2003 CHEVROLET EXPRESS 3500
0 recalls, 14 complaints - 109 TSBs
No recalls found for this vehicle.
Complaint Statistics
14 total complaints
1 crashes 4 fires 2 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| ELECTRICAL SYSTEM | 2 |
| SEAT BELTS | 2 |
| ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | 1 |
| VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM | 1 |
| VISIBILITY | 1 |
| STRUCTURE:BODY | 1 |
| SERVICE BRAKES, HYDRAULIC | 1 |
| AIR BAGS:FRONTAL | 1 |
| FUEL SYSTEM, GASOLINE | 1 |
| FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP | 1 |
SEAT BELTS
Feb 12, 2018
Incident date: Feb 12, 2018
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE SEAT BELT BUCKLES PREMATURELY DETERIORATED TO THE POINT THAT THE BUCKLES FAILED TO LOCK THE SEAT BELTS TO SECURE A PASSENGER. THE MANUFACTURER INDICATED THAT A SEAT BELT RECALL REPAIR WAS PERFORMED IN 2016, BUT THE CONTA... Read more
ELECTRICAL SYSTEM
Aug 6, 2014
Incident date: Jun 13, 2014
WHILE DRIVING VEHICLE, ALL ELECTRICAL STOPPED, DISCOVERED THAT THE IGNITION HAD TURNED OFF BY ITSELF AND CAUSED A LOSS OF ALL POWER CREATING DANGEROUS STEERING AND STOPPING SITUATION.. I WAS ABLE TO PULL TO THE SIDE OF ROAD AND STOPPED VEHICLE. TOOK THE TRUCK TO CHEVROLET DEALER IN SARASOTA RT. 41 A... Read more
ENGINE
Oct 25, 2012
Incident date: Aug 9, 2012
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE THE TRANSMISSION FAILED TO SHIFT INTO GEAR. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE CAUSE OF FAILURE WAS UNKNOWN. HOWEVER, THE TECHNICIAN STATED THAT THE MAF CENSOR NEEDED TO BE REP... Read more
FUEL/PROPULSION SYSTEM
Oct 24, 2012
Incident date: Jul 2, 2012
WHEN THE VEHICLE FUEL TANK IS FILLED, GAS FUMES ARE DETECTED AND SOME FUEL CAN BE SEEN ON THE BOTTOM OF THE TANK (A FEW DROPS OF FUEL). AS THE TANK CONTENTS LOWER THE SMELL AND LEAK GOES AWAY. AN ACCESS HOLE ON THE SIDE OF THE VAN REVEALS THAT THE TANK HAS A SMALL LEAK WHERE THE PLASTIC FILL NECK ... Read more
SEAT BELTS
Dec 14, 2011
Incident date: Dec 9, 2011
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE FRONT DRIVER AND REAR SEAT BELTS WOULD NOT LATCH AND ONE OF THE REAR SEAT BELTS WAS COMPLETELY INOPERABLE. THE DEALER AND MANUFACTURER WERE CONTACTED AND ADVISED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAM... Read more
FUEL SYSTEM, GASOLINE
Jul 19, 2011
Incident date: Jun 10, 2011
GAS LEAKING FROM FUEL FILLER PIPE ONTO INSIDE OF WHEEL WELL AND GROUND. EXAMINATION REVEALS DESIGN OF PIPE ASSEMBLY (METAL PIPE INSIDE CORRUGATED PLASTIC TUBE), TRAPS CONDENSATION AND WATER AROUND METAL PIPE GUARANTEEING RUST AND LEAKS. MAY BE WORSE IN HIGH HUMIDITY REGIONS BUT SAME ASSEMBLY IS OPEN... Read more
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
Jul 19, 2011
Incident date: Jun 10, 2011
GAS LEAKING FROM FUEL FILLER PIPE ONTO INSIDE OF WHEEL WELL AND GROUND. EXAMINATION REVEALS DESIGN OF PIPE ASSEMBLY (METAL PIPE INSIDE CORRUGATED PLASTIC TUBE), TRAPS CONDENSATION AND WATER AROUND METAL PIPE GUARANTEEING RUST AND LEAKS. MAY BE WORSE IN HIGH HUMIDITY REGIONS BUT SAME ASSEMBLY IS OPEN... Read more
ELECTRICAL SYSTEM
Jul 16, 2011
Incident date: Jun 26, 2011
WIRE HARNESS FIRE. WATER GOT INTO THE END OF ONE OF THE CONNECTORS FROM THE WIRE HARNESS GOING INTO THE TRASMISSION. THE RESULT OF THE WATER GETTING INTO THE TRANSMISSION CAUSED AN ELECTRICAL FIRE AND CAUSED A SHORT IN THE TRANSMISSION AND ENGINE WIRE HARNESS, THE FINAL RESULT WAS THE WIRE HARNESS W... Read more
Fire
AIR BAGS:FRONTAL
Feb 10, 2011
Incident date: Jan 28, 2011
I WAS IN AN ACCIDENT TRAVELING 65 MPH AND HIT ANOTHER VEHICLE BROADSIDE AND THE AIR BAG NEVER DEOLOYED. THE VEHICLE WAS TOTALED. ITS A 2003 3500 CHEVY VAN. *TR
Crash
2 injured
SERVICE BRAKES, HYDRAULIC
Jan 7, 2009
Incident date: Dec 1, 2008
TL*THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE VEHICLE MADE A GRINDING NOISE. HE INSPECTED THE VEHICLE AND DISCOVERED THAT THE FRONT AND REAR BRAKE PADS AND ROTORS WERE CORRODED. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THEY COULD COVER 50% OF ... Read more
STRUCTURE:BODY
May 23, 2008
Incident date: May 21, 2008
I PURCHASED MY 2003 CHEVY EXPRESS 3500 IN 2003. ON THE PASSENGER SIDE OF THE VAN THERE IS A FRONT PASSENGER DOOR AND ARE TWO PASSENGER DOORS ON THE SIDE OF THE VAN. IN FIVE YEARS TIME I HAVE HAD TROUBLE WITH THE SIDE PASSENGER DOOR HINGE SEIZING UP AND NOW I CAN'T OPEN THE LEFT SIDE DOOR AND IT IS I... Read more
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
Jan 8, 2008
Incident date: Jan 7, 2008
2003 CHEVY EXPRESS. TURNED ON THE REAR DEFROSTER. THE REAR PASSENGER SIDE WINDOW CAUGHT FIRE AND BEGAN BURNING. PULLED THE VEHICLE TO THE SIDE OF THE ROAD AND ANOTHER CAR PULLED OVER WITH ME. THE WINDOW CONTINUED TO BURN, AND THEN EXPLODED IN MY FACE. THE FIRE WENT OUT AND THE WINDOW HAD SHATTE... Read more
Fire
VISIBILITY
Jan 8, 2008
Incident date: Jan 7, 2008
2003 CHEVY EXPRESS. TURNED ON THE REAR DEFROSTER. THE REAR PASSENGER SIDE WINDOW CAUGHT FIRE AND BEGAN BURNING. PULLED THE VEHICLE TO THE SIDE OF THE ROAD AND ANOTHER CAR PULLED OVER WITH ME. THE WINDOW CONTINUED TO BURN, AND THEN EXPLODED IN MY FACE. THE FIRE WENT OUT AND THE WINDOW HAD SHATTE... Read more
Fire
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Sep 6, 2006
Incident date: Aug 29, 2006
FIRE TO VEHICLE . *JB
Fire
Technical Service Bulletins, 2003 CHEVROLET EXPRESS 3500
109 manufacturer communications from 65 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 060000 ENGINE AND ENGINE COOLING | 18 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 12 |
| 350000 EQUIPMENT | 11 |
| 110000 ELECTRICAL SYSTEM | 11 |
| 200000 WHEELS | 7 |
| 060000 ENGINE (PWS) | 6 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 5 |
| 353000 EQUIPMENT:ELECTRICAL | 5 |
10-08-45-001H
Mar 28, 2024
110000 ELECTRICAL SYSTEM
This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
16-NA-383
Mar 13, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
22-NA-074
Feb 22, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
18-NA-099
Jan 16, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
02-08-42-001J
Jan 12, 2024
120000 EXTERIOR LIGHTING
This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
PI1394B
Jan 12, 2024
060000 ENGINE AND ENGINE COOLING
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PI1394B
Jan 12, 2024
100000 POWER TRAIN
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
23-NA-219
Dec 12, 2023
350000 EQUIPMENT
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
23-NA-219
Dec 12, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
17-NA-170
Oct 6, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
10-00-89-006J
Sep 26, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
07-08-49-020R
Sep 21, 2023
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
350000 EQUIPMENT
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
23-NA-153
Sep 1, 2023
060000 ENGINE AND ENGINE COOLING
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
23-NA-153
Sep 1, 2023
100000 POWER TRAIN
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
18-NA-073
Aug 24, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
23-NA-144
Aug 18, 2023
030000 BRAKES (PWS)
This technical bulletin provides information and a solution to a condition of Brake Pedal Moves or Self Applies at Full Turns.
03-06-01-023G
Jul 31, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.
17-NA-170
Apr 27, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
19-NA-219
Apr 24, 2023
060000 ENGINE AND ENGINE COOLING
This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
19-NA-219
Mar 23, 2023
060000 ENGINE AND ENGINE COOLING
This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
22-NA-009
Mar 17, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
17-NA-073
Feb 21, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
23-NA-001
Feb 15, 2023
350000 EQUIPMENT
This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
01-08-42-001O
Feb 15, 2023
120000 EXTERIOR LIGHTING
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
23-NA-001
Jan 6, 2023
110000 ELECTRICAL SYSTEM
This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
23-NA-001
Jan 6, 2023
350000 EQUIPMENT
This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
09-00-89-008F
Dec 21, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
21-NA-124
Dec 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
PIT3271N
Nov 29, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271N
Nov 29, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
22-NA-074
Nov 9, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-205
Oct 19, 2022
110000 ELECTRICAL SYSTEM
This service bulletin provides information on Module Harvesting.
10-00-89-006I
Oct 7, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
22-NA-195
Sep 28, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.
06-00-89-031H
Sep 16, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.
06-00-89-031H
Sep 16, 2022
100000 POWER TRAIN
This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.
22-NA-009
Sep 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
22-NA-181
Sep 1, 2022
100000 POWER TRAIN
This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.
20-NA-065
Aug 15, 2022
060000 ENGINE AND ENGINE COOLING
This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.
22-NA-009
Jun 15, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
18-NA-099
May 16, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
12-00-89-003B
May 2, 2022
353000 EQUIPMENT:ELECTRICAL
This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
12-00-89-003B
May 2, 2022
060000 ENGINE (PWS)
This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
03-06-01-023E
Apr 27, 2022
060000 ENGINE AND ENGINE COOLING
This information bulletin explains how to measure for oil consumption and possible reasons for loss of oil.
18-NA-102
Apr 21, 2022
110000 ELECTRICAL SYSTEM
This technical bulletin provides a procedure to repair a possible wiring harness repair if damaged by the parking brake, brake booster mount or brake pedal bolt.
22-NA-074
Mar 31, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-009
Mar 22, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIT3271M
Mar 7, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271M
Mar 7, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271K
Nov 11, 2020
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271K
Nov 11, 2020
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
16NA383
Jan 2, 2020
073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
16NA383
Jan 2, 2020
350000 EQUIPMENT
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
16NA383
Jan 2, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
DOR-K2S2K-10
Jul 26, 2019
350000 EQUIPMENT
This SKU is a Pitman Arm. The customer communication requested return of unsold inventory to inspect for the spline size. If the spline size is incorrect it will not have a tight fit with the mating component, and would lead to detectabl
070849020M
Oct 1, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
IPC Odometer Programming Method Quick Reference Guide
070849020M
Oct 1, 2017
117110 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER:SENSOR/SENDING UNIT
IPC Odometer Programming Method Quick Reference Guide
150089004B
Oct 1, 2017
021300 SUSPENSION:FRONT:SHOCK ABSORBER
Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un
150089004B
Oct 1, 2017
021400 SUSPENSION:FRONT:MACPHERSON STRUT
Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un
150089004B
Oct 1, 2017
022400 SUSPENSION:REAR:SHOCK ABSORBER
Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un
PI1394A
Aug 29, 2016
060000 ENGINE (PWS)
THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE.
16NA260
Aug 26, 2016
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBR
000601012F
Aug 2, 2016
060000 ENGINE (PWS)
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES.
PIT5485B
Apr 27, 2016
110000 ELECTRICAL SYSTEM
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
PIT5485B
Apr 27, 2016
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
PIC5088F
Apr 21, 2016
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN. THE VEHICLE'S XM RADIO ONLY HAS XM PREVEIW CHANNELS.
PIC-5050-A
Apr 19, 2016
110000 ELECTRICAL SYSTEM
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CA
PIC-4935-E
Apr 19, 2016
110000 ELECTRICAL SYSTEM
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH
PIC-4935-E
Apr 19, 2016
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH
PIC4935E
Apr 19, 2016
110000 ELECTRICAL SYSTEM
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH
PIC5050A
Apr 19, 2016
353000 EQUIPMENT:ELECTRICAL
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CA
PIT5389A
Apr 19, 2016
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS.
PIT5485A
Apr 8, 2016
110000 ELECTRICAL SYSTEM
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
PIT5485A
Apr 8, 2016
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
06-00-89-031D
Dec 1, 2015
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
06-00-89-031D
Dec 1, 2015
060000 ENGINE (PWS)
OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
15-NA-079
Dec 1, 2015
110000 ELECTRICAL SYSTEM
OnStar? Voice Fallback Number Update Some customers may have received a letter from OnStar? stating that "We recently tried to provide a software update to the OnStar? hardware in your vehicle. However, your system could not be updated r
15-NA-079
Dec 1, 2015
350000 EQUIPMENT
OnStar? Voice Fallback Number Update Some customers may have received a letter from OnStar? stating that "We recently tried to provide a software update to the OnStar? hardware in your vehicle. However, your system could not be updated r
06-00-89-031D
Dec 1, 2015
100000 POWER TRAIN
OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
06-00-89-031D
Dec 1, 2015
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
06-00-89-031D
Dec 1, 2015
060000 ENGINE (PWS)
OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
15-NA-079
Dec 1, 2015
353000 EQUIPMENT:ELECTRICAL
OnStar Voice Fallback Number Update
15-NA-079
Dec 1, 2015
346000 COMMUNICATION:MANUFACTURER TELEMATICS
OnStar Voice Fallback Number Update
GCUS-3-289
Sep 18, 2015
060000 ENGINE (PWS)
14287 - Customer Satisfaction Program. On certain 2003-2015 model year Chevrolet Express, 2003-2007 Chevrolet Silverado, 2008-2013 Chevrolet Silverado HD, 2003-2015 GMC Savana, 2003-2007 GMC Sierra 3500, and 2007-2012 GMC Sierra HD model v
PIT3271G
Jan 15, 2015
350000 EQUIPMENT
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT CHANGING THE TIRE AND WHEEL SIZE ON VEHICLES. GENERAL MOTORS WILL ONLY SUPPORT A TIRE CALIBRATION FOR TIRES THAT HAVE BEEN SIZED, TESTED AND DESIGNED FO
PIT5264B
Nov 1, 2014
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.
PIT5353
Nov 1, 2014
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
XM Audio Traffic And Travel Link Availability And Operation.
05-02-32-008D
Jul 1, 2014
010000 STEERING
GENERAL MOTORS: DIAGNOSING POWER STEERING CONCERNS. IN RARE CASES, CUSTOMERS MAY COMMENT ON A LACK OF STEERING ASSIST WHEN STOPPED OR DURING PARKING LOT TYPE OF MANEUVERS. *JS UPDATED 09/02/14*LJ
05-02-32-008D
Jul 1, 2014
190000 TIRES
GENERAL MOTORS: DIAGNOSING POWER STEERING CONCERNS. IN RARE CASES, CUSTOMERS MAY COMMENT ON A LACK OF STEERING ASSIST WHEN STOPPED OR DURING PARKING LOT TYPE OF MANEUVERS. *JS UPDATED 09/02/14*LJ
Recalls
Jun 30, 2014
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Vehicle Recalls
PIC5588B
Jun 1, 2014
353000 EQUIPMENT:ELECTRICAL
Programming And Activation Of Replacement OnStar Modules.
PIT5264
Mar 1, 2014
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Canadian Customers Unable To Place Calls In The United States
PIT4864F
Mar 1, 2014
350000 EQUIPMENT
Information On Requests To Add OnStar Bluetooth Option.
99-08-51-007F
Feb 1, 2014
200000 WHEELS
Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe
99-08-51-007F
Feb 1, 2014
350000 EQUIPMENT
Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe
99-08-51-007F
Feb 1, 2014
356000 EQUIPMENT ADAPTIVE/MOBILITY
Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe
99-08-51-007F
Feb 1, 2014
200000 WHEELS
Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe
99-08-51-007F
Feb 1, 2014
350000 EQUIPMENT
Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe
Showing 100 of 109 bulletins.
CHEVROLET EXPRESS 3500 - All Years Overview
Complete safety history for the CHEVROLET EXPRESS 3500 across all model years (1999, 2014).
12
Total Recalls
163
Total Complaints
0
Investigations
9
Reported Crashes
11
Reported Fires
0
Reported Deaths
CHEVROLET EXPRESS 3500 - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2024 | 0 | 4 | View |
| 2021 | 0 | 1 | View |
| 2019 | 0 | 3 | View |
| 2014 | 1 | 1 | View |
| 2013 | 0 | 1 | View |
| 2012 | 0 | 5 | View |
| 2010 | 1 | 5 | View |
| 2009 | 2 | 11 | View |
| 2008 | 1 | 12 | View |
| 2007 | 1 | 12 | View |
| 2006 | 1 | 17 | View |
| 2005 | 1 | 26 | View |
| 2004 | 0 | 18 | View |
| 2003 (current) | 0 | 14 | |
| 2002 | 1 | 3 | View |
| 2001 | 1 | 14 | View |
| 2000 | 1 | 4 | View |
| 1999 | 1 | 4 | View |
| 1998 | 0 | 4 | View |
| 1997 | 0 | 4 | View |