2009 CHEVROLET EXPRESS 3500

EXTERIOR PAINT PEELS & FLAKES OFF IN SHEETS AS OF NOT ADHERING TO THE METAL. PEELS OFF BOTH WHILE DRIVING & WHEN PARKED. FLAKING OF PAINT IS CONTINUOUS.

TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED TO APPROXIMATELY 10 MPH. THE ENGINE WAS ON; HOWEVER, THE GEAR SHIFT WAS IN THE PARK POSITION WITH NO DRIVER. THE CONTACT MENTIONED THAT THE FRONT PASSENGER SEAT WAS OCCUPIED AT THE TIME OF THE FAILURE. THE VEHICLE CRASHED INTO A WALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. UPON STARTING THE VEHICLE, THE SERVICE AIR BAG INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ROLL OVER SENSOR BECAME INOPERABLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 59,747.

I TOOK THE VAN IN TO A DEALER TO FIND OUT WHY THE SERVICE AIR BAG LIGHT IS ON. AFTER PAYING $60.00 FOR A DIAGNOSTICS CHECK, (WHICH I STILL DON'T LIKE) THEY TOLD ME THE ROLLOVER SENSOR NEEDS TO BE REPLACED AT A CRIMINAL $700.00 WHICH I WILL NOT PAY. SOUNDS LIKE A GM ISSUE TO ME SO I CALLED THE HOT LINE AND A WEEK LATER THEY SAID THEY WOULD PAY $200.00 OUT OF THE $700.00 BECAUSE I WAS A GOOD GM BUYER. WRONG ANSWER. SO I FILLED OUT THE BBB COMPLAINT FORMS, WROTE AN ARTICLE ON CARCOMPLAINTS.COM, FILLING OUT THIS FORM, DROPPING OF THE PAPER WORK TO MY ATTORNEYS OFFICE TOMORROW, THEN HEADED TO THE FORD DEALERSHIP. UPDATED 10/01/15*LJ UPDATED 12/13/2017*CN

VEHICLE WAS SHAKING. TOOK TO [XXX] INC.IN SYRACUSE, NY FOR ALIGNMENT. WAS TOLD VEHICLE WAS IN ALIGNMENT. WAS TOLD THAT THE STEEL BELTS IN THE TIRES WERE BAD DUE TO TIRES BULGING ON THE OUTSIDE AND INDENTED IN THE CENTER OF THE TIRE. WOULD NOT RECOMMEND TIRE ROTATION. ALL 6 TIRES ARE EFFECTED. THE WORSE TIRE PASSENGER FRONT WAS USED IN THE DATA COLLECTED BY THIS SITE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE KEY FAILED TO TURN IN THE IGNITION IN ORDER TO START THE VEHICLE AND THE KEY COULD BE REMOVED FROM THE IGNITION WHILE THE VEHICLE WAS TURNED ON. THIS FAILURE OCCURRED INTERMITTENTLY FOR SEVERAL YEARS. THE VEHICLE WAS TAKEN TO A DEALER WHO STATED A NEW KEY WAS NEEDED TO REPAIR THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE KEY FAILED TO TURN IN THE IGNITION IN ORDER TO START THE VEHICLE AND THE KEY COULD BE REMOVED FROM THE IGNITION WHILE THE VEHICLE WAS TURNED ON. THIS FAILURE OCCURRED INTERMITTENTLY FOR SEVERAL YEARS. THE VEHICLE WAS TAKEN TO A DEALER WHO STATED A NEW KEY WAS NEEDED TO REPAIR THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

WHEN REFUELING THIS VEHICLE, THE GASOLINE DOES NOT FLOW WITH EASE THROUGH THE INTAKE TUBES. IT BACKS UP, OVERFLOWING THE FILLER PIPE, SPILLING OUT OR SHUTTING OFF THE GAS NOZZLE REPEATEDLY. IT CAN TAKE TEN MINUTES TO PUT TEN GALLONS OF GASOLINE IN THE TANK. THERE ARE MANY OTHER OWNERS HAVING THE SAME PROBLEM. IT HAS HAPPENED ALMOST EVERY TIME WE PUT GASOLINE IN THE TANK. NOT JUST ONE INCIDENT FOR SURE. THIS IS ON THE CHEVY EXPRESS 3500 WHICH HAS BEEN MADE INTO A 2009 ROADTREK MOTORHOME VERSATILE 210. *KB

WHEN REFUELING THIS VEHICLE, THE GASOLINE DOES NOT FLOW WITH EASE THROUGH THE INTAKE TUBES. IT BACKS UP, OVERFLOWING THE FILLER PIPE, SPILLING OUT OR SHUTTING OFF THE GAS NOZZLE REPEATEDLY. IT CAN TAKE TEN MINUTES TO PUT TEN GALLONS OF GASOLINE IN THE TANK. THERE ARE MANY OTHER OWNERS HAVING THE SAME PROBLEM. IT HAS HAPPENED ALMOST EVERY TIME WE PUT GASOLINE IN THE TANK. NOT JUST ONE INCIDENT FOR SURE. THIS IS ON THE CHEVY EXPRESS 3500 WHICH HAS BEEN MADE INTO A 2009 ROADTREK MOTORHOME VERSATILE 210. *KB

CHEVY EXPRESS 4500 DIESEL CUTAWAY. FUEL OIL HEATER (FOH) IS AN AUXILIARY HEATER LOCATED UNDER THE CAB OF THE VEHICLE AND EXHAUSTS IN THE SAME AREA. ODOR OF PARTIALLY BURNED FUEL AND A STRONG EXHAUST SMALL WOULD ENTER THE CAB OF THE VEHICLE DURING LOW SPEED OPERATION IN COLD WEATHER. DUE TO THE INTERMITTENT CHARACTER OF THE ODOR A HOME CO MONITOR WAS PLACED IN THE CAB OF THE VEHICLE WHICH DID ALARM, PROMPTING THE VEHICLE TO BE REMOVED FROM SERVICE AND SENT FOR REPAIR. THE FOH REQUIRED REPLACEMENT. *TR

I HAVE A 2009 CHEVROLET EXPRESS 3500 WITH 51,000 MILES ON IT. IN A TWO WEEK PERIOD AT THE END OF JAN '10 I HAD 3 TIRE VALVE STEM FAILURES. WHEN I ATTEMPTED TO REMOVE THE VALVE CAP TO CHECK AIR PRESSURE THE TOP OF THE STEM BLEW RIGHT OFF. I'VE REPLACED THREE AND THE ONE REMAINING FACTORY VALVE STEM IS ON THE DRIVERS SIDE FRONT TIRE. I'M IN FEAR OF MY LIFE DRIVING WITH THIS EQUIPMENT. WHAT HAPPENS IF IT FAILS WHILE I'M DRIVING 60 MPH DOWN THE HIGHWAY ?? *TR