2010 BMW 528I Recalls, Complaints & Safety

The contact owns a 2010 BMW 528I. The contact stated that the vehicle was repaired under NHTSA Campaign: 23V707000 (Engine and Engine Cooling); however, the repair failed to prevent a failure. The contact stated that while attempting to start the vehicle, there was an abnormally loud rattling sound coming from under the hood. The check engine warning light was illuminated. The contact stated that while driving at an undisclosed speed in Manual Mode, the vehicle independently shifted to neutral(N), the steering wheel became firm, and the transmission failed to shift out of neutral. In addition, the contact stated that while attempting to accelerate from a stop, the vehicle hesitated while accelerating with the accelerator pedal depressed. The contact stated that the vehicle was towed back to the same local dealer on various occasions; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.

insulation on wiring is deteriorated leading to possible fire and or shorting out of electrical system

The contact owns a 2010 BMW 528I. The contact stated while making a left turn and depressing the brake pedal, the vehicle failed to respond as needed. The brake and transmission warning lights illuminated. A dealer was contacted. The contact pulled over to the side of the road, turned off the vehicle, and then attempted to restart the vehicle; however, the vehicle failed to respond as intended and was towed back to the residence. The vehicle was next towed to an independent mechanic, where it was diagnosed and determined that the camshaft and timing belt chain needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Numbers: 23V707000 (ENGINE AND ENGINE COOLING) and 22V119000 (ENGINE AND ENGINE COOLING); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue but offered no assistance. The failure mileage was 124,000.

They lied to me made me buy a bad car and then didn't even give me a license plate of anything they stole my money

I brought the car into BMW Manhattan after receiving the recall letter. They have refused to perfom the correction based on the fact that I had to replace the engine dues to a engine defect that cracked the number 6 cylinder in the original engine. I am confident BMW has the abilty to check the engine number and see that it requires the recall. They only stated it wasnt the original engine so they did not perform the work required by ther recall.

The car smells like gas by the rear wheels. In speaking with other owners of this vehicle this is a defective flaw in the vehicle it is a known problem in this vehicle and there has been no recall. This is a serious concern as gasoline is highly flammable. I have had to spend thousands of dollars fixing problems with this car and I cannot afford to fix this issue. This is a major concern. Please advise a fix ASAP

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving at an undisclosed speed, the vehicle stall and jerked while coming to a stop. The check engine warning light was illuminated. The failure mileage was approximately 178,000. VIN tool confirms parts not available.

N/A Complaint is that no remedy is available 8 months after recall issued. Currently this particular car is still drivable, but suffers oil leaks from this lack of repair. No local dealer or repair shops can fix ahead of the recall because they cannot get the repair bolts either. Eight months is a ridiculous amount of time to wait for a manufacture repair.

The contact owns a 2010 BMW 528I. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated and flashed. The vehicle was towed to the dealer where it was diagnosed that fuel was leaking form the engine. The contact was unaware of what part needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was taken to a local dealer, where it was diagnosed that the VANOS bolts needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure but confirmed that parts were not yet available. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000. VIN tool confirms parts not available.

When driving any acceleration will cause the car to shift from Drive to Neutral. This can happen under normal driving conditions and at any speed.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528I. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The driver was able to coast off the roadway. While at a stop, the vehicle stalled upon acceleration. Upon starting the vehicle, the vehicle started to shake. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, and the contact was referred to the local dealer. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. VIN tool confirms parts not available. The approximate failure mileage was 100,000.

Camshaft over retarded. Stalled while driving.

The contact owns a 2010 BMW 528I. The contact stated that upon starting the vehicle, there was an abnormal knocking sound coming from the vehicle. There were no warning lights illuminated. The contact continued driving at an unknown speed and then parked and had the vehicle towed to the residence. The vehicle was then towed to the local dealer, where it was diagnosed and determined that the engine needed to be replaced. The contact was informed that there was debris in the filter. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 132,553. The contact stated when he took his wife’s car for an oil service at the BMW dealership he was told that there was a VANOS Unit recall much to his surprise. However the VANOS Unit recall did not include all 2010 528i BMW’s. The contact is requesting this vehicle to be included in the recall.

There seems to be a common problem with these vehicles according to similar complaints being discussed in forums. My steering wheel is malfunctioning and creating a safety concern. While driving straight my horn and electrical controls do not function. If I turn the steering wheel to one side then the horn and electrical components work. I am also afraid that the airbag may not function properly because of this.

Bolts on the backside of the camshaft adjusters broke off and went into the engine.

i was in a rear end crash accident my fault fast airbag didn’t deploy significant damage to my face car was totaled

Crash 1 injured

This recall notice received almost 8 months back. This recall concerns me. I didn’t have any accidents to report but it’s too bad no remedy was given by BMW.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that after she scheduled an appointment at the local dealer, she was later made aware that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount time for the recall repair. The contact stated that while driving at an undisclosed speed, he attempted to operate the heater and noticed a fuel odor inside the vehicle. The contact then stated that smoke was coming from under the hood. There was no warning light illuminated. The vehicle was towed to the dealer but was not diagnosed. The contact was informed that parts were not available for the recall repair. The manufacturer was not notified of the failure. The contact stated that he noticed a fuel odor throughout the vehicle. The failure mileage was approximately 100,000. VIN tool confirms parts not available.

The "Secure from Rolling" alert pops up on screen and car is prevented from moving. Engine must be shut off and ignition turned back on to work. Gears/spring probably need replaced per error message.

The contact owns a 2010 BMW 528I. The contact stated that the vehicle was experiencing rough starts and the failure persisted while driving. The vehicle was taken to the dealer where it was diagnosed that the motor mounts had collapsed and needed to be replaced. Additionally, the oil pan gasket was leaking and needed to be replaced. The contact was also informed that the fuel sending unit needed to be replaced due to a fuel leak. The parts were replaced; however, upon replacing the oil pan gasket, the dealer noticed fragments of vanos adjuster units bolts used to fasten the intake and exhaust camshaft inside the oil pan. The dealer informed the contact that the cylinder head cover needed to be taken apart to verify whether the motor mounts were fractured. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 132,000. Manufacturer Safety recall issued NHTSA #22V-119 Recall #22V-119:407 POSITIVE CRANKCASE VENTILATION (PCV) VALVE HEATER Status: Remedy Available

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that while driving at various speeds, an abnormal whistling sound was coming from the vehicle. The contact stated that the RPM was fluctuating. There was no warning light illuminated. The contact stated the vehicle started vibrating as if it was going to stall. There was no warning light illuminated. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 90,000. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528i. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528i. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that while driving at various speeds, a fuel odor began to emit from the vehicle without warning. Upon inspection, the contact discovered that a grayish smoke had emitted from the rear valve cover. The contact then had the had the vehicle towed to the dealer and was informed that the PCV valve was normal; however, the valve cover gasket was defective and needed to be replaced. The manufacturer had yet to be notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle had yet to be repaired. The failure mileage was approximately 170,000. VIN tool confirms parts not available.

The contact owns a 2010 BMW 528i. The contact stated upon starting the vehicle, she smelled a burning odor and there was smoke coming from underneath the hood and through the vent. The (!) malfunction indicator warning light illuminated. The contact continued to drive the vehicle. Additionally, the contact stated that the vehicle would jerk intermittently while driving. The contact received recall notification of NHTSA Campaign Number: 17V683000 (Engine And Engine Cooling), which she associated with the failure. The dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 141,000. VIN tool confirms parts not available.

Fire

The contact owned a 2010 BMW 528i. The contact stated while driving approximately 65 MPH the vehicle started to shake and vibrate, additionally smoke began to issue from under the hood. The contact stated no warning light was illuminated. The contact was able to safely pull of the highway and shut off the vehicle, the smoke emission increased and the vehicle caught fire. The fire department arrived and extinguished the fire using water. The police were also on scene. The contact is not aware if any reports were written by police or fire department. The vehicle was towed to an impound lot due to being consumed completely by the fire. The manufacturer had not been informed of the failure. The failure mileage was approximately 168,000.

Fire

The contact owns a 2010 BMW 528I. The contact stated while driving 65 MPH, there was an abnormal knocking sound coming from the engine. The vehicle independently decelerated. The contact pulled over to the side of the roadway. The contact attempted to restart the vehicle however, the vehicle would not restart. The contact had the vehicle towed to a local dealer to be diagnosed. The contact was informed that there were two bolts missing from the camshaft which caused the vehicle to stall. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 155,000.

WHEN I'M AT A STOP MY CAR SUDDENLY JUMPS FORWARD WHEN I HAVE MY FOOT ON THE BRAKE THIS IS A ONGOING ISSUE. IT'S SCARY CAUSE I FEEL LIKE I'M GOING TO HIT SOMETHING OR SOMEONE IF I'M AT A STOP LIGHT AND SOMEONE IS CROSSING THE STREET MY CAR COULD JUMP AND HIT THEM. I DO NOT DRIVE THIS VEHICLE NO MORE CAUSE OF THIS. IT ALSO HAPPENS WHEN I'M DRIVING IT PICKS UP SPEED ON IT'S OWN. THIS HAPPENS WHEN EVER THE CAR IS DRIVEN ANYWHERE.

FOUND FAULTS FOR VANOS SYSTEM. I WAS DRIVING ON THE HIGHWAY AND CAR START MAKING A RATTLE NOISE LIKE SOMETHING BUCKING AGAINST SOMETHING AS I ACCELERATED.

FRONT PASSENGER AIR BAG SEAT OCCUPANCY SENSOR SYSTEM MALFUNCTION WARNING ILLUMINATED WHILE DRIVING ON 12/29/2019. LOOKS LIKE IT'S COVERED BY THIS SERVICE BULLENTIN HTTPS://STATIC.NHTSA.GOV/ODI/TSBS/2014/SB-10056703-9690.PDF HOWEVER, AFTER CONTACTING BMW, BMW REFUSED TO COVER. THIS IS A SERIOUS SAFETY ISSUE

TL* THE CONTACT OWNS A 2010 BMW 528I. WHILE DRIVING APPROXIMATELY 5 MPH AND ATTEMPTING TO MAKE A TURN, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE RESTARTED AFTER A FEW SECONDS, BUT THE FAILURE RECURRED SEVERAL TIMES. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 129,000.

THE INSULATON OF THE WIRING TO BOTH MY HEADLIGHT AND PARKING LIGHT LAMPS IS FLAKING OFF IN SMALL AND LARGE PIECES LEAVING THE COPPER WIRING EXPOSED.

AIRBAG / SEATBELT SENSOR FAULTY PASSENGER RESTRAINT SYSTEM MALFUNCTION ERROR ON THE SYSTEM. BMW HAD A RECALL EARLIER FOR 2004-2006 VEHICLES WHERE BMW REPLACES THE SEAT MAT FREE OF COST. I CALLED THE DEALER FOR MY 2010 528I AND THEY ARE SAYING THERE IS NO RECALL; HOWEVER I SEE THOUSANDS OF USERS ACROSS THE COUNTRY ARE COMPLAINING ABOUT THE SAME ISSUE.

TL* THE CONTACT OWNS A 2010 BMW 528I. THE CONTACT STATED THAT THE DRIVER'S SIDE HEADLIGHT AND BRAKE LIGHT WARNING INDICATORS ILLUMINATED AND THE EXTERIOR LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER AN UNKNOWN RECALL; THEREFORE, THEY COULD NOT ASSIST. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.

WHILE ACCELERATING THE CAR JUMPS INTO NEUTRAL RANDOMLY. WHETHER FROM A SLOW START OR ACCELERATING ON A HIGHWAY. IT HAS HAPPENED DOZENS OF TIMES AND THE DEALER SAYS THERE IS NO FIX.