2020 ALFA ROMEO STELVIO

6 recalls, 36 complaints - 196 TSBs

BACK OVER PREVENTION:DISPLAY FUNCTION

Defect Description

Chrysler (FCA US, LLC) is recalling certain 2020-2025 Alfa Romeo Giulia and Alfa Romeo Stelvio vehicles. The printed circuit board and software for the rearview camera may contain defects that cause the rearview camera image not to display properly. As such, these vehicles fail to comply with the r... Read more

Consequence

A rearview image that does not display properly reduces the driver's view behind the vehicle, increasing the risk of a crash.

Remedy

Dealers will inspect and replace the radio, as necessary. In addition, dealers will update the rearview camera software, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed November 25, 2025. Owners may contact Chrysler customer service at 800-853-1403.... Read more

62,910 vehicles affected

Manufacturer: Chrysler (FCA US, LLC)

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

Defect Description

Chrysler (FCA US, LLC) is recalling certain 2019-2020 Alfa Romeo Giulia and Alfa Romeo Stelvio vehicles. The fastener that connects the brake pedal and the brake booster may have been improperly assembled during manufacturing, which can cause the brake pedal to detach from the brake booster.

Consequence

Brake pedal detachment can cause a loss of brake function and increase the risk of a crash.

Remedy

Dealers will inspect and repair, the brake booster connection, as necessary, free of charge. Owner notification letters were mailed March 18, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is E0B.

2,021 vehicles affected

Manufacturer: Chrysler (FCA US, LLC)

AIR BAGS:FRONTAL

Defect Description

Chrysler (FCA US, LLC) is recalling certain 2017-2024 Alfa Romeo Giulia, 2018-2025 Alfa Romeo Stelvio, 2019-2023 Fiat 500X, Jeep Renegade, and 2024 Fiat 500E vehicles. A seat belt buckle switch sensor may be improperly connected, preventing the front seat air bag from deploying as intended.

Consequence

A front seat air bag that does not deploy as intended can increase the risk of injury in a crash.

Remedy

Dealers will repair the connection, free of charge. Owner notification letters were mailed beginning August 27, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 82B.

337,128 vehicles affected

Manufacturer: Chrysler (FCA US, LLC)

SERVICE BRAKES, HYDRAULIC

Defect Description

Chrysler (FCA US, LLC) is recalling certain 2017-2020 Alfa Romeo Giulia and 2018-2020 Alfa Romeo Stelvio vehicles equipped with carbon ceramic matrix brakes. During certain driving maneuvers, the brake system may exert an excessive clamp force that may fracture the rotor, decreasing the brake perfo... Read more

Consequence

An unexpected decrease in brake performance increases the risk of a crash.

Remedy

Dealers will update the brake system module (BSM) software, free of charge. Owner notification letters were mailed July 20, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 68A.

719 vehicles affected

Manufacturer: Chrysler (FCA US, LLC)

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

Chrysler (FCA US, LLC) is recalling certain 2020-2021 Alfa Romeo Stelvio, and Alfa Romeo Giulia vehicles. The fuel line sensor housing may crack and leak fuel.

Consequence

A fuel leak may cause an engine stall, increasing the risk of a crash. A fuel leak also increases the risk of fire in the presence of an ignition source.

Remedy

Dealers will inspect and replace the fuel line sensor housing, as necessary, free of charge. Owner notification letters were mailed on January 11, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y91.

11,419 vehicles affected

Manufacturer: Chrysler (FCA US, LLC)

SERVICE BRAKES, HYDRAULIC

Defect Description

Chrysler (FCA US, LLC) is recalling certain 2019-2021 Alfa Romeo Stelvio and 2020-2021 Alfa Romeo Giulia vehicles. Hard braking may cause the Anti-Lock Brake System (ABS) Hydraulic Control Unit (HCU) rotor shaft to separate, a reduction of braking assist, and a loss of ABS.

Consequence

The loss of braking assistance and ABS functionality can reduce overall braking performance, increasing the risk of a crash.

Remedy

Dealers will replace the ABS HCU, free of charge. Owner notification letters were mailed on June 29, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403.

9 vehicles affected

Manufacturer: Chrysler (FCA US, LLC)

Complaint Statistics

36 total complaints 3 crashes 6 injuries

Top Reported Components

Component	Complaints
ELECTRICAL SYSTEM	6
POWER TRAIN	4
ENGINE	4
SERVICE BRAKES, HYDRAULIC	3
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING	3
STEERING	3
UNKNOWN OR OTHER	2
SERVICE BRAKES	2
WHEELS	1
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM	1

Incident date: Aug 10, 2026

I was parked in a parking lot and when I released my foot from the break, the car accelerated on its own and crashed into the car in front of me. The automatic emergency braking did not deploy. It was most recently a safety risk and put others in the parking lot, particularly the driver in front me,... Read more

Crash

Incident date: Nov 14, 2025

The contact owns a 2024 Forest River East to West Alta Trailer. The contact stated that while inspecting the trailer, it was discovered that the two rear tires on the driver’s and passenger’s side of the trailer were worn from the inner section of the tire. The trailer was taken to the local dea... Read more

Incident date: Nov 14, 2025

The contact owns a 2015 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V695000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The d... Read more

Incident date: Apr 24, 2026

Driver headrest deployed without any accident. I was sitting in my car and the headrest made a loud bang and hit the back of my head causing me whiplash

Incident date: Apr 24, 2026

On June 16, 2026, a 2021 Infiniti QX50 experienced a safety-related malfunction while being driven at approximately 15–20 mph. The vehicle suddenly jerked, lost power response, displayed multiple warning lights, showed a “System Fault – See Owner’s Manual” message, and became unresponsive/... Read more

Crash 3 injured

Incident date: Apr 24, 2026

Crash 3 injured

Incident date: Dec 19, 2025

My 2020 Toyota C-HR is exhibiting clear, escalating symptoms of the known K114 CVT internal bearing defect, creating an active safety hazard while driving. The transmission has not failed completely yet, but it regularly experiences high-pitched whining noise, sudden hesitation during acceleration, ... Read more

Incident date: May 21, 2026

Adaptive cruise control not working....,Intermitently shutting off. This is coinciding with numerous engine, oil and gas warning lights going off in the Audi MMI system. Lead tech at Audi dealership in Norwell MA is telling me that this is a well known issue with the 2025 Audi Q5 needing a softwar... Read more

Incident date: May 4, 2026

Clicking noise coming from the front axles when turning either right or left. ADAS settings seem to be too sensitive. Car slams on the emergency brake when backing out of a parking spot with no obstacles in view. Forward warning system alerts occur even though there is nothing in front of the car... Read more

Incident date: Dec 17, 2025

NHTSA ODI COMPLAINT UPDATE — #XXX 2024 Jeep Grand Wagoneer L | VIN: [XXX] Date of Update: April 15, 2026 Current Odometer: 94,896 miles This is a formal update to my previously filed NHTSA complaint (ODI #XXX) to document new evidence, continued defect progression, dealer misconduct, and retaliat... Read more

Incident date: Feb 20, 2026

The contact owns a 2020 Cadillac CT5. The contact stated that while driving at various speeds, the vehicle shuddered and experienced hard shifts intermittently. There was no warning light illuminated. The contact stated that the failure progressively worsened, and the vehicle made an abnormally loud... Read more

Incident date: Feb 20, 2026

Odometer Fraud. The contact purchased a 2011 Honda Pilot. It was discovered that there was a mileage discrepancy. The vehicle was a private sale from the Facebook Marketplace on 2/25/26. At the time of purchase, the vehicle mileage was 144,135. After retrieving a Carfax Report, the contact discovere... Read more

Incident date: Oct 22, 2025

Transmission failed to engage gear properly after backing up. Grinding sounds heard when vehicle was in drive. Problem has been confirmed and inspected by Chevrolet dealership. Vehicle is available for inspection. Occupants safety was at risk because gears could have locked up during commute causin... Read more

Incident date: Oct 4, 2025

The contact owns a 2016 Chevrolet Colorado. The contact stated while driving approximately 27 MPH and making a right turn, the steering wheel became difficult to turn. The contact stated that the failure initially occurred while making turns but had started occurring while driving straight. The cont... Read more

Incident date: Oct 4, 2025

The ABS, BREAK, and Traction Control, suddenly turned on when I was traveling on the freeway in mild traffic. I was traveling at about 60-65 mph. I attempted to use the breaks and could feel a substantial difference in how much and how hard I had to push in order to stop. The problem has not been co... Read more

Incident date: Oct 29, 2025

All of the electric warning lights turn on and the power steering goes out while I am driving.

Incident date: Oct 29, 2025

While cruising on the highway at 55 MPH, I received a dashboard error message that indicated "Service Shifter". At the same moment, the lights on the gear lever went dark. I immediately took my foot off the throttle pedal, activated my right indicator, and changed lanes into the exit lane to leave t... Read more

Incident date: Oct 29, 2025

All of the electric warning lights turn on and the power steering goes out while I am driving.

Incident date: Jul 19, 2025

In late May 2025, I took delivery of a new leased 2025 Rivian R1S equipped with the MaxPack battery. Since delivery, the vehicle has had intermittent electrical issues with the USB-C ports that I reported on June 12th (approx 3 weeks from taking delivery), but on July 28, 2025, it experienced a sudd... Read more

Incident date: Jul 19, 2025

The multipurpose camera failed bring down all driver assistance functionality including lane keep assist, emergency brake, auto high beam, parking sensors, cruise control, etc. fix is outrageously high $2500+. Internet search finds this to be a very common issue and deserves a recall.

Incident date: Jul 22, 2025

When i accelerate, the car jerks back and forth and stalls. ford has said the car was throwing codes but the TECH didnt feel the issue so they sent me on my way.... well fast forward to today, i am informed my car has thrown codes 4 times in the past few days and this morning i was scared to drive m... Read more

Incident date: Jul 22, 2025

The contact owns a 2019 Ram 1500. The contact stated that while his wife was driving at an undisclosed speed, the left turn signal failed to engage as intended. Additionally, the contact stated that the instrument panel displayed that the right turn signal had engaged independently while driving. Th... Read more

Incident date: Jul 22, 2025

Incident date: Aug 11, 2024

When I am backing out of my garage, the emergency brake activates. And my information screen is black, the volume goes up and down, and sometimes it does not connect to my cell phone.

Incident date: Aug 11, 2024

The vehicle was stopped, preparing to make a left-hand turn at a four-way intersection, in Drive with my foot on the brake. I had manually pressed the button to disable the "Auto Start-Stop" feature earlier in this trip, and the light was on indicating that feature was still disabled. While stopped,... Read more

Incident date: Aug 11, 2024

When I am backing out of my garage, the emergency brake activates. And my information screen is black, the volume goes up and down, and sometimes it does not connect to my cell phone.

Incident date: Feb 1, 2024

The contact owns a 2013 Kia Sorento. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact was adding additional oil after driving for thirty minutes. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was c... Read more

Incident date: Jan 16, 2024

I brought the 'new to me' truck to the dealership 2 weeks after purchase to address a known recall and a Customer Satisfaction Notification. The latter related to the PCM software to address an issue of staling (08A). No problems were experienced before the service nor were any services noted on t... Read more

Incident date: Jan 16, 2024

The contact owns a 2023 Honda HR-V. The contact stated that while driving at 50 MPH, the rear defroster was activated, and the rear window exploded. The vehicle was not diagnosed but was repaired by a mobile window repair company. The manufacturer was notified of the failure. The failure mileage was... Read more

Incident date: Jan 16, 2024

The contact owns a 2012 Hyundai Accent. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceed... Read more

Incident date: Jun 11, 2023

The contact owns a 2015 Hyundai Elantra. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall... Read more

Incident date: Jun 11, 2023

I was driving my car and it shut down in the middle of traffic on the freeway on [XXX] I thought I was dead I almost had a accident the car started back up and it did it again 4 times I am afraid to drive the car when it shuts down the steering wheel locks up and nothing happens I am so afraid of t... Read more

Incident date: Nov 10, 2022

When leaving to go to work, I pressed the button on the gear shift to put the car into reverse and then drive. I heard something click into the cupholders as I drove. It was the gear shift button. The plastic actuator button fell off completely. It would not fit back in. I think the plastic br... Read more

Incident date: Mar 16, 2021

ALFA ROMEO IN DETROIT, MI HAS BEEN CONTACTED, AND THE REPLY AFTER A ONE-DAY WAIT THAT THE TEAM CONCLUDED THAT THE TIRE ON THE CAR IS GOOD EVEN TRIED TO EXPLAIN THAT THE TOP SPEED OF AN ALFA ROMEO STELVIO TI SPORT AWD CAN RUN EASILY 140 MPH. THESE CONTINENTAL TIRES RATING 'H' TOP SPEED IS 130 MPH. A... Read more

EPA Fuel Economy, 2020 ALFA ROMEO STELVIO

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.0L 4-cyl, Automatic 8-spd (Rear-Wheel Drive)	22.0	29.0	25.0	Premium	$3,050

CO2 Emissions: 359.0 g/mile (Small Sport Utility Vehicle 2WD)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2020 ALFA ROMEO STELVIO

196 manufacturer communications from 85 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	46
060000 ENGINE AND ENGINE COOLING	18
350000 EQUIPMENT	18
160000 STRUCTURE	11
100000 POWER TRAIN	9
353000 EQUIPMENT:ELECTRICAL	9
060000 ENGINE (PWS)	5
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)	5

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On

118000 ELECTRICAL SYSTEM:SOFTWARE

USB Software Update to 131.010.002 for RAN Radio The customer may describe the following: ? Wrong temperature information is displayed on the performance page. This bulletin involves inspecting the software level to see if the radio need

020000 SUSPENSION

LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.

114000 ELECTRICAL SYSTEM:WIRING

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing

110000 ELECTRICAL SYSTEM

353000 EQUIPMENT:ELECTRICAL

Wireless Qi Charger Not Charging

110000 ELECTRICAL SYSTEM

Wireless Qi Charger Not Charging

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used

353000 EQUIPMENT:ELECTRICAL

Wireless Qi Charger Not Charging

060000 ENGINE AND ENGINE COOLING

Water Quality When Mixed With Engine Coolant

135000 VISIBILITY:REARVIEW MIRRORS/DEVICES

Mirror

060000 ENGINE AND ENGINE COOLING

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

350000 EQUIPMENT

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

110000 ELECTRICAL SYSTEM

160000 STRUCTURE

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: **Verify current warranty policy to d

160000 STRUCTURE

100000 POWER TRAIN

Vehicle Cranks, No Start

160000 STRUCTURE

110000 ELECTRICAL SYSTEM

Oil Change Monitor Displaying Prematurely This bulletin involves resetting the oil life monitor and if necessary changing the engine oil and filter. The customer may experience the oil change light illuminated on the dash shortly after ta

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

Check engine lamp/Mil lamp-on. Engine misfires.

060000 ENGINE AND ENGINE COOLING

Check engine lamp/Mil lamp-on. Engine misfires.

060000 ENGINE AND ENGINE COOLING

Check engine lamp/Mil lamp-on. Engine misfires.

160000 STRUCTURE

Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding

980000 UNKNOWN OR OTHER

163200 STRUCTURE:INTERIOR PANELS:DOOR

160000 STRUCTURE

110000 ELECTRICAL SYSTEM

Global Telematics Box Module (TBM2) Flash Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a custome

110000 ELECTRICAL SYSTEM

346000 COMMUNICATION:MANUFACTURER TELEMATICS

100000 POWER TRAIN

ACC Does Not Operate. Start Stop Unavailable, ACC Unavailable Service Required Messages. C1452-86 Engine Torque DASM- Signal Invalid

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Heating Ventilation and Air Conditioning (HVAC) Updates

060000 ENGINE AND ENGINE COOLING

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

350000 EQUIPMENT

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

110000 ELECTRICAL SYSTEM

No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting

980000 UNKNOWN OR OTHER

No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting

115000 ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting

100000 POWER TRAIN

No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting

350000 EQUIPMENT

Wireless Qi Charger Not Charging

353650 EQUIPMENT:ELECTRICAL:WIRELESS CHARGER/CRADLE

Wireless Qi Charger Not Charging

980000 UNKNOWN OR OTHER

Wireless Qi Charger Not Charging

353650 EQUIPMENT:ELECTRICAL:WIRELESS CHARGER/CRADLE

Wireless Qi Charger Not Charging

353000 EQUIPMENT:ELECTRICAL

Wireless Qi Charger Not Charging

119423 ELECTRICAL SYSTEM:PROPULSION SYSTEM:CHARGING:CABLE/CORD:ACCESSORY

Wireless Qi Charger Not Charging

353650 EQUIPMENT:ELECTRICAL:WIRELESS CHARGER/CRADLE

Wireless Qi Charger Not Charging

110000 ELECTRICAL SYSTEM

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off

980000 UNKNOWN OR OTHER

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off

114710 ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS:ACCESORY POWER OUTLET/JACK/PORT/USB/SAE/CIGARETTE LIGHTER

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off

353000 EQUIPMENT:ELECTRICAL

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation After Key Off

353000 EQUIPMENT:ELECTRICAL

Wireless Qi Charger Not Charging

020000 SUSPENSION

FCW Light Is On. DTC Revealed Misaligned DASM. Alignment Pins Not Properly Seated

140000 AIR BAGS

FCW Light Is On. DTC Revealed Misaligned DASM. Alignment Pins Not Properly Seated

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

FCW Light Is On. DTC Revealed Misaligned DASM. Alignment Pins Not Properly Seated

270000 LANE DEPARTURE

U0422-64 Set In The FFCM/HALF Module. Lane Departure And Blindspot Warning Displayed In The Cluster

353000 EQUIPMENT:ELECTRICAL

Media Device Connection Guidelines For Bluetooth, Apple CarPlay, Android Auto Or USB To The Radio Head Unit

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

The customer?s complaint includes a Mil/check engine lamp-on condition. Upon further investigation, a P1CEA - Boost Side Evap Purge System Performance DTC may be set in the PCM with no other DTCs set.

110000 ELECTRICAL SYSTEM

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration

110000 ELECTRICAL SYSTEM

No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration

060000 ENGINE AND ENGINE COOLING

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

060000 ENGINE AND ENGINE COOLING

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Customer complaint includes a Mil-on condition. Upon further investigation, one or more of the following fault codes may be set in the PCM:

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Customer complaint includes a Mil-on condition. Upon further investigation, one or more of the following fault codes may be set in the PCM:

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

Customer Complaint May Include Engine Oil Leak Or Consumption

060000 ENGINE AND ENGINE COOLING

Customer Complaint May Include Engine Oil Leak Or Consumption

114000 ELECTRICAL SYSTEM:WIRING

WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Please email pictures of harness defects to FCA Re

110000 ELECTRICAL SYSTEM

Flash: Heating, Ventilation and Air Conditioning (HVAC) Module Updates This bulletin involves reprogramming the HVAC control module with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumin

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

110000 ELECTRICAL SYSTEM

120000 EXTERIOR LIGHTING

061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

353000 EQUIPMENT:ELECTRICAL

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination After Key Off

110000 ELECTRICAL SYSTEM

Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination After Key Off

100000 POWER TRAIN

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message

110000 ELECTRICAL SYSTEM

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message

110000 ELECTRICAL SYSTEM

Battery Tester Warranty Code Procedures, Midtronics Charger Update Process

350000 EQUIPMENT

Battery Tester Warranty Code Procedures, Midtronics Charger Update Process

100000 POWER TRAIN

Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders

110000 ELECTRICAL SYSTEM

Battery Tester Warranty Code Procedures, Medtronic Update Process

350000 EQUIPMENT

Battery Tester Warranty Code Procedures, Medtronic Update Process

100000 POWER TRAIN

Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usag

060000 ENGINE AND ENGINE COOLING

Customer complaint may include engine oil leak/consumption.

060000 ENGINE AND ENGINE COOLING

Creak Noise From Front Of Vehicle

110000 ELECTRICAL SYSTEM

Flash: Body Control Module (BCM) Updates This bulletin involves reprogramming the BCM with the latest available software. Customers may experience the following:When using the remote start feature after the vehicle has completely cooled d

160000 STRUCTURE

Creak Noise From Front Of Vehicle

350000 EQUIPMENT

Creak Noise From Front Of Vehicle

110000 ELECTRICAL SYSTEM

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

A/C does not cool and vehicle is low on Freon charge but no leak is found with sniffer or black light anywhere in the system

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

A/C does not cool and vehicle is low on Freon charge but no leak is found with sniffer or black light anywhere in the system

060000 ENGINE AND ENGINE COOLING

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Showing 100 of 196 bulletins.

ALFA ROMEO STELVIO - All Years Overview

Complete safety history for the ALFA ROMEO STELVIO across all model years (2018, 2025).

43 Total Recalls

349 Total Complaints

0 Investigations

20 Reported Crashes

5 Reported Fires

1 Reported Deaths

ALFA ROMEO STELVIO - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2025	2	2	View
2024	3	4	View
2023	4	12	View
2022	3	10	View
2021	6	9	View
2020 (current)	6	36
2019	8	56	View
2018	11	220	View

Other ALFA ROMEO Models

Model	Recalls	Complaints
GIULIA	88	380	View
TONALE	22	18	View
SPIDER	16	4	View
GT VELOCE	7	0	View
ALFETTA	7	0	View
164	5	15	View
BERLINA	5	0	View
GTV	3	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2020 ALFA ROMEO STELVIO

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2020 ALFA ROMEO STELVIO

Technical Service Bulletins, 2020 ALFA ROMEO STELVIO

Most Affected Components

ALFA ROMEO STELVIO - All Years Overview

ALFA ROMEO STELVIO - Year by Year

Other ALFA ROMEO Models