2000 CHEVROLET PRIZM
1 recalls, 32 complaints - 294 TSBs
10E002000 Feb 11, 2010
SUSPENSION
Defect Description
RIDE CONTROL IS RECALLING CERTAIN FRONT STRUT MOUNTS BRANDED AS GABRIEL RIDE CONTROL OR ARVINMERITOR, P/NOS. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE ... Read more
Consequence
THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.
Remedy
RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.
Complaint Statistics
32 total complaints
6 crashes 3 fires 5 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| ENGINE | 2 |
| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | 2 |
| AIR BAGS | 2 |
| ENGINE AND ENGINE COOLING | 2 |
| TIRES | 2 |
| SEATS:FRONT ASSEMBLY:RECLINER | 2 |
| SEAT BELTS:FRONT:WARNING LIGHT/DEVICES | 2 |
| ENGINE AND ENGINE COOLING:ENGINE | 2 |
| LATCHES/LOCKS/LINKAGES:HOOD:LATCH | 2 |
| POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH | 1 |
ENGINE
Jan 13, 2015
Incident date: Jan 12, 2015
TL* THE CONTACT OWNED A 2000 CHEVROLET PRIZM. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE FRONT OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND; HOWEVER, THE CONTACT WAS ABLE TO PREVENT A CRASH. THE VEHICLE CA... Read more
Fire
SERVICE BRAKES
Jan 13, 2015
Incident date: Jan 12, 2015
TL* THE CONTACT OWNED A 2000 CHEVROLET PRIZM. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE FRONT OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND; HOWEVER, THE CONTACT WAS ABLE TO PREVENT A CRASH. THE VEHICLE CA... Read more
Fire
AIR BAGS
Apr 16, 2014
Incident date: Apr 1, 2008
TL* THE CONTACT OWNS A 2000 CHEVROLET PRISM. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE AIR BAG AND AIR BAG SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS N... Read more
ENGINE
Jul 27, 2012
Incident date: May 3, 2010
THE PISTON SKIRTS ON THE 2000 MODEL WERE TOO SHORT (THEY WERE REPLACED WITH APPROPRIATE SKIRTS IN A LATER YEAR MODEL). THE VERY SHORT SKIRT ALLOWS THE PISTON TO TILT IN THE CYLINDER MUCH SOONER THAN WOULD HAPPEN IN NORMAL ENGINES. THIS CAUSES THE RINGS TO FAIL TO SEAT PROPERLY MUCH EARLIER THAN WOU... Read more
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Feb 8, 2011
Incident date: Feb 8, 2011
TL* THE CONTACT OWNS A 2000 CHEVROLET PRISM. THE CONTACT STATED THAT WHEN THE DRIVERS DOOR WOULD LOCK, THE DRIVER WAS UNABLE TO EXIT THE VEHICLE FROM INSIDE. IN ORDER TO EXIT THE VEHICLE, HE WOULD HAVE TO OPEN THE WINDOW TO ENGAGE THE EXTERIOR DOOR LATCH. THE VEHICLE WAS NOT INSPECTED BY A DEALER NO... Read more
ENGINE AND ENGINE COOLING:ENGINE
Jan 15, 2011
Incident date: Mar 1, 2008
CHEVROLET PRIZM...COROLLA IN DISGUISE. CAR DRINKS OIL BAD. HAVE OWNED A 2000 MODEL BOUGHT IN 2008 WITH 44,000 MILES CAR LOOKED AND DROVE LIKE NEW SO I THOUGHT CAR IS MADE BY TOYOTA NO NEED TO CHECK UNDER THE HOOD. WRONG!!! GOT HOME WITH THE CAR AND MY DAD WANTED TO DRIVE IT,HE'S A MECHANIC.GETS BACK... Read more
ENGINE AND ENGINE COOLING
Oct 12, 2007
Incident date: Oct 1, 2004
TL*THE CONTACT OWNS A 2000 CHEVROLET PRIZM. THE VEHICLE BEGAN BURNING A QUART OF OIL PER MONTH AND CURRENTLY USES THREE QUARTS OF OIL PER WEEK. WHEN DIAGNOSTIC TESTS WERE INITIALLY PERFORMED, THE RESULTS INDICATED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE LINES WERE TESTED AND THE RESULT... Read more
TIRES
Jul 21, 2006
Incident date: May 29, 2006
2000 PRIZM LEFT FRONT TIRE BLEW OUT. *TS THE BLOWOUT CAUSED DAMAGE TO THE LEFT FRONT OF THE VEHICLE. *NM UPDATED 07/20/06 *JB
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Aug 16, 2005
Incident date: Dec 2, 2004
DT: THE CONTACT STATED THE DRIVER'S SIDE FRONT SEAT BELT WILL NOT LATCH. THE SERVICE DEALER REFERRED THE CONTACT TO CHEVROLET CONSUMER HOTLINE; THEY INFORMED HIM THAT THE VEHICLE NEEDED TO HAVE A DIAGNOSTIC TEST RAN BEFORE THE SERVICE MANAGER WOULD BE AUTHORIZED TO PERFORM THE WORK ON THE VEHICL... Read more
STRUCTURE:BODY:DOOR
Jul 26, 2005
Incident date: Jun 1, 2001
AT 15K MILES, MY REAR PASSENGER WINDOW MOTOR QUIT WORKING. AT 35K MILES, MY DRIVER INDOOR "PLASTIC" DOOR HANDLE COMPLETELY BROKE OFF WITH NO WARNING WHATSOEVER. AT 75K MILES, MY DRIVER WINDOW MOTOR QUIT WORKING (I NOW HAVE NO WAY OF OPENING MY DOOR FROM THE INSIDE). AND AT 85K, MY PASSENGER FRONT DO... Read more
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
Jul 26, 2005
Incident date: Jun 1, 2001
AT 15K MILES, MY REAR PASSENGER WINDOW MOTOR QUIT WORKING. AT 35K MILES, MY DRIVER INDOOR "PLASTIC" DOOR HANDLE COMPLETELY BROKE OFF WITH NO WARNING WHATSOEVER. AT 75K MILES, MY DRIVER WINDOW MOTOR QUIT WORKING (I NOW HAVE NO WAY OF OPENING MY DOOR FROM THE INSIDE). AND AT 85K, MY PASSENGER FRONT DO... Read more
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
Jul 26, 2005
Incident date: Jun 1, 2001
AT 15K MILES, MY REAR PASSENGER WINDOW MOTOR QUIT WORKING. AT 35K MILES, MY DRIVER INDOOR "PLASTIC" DOOR HANDLE COMPLETELY BROKE OFF WITH NO WARNING WHATSOEVER. AT 75K MILES, MY DRIVER WINDOW MOTOR QUIT WORKING (I NOW HAVE NO WAY OF OPENING MY DOOR FROM THE INSIDE). AND AT 85K, MY PASSENGER FRONT DO... Read more
EQUIPMENT
Jul 26, 2005
Incident date: Jun 1, 2001
AT 15K MILES, MY REAR PASSENGER WINDOW MOTOR QUIT WORKING. AT 35K MILES, MY DRIVER INDOOR "PLASTIC" DOOR HANDLE COMPLETELY BROKE OFF WITH NO WARNING WHATSOEVER. AT 75K MILES, MY DRIVER WINDOW MOTOR QUIT WORKING (I NOW HAVE NO WAY OF OPENING MY DOOR FROM THE INSIDE). AND AT 85K, MY PASSENGER FRONT DO... Read more
POWER TRAIN:AUTOMATIC TRANSMISSION
May 19, 2005
Incident date: Dec 8, 2004
SPRING 2004, OIL CHANGE MECHANIC NOTICED EXCESSIVE SLUDGE (APPX 65000 MILES ON CAR). CLEANED ENGINE OUT, CHANGED OIL (CAR HAS HAD REGULAR OIL CHANGES EVERY 3-4K MILES). AFTER THAT CAR WAS NOTED TO BE USING TOO MUCH OIL (TOPPING OFF AT EACH 1500 MILES THEY HAD TO ADD 2 AND A HALF QUARTS). TOOK TO ... Read more
ENGINE AND ENGINE COOLING
May 19, 2005
Incident date: Dec 8, 2004
SPRING 2004, OIL CHANGE MECHANIC NOTICED EXCESSIVE SLUDGE (APPX 65000 MILES ON CAR). CLEANED ENGINE OUT, CHANGED OIL (CAR HAS HAD REGULAR OIL CHANGES EVERY 3-4K MILES). AFTER THAT CAR WAS NOTED TO BE USING TOO MUCH OIL (TOPPING OFF AT EACH 1500 MILES THEY HAD TO ADD 2 AND A HALF QUARTS). TOOK TO ... Read more
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Feb 2, 2005
Incident date: Aug 29, 2003
I WAS DRIVING OF A HIGHWAY AND MY SPEED WAS ABOUT 60 MPH ALL OF A SUDDEN THE HOOD OPENED AND HIT MY WINDSHIELD. THIS COULD HAVE RESULTED IN A HUGE ACCIDENT WITH OTHER CARS AS I COULD NOT SEE ANYTHING. LUCKLY I DID NOT LOOSE CONTROL OF MY CAR AND I PULLED IT ONTO THE RIGHT SHOULDER. LATCH WAS WOR... Read more
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
Aug 5, 2004
Incident date: Jan 10, 2001
AFTER OWNING THE CAR FOR JUST A FEW MONTHS, BOUGHT NEW, I NOTICED THAT THE SEAT BELT WARNING LIGHT WOULD COME ON/OFF AS IT PLEASED. SOMETIMES WITH BEING BELTED IN, IT WOULD SHOW UP, AND OTHERTIMES IT WOULD BE OFF. THE REPAIR ESTIMATE FOR THIS JOB AT THE DEALERSHIP WAS OVER $300.00, SAYING THEY WOUL... Read more
ENGINE AND ENGINE COOLING:ENGINE
Jul 13, 2004
Incident date: Jun 10, 2004
HAVE DAMAGED LIFTERS IN 2000 CHEVY PRIZM ENGINE MADE BY TOYOTA, DUE TO A MFG. DEFECT, ACCORDING TO MY CHEVY DEALERSHIP REPAIMAN. HE SAYS UPPER ENGINE DRAIN HOLES FOR OIL WERE DRILLED SMALLER THAN AMERICAN MADE MOTORS WHICH WILL GUM UP AND RESTRICT FLOW OF OIL, CAUSING DAMAGE TO HYDRAULIC LIFTERS. ... Read more
ELECTRICAL SYSTEM:WIRING
Jun 23, 2004
Incident date: Jun 23, 2004
AFTER PARKING VEHICLE FOR ONLY FIVE MINUTES CONSUMER RETURNED TO VEHICLE AND NOTICED VEHICLE WAS ON FIRE. DEALER AND MANUFACTURER WERE CONTACTED. *AK
Fire
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Feb 11, 2004
Incident date: Feb 10, 2004
SAFETY LATCH ON HOOD MALFUNCTIONED SO HOOD NOT SECURE. HOOD FLEW OPEN WHILE CAR TRAVELING AT APPROX 50MPH. LATCH IS SPRING LOADED BUT SPRING DID NOT WORK. LATCH DOES NOT APPEAR TO BE CORRODED. WINDSHIELD CRACKED. HOOD DAMAGED TOATL COST $1700. *AK
SEATS:FRONT ASSEMBLY:RECLINER
Feb 6, 2004
Incident date: Sep 1, 2002
I WAS INVOLVED IN AN AUTO ACCIDENT ON 9/1/2002 IN WHICH MY SEAT BACK FAILED. I WAS TRAVELING AT APPROXIMATELY 65 MPH IN MY 2000 CHEVROLET PRIZM LSI. I WAS REAR ENDED BY A HONDA CIVIC TRAVELING AT APPROXIMATELY 100 MPH. THE FORCE OF THE IMPACT WAS SUCH THAT WHEN I WAS THROWN TO THE BACK OF THE SEA... Read more
Crash
1 injured
SEATS
Feb 6, 2004
Incident date: Sep 1, 2002
I WAS INVOLVED IN AN AUTO ACCIDENT ON 9/1/2002 IN WHICH MY SEAT BACK FAILED. I WAS TRAVELING AT APPROXIMATELY 65 MPH IN MY 2000 CHEVROLET PRIZM LSI. I WAS REAR ENDED BY A HONDA CIVIC TRAVELING AT APPROXIMATELY 100 MPH. THE FORCE OF THE IMPACT WAS SUCH THAT WHEN I WAS THROWN TO THE BACK OF THE SEA... Read more
Crash
1 injured
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
Feb 6, 2004
Incident date: Sep 1, 2002
I WAS INVOLVED IN AN AUTO ACCIDENT ON 9/1/2002 IN WHICH MY SEAT BACK FAILED. I WAS TRAVELING AT APPROXIMATELY 65 MPH IN MY 2000 CHEVROLET PRIZM LSI. I WAS REAR ENDED BY A HONDA CIVIC TRAVELING AT APPROXIMATELY 100 MPH. THE FORCE OF THE IMPACT WAS SUCH THAT WHEN I WAS THROWN TO THE BACK OF THE SEA... Read more
Crash
1 injured
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
Feb 10, 2003
Incident date: Aug 10, 2003
THE DEFROSTER WAS INOPERATIVE, WHICH CAUSED POOR VISIBILITY WHILE DRIVING.*JB
SEATS:FRONT ASSEMBLY:RECLINER
Sep 20, 2002
Incident date: Sep 1, 2002
THE DRIVER (MYSELF) WAS REAR ENDED BY A HONDA CIVIC TRAVELING AT APPROXIMATELY 100 MPH. UPON IMPACT THE BACK OF THE DRIVER'S SEAT FAILED AND PROCEEDED TO CHANGE FROM 90 DEGREES IN SHAPE TO 150 DEGREES IN SHAPE. I THEREBY LOST SIGHT OF THE ROAD AND ONLY HAD THE STEERING WHEEL TO HOLD ON TO. WHEN I... Read more
Crash
1 injured
TIRES
Aug 13, 2002
ONE OF THE ORIGINAL FIRESTONE TIRES BLEW WHILE THE CONSUMER WAS TRAVELING. THE CONSUMER REPLACED ALL FOUR TIRES SINCE ALL WERE IN BAD SHAPE. *YH
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
Jun 5, 2002
Incident date: Feb 13, 2002
AT 50MPH, BRAKES ENGAGE AND CONSUMER WAS UNABLE TO ACCELERATE. CAUSE UNKNOWN. DEALER NOTIFIED.*AK. WHILE ATTEMPTING TO APPPLY THE BRAKES, THEY WENT TO THE FLOOR AND CONSUMERS DAUGHTER REAR ENDED ANOTHER VEHICLE, CONSUMER ATTEMPTED TO APPLY THE BRAKES AGAIN, BUT THE BRAKES LOCKED UP AND THEN RELEASED... Read more
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
Jun 5, 2002
Incident date: Feb 13, 2002
AT 50MPH, BRAKES ENGAGE AND CONSUMER WAS UNABLE TO ACCELERATE. CAUSE UNKNOWN. DEALER NOTIFIED.*AK. WHILE ATTEMPTING TO APPPLY THE BRAKES, THEY WENT TO THE FLOOR AND CONSUMERS DAUGHTER REAR ENDED ANOTHER VEHICLE, CONSUMER ATTEMPTED TO APPLY THE BRAKES AGAIN, BUT THE BRAKES LOCKED UP AND THEN RELEASED... Read more
AIR BAGS
May 21, 2002
Incident date: Mar 12, 2001
THE AIR BAG FAILED TO DEPLOY DURING AN ACCIDENT IN WHICH THE VEHICLE SUSTAINED CONSIDERABLE FRONT END DAMAGE, THE DRIVER SUSTAINED CERVICAL (NECK) STRAIN. *YH
Crash
1 injured
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
Mar 26, 2001
Incident date: Nov 1, 2000
CONSUMER REPORTS BRAKE PROBLEMS. TOOK VEHICLE TO DEALER 5 TIMES, BRAKES STILL NOT WORKING PROPERLY. WHEN APPLYING BRAKES IT SOUNDS LIKE A SPRING IS BEING RELEASED, AND BRAKING DISTANCE IS TOO LONG. *AK ABS ENGAGES WHEN IT SHOULD NOT. THE DEALER COULD NOT DUPLICATE THE PROBLEM. *YH
VEHICLE SPEED CONTROL
Apr 27, 2000
Incident date: Apr 14, 2000
THE VEHICLE SPUN OUT OF CONTROL AND HEADED TOWARDS LEFT SIDE WHILE PERFORMING A ROUTINE LANE CHANGE. THERE WERE NO ADVERSE WEATHER CONDITIONS, NO UNUSUAL TRAFFIC PATTERNS, AND I WAS NOT GOING ABOVE THE SPEED LIMIT. I WAS IN THE FAR RIGHT LANE ON A FOUR LANE HIGHWAY, WHEN THE VEHICLE STARTED VEERIN... Read more
Crash
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
Feb 28, 2000
TRANSMISSION MALFUNCTIONED, GEAR SHIFTED INTO NEUTRAL WHILE DRIVING. YH
EPA Fuel Economy, 2000 CHEVROLET PRIZM
| Trim / Engine | City MPG | Highway MPG | Combined MPG | Fuel Type | Annual Fuel Cost |
|---|---|---|---|---|---|
| 1.8L 4-cyl, Automatic 3-spd (Front-Wheel Drive) | 24.0 | 29.0 | 26.0 | Regular | $2,350 |
| 1.8L 4-cyl, Automatic 4-spd (Front-Wheel Drive) | 25.0 | 34.0 | 28.0 | Regular | $2,200 |
| 1.8L 4-cyl, Manual 5-spd (Front-Wheel Drive) | 27.0 | 34.0 | 30.0 | Regular | $2,050 |
CO2 Emissions: -1.0 g/mile (Compact Cars)
Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.
Technical Service Bulletins, 2000 CHEVROLET PRIZM
294 manufacturer communications from 198 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 41 |
| 110000 ELECTRICAL SYSTEM | 26 |
| 060000 ENGINE AND ENGINE COOLING | 26 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 23 |
| 353000 EQUIPMENT:ELECTRICAL | 22 |
| 060000 ENGINE (PWS) | 19 |
| 118000 ELECTRICAL SYSTEM:SOFTWARE | 15 |
| 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) | 15 |
16-NA-383
Mar 13, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
22-NA-074
Feb 22, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
18-NA-099
Jan 16, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PI1394B
Jan 12, 2024
100000 POWER TRAIN
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PI1394B
Jan 12, 2024
060000 ENGINE AND ENGINE COOLING
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PIP5601B
Jan 12, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di
23-NA-219
Dec 12, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
23-NA-219
Dec 12, 2023
350000 EQUIPMENT
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
17-NA-170
Oct 6, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
PIT5099G
Sep 26, 2023
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
23-NA-153
Sep 1, 2023
100000 POWER TRAIN
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
23-NA-153
Sep 1, 2023
060000 ENGINE AND ENGINE COOLING
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
18-NA-073
Aug 24, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
PIP5628G
Aug 10, 2023
060000 ENGINE (PWS)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
PIP5358C
Jul 18, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
17-NA-170
Apr 27, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
PIP5628F
Apr 24, 2023
061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
22-NA-009
Mar 17, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
17-NA-073
Feb 21, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
01-08-42-001O
Feb 15, 2023
120000 EXTERIOR LIGHTING
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
PIP5628E
Feb 10, 2023
353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
PIP5540J
Dec 15, 2022
138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
21-NA-124
Dec 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
22-NA-074
Nov 9, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-205
Oct 19, 2022
110000 ELECTRICAL SYSTEM
This service bulletin provides information on Module Harvesting.
PIC5453D
Sep 30, 2022
980000 UNKNOWN OR OTHER
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
22-NA-195
Sep 28, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.
22-NA-009
Sep 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
22-NA-181
Sep 1, 2022
100000 POWER TRAIN
This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.
PIP5640A
Sep 1, 2022
100000 POWER TRAIN
This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an
20-NA-065
Aug 15, 2022
060000 ENGINE AND ENGINE COOLING
This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.
22-NA-009
Jun 15, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIT5099F
Jun 13, 2022
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
PIP5358B
May 31, 2022
160000 STRUCTURE
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
22-NA-074
Mar 31, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-009
Mar 22, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIP4723F
Jan 14, 2022
070000 FUEL SYSTEM, GASOLINE
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and
PIP4723F
Jan 14, 2022
030000 SERVICE BRAKES, HYDRAULIC
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and
22NA009
Jan 11, 2022
061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIP5628E
Dec 14, 2021
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
PIT3099U
Aug 11, 2021
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician
010842001N
Jun 21, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
010842001N
Jun 21, 2021
350000 EQUIPMENT
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
010842001N
Jun 21, 2021
120000 EXTERIOR LIGHTING
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
21NA124
May 25, 2021
071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
21NA124
May 25, 2021
110000 ELECTRICAL SYSTEM
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
PIP5358A
May 12, 2021
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
PIP5358A
May 12, 2021
160000 STRUCTURE
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
PIP5640A
Apr 12, 2021
200000 WHEELS
This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an
18NA099
Mar 30, 2021
350000 EQUIPMENT
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PIP5163E
Mar 30, 2021
070000 FUEL SYSTEM, GASOLINE
This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
PIP5540G
Mar 22, 2021
061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
PIP5725A
Mar 19, 2021
350000 EQUIPMENT
This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in
PIP5628C
Oct 8, 2020
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
18NA099
Aug 5, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PIP5226D
Jul 27, 2020
060000 ENGINE (PWS)
This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is
PIP5226D
Jul 27, 2020
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is
PIT5099E
Jul 27, 2020
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
PIC5453D
Jul 22, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
PIC5453D
Jul 22, 2020
355100 EQUIPMENT:OTHER:LABELS
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
PIC5453C
Jun 5, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
PIP5628B
May 21, 2020
060000 ENGINE (PWS)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
16NA383
May 8, 2020
060000 ENGINE (PWS)
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
16NA383
May 8, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
16NA383
May 8, 2020
073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
PIP5725
May 8, 2020
070000 FUEL SYSTEM, GASOLINE
This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in
PIT3099T
Feb 4, 2020
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician
PIP4723D
Jan 31, 2020
110000 ELECTRICAL SYSTEM
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and
PIP5540F
Jan 14, 2020
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
16NA383
Jan 2, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
16NA383
Jan 2, 2020
350000 EQUIPMENT
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
16NA383
Jan 2, 2020
073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
19NA273
Dec 2, 2019
350000 EQUIPMENT
This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.
19NA273
Dec 2, 2019
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.
PIC4696E
Nov 22, 2019
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce
PIC4696E
Nov 22, 2019
353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce
010842001M
Nov 12, 2019
120000 LIGHTING (PWS)
This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.
010842001M
Nov 12, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.
010842001M
Nov 12, 2019
350000 EQUIPMENT
This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.
PIP5540E
Oct 14, 2019
060000 ENGINE (PWS)
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
PIP5601A
Oct 10, 2019
110000 ELECTRICAL SYSTEM
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di
17NA073
Sep 18, 2019
350000 EQUIPMENT
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
150844001J
Sep 11, 2019
118000 ELECTRICAL SYSTEM:SOFTWARE
This informational bulletin provides information for the GM of Canada OnStar Cellular Communication Upgrade to 3G/4G LTE for vehicles that may need an upgrade.
PIT3099S
Sep 5, 2019
353000 EQUIPMENT:ELECTRICAL
This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician
PIC4696D
Sep 5, 2019
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce
PIT3099R
Jul 10, 2019
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician
16NA383
May 21, 2019
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.
PIP5640
May 7, 2019
060000 ENGINE (PWS)
This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an
PIP5226C
May 6, 2019
060000 ENGINE (PWS)
This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is
PIP5226C
May 6, 2019
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is
PIP5540D
Feb 19, 2019
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
PIP5628
Feb 18, 2019
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
17NA073
Feb 15, 2019
350000 EQUIPMENT
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
010842001L
Dec 13, 2018
120000 EXTERIOR LIGHTING
This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.
PIP5540B
Dec 6, 2018
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
PIP4925B
Dec 3, 2018
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
This preliminary information document communicates a tip on the way to diagnose possible induction or exhaust air leaks using the evaporative emission cart smoke machine and ultrasonic leak detector tools.
PIP5601
Oct 23, 2018
350000 EQUIPMENT
This Preliminary information communicates
PIT5099D
Oct 10, 2018
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
PIP5163D
Aug 8, 2018
060000 ENGINE (PWS)
This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
PIT5099C
Jun 20, 2018
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
Showing 100 of 294 bulletins.
NHTSA Safety Investigations, CHEVROLET PRIZM
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE95034
Opened: Jun 5, 1995 , Closed: Oct 26, 1995
HOOD FLY UP
There is no summary currently available
CHEVROLET PRIZM - All Years Overview
Complete safety history for the CHEVROLET PRIZM across all model years (1998, 2002).
5
Total Recalls
195
Total Complaints
1
Investigations
36
Reported Crashes
11
Reported Fires
0
Reported Deaths