2004 CADILLAC XLR

5 recalls, 45 complaints - 712 TSBs

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.

Consequence

A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.

Remedy

TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.

4,887 vehicles affected

Manufacturer: TI GROUP AUTOMOTIVE SYSTEMS, LLC

EXTERIOR LIGHTING:TURN SIGNAL

Defect Description

ON CERTAIN PASSENGER VEHICLES, THE DAYLIGHT RUNNING LIGHTS (DRL), TURN SIGNAL, AND PARKING LAMPS USE THE SAME BULB. THE BULB MAY BECOME DAMAGED FROM VIBRATION WITHIN A LOOSE FITTING SOCKET OR AIR ENTERING THE BULB DUE TO AN INADEQUATE SEAL. BOTH OF THESE CONDITIONS WILL CAUSE THE BULB TO BURN OUT... Read more

Consequence

IF THIS WERE TO OCCUR, THE DRIVER WOULD NOTICE THAT THE ARROW IN THE INSTRUMENT PANEL WOULD FLASH FASTER THAN NORMAL WHEN THE TURN SIGNAL IS ACTIVATED. THE LOSS OF THE DRL AND TURN SIGNALS COULD FAIL TO WARN OTHERS OF THE DRIVER'S PRESENCE OR INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.

Remedy

DEALERS WILL REPLACE THE SOCKET AND BULB IN BOTH LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.

7,689 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Defect Description

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F, THE ENGINE MAY NOT RETURN TO IDLE WITHIN T... Read more

Consequence

IF THIS WERE TO OCCUR, GREATER BRAKE PEDAL FORCE AND A LONGER DISTANCE MAY BE REQUIRED TO STOP THE VEHICLE.

Remedy

DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY. THIS RECALL BEGAN ON MARCH 8, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR PONTIAC AT 1-800-620-7668.

19,924 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH ONE OR BOTH REAR BRAKE HYDRAULIC LINES THAT CAN COME IN CONTACT WITH OR BE AFFECTED BY HEAT FROM THE LEFT ENGINE EXHAUST MANIFOLD AND THE LEFT EXHAUST PIPE. THE BRAKE FLUID COULD REACH ELEVATED TEMPERATURES AND BOIL.

Consequence

IF THE BRAKE FLUID BOILS IN A REAR BRAKE LINE, THE EFFECTIVENESS OF THE REAR BRAKE SYSTEM WOULD BE REDUCED WHICH COULD RESULT IN A BRAKE LINE LEAK AND LOSS OF BRAKE FLUID. IF ENOUGH FLUID LEAKS FROM THE REAR BRAKE SYSTEM SO THAT BRAKE PEDAL APPLICATION CAN NO LONGER BUILD PRESSURE TO THE REAR BRAKE... Read more

Remedy

DEALERS WILL (1) INSPECT THE LEFT ENGINE EXHAUST MANIFOLD CLIP FOR PROPER ALIGNMENT AND PLACEMENT ON THE BODY-MOUNTED STUD. IF INCORRECT, THEY WILL REPOSITION THE CLIP ON THE BRAKE LINES AND REINSTALL THE CLIP ON THE STUD; (2) THE DEALER WILL VERIFY THAT BOTH REAR BRAKE LINES HAVE THE PROPER CLEA... Read more

5,225 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

STEERING:LINKAGES

Defect Description

ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STE... Read more

Consequence

IF THE CONTROL ARM SEPARATES FROM THE KNUCKLE, THE AFFECTED CORNER OF THE VEHICLE WILL DROP AND THE CONTROL ARM WOULD BE FORCED DOWNWARD, CONTACTING THE WHEEL. THE AFFECTED WHEEL COULD TILT OUTWARD AND CREATE A DRAGGING ACTION THAT WOULD TEND TO SLOW THE VEHICLE AND CREATE A TENDENCY FOR THE VEHIC... Read more

Remedy

DEALERS WILL INSPECT THE BALL STUD JOINTS AND MEASURE THE TORQUE OF THE NUT FOR ALL FRONT LOWER CONTROL ARMS IN ALL MODELS AFFECTED AS WELL AS THE REAR LOWER CONTROL ARMS ON THE XLR AND CORVETTE. IF THE TORQUE IS NOT AT SPECIFICATION, THE DEALERS WILL REPLACE THE BALL STUD, THE KNUCKLE, AND THE NUT... Read more

41,928 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

45 total complaints 5 crashes

Top Reported Components

Component	Complaints
STRUCTURE:BODY	7
POWER TRAIN	4
FUEL SYSTEM, GASOLINE	3
FUEL/PROPULSION SYSTEM	3
ELECTRONIC STABILITY CONTROL (ESC)	3
EXTERIOR LIGHTING	3
TIRES:SIDEWALL	2
ELECTRICAL SYSTEM	2
VEHICLE SPEED CONTROL	2
SERVICE BRAKES	2

Incident date: Dec 15, 2025

The contact owns a 2021 Mazda CX-5 equipped with Firestone Tires, Tire Line: Destination LE3, Tire Size: 225/55/R19, DOT Numbers: 17XEFLE320725 and 17XEFLE321524. While the vehicle was parked, the contact was informed by a co-worker that there was a bubble on the rear passenger's side tire. The cont... Read more

Incident date: Apr 15, 2024

2022 MDX Type S. So far I have replaced one tire and two rims. Air suspension does not absorb any road hazard. Pot holes or expansion cracks the front end dives into them letting the tires and rims absorb the impact. Thank goodness no high speed loss of tire pressure

Incident date: Apr 15, 2024

The contact owns a 2015 Ford Escape. The contact stated that while her daughter was driving approximately 45 MPH, the vehicle started losing motive power and then stalled. The vehicle was eventually towed to the local mechanic who replaced the turbo and shifter cable bushing; however, the failure pe... Read more

Incident date: Apr 15, 2024

Incident date: Jul 20, 2023

(Please check the attached full complaint letter) I hope this letter finds you well. I am writing to bring to your attention a concerning matter regarding my experience with the American Honda Motor Company. As a loyal consumer and a law-abiding citizen, I believe it is crucial to address issues th... Read more

Incident date: Jul 20, 2023

Incident date: Aug 18, 2022

The top roof panel separated while driving on the highway, and almost struck another vehicle causing it to swerve to miss it. The vehicle then proceeded to follow me as he though I was to blame. Once I got off the highway he got out of his car an violently started screaming at me for almost causing ... Read more

Incident date: Aug 12, 2022

The contact owns a 2004 Cadillac XLR. The contact stated that fuel had begun to leak from the fuel pump without warning. The contact took the vehicle to an independent mechanic who diagnosed the failure and informed him that while the motor was running, the fuel would leak from the rear driver's si... Read more

Incident date: Jul 15, 2022

The contact owns a 2004 Cadillac XLR. The contact stated there were strong fumes coming from the vehicle. The contact parked his vehicle in the garage and then leave it partially cracked due to the fumes. The contact changed the gas cap; however, the fumes continues. There were no warning lights ill... Read more

Incident date: Jul 15, 2022

Incident date: Nov 11, 2021

The contact owns a 2004 Cadillac XLR. The contact stated while driving 65 MPH, there was an abnormally loud whistling sound coming inside the vehicle. The contact looked up and noticed that the sunroof glass had detached from the vehicle. The contact pulled over to the side of the road and retrieved... Read more

Incident date: Mar 23, 2021

My roof panel is separating from the roof frame of my 04 Cadillac XLR. If it come off it will cause property damage to another vehicle or death! It a GM defect that should be recall !!!! Thanks!

Incident date: Sep 24, 2021

Was driving on interstate and top panel on convertible top flew off.

Incident date: Mar 15, 2019

I PURCHASED A 2004 XLR IN 2019 FROM AN AGENT IN FL. I IMMEDIATELY OR WITH-IN 200 MILES I BEGAN TO RECEIVE MESSAGES ON MY DASH! FIRST IT WAS TRACTION CONTROL THAT APPLIED THE BRAKES AND CAUSED THE CAR TO VET VIOLENTLY TO THE LEFT AS SOON AS I HIT 65 MILES AN HOUR. THEN THE CHECK GAS CAP FOLLOWED BY ... Read more

Incident date: Mar 15, 2019

Incident date: Mar 1, 2019

TL* THE CONTACT OWNS A 2004 CADILLAC XLR. WHILE THE VEHICLE WAS BEING PULLED INTO THE GARAGE, THE CONTACT NOTICED THAT THE HEADLIGHTS MELTED AND MADE IT IMPOSSIBLE FOR THE CONTACT TO SEE CLEARLY. THE CONTACT CALLED SEVERAL DEALERS, INCLUDING WALLACE CADILLAC (772-286-3555, LOCATED AT 3555 SE FEDERA... Read more

Incident date: May 1, 2019

TL* THE CONTACT OWNS A 2004 CADILLAC XLR. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE INTERIOR DRL HEADLIGHT ASSEMBLIES MELTED AND CAUSED THE HEADLIGHTS TO ILLUMINATE DIMLY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. WALLACE CADILLAC(3555 SE FEDERAL HWY, STUART, FL) AND THE MANUFAC... Read more

Incident date: Jul 15, 2016

WHEN DRIVING I NOTICED A SEVERE WHISTLING SOUND COMING FROM JUST ABOVE THE REAR VIEW MIRROR. UPON INSPECTING, I NOTICED THAT THE ROOF PANEL HAD A 8' SECTION THAT HAD SEPARATED. WHEN GOOGLED, I SAW SEVERAL PEOPLE HAD REPORTED THAT THEIR XLR'S HAD A ROOF PANEL SEPARATE WHILE DRIVING. I IMMEDIATELY... Read more

Incident date: Jan 25, 2019

WHILE DRIVING ON THE FLORIDA TURNPIKE SUDDENLY THERE WAS A RUSH OF AIR COMING FROM THE REARVIEW MIRROR AREA. I STOPPED AT THE NEXT SERVICE PLAZA AND OBSERVED THE FRONT OF THE ROOF PANEL SEPARATING FROM THE FRAME. GM USED A ADHESIVE ON THESE XLR ROOFS THAT IS FAILING NOW. CORVETTE ROOFS PANELS WER... Read more

Incident date: Jul 3, 2018

CHECK GAS CAP, CHECK ENGINE LIGHT. DEALER SAYS I NEED A NEW RT FUEL TANK BUT NONE ARE AVAILABLE. WHAT DO I DO NOW?

Incident date: May 8, 2017

SEVERAL XLR OWNERS HAVE REPORTED THAT THEIR ROOF PANEL HAS SEPARATED AND FLOWN OFF THE CAR AT HIGHWAY SPEEDS. MY TOP BEGAN EMITTING A WHISTLING NOISE AT HIGHWAY SPEEDS. WHEN INSPECTING IT, THE CENTER FRONT OF THE TOP HAS BEGUN TO SEPARATE. THESE TOPS WERE APPARENTLY ONLY GLUED AS THE ONLY SECUREM... Read more

Incident date: Jun 15, 2015

THE RETRACTABLE ROOF FLEW OFF WHILE THE CAR WAS MOVING. GM OFFERED NO ASSISTANCE WITH THIS AND DENIED ANY NEGLIGENCE. CASE #8-2866250293

Incident date: Apr 2, 2017

I DRIVING FREEWAY ABOUT 70MPH, BIG AIR NOISE THEN ROOF PANEL COME OFF & FRYING.

Incident date: Mar 16, 2015

I PURCHASED A PRE-OWNED 2004 XLR FROM THE DEALERSHIP THE CAR STORE IN RIVERSIDE. UPON STORING IT IN MY GARAGE, I FOUND THE NEXT MORNING AN OVERWHELMING GASOLINE SMELL. UPON TAKING IT TO MY LOCAL GM DEALER FOR INSPECTION, I WAS TOLD THAT THE ISSUE WAS NO LONGER COVERED BY EXTENDED PROTECTION BY CAD... Read more

Incident date: Dec 8, 2011

FUEL SENDING UNIT KEEPS FAILING CAN'T TELL HOW MUCH FUEL IS IN TANK. HAD FIRST ONE REPLACED AT COST OF AROUND $2300.00 REPLACEMENT LASTED AROUND 18 MONTHS THEN IT FAILED . NEVER KNOW WHEN WHOLE UNIT WILL SHUT DOWN AND LEAVE ME VULNERABLE TO A REAR END OR STALL. *TR

Incident date: Jun 7, 2013

MY 2004 CADILLAC XLR APPLIED THE FRONT LEFT BRAKE ONLY AND ILLUMINATED THE STABILITY CONTROL LIGHT CAUSING A BRIEF AND SEVERE SWERVE FOR ABOUT 1 SECOND. I PULLED OVER AND SHUT THE CAR OFF AND RESTARTED. EVERYTHING WAS FINE FOR ABOUT 4 MONTHS WHEN IT DID IT AGAIN, LUCKILY NO ONE IN MY PATH OF TRAVEL.... Read more

Incident date: Jun 7, 2013

Incident date: Nov 1, 2013

TL* THE CONTACT OWNS A 2004 CADILLAC XLR. THE CONTACT STATED THAT THE HEADLIGHT LENSES BECAME FROSTED AND CAUSED THE COLOR TO CHANGE. THE DEALER INSPECTED THE VEHICLE AND WAS UNABLE TO DETERMINE WHAT CAUSED THE LENSES TO CHANGE COLOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF ... Read more

Incident date: Nov 27, 2013

TL* THE CONTACT OWNS A 2004 CADILLAC XLR. THE CONTACT STATED THAT THE STEERING WHEEL WOULD EMIT AN ABNORMAL NOISE WHEN TURNED IN EITHER DIRECTION. ALSO, THE CONTACT WAS TRAVELING APPROXIMATELY 40 MPH WHEN THE STABILITY CONTROL WARNING LIGHT ILLUMINATED. THE CONTACT APPLIED THE BRAKES FOR A TRAFFIC ... Read more

Crash

Incident date: Nov 27, 2013

Crash

Incident date: Nov 27, 2013

Crash

Incident date: Jul 9, 2007

TL* THE CONTACT OWNS A 2004 CADILLAC XLR. THE CONTACT SMELLED A BURNING ODOR AROUND THE TURN SIGNAL AND INFORMED AN AUTHORIZED DEALER AND THE MANUFACTURER. THE DEALER DIAGNOSED THAT THE SOCKET WAS MELTING AND THE PLASTIC HOUSING WAS WARPED. THE FAILURES WERE RELATED TO NHTSA RECALL CAMPAIGN 06V2630... Read more

Incident date: Dec 30, 2013

PARKED IN A PARKING LOT & PLACED IT IN PARK. UPON RETURNING I STARTED THE CAR & PLACED IT IN DRIVE. I TOOK FOOT OFF BRAKE & CAR MOVED REARWARD. PUT CAR IN NEUTRAL & CAR MOVED REARWARD. I TRIED ALL GEARS INCLUDING PARK & CAR MOVED REARWARD, TURNED CAR OFF. CAR WOULD NOT RESTART BECAUSE IT WAS NOT IN ... Read more

Incident date: Dec 30, 2013

Incident date: Aug 24, 2011

8/24/11 - VEHICLE STUCK IN REVERSE. WOULD NOT GO INTO ANY OTHER GEAR. DEALER FOUND SHIFT CABLE BROKEN. - 09/19/13-PARKED WAITING ON A FAMILY MEMBER. HAD THE VECHILE IN PARK (SO I THOUGHT). WHEN I WAS READY TO LEAVE THE CAR WOULD NOT GO INTO ANY GEAR. DEALER FOUND SHIFT CABLE BROKE. *JS

Incident date: Apr 13, 2013

I BOUGHT THIS USED VEHICLE ON THE DATE SHOWN ABOVE AT THE "INCIDENT DATE". I DON'T KNOW WHEN THE ACTUAL PROBLEM BEGAN ON THIS CAR, BUT IT WAS PROBABLY YEARS EARLIER. THE SAFETY PROBLEM IS THAT THE LENSES OF BOTH RIGHT AND LEFT DRIVING/PARKING/DIRECTIONAL LAMPS HAVE APPARENTLY BEEN HEAT AFFECTED...... Read more

Incident date: Jul 20, 2010

I WOULD LIKE TO SECOND THE COMPLAINT BELOW REGARDING MY 2004 CADILLAC XLR. I AM ALSO EXPERIENCING THE SAME PROBLEMS DESCRIBED BELOW. MAKE : CADILLAC MODEL : XLR YEAR : 2004 MANUFACTURER : GENERAL MOTORS CORP. CRASH : NO FIRE : NO NUMBER OF INJURIES: 0 ODI ID NUMBER : 10342498 NUMBER OF ... Read more

Incident date: Jul 1, 2010

2004 CADILLAC XLR STRONG FUEL SMELL AFTER FILLING UP GAS TANK. MECHANIC SAID THERE IS A LEAK IN THE CROSSOVER TUBES LEADING TO THE FUEL TANK. *TR

Incident date: Jul 10, 2010

I HAVE A 2004 CADILLAC XLR THAT HAS THE EXACT SAME PROBLEM AS THE 2005-2009 CORVETTES HAVE. THE SERVICE STABILITRAK MESSAGE AND TRACTION CONTROL LIGHT COMES ON AND THE CARS BRAKES LIGHT DO NOT WORK WHEN THIS COMES ON. YOUR CASE NUMBERS FOR THIS ARE PE08056 AND EA09-002 MY CAR PULLED TO THE RIGHT SU... Read more

Incident date: Aug 3, 2009

A PRONOUNCED ODOR OF GASOLINE AND APPEARANCE OF AN ERROR MESSAGE STATING "CHECK GAS CAP" LED ME TO BRING THE VEHICLE, A 2004 CADILLAC XLR, TO THE DEALER FOR SERVICE. THE DEALER DETERMINED THAT A CROSSOVER PIPE BETWEEN THE TWO GASOLINE TANKS WAS LEAKING. REPLACEMENT OF THE CROSSOVER PIPE (AT A COST... Read more

Incident date: Nov 6, 2006

TL*THE CONTACT OWNS A 2004 CADILLAC XLR. WHILE DRIVING 5 MPH, THE VEHICLE ACCELERATED ON ITS OWN TO APPROXIMATELY 55 MPH. THE CONTACT ATTEMPTED TO ENGAGE THE BRAKES, BUT WAS UNSUCCESSFUL. ON NOVEMBER 6, 2006, THE CONTACT'S VEHICLE CRASHED INTO NINE PARKED VEHICLES. ALL OF THE VEHICLES WERE DAMAG... Read more

Crash

Incident date: Nov 6, 2006

Crash

Incident date: Sep 9, 2004

I HAVE A 2004 CADILLAC XLR WITH 8031 MILES. THE CAR HAS MICHELIN PILOT ZEROPRESSURE TIRES. THE SIDEWALLS BUBBLE WHEN YOU HIT A POTHOLE, AND I DON'T MEAN A BIG POT HOLE. I HAVE WATCHED MANY CARS TRAVEL THROUGH THIS PART OF THE ROAD AND HIT THE SAME POT HOLE I HIT WITHOUT THEIR SIDEWALLS BUBBLING AND... Read more

Incident date: Jan 24, 2004

THE CAR STARTED EMITTING GASOLINE FUMES THROUGHOUT THE GARAGE AND HOUSE. THE DEALER REMOVED THE GASOLINE TANK AND DISCOVERED A LEAK AT THE MOLDED SECTION WHERE THE FILL TUBE ENTERS THE TANK. THE TANK HAD TO BE REPLACED. *JB

EPA Fuel Economy, 2004 CADILLAC XLR

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
4.6L 8-cyl, Automatic 5-spd (Rear-Wheel Drive)	15.0	23.0	18.0	Premium	$4,200

CO2 Emissions: -1.0 g/mile (Two Seaters)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2004 CADILLAC XLR

712 manufacturer communications from 492 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	86
110000 ELECTRICAL SYSTEM	80
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	63
060000 ENGINE AND ENGINE COOLING	34
353000 EQUIPMENT:ELECTRICAL	33
356000 EQUIPMENT ADAPTIVE/MOBILITY	31
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	27
118000 ELECTRICAL SYSTEM:SOFTWARE	24

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

200000 WHEELS

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

100000 POWER TRAIN

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

020000 SUSPENSION

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

010000 STEERING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

This Preliminary Information communicates helpful information on diagnosing general customer concerns related to a power folding top.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

350000 EQUIPMENT

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

100000 POWER TRAIN

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.

353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.

110000 ELECTRICAL SYSTEM

This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.

138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

190000 TIRES

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

This service bulletin provides information on Module Harvesting.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

980000 UNKNOWN OR OTHER

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.

100000 POWER TRAIN

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

100000 POWER TRAIN

This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

160000 STRUCTURE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

060000 ENGINE (PWS)

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

353000 EQUIPMENT:ELECTRICAL

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

200000 WHEELS

190000 TIRES

350000 EQUIPMENT

This Preliminary Information communicates helpful information on diagnosing general customer concerns related to a power folding top.

160000 STRUCTURE

This Preliminary Information communicates helpful information on diagnosing general customer concerns related to a power folding top.

200000 WHEELS

190000 TIRES

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

This service bulletin provides information for accurate tire pressures that ensure the safe handling and appropriate ride characteristics of GM cars and trucks.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

356230 EQUIPMENT ADAPTIVE/MOBILITY:VEHICLE CONTROLS:STEERING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure, when diagnosing vibration concerns.

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician

356000 EQUIPMENT ADAPTIVE/MOBILITY

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

110000 ELECTRICAL SYSTEM

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

350000 EQUIPMENT

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

160000 STRUCTURE

350000 EQUIPMENT

200000 WHEELS

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

350000 EQUIPMENT

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR

350000 EQUIPMENT

This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in

200000 WHEELS

190000 TIRES

350000 EQUIPMENT

This Preliminary Information communicates helpful information on diagnosing general customer concerns related to a power folding top.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

060000 ENGINE (PWS)

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

355100 EQUIPMENT:OTHER:LABELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

Showing 100 of 712 bulletins.

NHTSA Safety Investigations, CADILLAC XLR

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2004

Roof Skin Separation While Driving

On August 23rd, 2018 - the Office of Defects Investigation (ODI) received a media inquiry pertaining to a motorist experiencing separation of the roof skin from their Cadillac XLR while driving.Based on the data in-hand at that time and a subsequent (December) consumer complaint, ODI opened PE19-001... on February 1, 2019 to evaluate the scope of this condition in the 2004 - 2005 XLR population.The subject vehicle model is a two-seat roadster equipped with an electrically powered retractable roof system. The outer roof skin is a Sheet Molded Composite (SMC) which is adhered to the magnesium alloy roof frame.ODI's February 7, 2019 Information Request (IR) letter to General Motors (GM) covered the entirety of XLR production: MY 2004 - 2009. GM's March 21, 2019 IR response attributed the separations to an unexpected oxide layer on the magnesium framework. A total of eight separations were identified, six of which coincided with consumer complaints to NHTSA. Separations occurred at two per calendar year with the most recent taking place in late 2018.An additional twenty-one noise, fit/finish/ functionality claims were identified that did not lead to separations.ODI compared the separation rate in the subject vehicles to those in to two roof skin separation safety recalls involving the Corvette (06V181: 2005 - 2006 Corvette; 09V491: 2005 - 2007 Corvette) to find that the subject vehicles took over ten years of exposure to reach the failure rate that triggered the 06V181.Since PE19-001 opened, ODI has received only one additional consumer complaint which reported wind noise symptoms. The complainant has not responded to outreach efforts by ODI or GM.Based on a low failure rate, sporadic occurrence, and high detectability of the alleged defect in the subject vehicles, this investigation is closed. Further use of agency resources on this matter is not warranted. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist in the subject vehicles.The agency reserves the right to take further action if warranted by the circumstances. The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers: Separations: 11155574, 11101657, 11012176, 11012166, 10970736, 10970383, 10653304Note: ODI 11012176 & 11012166 pertain to the same incidentNot Separated: 11243947, 11194359, 11176647, 11173362, 11074433, 10985013 Note: 11176647 & 10985013 pertain to the same incidentRead more

CADILLAC XLR - All Years Overview

Complete safety history for the CADILLAC XLR across all model years (2004, 2009).

12 Total Recalls

108 Total Complaints

1 Investigations

9 Reported Crashes

2 Reported Fires

0 Reported Deaths

CADILLAC XLR - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2009	1	1	View
2008	1	6	View
2007	1	2	View
2006	1	15	View
2005	3	39	View
2004 (current)	5	45

Other CADILLAC Models

Model	Recalls	Complaints
ESCALADE	163	2,182	View
ESCALADE ESV	128	666	View
CTS	64	3,088	View
ESCALADE EXT	63	126	View
DEVILLE	59	3,662	View
FLEETWOOD	50	265	View
BROUGHAM	46	69	View
SEVILLE	46	1,049	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2004 CADILLAC XLR

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2004 CADILLAC XLR

Technical Service Bulletins, 2004 CADILLAC XLR

Most Affected Components

NHTSA Safety Investigations, CADILLAC XLR

CADILLAC XLR - All Years Overview

CADILLAC XLR - Year by Year

Other CADILLAC Models