2016 AUDI A3 Recalls, Complaints & Safety

This vehicle was involved in a rear end collision in late 2025. The vehicle was just sold at auction with a clean title even though it has frame damage that is more than 100% of the cost of this vehicle. It is sold with a clean title and I am worried that a used car dealership will try to sell it with no accident history and clean title to an unsuspecting person.

Crash 1 injured

This vehicle was involved in a rear end collision in late 2025. The vehicle was just sold at auction with a clean title even though it has frame damage that is more than 100% of the cost of this vehicle. It is sold with a clean title and I am worried that a used car dealership will try to sell it with no accident history and clean title to an unsuspecting person.

Crash 1 injured

This vehicle was involved in a rear end collision in late 2025. The vehicle was just sold at auction with a clean title even though it has frame damage that is more than 100% of the cost of this vehicle. It is sold with a clean title and I am worried that a used car dealership will try to sell it with no accident history and clean title to an unsuspecting person.

Crash 1 injured

FUEL LEAKED ALL MY GARAGE ALMOST CAUSING A FIRE IN MY HOME WHILE I WAS SLEEPING. I HAVE HAD THE FUEL TANK REPLACED 3 TIMES. AND I HAD TO PAY OUT OF POCKET TO HAVE IT REPLACED BECAUSE AUDI WOULD NOT REPLACE THE RECALL OF IT SO I AM REACHING OUT TO YOU SO YOU CAN REACH OUT TO AUDI ABOUT NOT STANDING BY THE RECALL PROCEDURE!

Fire

My 2016 Audi A3 Sportsback E-tron vehicle was parked at my house. When I went to start it the engine did nothing, no power. The message “Driver System Fault” and a red triangle with a red ! in the middle was displayed on the instrument panel. I was unable to start or operate the vehicle. I called AAA and they towed the vehicle to a Recharge Hybrid pump location near my house. I tired to charge the battery and it would just turn off. Then I called AAA again and they towed my car back to my house and checked the small 12 volt battery to see if that was the problem, they determined that the 12 volt battery still had 75% life in it. They were unable to get my vehicle started. The same message is still on the dashboard “Driver System Fault." The failure mileage is approximately 81,567. I want to know before I call the Dealer and get it towed again if this issue is the Hybrid High-Voltage Battery or the housing bonded seam could have lead to corrosion the service recall from a while ago. Service Action Code 93D2

The contact owns a 2016 Audi A3. The contact stated that while the vehicle was parked with the engine running, the vehicle experienced a sudden loss of motive power. During the failure, the message “Driver System Fault” was displayed on the instrument panel. The contact was unable to restart or operate the vehicle. The vehicle was towed to the dealer, where it was diagnosed and determined that the Hybrid battery had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 83,000.

Passenger airbag not activated when passenger is seated

Passenger Occupancy Detection System is malfunctioning. Pre-sense system fault

The rearview camera is failed. Yes I can have an inspection done. Yes, dealer confirmed that camera is failed but wanted hundreds of dollars to troubleshoot. Has not been inspected by police or insurance. No it just stopped working one day.

The rear wiper hose is consistently getting completely clogged so that no fluid comes out when the spray mechanism is engaged. The dealership has replaced it for a fee two or three times. At the last service they told us they cleaned it and did not charge a fee. However, within two months it was clogged again. I have noticed that the issue is more likely to occur after (intentionally or accidentally) using the rear window defroster. I am therefore wondering whether the hose is made of a plastic that is too soft, causing it to change shape as a response to the defroster heat.

Mechatronics unit failed, stalled on freeway nearly caused an accident behind me.

Passenger air bag not working light of airbag system stays on

The contact owns a 2016 Audi A3. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the dealer who diagnosed that the front passenger’s seat air bag sensor had failed and needed to be replaced. The vehicle was repaired under NHTSA Campaign Number: 21V198000 (Air Bags). The air bag warning was illuminated approximately one and a half years later. The vehicle was returned to the dealer who informed the contact that the repair was no longer covered under warranty. The vehicle had not been repaired. The manufacturer was made aware of the failure and a claim was opened. The failure mileage was approximately 67,000.

The **mechatronic unit** (integrated into the S-Tronic dual-clutch transmission) is the primary component that fails. This unit controls gear shifts, clutch engagement, and hydraulic pressure within the transmission. Common failure points include: - Internal electronic control module (ECU) faults. - Malfunctioning solenoids or pressure valves. - Software glitches or calibration errors. **2. Safety Risks** Mechatronic failure poses significant safety risks: - **Erratic Gear Shifts**: Sudden jerks, delayed engagement, or refusal to shift gears could lead to loss of vehicle control, especially in traffic or during overtaking . - **Limp Mode**: The transmission may default to a single gear (e.g., 3rd gear), severely limiting acceleration and braking responsiveness . - **Complete Gear Loss**: Loss of reverse or multiple forward gears increases collision risks during parking or low-speed maneuvers . --- **3. Confirmation by Dealers/Service Centers** Dealers and independent specialists can reproduce and confirm the issue through: - **Diagnostic Scans**: Fault codes like "implausible gear ratio," "valve electrical faults," or "clutch adaptation limits" often indicate mechatronic failure . - **Physical Testing**: Symptoms such as harsh shifting, RPM fluctuations, or transmission warnings (e.g., flashing PRNDS lights) are observable during test drives . - Audi has issued **Technical Service Bulletins (TSBs)** for related transmission issues, though the 2016 A3 e-tron’s mechatronic unit isn’t part of a formal recall.

The contact owns a 2016 Audi A3. The contact stated while driving 60 MPH, the Electronic Power Control System (EPC light) malfunctioned, and the vehicle lost power. The contact stated that the vehicle lost motive power, the temperature gauge raised with the radiator fan activated. The contact pulled over to the side of the road and the vehicle restarted immediately. No warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The vehicle was not repaired. The check engine warning light and the electronic power control system warning light was illuminating on and off. The manufacturer was notified of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

The contact owns a 2016 Audi A3. The contact stated that while the vehicle was parked, there was a strong fuel odor coming from the vehicle, and the vehicle hesitated while starting. Additionally, the contact stated that the failure persisted before starting. The vehicle was driven to an independent mechanic where it was diagnosed that there was an engine misfire and a leak in the fuel pump. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 16V647000 (FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING). The manufacturer was not notified of the failure. The approximate failure mileage was 92,000.

225/45r17 Dry rot on all four tires less than three years old - and actually used for fewer than 18 months as alternated with winter tires - crack runs entire circumference of tire - deep - at joining of sidewall to tread. Nokian has said that this is “cosmetic sidewall cracking” - there is nothing cosmetic about it and each tire dealer I have visited reports that the tires are unsafe and need to be replaced. This is also supposedly a known issue that Nokia has acknowledged but not provided any extra coverage for.

The contact owns a 2016 Audi A3. The contact stated that while refueling the vehicle, fuel started leaking from the vehicle. The contact stated that the vehicle was sputtering while being started. The failure occurred intermittently. There were no warning lights illuminated. The contact removed the EVAP hose and became aware that the hose was filled with gasoline. The contact became aware of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline); however, the VIN was not included. The dealer was contacted and made aware of the failure. The dealer confirmed that there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 95,000.

The contact owns a 2016 Audi A3. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine and low oil warning lights illuminated. The contact also became aware that there was fuel leaking from the charcoal canister. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer and was diagnosed and determined that the evaporative emissions and charcoal canister needed to be replaced. The contact was informed that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unavailable.

Audi continues to tell me that this recall has been completed yet Audi’s website clearly states of the recall has not been completed your website. States of the recalls not completed and car fractures that recalls not been completed. Yet they refuse to complete the recall in my car.

The suction jet pump inside the fuel tank is designed to purge fuel from the Evaporative Emissions (EVAP) system. This mechanism could leak and cause a fire. I have informed Audi about the issue but they indicated there isn't a fix for the repair currently. They even stated there isn't a deadline or date they could give me for the repair.

The contact owns a 2016 Audi A3. The contact stated that while driving at an undisclosed speed, the engine seized. The contact stated that there was an abnormally strong fuel odor inside the vehicle. Additionally, the contact stated that there was fuel leaking from the fuel tank. The vehicle was taken to the dealer where it was diagnosed with a failed suction jet pump. The contact was informed that the fuel tank and the EVAP charcoal canister needed to be replaced. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline). The contact expressed that the failure was very scary. The manufacturer was made aware of the failure. The failure mileage was approximately 41,259.

24V110-The suction jet pump inside the fuel tank, designed to purge fuel from the EVAP system is defected and if a specific seal inside an affected suction jet pump fails, the fuel may flow directly into the EVAP system. If this happens, fuel could accumulate in the EVAP system and may leak through the charcoal canister filter element. Leaking fuel, in the presence of an ignition source, may result in a fire. My live and the live of my children is at risk every time I/we drive my car, due to the fact that my car could catch on fire. It is just a matter of time and I am not willing to risk getting caught in a fire, getting hurt or even dying inside my car. There is no repair available and I can not wait any longer. I am requesting replacement of my car ASAP

EPC WARNING LIGHT IS COMING AND FUEL TANK NOT RESPONDING

What component or system failed or malfunctioned, and is it available for inspection upon request? Power Train system failed also engine light is now on How was your safety or the safety of others put at risk? Me and my toddler were in the vehicle when it started to jerk in bad traffic. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the mechanic said this is a serious problem and i should be concerned. He stated i should not drive my vehicle. It was inspected by a certified mechanic. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, everything happen at one time.

There is a current recall for 2015-2020 Audi A3 sedan models regarding the vehicles EVAP SYSTEM, and I believe my car is experiencing that same issue but my specific vehicle isn’t listed as it is a 2016 Audi A3 Premium Plus Sportback E-tron. My engine light is illuminated and when checked, the detecting device says the warning is due to a small leak from the EVAP system in the vehicle.

EL AUTO TIENE UN OLOR FUERTE A GAS Y CUANDO ME DETUVE VOTO GASOLINA POR LA PARTE DE ATRAS EN EL LADO TRASERO DEL PASAJERO. DESPUES INTENTE HECHARLE GAS Y SE LLENA EL CUELLO DEL TANQUE HASTA DESVOLDARSE. NO PERMITE LA ENTRADA DE GAS. AUTO NO TIENE CODIGO DE FALLA. ESTOY PREOCUPADO PORQUE ESTA SITUACION PODRIA OCACIONAR UN INCENDIO. ENCONTRE UN RECALL 20Y6/20Y5 EL CUAL SE REFIERE A MI PROBLEMA. QIERO SABER SI ESTE RECALL ME APLICA. GRACIAS

Car start running loosing fuel.

I was entering the interstate and accelerating to merge with the traffic. When I reached about 70 mph the car stalled and a message appeared, transmission faulty, no reverse, safe to continue to drive. The car was drivable at a low speed and a high rpm. After having it towed to an Audi dealership, I was informed that the transmission would need to be replaced. According to the dealership, the mechatronic unit was faulty due to an unknown short in the transmission.

Cust gasoline is spilling out of the rear part of the unit. The following complaint, was escalated to AUDi USA related to recall of the suction pump, campaign number 16V647000. My vehicle was replaced or completed the recall on 2017, as requested, approximately 1 years or less of the purchase. Now my vehicle presents the same situation with only 32,000miles and Audi, may be a quotation over $5300 to repair a car that have the same behavior or symptoms that the suction pump recall, with its a safety recall. The car didn't present in the dashboard any flag of malfunction to advise of the danger situation, was in the store parking and one person point me that the car is spill gasoline. The car was moved in the trolley crane to the mechanic's shop. The mechanics, told me that Audi, is responsible for this situation because was a recall. I called to Audi Puerto Rico, and uSA and told me that the car has 7 years, and it is out of warranty. I reiterated, that is a manufactured detects and Audi will be responsible because is a safety issue and the car didn’t present any advice of .

Gearshifter sensor going off. Been told this shifter issue can cause car to shift into a different gear at any given moment. Read plenty of forums reporting the same thing.

PODS system recall was fixed, but not properly, 3 months after it was "fixed" the passenger airbag is off warning comes on beeping loud and turns off and back on constantly. Super annoying and dealership won't do anything without paying a huge fee.

Backup Camera, not displaying image on dash screen. Big safety issue when parking, no visibility while backing up, viewing obstacles and parking. No the vehicle has not be inspected. No other warnings or messages prior to failure. Camera failed Friday 5/12/2023

At 100,000 miles my engine lost all compression in cylinder 4 causing the vehicle to suffer a serious lack of power and become a danger to drive. Upon further research I have found that this is not uncommon for the Audi/VW 2.0 Liter TFSI (direct injected) engines. It appears that injector issues lead to either lean or rich running conditions that essentially melt the pistons and/or rings. I did have to have the engine replaced as there was no way to reliably verify whether the engine could be re-built so another engine was sourced from a salvage yard. The entire cost for the job was roughly $9,000. Again, this appears to be more common than a person should expect for an engine with such low mileage.

I had a safety issue with the gas tank not accepting gas and spilling over and out. I replaced the gas tank and vapor canister, and costly labor. My car was taken to: Palm Beach Performance RO#: 11887 1761 Latham Rd West Palm Beach, FL 33409 Tel#: 561-932-8840

I've been told by the dealer that a fix for the PODS system recall is still not available. This is after almost a year and a half of the issue being known. My car is now regularly illuminating the airbag light and beeping for the passenger to put the seat belt on even if no one is using the seat. This is becoming very annoying and I'm told there is no way to fix this.

I have been trying to get this recall fixed since December 2019. This recall are pods needed to be replaced on the passenger seat. As of today, October 21, 2022, my passenger airbag is off at all times and is unable to provide safety for my passenger. This is due to the recall. I have contacted Audi multiple times and they are unable to help. I have documentation proof for everything. This is a safety hazard for my passenger. I am too afraid to drive my car.

the light on the passenger side airbag is on all the time and a letter explaining my car had a recall to fix the issue was received back in 2020. I've been informed and also researched myself that the passenger side should not be used due to the airbag malfunctioning and being dangerous and possibly fatal. For those reasons I don't have anyone sitting in that sear and actually I don't feels safe having anyone in the back of the car. The dealerships say they do not have the parts

The component failing seems to be the fuel system. It is unsafe because the vehicle shoots out fuel all over the place (which is a fire hazard) when I attempt to add fuel to the car. Even though this problem (for our vehicle) is listed on an Audi Technical Service Bulletin, they said that they have nothing to do with the problem. Audi won't inspect the problem just said I have to pay for any repairs. There were no warning lamps, etc. One day the car just starting spitting gas out and has become progressively worse as time has passed. Can only add an extreme minimum amount (about $5.00 worth or less) of fuel to the fuel tank before it shoots out all over the place. The Audi Technical Service Bulletin is uploaded below. We purchased the 2016 car about two years ago but haven't driven it much until recently.

The passenger airbag sign switch on and off while the passenger was on the seat.

I purchased my 2016 Audi A3 in April of 2020 from Audi San Diego. Less than a year later, I was getting airbag warning lights on my dash, as well as constant warning sounds when driving. I brought my vehicle into Audi San Diego, and they "fixed" the issue free of charge. A few months later, I started getting the same warning lights/sounds - this time, the passenger airbag was turning on and off even while somebody was sitting in the passenger seat. I received a recall letter in the mail shortly thereafter. When I called in the summer of 2021 to schedule a service appointment, I was told there was not yet a remedy to this recall and that in the next few months I should receive a phone call to schedule service. Over a year later, I called Audi San Diego to get an update (since I did receive a phone call as promised), and I am still told that there is no solution. For over a year now, I have been unable to have passengers in my front seat, due to the fear of the airbags not working in the event of a crash.