2005 CHEVROLET EQUINOX

1 recalls, 950 complaints - 792 TSBs

POWER TRAIN:AUTOMATIC TRANSMISSION

Defect Description

CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION.' AN IGNITION KEY PARK LOCK CABLE END FITTING WAS NOT FULLY SEATED ON THE AUTOMATIC TRANSMISSION SHIFTER NAIL HEAD DURING INSTALLATION.

Consequence

THIS CAN PREVENT THE CABLE AUTO-SET FROM CORRECTLY ADJUSTING THE CABLE. AN INCORRECTLY ADJUSTED CABLE PREVENTS THE SHIFTER FROM LOCKING IN THE 'PARK' POSITION WHEN THE KEY IS REMOVED FROM THE KEY CYLINDER.

Remedy

DEALERS WILL INSPECT FOR A PROPERLY FUNCTIONING SHIFT LOCK WHEN THE IGNITION KEY IS REMOVED. DEALERS WILL REPAIR VEHICLES THAT EXHIBIT THE SUBJECT CONDITION. THE RECALL BEGAN AUGUST 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.

132 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

950 total complaints 91 crashes 18 fires 73 injuries

Top Reported Components

Component	Complaints
ELECTRICAL SYSTEM	124
POWER TRAIN	57
ENGINE	55
STEERING	45
ENGINE AND ENGINE COOLING	45
SERVICE BRAKES	44
UNKNOWN OR OTHER	40
SUSPENSION	38
SERVICE BRAKES, HYDRAULIC	32
POWER TRAIN:AUTOMATIC TRANSMISSION	30

Incident date: Feb 20, 2023

I was driving during the snow storm, my front sensor stopped working because it was covered in snow. That warning popped up on my dash screen and the warning light was on, after about half hour, the front collision warning light also turned on. I had not been able to stop to clean the sensor. I stop... Read more

Incident date: Feb 20, 2023

Incident date: Jan 25, 2023

The contact owns a 2021 Harley-Davidson Road Glide FLTRK. The contact stated that the motorcycle was taken to a local dealer for unknown repairs, he was made aware that the VIN was included in NHTSA Campaign Number: 22V781000 (Exterior Lighting); however, the part to do the repair was unavailable. T... Read more

Incident date: Jan 10, 2022

Upon purchasing the vehicle from a buy here pay here they did not enclose any possible or current failures or problems with the vehicle. It started with the battery and within 2 months of purchase the check engine light came on. I had previously taken the vehicle to the dealership 3 times to assess ... Read more

Incident date: Jul 15, 2010

The contact owns a 2005 Chevrolet Equinox. The contact stated that upon inserting the key into the ignition switch, it failed to function properly. There was no warning light illuminated. The vehicle was taken to the dealer where it was repaired under NHTSA Campaign Number: 04V302000 (POWER TRAIN). ... Read more

Incident date: Apr 29, 2022

The front sub frame where it bolts to the frame was completely rusted loose on the right side. The left side was barely holding on. This is what holds the motor up and control arms. My mechanics are telling me this is a common problem with Chevy Equinoxes. If it's common why aren't there recalls. My... Read more

Incident date: Apr 29, 2022

Incident date: Aug 1, 2021

The contact owns a 2005 Chevrolet Equinox. The contact stated that after starting the vehicle, the vehicle remained in LIMP mode. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer but they are all unable to identify the issue. The manufac... Read more

Incident date: Jan 17, 2022

I was at the car wash, when the vehicle was near the end, suddenly the engine light and powertrain light came on then shut off automatically. I tried to restart, put the truck in the drive, but it wouldn't go like the gas wasn't reaching. So, I turned it off and restarted to see if the lights would ... Read more

Incident date: Jan 17, 2022

Incident date: Oct 11, 2021

unknown replaced complete ac system/starter/new battery/ key inserted no response at all ingigtion seems to be a problem turn on key let go it was starting now nothing

Incident date: Oct 11, 2021

unknown replaced complete ac system/starter/new battery/ key inserted no response at all ingigtion seems to be a problem turn on key let go it was starting now nothing

Incident date: Oct 11, 2021

unknown replaced complete ac system/starter/new battery/ key inserted no response at all ingigtion seems to be a problem turn on key let go it was starting now nothing

Incident date: Jun 17, 2021

It was recently brought to my attention that the keys can fall out of the ignition with the vehicle running. Which creates an extreme likelihood that the vehicle can move forward or backward without assistance. My keys fall right out of the ignition you should not be able to take the keys out of an ... Read more

Incident date: Jun 17, 2021

Incident date: May 1, 2021

WHILE DRIVING I CAN HEAR CLINKING NOISE IN REAR OF CAR. AND IT SOMETIMES FEELS LIKE IT'S DRAGGING MY SPEED DOWN. TO THE POINT WE'RE I CAN GO THREW $20 IN GAS IN 2 DAYS BARELY DRIVING IT. WHEN GOING TO STOP WHEN BREAKING IT PULSATE UNDER FOOT I HAVE BRAND NEW BREAKS ALL AROUND CAN STILL HEAR GRINDIN... Read more

Incident date: Jul 31, 2020

THE CONTACT OWNS A 2005 CHEVROLET EQUINOX. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20-30 MPH, THE TRANSMISSION FAILED TO SHIFT AS NEEDED. THE CONTACT STATED THAT THE VEHICLE WAS UNABLE TO EXCEED 20 MPH. ADDITIONALLY, THERE WAS AN ELECTRICAL SURGE THAT WENT THROUGH THE STEERING WHEEL CAUSING A... Read more

1 injured

Incident date: Jul 31, 2020

1 injured

Incident date: Jul 31, 2020

1 injured

Incident date: Mar 24, 2021

BRAKE WON'T RELEASES AFTER PUTING ON BRAKE PEDAL KEY FALLS OUT OF IGNITION WHILE DRIVE ING STEERING SEEMS LIKE GOING TO FALL APART WHEN TURNINGS CAT HARDLY PUT GAS IN IT CODE 0445 LARGE EVAP LEAK DETECTOR

Crash

Incident date: Mar 24, 2021

Crash

Incident date: Mar 24, 2021

Crash

Incident date: Apr 14, 2021

TL* THE CONTACT OWNED A 2005 CHEVROLET EQUINOX. THE CONTACT STATED UPON STARTING THE VEHICLE, SHE SAW FIRE EMERGING FROM BOTTOM OF THE VEHICLE. UPON EXITING THE VEHICLE, THE CONTACT STATED THAT THE VEHICLE WAS TRYING TO START EVEN WITH THE KEYS OUT OF THE IGNITION. THERE WERE NO CRASH OR INJURIES DU... Read more

Fire

Incident date: Jan 15, 2021

BRAKES WERE PULSATING AND NOT STOPPING ABS AND TRACTION CONTROL LIGHTS COME ON

Incident date: Jan 1, 2017

TL* THE CONTACT OWNS A 2005 CHEVROLET EQUINOX. THE CONTACT STATED THAT WHILE THE OWNER WAS DRIVING, THE VEHICLE HAD SUDDENLY SHUT OFF DUE TO A FAULTY IGNITION SWITCH. THE OWNER HAD ALSO EXPERIENCED SEVERAL SAFETY RELATED FAILURES WHILE OPERATING THE VEHICLE INVOLVING THE BRAKING SYSTEM THE TRANSMISS... Read more

Incident date: Dec 23, 2020

I HAVE BEEN HAVING MAJOR OVERHEATING IN MY VVEHICAL. I HAVE ONLY BEEN USING IT FOR SHORT DISTANCES DUE TO THE ISSUE BUT NOW HAVE BEEN LETTING IT SIT STILL AFTER READING THAT THE 2005 EQUINOX HAD HEAD GASKET PROBLEMS BEFORE. AND AFTER A UNCLE JUST LOOKING IT OVER I BELIEVE THAT IS WHAT'S WRONG. THERE... Read more

Incident date: Nov 1, 2020

VEHICLE IS ABLE TO DRIVE WHILE KEY IS OUT OF IGNITION WHEN ENGINE IS ALREADY RUNNING. SEAT BELT DISCONNECTS RANDOMLY. VEHICLE CAN BE OPEN WITH A NICKEL COIN. ECU TRIGGERS WARNING LIGHTS RANDOMLY

Incident date: Nov 1, 2020

VEHICLE IS ABLE TO DRIVE WHILE KEY IS OUT OF IGNITION WHEN ENGINE IS ALREADY RUNNING. SEAT BELT DISCONNECTS RANDOMLY. VEHICLE CAN BE OPEN WITH A NICKEL COIN. ECU TRIGGERS WARNING LIGHTS RANDOMLY

Incident date: Nov 1, 2020

VEHICLE IS ABLE TO DRIVE WHILE KEY IS OUT OF IGNITION WHEN ENGINE IS ALREADY RUNNING. SEAT BELT DISCONNECTS RANDOMLY. VEHICLE CAN BE OPEN WITH A NICKEL COIN. ECU TRIGGERS WARNING LIGHTS RANDOMLY

Incident date: Aug 23, 2020

WELL I BOUGHT IT FROM A INDIVIDUAL 3 MONTHS AGO N THE SECOND DAY OF GETTING IT MY CHECK ENGINE LIGHT CAME ON IT FEELS LIKE IT JERKS THE CRAP OUT OF U WHEN TRYING TO TO GAIN SPEED FROM 40-55 RANGE N WHEN COMING TO A STOP SIGN IT FEELS LIKE IT DON'T WANT TO STOP NOW THE ABS N TRACTION CONTROL LIGHT IS... Read more

Incident date: Sep 28, 2020

STEERING WHEEL GOT LOCKED I TRIED WITH DIFFERENT KEYS EVEN A NEW DEALERS KEY AND IT STILL DIDN'T UNLOCK . IT WAS PARKED

Incident date: Dec 12, 2015

WHEN I TOOK MY CAR IN 2015 TO THE PADDOCK CHEVROLET DEALERSHIP IN KENMORE NY, MY BATTERY WAS REPLACED. THIS CAUSED THE CD CHANGER TO NO LONGER WORK. IT IS STILL NOT FUNCTIONING, CDS WONT EJECT AND ALL IT DOES IS MAKE A CLICKING SOUND.

Incident date: Mar 9, 2020

KEY FALLS OUT OF THE IGNITION SINCE I GOT IT A YEAR AGO I HAVE REPLACED 02 SENSOR AC COMPRESSOR AND A WATER TANK. IT WAS ACTING LIKE IT WASN'T GETTING FUEL LIKE LOSING POWER AND THEN I KILLED IT WENT TO START IT THE NEXT DAY AND IT WON'T CRANK IT WILL TURN OVER AND ACT LIKE IT WANTS TO RUN BUT IT DI... Read more

Incident date: Mar 1, 2019

THERE ARE TWO ISSUES WITH THIS EQUINOX. THE FIRST, IS THE KEY SOMETIMES LOCKS ON THE IGNITION AND I CANNOT TURN THE VEHICLE ON NOR TURN THE KEY - IT COMPLETELY LOCKS LEADING TO ANXIETY AND FRUSTRATION BECAUSE IT WILL TAKE SEVERAL ATTEMPTS AT TRYING TO PUT THE KEY IN OR EVEN TRYING TO PULL IT OUT OF... Read more

Incident date: Feb 1, 2019

TL-THE CONTACT OWNS A 2004 CHEVROLET EQUINOX. THE CONTACT STATED THAT SHE BOUGHT THE VEHICLE USED BACK ON 02/2019. THE DRIVE SHAFT FELL OUT OF THE VEHICLE ON 07/2019 AND AN INDEPENDENT MECHANIC DEEMED THE VEHICLE UNDRIVABLE ON 12/23/19. THE CONTACT CALLED THE STATE POLICE FOR VEHICLE FRAUD AN DWAS S... Read more

Incident date: Feb 1, 2019

Incident date: Jan 5, 2020

TL* THE CONTACT OWNED A 2005 CHEVROLET EQUINOX. THE CONTACT STATED THAT WHILE DRIVING 55 MPH AND TURNING ON CURVE TOO FAST, CONTROL OF THE VEHICLE WAS LOST. THE VEHICLE SWERVED LEFT AND RIGHT ULTIMATELY COMING TO A STOP AFTER CRASHING INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. DURING THE IMPACT THE... Read more

Crash 1 injured

Incident date: Oct 26, 2019

MY KEY TO MY CAR WON'T TURN. AND WHEN YOU DO GET IT STARTED BY HITTING IT THE KEY FALLS OUT WHILE DRIVING. THIS IS MY THIRD TIME REPLACING IT BUT SAW THERE'S BEEN RECALLS FOR THE LOCK IGNITION SWITCH FOR THIS MODEL. IT'S STARTED HAPPENING AGAIN A YEAR AFTER I LAST REPLACED THE LOCK IGNITION SWITCH.

Incident date: Aug 9, 2019

MY UNDER HOOD FUSE BOX WENT UP IN FLAMES WHILE DRIVING ON A BACK ROAD IN MY HOME TOWN. I WAS DOING 45 MPH WHEN THEN TRUCK SHUT DOWN WITHOUT WARNING. I AT FIRST THOUGHT WAS THE FUEL PUMP WENT. WHEN I OPENED MY DRIVERS DOOR I COULD SMELL SOMETHING WAS BURNING. I PULLED THE HOOD RELEASE AS I EXITED KIN... Read more

Fire

Incident date: Mar 26, 2019

THE TRACTION CONTROL LIGHT AND THE ABS LIGHT COME ON WHEN DRIVING AND WHEN YOU GO TO STOP OR SLOW DOWN, THE BRAKES PULSATE AND MAKE IT TO WHERE YOU CAN'T STOP OR SLOW DOWN, EVEN ON DRY ROADS.

Crash

Incident date: Mar 27, 2019

TL* THE CONTACT OWNS A 2005 CHEVROLET EQUINOX. WHILE DRIVING 35 MPH AND DRIVING STRAIGHT PREPARING TO MAKE A RIGHT TURN, THE CONTACT CRASHED INTO THE FRONT QUARTER PANEL OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE HEAD AND ANKLE, WHICH REQUIRED MEDICAL ATTE... Read more

Crash 1 injured

Incident date: Aug 5, 2018

OUR CHEVROLET EQUINOX 2005 IS SHIFTING HARD DOWN SHIFT AND UPSHIFT BUT DOESN'T SHOW ANY RECALLS ON THEM WHICH THERE SHOULD SINCE THERE IS PROBLEMS AND ANOTHER VEHICLE SOMEONE ELSE OWNS IS A CHEVROLET EQUINOX 2008 MODEL IS ALSO SHIFTING HARD IT'S A SERIUSE PROBLEM IT COULD CAUSE A WRECK DUE POSSIBILI... Read more

Incident date: Jul 20, 2018

TL* THE CONTACT OWNS A 2005 CHEVROLET EQUINOX. WHILE DRIVING 24 MPH ON AN EXIT RAMP, THE VEHICLE INADVERTENTLY DROVE OFF THE SIDE OF THE RAMP AND CRASHED. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT FAILED TO RESTRAIN THE CONTACT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT SUSTAIN... Read more

Crash 1 injured

Incident date: Jul 20, 2018

Crash 1 injured

Incident date: Aug 17, 2018

ABS KICKS ON RANDOMLY, DRIVING OR BRAKING AND AT VARIOUS SPEEDS. I HAVE HAD ONE ACCIDENT BECAUSE OF THIS ISSUE, HAVE SINCE PULLED THE FUSE AND SPENT OVER $1,000 AT THE SHOP TO FIX THIS ISSUE WITH NO RESULTS. THIS HAS BEEN AN ISSUE SINCE DECEMBER OF 2017 UNTIL PRESENT.

Crash

Incident date: May 20, 2018

VEHICLE WILL STALL DURING OPERATION OR AT IDLE. TSB 05539 COVERS THIS ISSUE FOR EARLIER VIN NUMBERS. THIS NEEDS TO BE EXPANDED TO INCLUDE ADDITIONAL VIN NUMBERS FOR LATER PRODUCTION EFFECTED BY THE SAME PROBLEM.VEHICLE WILL RESTART AFTER SEVERAL ATTEMPTS, BUT MAY FAIL AGAIN IN AS FEW AS FIVE MINUT... Read more

Incident date: May 19, 2018

TAKATA RECALL: I BOUGHT MY CHEVY EQUINOX IN AUGUST OF 2017, SINCE TAKING IT HOME IT HAS HAD A LURCHING PROBLEM WHEN DRIVING OR WHEN STOPPED AT A RED LIGHT. IT LURCHES FORWARD AND BACKWARDS LIKE A BULL TRYING TO THROW YOU OFF. I PUT NEW BRAKES ON EVERY 3 MONTHS BECAUSE MY BRAKES DO NOT WORK EVEN WHEN... Read more

Incident date: May 19, 2018

Showing 50 of 950 complaints.

Technical Service Bulletins, 2005 CHEVROLET EQUINOX

792 manufacturer communications from 528 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	113
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	84
110000 ELECTRICAL SYSTEM	74
060000 ENGINE AND ENGINE COOLING	57
356000 EQUIPMENT ADAPTIVE/MOBILITY	42
353000 EQUIPMENT:ELECTRICAL	33
060000 ENGINE (PWS)	28
100000 POWER TRAIN	24

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

100000 POWER TRAIN

This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle

060000 ENGINE AND ENGINE COOLING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

200000 WHEELS

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

100000 POWER TRAIN

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

020000 SUSPENSION

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

010000 STEERING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).

117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

350000 EQUIPMENT

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

100000 POWER TRAIN

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

060000 ENGINE AND ENGINE COOLING

This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

110000 ELECTRICAL SYSTEM

The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only).

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

100000 POWER TRAIN

This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.

138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

100000 POWER TRAIN

060000 ENGINE AND ENGINE COOLING

200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

190000 TIRES

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on Policies Applicable to All U.S. Dealers for Engine and Transmission Assembly Replacement Under Warranty, Policy or Customer Enthusiasm and information on Submission of Warranty Transaction in Global War

100000 POWER TRAIN

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

This service bulletin provides information on Module Harvesting.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

980000 UNKNOWN OR OTHER

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

100000 POWER TRAIN

This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.

134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

This Preliminary Information communication advises the technician the steps on diagnosing the concern. Customer's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

160000 STRUCTURE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

060000 ENGINE (PWS)

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

353000 EQUIPMENT:ELECTRICAL

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

This Preliminary Information communication advises the technician the steps on diagnosing the concern. Customer's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.

350000 EQUIPMENT

This informational bulletin provides information on a guide to help reduce repeat visits for the same customer concern.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides the technician with additional information on fuels, fuel additives and fuel management.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides the technician with additional information on fuels, fuel additives and fuel management.

200000 WHEELS

190000 TIRES

200000 WHEELS

190000 TIRES

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

This service bulletin provides information for accurate tire pressures that ensure the safe handling and appropriate ride characteristics of GM cars and trucks.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

356230 EQUIPMENT ADAPTIVE/MOBILITY:VEHICLE CONTROLS:STEERING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure, when diagnosing vibration concerns.

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician

356000 EQUIPMENT ADAPTIVE/MOBILITY

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

100000 POWER TRAIN

This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.

350000 EQUIPMENT

This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.

110000 ELECTRICAL SYSTEM

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

350000 EQUIPMENT

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

350000 EQUIPMENT

Showing 100 of 792 bulletins.

NHTSA Safety Investigations, CHEVROLET EQUINOX

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2010

Momentary Increased Steering Effort

On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Eq... uinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745Read more

EA, Closed , Model Year: 2010

Front Wiper Transmission Inoperative

On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles,... MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.Read more

RQ, Closed , Model Year: 2010

Windshield Wiper Transmission Failure

On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrai... Read more

CHEVROLET EQUINOX - All Years Overview

Complete safety history for the CHEVROLET EQUINOX across all model years (2005, 2026).

47 Total Recalls

12,762 Total Complaints

3 Investigations

589 Reported Crashes

141 Reported Fires

17 Reported Deaths

CHEVROLET EQUINOX - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	131	View
2025	0	358	View
2024	1	131	View
2023	3	143	View
2022	5	223	View
2021	4	128	View
2020	4	495	View
2019	4	421	View
2018	5	591	View
2017	0	371	View
2016	1	493	View
2015	2	845	View
2014	1	699	View
2013	2	991	View
2012	3	945	View
2011	3	1,140	View
2010	3	1,118	View
2009	0	151	View
2008	0	535	View
2007	4	953	View
2006	0	950	View
2005 (current)	1	950

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2005 CHEVROLET EQUINOX

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2005 CHEVROLET EQUINOX

Most Affected Components

NHTSA Safety Investigations, CHEVROLET EQUINOX

CHEVROLET EQUINOX - All Years Overview

CHEVROLET EQUINOX - Year by Year

Other CHEVROLET Models