYSTEM:IGNITION	1
ELECTRICAL SYSTEM:IGNITION:SWITCH	1
AIR BAGS:FRONTAL	1
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE	1
ENGINE AND ENGINE COOLING:ENGINE	1
LATCHES/LOCKS/LINKAGES:HOOD:LATCH	1

Incident date: May 8, 2008

ENGINE ABSORBS OIL. AFTER PURCHASING; ENGINE SEIZED. PURCHASED 2ND ENGINE AT BEECHMONT CHEVROLET...SAME FLAW. ENGINE SEIZED AT FIVE MILE ROAD EXIT OFF OF I-275. TO THIS DAY IF I DO NOT CHECK OIL ON REGULAR BASIS. I POSE A RISK OF ENGINE SEIZING AGAIN.

Incident date: Jan 1, 2010

MY 2002 CHEVROLET PRIZM (SAME AS A TOYOTA COROLLA) HAS ITS CRUSE CONTROL, HORN, AND THE DRIVERS SIDE AIRBAG ALL MOUNTED ON THE STEERING WHEEL, ELECTRICALLY CONNECTED TO THE REST OF THE CAR THROUGH AN INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AKA CLOCK SPRING) MECHANISM. BOTH THE CRUSE CON... Read more

Incident date: Jun 27, 2014

TL* THE CONTACT OWNS A 2002 CHEVROLET PRIZM. WHILE DRIVING AT 30 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT STRUTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT I... Read more

Incident date: Jan 1, 1901

2002 CHEVROLET PRIZM. CONSUMER STATES PROBLEM WITH STEERING WHEEL LOCKING UP *TGW

Incident date: Jul 31, 2009

PURCHASED CAR JULY '09 WITH 64,000 ON ENGINE. VEHICLE PURCHASED WITH 90 DAY WARRANTY. 2700 MILES AFTER PURCHASE, ENGINE EMITTED BLUE SMOKE AFTER HIGHWAY DRIVING. VEHICLE TAKEN TO REPAIR SHOP, PISTONS HOLD NO COMPRESSION, ONE VALVE SHOT, REPAIR SHOP AND WARRANTY COMPANY STATE VEHICLE NOT DRIVABLE, NE... Read more

Incident date: Nov 2, 2009

DEAR MADAM/SIR, IN TODAY'S (12/08/09) WALL STREET JOURNAL, IN THE ARTICLE ABOUT TOYOTA RECALLS, IT WAS MENTIONED THAT 2003 AND 2004 COROLLAS AND MATRIXES WERE RECALLED TO FIX A FLAW THAT COULD CAUSE THE POWER WINDOWS TO STOP WORKING. I OWN A 2002 PRIZM, WHICH I BELIEVE IS A COROLLA WITH A PRIZM B... Read more

Incident date: Sep 18, 2009

Incident date: Jan 1, 2006

CHECK ENGINE LIGHT HAS COME ON PERMANENTLY. THIS CAN BE TEMPORARILY TURNED OFF BY MECHANICS BUT ALWAYS COMES BACK ON AGAIN. SINCE THERE IS NO PROBLEM WITH THE ENGINE, THIS WARNING LIGHT IS USELESS IF I HAVE A REAL PROBLEM. *TR

Incident date: Dec 1, 2007

HOOD LATCH COMPLETELY BROKE SO THAT EITHER IT COULD NOT BE CLOSED COMPLETELY, OR, WHEN FINALLY CLOSED, IT WAS IMPOSSIBLE TO OPEN. THIS, COUPLED WITH OTHER HOOD LATCH PROBLEMS REPORTED BY OTHERS SEEMS TO INDICATE A DEFINITE HOOD LATCH PROBLEM. *TR

Incident date: Feb 6, 2009

HOOD LATCH/SAFETY LATCH FAILED AND HOOD OPENED UP AND CRASHED AGAINST WINDSHIELD AT APPROXIMATELY 55 MPH. DAMAGED HOOD, HINGES, COWLING, AND CRACKED WINDSHIELD. *TR

Incident date: Nov 10, 2008

I INSTALLED FOUR KUMHO 795 TIRES (P185/65R14) ON 10/03/2006 ON MY 2002 CHEVROLET PRISM LSI. IN NOVEMBER 2008, WITHOUT ANY WARNING, ONE TIRE (FRONT PASSENGER SIDE) RUPTURED ON THE INSIDE SIDE WALL. I WAS LUCKY NOT DRIVING ON THE HIGHWAY. THE CAR ALMOST LOST CONTROL. I WENT TO THE DEALER (EXECUT... Read more

Incident date: Aug 25, 2008

HOOD LATCH AND SAFETY CATCH FAILED; HOOD FLEW OPEN ON EXPRESSWAY @ 50-55 MPH CAUSING DAMAGE TO HOOD, HINGES, COWLING, FENDERS AND WINDSHIELD. *TR

Incident date: Jun 19, 2008

TL*THE CONTACT OWNS A 2002 CHEVROLET PRIZM. WHILE DRIVING APPROXIMATELY 55 MPH, THE HOOD AUTOMATICALLY DETACHED FROM THE LATCH. THE HOOD SLAMMED AGAINST THE WINDSHIELD, WHICH SHATTERED THE INSIDE AND OUTSIDE GLASS. THERE WAS NO WARNING PRIOR TO THE FAILURE. THE CONTACT OBSERVED THAT THE WINDSHIE... Read more

Incident date: Aug 1, 2007

TL*THE CONTACT OWNS A 2002 CHEVROLET PRIZM. TWO YEARS AGO, THE EMISSIONS CONTROL BOX FAILED AT 41,000 MILES AND CAUSED THE CHECK ENGINE LIGHT TO ILLUMINATE. AT 72,000 MILES, THE ENGINE HAS A PISTON KNOCK. TWO DIFFERENT MECHANICS STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE ENGINE KNOCKING H... Read more

Incident date: Jan 14, 2007

THE TIE DOWN STRAP ON THE MUFFLER RUSTED OUT AT 45,000 MILES. THE MUFFLER IS STAINLESS STEEL AND SHOULD LAST 100,000 MILES. *NM

Incident date: Jan 23, 2005

TILT STEERING DID NOT LOCK DURING A TIGHT RIGHT TURN.*AK

Crash

Incident date: Sep 16, 2004

WHILE DRIVING AT 45 MPH CONSUMER'S VEHICLE WAS INVOLVED IN A FRONT END COLLISION. UPON IMPACT, AIR BAGS DID NOT DEPLOY. AS RESULT, MAJOR DAMAGE OCCURRED. NO WARNING LIGHT APPEARED PRIOR TO THE CRASH. MANUFACTURER WAS NOTIFIED. *AK *TC

Crash

Incident date: Jun 18, 2002

VEHICLE STALLED AT 35 MPH. DEALER DETERMINED THAT IGNITION COIL HAD BURNED OUT. 2 CYLINDERS HAD TO BE REPLACED AS WELL.*AK

Incident date: Jun 18, 2002

VEHICLE STALLED AT 35 MPH. DEALER DETERMINED THAT IGNITION COIL HAD BURNED OUT. 2 CYLINDERS HAD TO BE REPLACED AS WELL.*AK

Incident date: May 12, 2002

HEADLIGHTS STAY ON ALLDAY AND ARE VERY BRIGHT. WHICH BLINDS OTHER DRIVERS.*AK

EPA Fuel Economy, 2002 CHEVROLET PRIZM

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.8L 4-cyl, Automatic 3-spd (Front-Wheel Drive)	25.0	30.0	27.0	Regular	$2,300
1.8L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	26.0	36.0	30.0	Regular	$2,050
1.8L 4-cyl, Manual 5-spd (Front-Wheel Drive)	27.0	37.0	31.0	Regular	$2,000

CO2 Emissions: -1.0 g/mile (Compact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2002 CHEVROLET PRIZM

357 manufacturer communications from 237 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	57
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	38
110000 ELECTRICAL SYSTEM	32
060000 ENGINE AND ENGINE COOLING	27
356000 EQUIPMENT ADAPTIVE/MOBILITY	23
353000 EQUIPMENT:ELECTRICAL	21
060000 ENGINE (PWS)	19
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)	14

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

100000 POWER TRAIN

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

This service bulletin provides information on Module Harvesting.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

980000 UNKNOWN OR OTHER

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

100000 POWER TRAIN

This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

160000 STRUCTURE

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician

356000 EQUIPMENT ADAPTIVE/MOBILITY

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

110000 ELECTRICAL SYSTEM

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

350000 EQUIPMENT

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

350000 EQUIPMENT

160000 STRUCTURE

200000 WHEELS

350000 EQUIPMENT

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR

350000 EQUIPMENT

This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

350000 EQUIPMENT

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

355100 EQUIPMENT:OTHER:LABELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

070000 FUEL SYSTEM, GASOLINE

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE (PWS)

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels

350000 EQUIPMENT

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information on key code security rules and information on GM keycode look-up applications.

350000 EQUIPMENT

This informational bulletin provides information on key code security rules and information on GM keycode look-up applications.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

120000 LIGHTING (PWS)

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information for dealers how to submit a product information report (PIR) (Canada Only).

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information on key code security and information on GM key code look up applications.

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.

060000 ENGINE (PWS)

350000 EQUIPMENT

Showing 100 of 357 bulletins.

NHTSA Safety Investigations, CHEVROLET PRIZM

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 1990

HOOD FLY UP

There is no summary currently available

CHEVROLET PRIZM - All Years Overview

Complete safety history for the CHEVROLET PRIZM across all model years (1998, 2002).

5 Total Recalls

195 Total Complaints

1 Investigations

36 Reported Crashes

11 Reported Fires

0 Reported Deaths

CHEVROLET PRIZM - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2002 (current)	1	20
2001	1	59	View
2000	1	32	View
1999	1	47	View
1998	1	33	View
1996	0	1	View
1991	0	2	View
1990	0	1	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2002 CHEVROLET PRIZM

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2002 CHEVROLET PRIZM

Technical Service Bulletins, 2002 CHEVROLET PRIZM

Most Affected Components

NHTSA Safety Investigations, CHEVROLET PRIZM

CHEVROLET PRIZM - All Years Overview

CHEVROLET PRIZM - Year by Year

Other CHEVROLET Models