2014 BMW 528I

3 recalls, 92 complaints - 537 TSBs - 5/5 safety rating

ENGINE AND ENGINE COOLING:COOLING SYSTEM:PUMP

Defect Description

BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 201... Read more

Consequence

An electrical short increases the risk of a fire.

Remedy

Dealers will inspect and replace the water pump and plug connector as necessary, and install a protective shield, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact BMW customer service at 1-800-525-7417.

720,796 vehicles affected

Manufacturer: BMW of North America, LLC

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Defect Description

BMW of North America, LLC (BMW) is recalling certain 2015 6 Series Gran Coupe, 2014 5 Series Gran Turismo, 2014 5 Series Sedan, 2015 6 Series Convertible, 2015 6 Series Coupe, 2014 X5, 2013-2014 X3, 2014-2015 3 Series Sedan, 2014 4 Series Coupe, 2014 4 Series Convertible, 2014 3 Series Gran Turismo,... Read more

Consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, increasing the risk of injury or death.

Remedy

The driver's front air bag will be replaced, free of charge. Owner notification letters were mailed September 6, 2024. Owners may contact BMW customer service at 1-800-525-7417.

1,145 vehicles affected

Manufacturer: BMW of North America, LLC

EXTERIOR LIGHTING

Defect Description

BMW of North America, LLC (BMW) is recalling certain model year 2013 528i, 528i xDrive, 535i, 535i xDrive, 550i, 550i xDrive, and ActiveHybrid 5 vehicles. The rear reflex reflectors may not reflect enough light. As such, the vehicles fail to comply with the requirements of Federal Motor Vehicle Sa... Read more

Consequence

The vehicle may be less visible to other vehicles, increasing the risk of a crash.

Remedy

BMW will notify owners, and dealers will replace the rear reflex reflectors, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.

13,443 vehicles affected

Manufacturer: BMW of North America, LLC

Complaint Statistics

92 total complaints 2 crashes 2 fires 5 injuries

Top Reported Components

Component	Complaints
ENGINE	24
POWER TRAIN	11
UNKNOWN OR OTHER	7
ELECTRICAL SYSTEM	7
FUEL/PROPULSION SYSTEM	5
AIR BAGS	4
STEERING	3
ENGINE AND ENGINE COOLING	3
FORWARD COLLISION AVOIDANCE: WARNINGS	3
STRUCTURE:BODY	3

Incident date: Aug 20, 2025

car was brought in for a recall could erupt fire from engine and electrical brought car to bmw 8/2025 have checked list when brought in car was in perfect condition per bmw .pick up car checked engine light was on brought back immediately manager took to shop and cleared light immediately came back ... Read more

Incident date: Aug 20, 2025

Incident date: Nov 26, 2025

Catastrophic Engine failure while driving on highway with family. System gave error codes DTC P054A, DTC P0301, DTC P0017. Vehicle was not drivable. Always serviced with oil and filter change at recommended service intervals at authorized Audi dealer. Never showed any signs of malfunction or warning... Read more

Incident date: Nov 26, 2025

Incident date: Apr 16, 2025

The Multimedia Interface (MMI) Touchscreen Radio will constantly reboot while driving regardless of variables. Diagnosis’ have proven problem to be undeterminable, this is a serious safety concern as I have lost back up camera and other safety features while driving, while I await the system to re... Read more

Incident date: Apr 16, 2025

Incident date: Jun 14, 2025

There was no incident however I received a recall for a windshield piece that was back in 2024 and supposedly would be available for repair in the latter half of 2024. However nothing has been sent to me regarding this and when the piece came off it cracked my windshield so I have a crack across tha... Read more

Incident date: Jun 1, 2025

Transmission needs to be replaced at 60k miles. This issue seems to be encountered way too often with this vehicle.

Incident date: May 30, 2025

The contact owned a 2020 Hyundai Accent. The contact stated that while the vehicle was parked, smoke was emitting from the vehicle. The contact was inside her residence and noticed the smoke from her window. Unknown if the air bags deployed. The contact stated that the fire spread to another parked ... Read more

Fire

Incident date: May 30, 2025

Intermittent power steering loss. Steering becomes very difficult to turn and unsafe as it is unpredictable. The issue is persistent and ongoing.

Incident date: Mar 1, 2025

Parking, brake, and abs alert lights constantly alert on the dash. When reaching approximately 50mph the steering wheel and vehicle begin to shake and wobble excessively, and the vehicle moves side to side in the road requiring an almost complete stop to control the vehicle. The brake pedals go al... Read more

Incident date: Mar 10, 2025

Incident date: Mar 1, 2025

Incident date: May 19, 2025

The contact owns a 2019 Ford Edge. The contact stated while driving 30 MPH, the vehicle jerked and vibrated and failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle stalled; however, the contact was able to pull over to the side of the road. Th... Read more

Incident date: May 19, 2025

The contact owns a 2018 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, there was an abnormal shuddering sound coming from the engine compartment. The contact stated that the stabili-trak warning light was illuminated. Additionally, on one occasion when the vehicle... Read more

Incident date: Apr 2, 2025

Critical Issue: Gasoline leaks into engine. That causes increasing engine oil level significantly and mixed with engine oil. I dropped off me car (mileage: 11731) at Kia Pro in Glendale, CA on 5/1/2025 as soon as I confirmed that engine oil level exceeds the maximum (twice of max) and smelled Gasoli... Read more

Incident date: Apr 2, 2025

Incident date: Apr 3, 2025

Vehicle has many fault codes that will not clear. Took to dealership and the state they believe its a wheel speed sensor and vehicle is safe to drive. Flashing warnings include AWD system problem, electric parking brake problem, brake system problem, brake hold system problem, electric power steer... Read more

Incident date: Apr 3, 2025

Hello this is my second time filing for a complaint because the first time I did not receive an email confirmation. On Thursday night (April 4th) I was driving back home, I had just existed the highway and was now on a regular big busy street. I was driving approximately no more than 25 MPH. At the... Read more

Incident date: Mar 20, 2024

My SUV was sitting in the driveway and a crack appeared out of nowhere.

Incident date: Feb 28, 2025

Good morning Ford motor corporation headquarters as well as my advisor They are located at AutoNation Ford Torrance California this is with the 2015 escape eco-boost that should be on your lot. Anyway I took your advice and followed your directions and made contact with Ford motor corporation they d... Read more

Incident date: Feb 28, 2025

While driving my Pilots RPM suddenly dropped and started to go up and down. My car started to lose power and the car suddenly slowed down as if it wanted to turn off. I was stopped in the middle of the road and turned off the engine. Waited 2 minutes to turn on again and was able to get home. I che... Read more

Incident date: Oct 13, 2024

The other day approximately 5 minutes after leaving my house I noticed a smell and saw some slight smoke coming from my rear window. I immediately turned off the rear defrost and my rear window shattered. The next day I discovered other Chevy/gmc vehicles have a recall for a short circuit in the rea... Read more

Incident date: Oct 13, 2024

I was driving straight when a vehicle coming from the opposite direction made a left turn without yielding, crossing into my lane. As a result, my vehicle collided with the other car at full speed. However, the airbag in my steering wheel did not deploy upon impact, as it should have. My injuries ha... Read more

Crash 1 injured

Incident date: Feb 18, 2025

While steering and turning, the wheel continuously feels sticky and there is a clicking and squeaking sound when I begin to turn the wheel. It is available to inspect. This vehicle does not feel safe. I have had to turn the wheel with more effort when changing lanes on the highway causing overcorre... Read more

Incident date: Feb 18, 2025

Incident date: Feb 5, 2025

The engine in my 2015 Ford Escape failed due to coolant intrusion leading to the long block and coolant system needing to be replaced. The problem was diagnosed by the Ford service technician and Ford service advisor when it was taken in for service after the heating system stopped working, the car... Read more

Incident date: Feb 5, 2025

The contact owns a 2017 Buick Envision. The contact stated while driving 70 MPH, there was an abnormal sound coming from the windshield and the windshield shattered. The contact called the insurance company to get a list of places to repair the vehicle and provided an estimate for the repair. The ve... Read more

Incident date: Jun 27, 2023

This has been an ongoing issue since the date of purchase 10/23. I've been taking my vehicle for regular check ups and oil changes. My vehicle appears to be consuming oil. I have to put a quart in every week, but no one can find the issue. The dealership told me there is a recall on these particula... Read more

Incident date: Jan 27, 2025

in normal drive mode the transmission downs shifts thru the gears and skips from 3 to 1. becuase of that skip it feels like you got rear ended by another car. if your not prepared for it you could let off the brakes which could cuase you to hit the person in front. in sport mode it downshifts thru ... Read more

Incident date: Jan 27, 2025

I’m still waiting for the current recall to be corrected. The suspension is worn out. Replaced rear shocks, front struts, lower control arm. This is the worse automobile I’ve ever owned. If possible, I will never buy another ford. The car’s rear back up camera has been replaced and has stopped... Read more

Incident date: Sep 1, 2024

On Monday, August 5, 2024 when I started the vehicle and began driving to work I noticed upon startup the engine was clearly noticeably louder. It also made a strange bogging downshift type noise when idling. Upon driving, the noise seemed to go in and out but once reaching approximately 40mph the n... Read more

Incident date: Sep 1, 2024

The contact owns a 2018 Ram 2500. The contact received notification of NHTSA Campaign Number: 24V896000 (SERVICE BRAKES, HYDRAULIC); however, the parts for the recall repair were not yet available. The contact stated while driving 65 MPH, the brake pedal was depressed but the vehicle failed to stop ... Read more

Incident date: Jan 7, 2025

The contact owns a 2024 Honda CT125 Motorcycle. The contact stated that while riding at undisclosed speeds, debris from the wood trail was entering the skid pan near the exhaust. The contact was concerned about the potential fire risk. No warning light was illuminated. The local dealer was contacted... Read more

Incident date: May 1, 2024

I was in the middle of driving on the freeway and my motor started to get loss in power. Moments later a malfunction engine sign popped up. The codes I was able to pull from the vehicle were pointing towards a recall that already exists for BMW but for some reason my vehicle was not a part of the re... Read more

Incident date: May 1, 2024

The contact owns a 2018 Honda CR-V. The contact stated while the vehicle was parked, there was an abnormal odor coming from the vehicle. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with an internal coolant leak into the cylinder. The cont... Read more

Incident date: Dec 27, 2024

added information: the issue is the piston, it went off due to a bad part. Mercedes Benz knew about the issue with the type of engine M247. there is a class action lawsuit pending. But I'm reporting this because i didn't know and it happened to me just a month out of warranty. Now, the dealership is... Read more

Incident date: Dec 27, 2024

In my 2019 Ford Ranger, which has 75,570 miles, on [XXX], I was at a stop sign on [XXX] , at [XXX] , near Statesboro, GA, waiting for a break in traffic to safely cross. When a safe break occurred, I proceeded to cross, and at about the halfway point of crossing, the transmission bucked, and the tru... Read more

Incident date: Jan 7, 2025

Incident date: Dec 30, 2023

Airbag light has been lit for a while now for my 2004 Acura MDX. I originally took the car to Courtesy Acura for them to check what causing it. They told me that the sensor should be replaced and I paid $260+. After replacing sensor, the Airbag light still lit. They told me that they need to replace... Read more

Incident date: Dec 30, 2023

Incident date: Aug 13, 2024

I am experiencing two safety issues with my Canyon 1) Forward collision alert system is triggered unnecessarily (e.g., when there isn't a car in front of me, when the car in front is far away and not posing a risk). I took it to GMC a few months back since there was a previous recall for this syste... Read more

Incident date: Dec 14, 2024

Car seat is Chicco Fit 360 rotating car seat The lever to secure/relesse the seatbelt is directly inline with my child’s feet while rearfacing. When he rides he is able to kick the lever and release it allowing the seatbelt to be loose while the car is in motion. This happens 9/10 times he rides... Read more

Incident date: Dec 14, 2024

Incident date: Nov 2, 2024

my gear shifter in my 2021 Rogue was stuck in park. I was stuck in the middle of a 6 lane road. Car would not go into drive or reverse in heavy traffic or neutral. Had waited for police they arrived 15 minutes later car was able to engage drive . Then towed to Nissan of Rockville Center NY. I was in... Read more

Incident date: Nov 2, 2024

Started experiencing engine hesitation while driving during May, 2024. Dealer refused to accept that it is not related to the Recall (2016-21 Pilot Fuel Pump Mtr Saf Recall Exp2 NHTSA Recall Number23V-858), instead suggested for a fuel injector cleanup. I ended up spending $500 because my wife and k... Read more

Incident date: Aug 12, 2024

The contact owns a 2013 BMW X3. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the r... Read more

Incident date: Aug 12, 2024

Incident date: Sep 3, 2024

The contact owns a 2015 Ford Explorer. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the RPM increased to 6,000 and the vehicle lost motive power. In addition, the check en... Read more

Showing 50 of 92 complaints.

NHTSA Safety Ratings, 2014 BMW 528I

2014 BMW 528 I 4 DR RWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash, Driver	4 / 5 ★★★★☆
Frontal Crash, Passenger	4 / 5 ★★★★☆
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	5 / 5 ★★★★★
Rollover Risk	9.3%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Optional
Lane Departure Warning	Optional

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

EPA Fuel Economy, 2014 BMW 528I

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.0L 4-cyl, Automatic (S8) (Rear-Wheel Drive)	23.0	33.0	26.0	Premium	$2,950

CO2 Emissions: 335.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2014 BMW 528I

537 manufacturer communications from 236 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	75
350000 EQUIPMENT	69
060000 ENGINE (PWS)	62
356000 EQUIPMENT ADAPTIVE/MOBILITY	29
070000 FUEL SYSTEM, GASOLINE	24
060000 ENGINE AND ENGINE COOLING	24
353000 EQUIPMENT:ELECTRICAL	23
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)	16

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

The basic conditions for initializing the power windows are not met.

110000 ELECTRICAL SYSTEM

The basic conditions for initializing the power windows are not met.

110000 ELECTRICAL SYSTEM

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on ho

060000 ENGINE AND ENGINE COOLING

Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pre

070000 FUEL SYSTEM, GASOLINE

110000 ELECTRICAL SYSTEM

Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicle??A?A?s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) i

350000 EQUIPMENT

200000 WHEELS

The Dynamic Stability Control (DSC) warning light comes on while driving. The following DSC fault codes for the wheel speed sensors are stored: 480712 and/or 480715 and/or 480718 and/or 48071B They cannot be cleared, even though the whe

110000 ELECTRICAL SYSTEM

After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes repeatedly fails.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the following class action: Isley, et al. v. Bayerische Motoren Werke Aktiengesellschaft and BMW of North Am

070000 FUEL SYSTEM, GASOLINE

For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Fuel Injectors to 10 years/120,000 miles as determined by the vehicle's original in-service date.

140000 AIR BAGS

According to the customer, the airbag warning light was on, but it may not be illuminated when the vehicle arrives in the workshop. 1. ACSM fault code "930A60 - Seat occupancy detection, front passenger; malfunction" is stored. The fault ma

980000 UNKNOWN OR OTHER

220100 SEATS:BARRIERS

270000 LANE DEPARTURE

280000 BACK OVER PREVENTION

110000 ELECTRICAL SYSTEM

The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain MY2013 vehicles with option 609 (as of 7/2012 production). This uses map North America NEXT. The Headunit High 2 (HU-H2), also called N

350000 EQUIPMENT

Component specific limited warranty extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle Nitrogen Oxide (NOx) Sensor(s) to: 10 years/120,000 miles as determined by the ve

061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR

060000 ENGINE AND ENGINE COOLING

This bulletin outlines the procedure for checking the engine timing chains for wear, and should be completed in conjunction with SI B11 06 14, "N63 Customer Care Package." The N63CCP and N63 Engine Check the Timing Chain are NOT mandatory T

060000 ENGINE (PWS)

060000 ENGINE AND ENGINE COOLING

For the above-referenced vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the engine timing chain and oil pump drive chain modules to: 7 years/70,000 miles as determined by the vehicle's original in-service

060000 ENGINE AND ENGINE COOLING

BMW of North America, LLC (BMW NA) is extending the limited warranty for the engine timing chain and oil pump drive chain modules to: 7 years/70,000 miles as determined by the vehicle's original in-service date

100000 POWER TRAIN

030000 SERVICE BRAKES, HYDRAULIC

Inform the customer during a consultation that the M Compound (standard equipment) and M Carbon Ceramic (optional) brakes are high-performance brake systems which are designed for sporty, dynamic driving styles. As a side effect of the high

353000 EQUIPMENT:ELECTRICAL

With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the following class action: Gelis, et al. v. Bayerische Motoren Werke Aktiengesellschaft and BMW of North Am

105700 POWER TRAIN:DRIVELINE:CHAIN/BELT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

030000 SERVICE BRAKES, HYDRAULIC

060000 ENGINE AND ENGINE COOLING

BMW of North America, LLC BMW NA is extending the limited warranty for the engine timing chain and oil pump drive chain modules to: 7 years/70,000 miles as determined by the vehicle's original in-service date

350000 EQUIPMENT

Distribution of the following tool will be through the Automatic Tool Shipment Program

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Distribution of the following tool will be through the Automatic Tool Shipment Program

356000 EQUIPMENT ADAPTIVE/MOBILITY

Distribution of the following tool will be through the Automatic Tool Shipment Program

353000 EQUIPMENT:ELECTRICAL

TELEMATICS UNIT DEACTIVATION DUE TO 3G CELLULAR TECHNOLOGY DISCONTINUATION: The discontinuation of 3G cellular communication for Combox, TCB 3G and ATM 3G (Telematics ControlModule) can no longer be supported by the cellular network provide

011000 STEERING: STEERING WHEEL/HANDLE BAR

Diagnosis of Compound Brake System Complaints in M Vehicles: 1. Visible cracks are caused by high thermal stresses during rapid heating and cooling of the brake discs. Braking from high speed with cold brake components (less than 212 degree

045000 SERVICE BRAKES, AIR:DISC

160000 STRUCTURE

COLLECTION OF DRIVER'S AND PASSENGER'S SIDE AIR BAGS: BMW intends to perform evaluations and analyses on these side air bags.

060000 ENGINE AND ENGINE COOLING

N20 AND N26 ENGINE TIMING CHAIN AND OIL PUMP DRIVE CHAIN: Whining noise from the lower engine area near the engine oil pump that increases frequency when increasing the engine RPM. Wear on the engine oil pump chain drive and timing chain sp

350000 EQUIPMENT

070000 FUEL SYSTEM, GASOLINE

INCORRECT TORQUE SPECIFICATION FOR THE HIGH-PRESSURE PUMP IN ISTA: The current version of ISTA states the incorrect tightening torque for the High-Pressure pump M6 mounting bolts to the cylinder head cover. The correct tightening torque is

350000 EQUIPMENT

020000 SUSPENSION

TICKING NOISE FROM THE FRONT AXLE WHEN CORNERING: The customer may complain of a metallic ticking noise from the front axle, when cornering, maneuvering, parking or pulling away from a parking space.

203000 WHEELS:LUGS/NUTS/BOLTS/STUDS

TICKING NOISE FROM THE FRONT AXLE WHEN CORNERING: The customer may complain of a metallic ticking noise from the front axle, when cornering, maneuvering, parking or pulling away from a parking space.

350000 EQUIPMENT

TICKING NOISE FROM THE FRONT AXLE WHEN CORNERING: The customer may complain of a metallic ticking noise from the front axle, when cornering, maneuvering, parking or pulling away from a parking space.

356000 EQUIPMENT ADAPTIVE/MOBILITY

TICKING NOISE FROM THE FRONT AXLE WHEN CORNERING: The customer may complain of a metallic ticking noise from the front axle, when cornering, maneuvering, parking or pulling away from a parking space.

100000 POWER TRAIN

N20 and N26 Differential Pressure Sensor Fault: 195002 Stored in DME: The Service Engine Soon (MIL) light is on with the following differential pressure sensor fault stored: 195002 - Differential pressure sensor, tank vent valve, electrical

020000 SUSPENSION

CRACKING NOISES FROM THE FRONTAXLE AREA WHILE TURNING THE WHEELS, WHEN STATION: Cracking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers) or when turning the steering wheel while statio

030000 SERVICE BRAKES, HYDRAULIC

TICKING NOISE WHILE CORNERING WITHOUT THE BRAKES APPLIED: Ticking noise coming from front wheel while cornering without brakes applied, noticeable at low speeds. The vehicle must be moving.

200000 WHEELS

TICKING NOISE WHILE CORNERING WITHOUT THE BRAKES APPLIED: Ticking noise coming from front wheel while cornering without brakes applied, noticeable at low speeds. The vehicle must be moving.

118000 ELECTRICAL SYSTEM:SOFTWARE

NAVIGATION SYSTEM - REPORTING MISSING OR INCORRECT ROADMAP DATA: Do not replace parts and do not program the vehicle. Roads can change by up to 15% every year. To ensure the best navigation experience, we do everything in our power to creat

030000 SERVICE BRAKES, HYDRAULIC

TICKING NOISE WHILE CORNERING WITHOUT THE BRAKES APPLIED: This Service Information Bulletin (Revision 3) replaces SI B34 05 17 dated September 2017. Ticking noise coming from front wheel while cornering without brakes applied noticeable at

100000 POWER TRAIN

200000 WHEELS

280000 BACK OVER PREVENTION

050000 PARKING BRAKE

TAILGATE UNINTENTIONALLY OPENS: This Service Information Bulletin (Revision 4) replaces SI B51 30 16 dated March 2018. Trunk/tailgate may open when vehicle is locked Trunk/tailgate may open while the vehicle is in motion usually after stopp

140000 AIR BAGS

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

AUTOMATED ACTIVATION OF NAVIGATION SYSTEM DURING PDI/QC1: This Service Information Bulletin (Revision 2) replaces SI B65 22 14 dated October 2015. The INITIAL NAV enabling code no longer needs to be pre-ordered through the Parts department!

110000 ELECTRICAL SYSTEM

CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION: This Service Information Bulletin (Revision 7) replaces SI B84 02 14 dated May 2019. ConnectedDrive/BMW Assist features are partially or completely inoperative. This Service Informatio

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE (PWS)

LIMITED WARRANTY EXTENSIONTO 10 YEARS/120000 MILES: This Service Information Bulletin replaces SI B01 05 18 dated July 2019. Engine starts poorly (hard starting) rough idle and misfires. The Service Engine Soon (MIL) lamp is on.

030000 SERVICE BRAKES, HYDRAULIC

HELPFUL INFORMATION FOR CUSTOMER DISCUSSIONS REGARDING MOTORSPORT VEHICLE BRAKES: INFORMATION Inform the customer during a consultation that the M Compound (standard equipment) and M Carbon Ceramic (optional) brakes are high-performance bra

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

160000 STRUCTURE

NOISE FROM FRONT AREA: There is a hissing or wind noise present from the front area of the vehicle at speeds above 60 mph.

162800 STRUCTURE:BODY:HOOD

NOISE FROM FRONT AREA: There is a hissing or wind noise present from the front area of the vehicle at speeds above 60 mph.

350000 EQUIPMENT

SECURITY IMPROVEMENTS FOR CONNECTEDDRIVE. Security patches for non-safety critical vulnerabilities in BMW head units Entry Nav Entry Media NBT and NBT EVO.

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

The crankcase ventilation hoses may become brittle and break when they come in contact with hot engine components. One or more of the crankcase ventilation hoses are not FPM (fluoroelastomer) rubber material. The FPM rubber material is engi

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

DIAGNOSTIC HINT: CATALYTIC CONVERTER INSPECTION AFTER LOSS OF CRANKSHAFT SIGNAL. In certain situations when the crankshaft position signal is lost while driving the malfunction indicator lamp (MIL) and an engine malfunction check control me

353000 EQUIPMENT:ELECTRICAL

356000 EQUIPMENT ADAPTIVE/MOBILITY

350000 EQUIPMENT

N63 ENGINE: OIL CONSUMPTION CLASS ACTION SETTLEMENT DIAGNOSIS AND REPAIR PROCEDURES. While engine oil consumption may create a customer inconvenience in the short term it should not cause any drivability problems that would prevent normal d

060000 ENGINE (PWS)

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

ENGINE VIBRATIONS OR NOISE This Service Information bulletin replaces SI B11 01 19 dated February 2019.

060000 ENGINE (PWS)

ENGINE VIBRATIONS OR NOISE This Service Information bulletin replaces SI B11 01 19 dated February 2019.

070000 FUEL SYSTEM, GASOLINE

NEW REPLACEMENT FUEL TANK INTERNAL FUEL LINE CONNECTION. INFORMATION WARRANTY INFORMATION Not applicable. This Service Information bulletin provides technical and repair procedure-related information.

110000 ELECTRICAL SYSTEM

BLACK SPOT IN THE CENTRAL INFORMATION. This Service Information bulletin replaces SI B62 11 18 dated January 2019. Whats New: a?? Warranty section - Programming information added. A small black spot remains on the Central Information Displa

030000 SERVICE BRAKES, HYDRAULIC

"Carbon Ceramic Brake Noise. INFORMATION ""M"" vehicles are designed for high-performance, spirited driving. To accommodate this type of driving profile, a braking system which exceeds the standards for handling heavy brake forces, extreme

060000 ENGINE (PWS)

N63 AND N63T ENGINE: ENGINE OIL CONSUMPTION, ENGINE OIL TOP-UPS AND REFILL CAPACITY. Customers with one of the vehicles above may complain that the engine's oil consumption is "too high," resulting in engine oil top-ups and workshop visits

110000 ELECTRICAL SYSTEM

RAIN/LIGHT SENSOR (RLS): OIL LEAKAGE FROM GEL PAD. ??Oil leaking from the Rain/Light Sensor (RLS). Note: This oil serves as a separation medium between the RLS mounting gel pad and the windscreen. The oil ensures damage free disassembly in

110000 ELECTRICAL SYSTEM

?BMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT. BMW Online/BMW ConnectedDrive not functional. Vehicle and service cockpit have different ICC-ID's (Integrated Circuit Card Identifier).

110000 ELECTRICAL SYSTEM

?CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION. ConnectedDrive/BMW Assist features are partially or completely inoperative. This Service Information bulletin is being published because vehicles are down for an extended period of t

060000 ENGINE (PWS)

?ENGINE LEAK DIAGNOSIS ON TURBOCHARGED V8 ENGINES. When diagnosing an engine oil leak or a coolant leak on turbocharged V8 engines it is necessary to use a borescope to identify if the source of the leak is from under the turbochargers. En

060000 ENGINE (PWS)

N63 and S63 Engine: Valve Seal Replacement. Refer to the following applicable SIBs before replacing the valve seals. * B11 07 11 - Turbocharger Failure: Oil Supply and Return Line Blockage and Proper Repair * B11 07 12 - N63 Engine: Oil Con

350000 EQUIPMENT

CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION: ConnectedDrive/BMW Assist features are partially or completely inoperative.

220000 SEATS

MEMORY SEAT ADJUSTMENT IS LIMITED: After programming the vehicle with ISTA 4.10.2x, the adjustment range of the memory seat may restricted.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

110000 ELECTRICAL SYSTEM

BMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT: BMW Online/BMW ConnectedDrive not functional.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

BMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT: BMW Online/BMW ConnectedDrive not functional.

118000 ELECTRICAL SYSTEM:SOFTWARE

BMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT: BMW Online/BMW ConnectedDrive not functional.

110000 ELECTRICAL SYSTEM

COMFORT ACCESS SPORADICALLY INACTIVE VIA DOOR HANDLE: Sporadically, CA (Comfort Access) locking or unlocking of the vehicle does not work via the door handles.

021000 SUSPENSION:FRONT

CRACKING NOISES FROM THE FRONT AXLE AREA WHILE TURNING THE WHEELS, WHEN STATIONARY OR PARKING

021600 SUSPENSION:FRONT:WHEEL BEARING

CRACKING NOISES FROM THE FRONT AXLE AREA WHILE TURNING THE WHEELS, WHEN STATIONARY OR PARKING

200000 WHEELS

CRACKING NOISES FROM THE FRONT AXLE AREA WHILE TURNING THE WHEELS, WHEN STATIONARY OR PARKING

021000 SUSPENSION:FRONT

TICKING NOISE FROM THE FRONT AXLE WHEN CORNERING: The customer may complain of a metallic ticking noise from the front axle when cornering, maneuvering, parking or pulling away from a parking space.

021600 SUSPENSION:FRONT:WHEEL BEARING

TICKING NOISE FROM THE FRONT AXLE WHEN CORNERING: The customer may complain of a metallic ticking noise from the front axle when cornering, maneuvering, parking or pulling away from a parking space.

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

INSTRUMENT CLUSTER OUTSIDE TEMPERATURE DISPLAY IMPLAUSIBLE: In the Instrument Cluster (Kombi) display you may observe an implausible outside temperature reading.

353000 EQUIPMENT:ELECTRICAL

CONTACTLESS TAILGATE (SMART OPENER) IS TOO SENSITIVE: When the remote is located in the range of the Smart Opener operation may be the contactless tailgate (Smart Opener) opens / close unintentionally from objects in the vicinity of the rea

Showing 100 of 537 bulletins.

BMW 528I - All Years Overview

Complete safety history for the BMW 528I across all model years (2000, 2016).

28 Total Recalls

1,236 Total Complaints

0 Investigations

51 Reported Crashes

48 Reported Fires

0 Reported Deaths

BMW 528I - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2016	4	103	View
2015	1	105	View
2014 (current)	3	92
2013	4	119	View
2012	4	145	View
2011	4	164	View
2010	2	87	View
2009	2	33	View
2008	2	181	View
2007	1	1	View
2001	0	3	View
2000	1	53	View
1999	0	59	View
1998	0	39	View
1997	0	49	View
1980	0	2	View
1979	0	1	View

Other BMW Models

Model	Recalls	Complaints
X5	223	4,349	View
X3	155	2,661	View
330I	122	1,050	View
X6	110	293	View
328I	108	3,743	View
M3	95	550	View
325I	83	1,809	View
Z4	83	1,439	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2014 BMW 528I

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2014 BMW 528I

Safety Technology

EPA Fuel Economy, 2014 BMW 528I

Technical Service Bulletins, 2014 BMW 528I

Most Affected Components

BMW 528I - All Years Overview

BMW 528I - Year by Year

Other BMW Models