Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 692 bulletins for MINI
M000314
Sep 1, 2014
350000 EQUIPMENT
"?Incorrect Vehicle Identification Number (VIN) Labels Installed. Twenty-six ""Model Year 2014"" vehicles have incorrect VIN labeling that indicates they are ""Model Year 2015."" Incorrect VIN labels were applied at the factory. The 9th an
M011214
Sep 1, 2014
350000 EQUIPMENT
"MINI ""AMP-up"" Motorer Care Fleet Increases. MINI USA, a division of BMW of North America, LLC (""MIN USA""), is pleased to introduce the Aftersales Mobility Program (AMP) Motorer Care Fleet Increase. The ""AMP-up"" program is designed to
M121014
Sep 1, 2014
060000 ENGINE (PWS)
Service Action: Program Control Units (DME). Due to unfavorable DME software, the engine idle speed may be unstable and fluctuate at times.
M121114
Sep 1, 2014
100000 POWER TRAIN
"CCM ""Drivetrain: Drive Moderately"" with Misfire Faults Stored. The Check Control Message ""Drivetrain: Drive Moderately"" is displayed; however, the engine is performing normally. Misfire faults are stored only in the following cylinder
M121214
Sep 1, 2014
100000 POWER TRAIN
"This Service Information bulletin supersedes SI M12 12 14 dated September 2014. SUBJECT VANOS Faults Stored in DME (Bosch). The Service Engine Soon (MIL) is on and the engine could go into a reduced power mode with the ""Drivetrain Malfunc
M121314
Sep 1, 2014
060000 ENGINE (PWS)
"The Service Engine Soon (MIL) On with Fault 102001: Air Mass Too High. The Service Engine Soon light (MIL) is illuminated with the Check Control message: ""Drivetrain: Drive Moderately"" displayed. Fault 102001: Air mass too high is stored
SIM-12-12-14
Sep 1, 2014
060000 ENGINE (PWS)
MINI: DUE TO ENGINE POSITION MANAGEMENT (EPM) UNFAVORABLE PARAMETERS, IN DME SOFTWARE, VARIOUS CONTROL FAULTS ARE SET AND ENGINE CAN GO INTO POWER MODE, WHILE DISPLAYING DRIVETRAIN MALFUNCTION MESSAGE. MODEL 2011-14 F56 (COOPER, COOPER S)
BMS-32-30-6
Aug 21, 2014
356000 EQUIPMENT ADAPTIVE/MOBILITY
MINI: A BACKORDER ON PARTS, (32-30-6-763-722) FOR STEERING SPINDLE AND IS CURRENTLY OPEN FOR ORDERING BY DEALERS, FOR DOWN VEHICLE SITUATIONS. *PE UPDATED 2/3/15. *PE
M110414
Aug 1, 2014
060000 ENGINE (PWS)
N16 Engine: Oil Leak from Cylinder Head Sealing Plug. An oil leak can develop at a sealing plug located in the cylinder head, just below the vacuum pump. CAUSE The sealing plug was not tightened sufficiently during production.
M310114
Aug 1, 2014
010000 STEERING
Knocking Noise from Front of Vehicle when Turning. While driving or with the vehicle stationary, a knocking or popping noise can be heard from the front of the
M320114
Aug 1, 2014
010000 STEERING
Power-assisted Steering Intermittently Not Available at Engine Start-up. An EPS warning lamp may light up in the instrument cluster intermittently at engine start-up. At the same time, the power-assisted steering is unavailable. After switc
M320214
Aug 1, 2014
010000 STEERING
Installation of Right-Hand Drive Steering Spindle in Left-Hand Drive Vehicle. Supply shortage of left-hand drive steering spindles
SIM-00-03-14
Aug 1, 2014
355100 EQUIPMENT:OTHER:LABELS
MINI: THE MISLABELING OF INCORRECT VIN ON SOME VEHICLES INDICATING THEY ARE 2015 WHEN IN ACTUALITY THEY ARE 2014, AT TIME OF MANUFACTURING. MODEL F56 (COOPER, COOPER S). *PE
SIM-31-01-14
Aug 1, 2014
010000 STEERING
MINI: THERE IS NOISE, POPPING OR KNOCKING, HEARD FROM FRONT OF VEHICLE, WHEN DRIVING OR STATIONARY, AND TURNING STEERING WHEEL TO LOCK POSITION AND IS CAUSED BY SCREW THAT IS CONNECTED BETWEEN CONTROL ARM AND SWIVEL BEARING. MODEL F56 HAR
SIM-32-01-14
Aug 1, 2014
016000 STEERING:ELECTRIC POWER ASSIST SYSTEM
MINI: WHEN ENGINE IS STARTED, POWER ASSISTED STEERING IS NOT AVAILABLE AND INTERMITTENT AND WOULD TURN IGNITION OFF AND BACK ON AGAIN BEFORE POWER ASSISTED STEERING IS AVAILABLE. MODEL F56 (HARDTOP 2 DOOR). *PE
SIM-32-02-14
Aug 1, 2014
010000 STEERING
MINI: IT IS POSSIBLE, ON VEHICLES WITH LEFT HAND DRIVE, CAN HAVE THE RIGHT HAND DRIVE STEERING SPINDLE INSTALLED. MODEL R50 (COOPER), R52 (COOPER CONVERTIBLE, COOPER S CONVERTIBLE), R53 (COOPER S). *PE
M120514
Jul 1, 2014
060000 ENGINE (PWS)
?Service Engine Soon Lamp (MIL) On with DME Fault 120408 Stored. The Service Engine Soon lamp (MIL) is illuminated with a reduction of engine power. Fault 120408: Charging pressure control: Switch-off, pressure build-up blocked is stored in
M120614
Jul 1, 2014
060000 ENGINE AND ENGINE COOLING
At operating temperature, the engine idle speed could dip low. In rare cases, the engine may stall, requiring a restart. This could mostly likely occur at a low speed (2nd gear) when coasting off the throttle and slowing to a stop. This sit
M120714
Jul 1, 2014
100000 POWER TRAIN
B38M Shuts Off when Placed into Gear After Cold Engine Start. After a cold start, the engine idles poorly and could shut off when the transmission in placed into Reverse or Drive position. Unfavorable DME software.
M120814
Jul 1, 2014
070000 FUEL SYSTEM, GASOLINE
Various Check Control Messages with Fault 11B033 Stored in DME. A drivetrain or MSA malfunction Check Control message may be displayed, along with a Service Engine Soon light (MIL). DME fault 11B033: Fuel pump control module (FPC), signal:
M510614
Jul 1, 2014
130000 VISIBILITY
Squeaking Noise When Operating Front Windshield Wiper. A squeaking noise can be heard when operating the front windshield wiper. Fitment between the cowl panels and the left windshield wiper post
SIM-12-07-14
Jul 1, 2014
060000 ENGINE (PWS)
MINI: WHEN TRANSMISSION IS PLACED IN EITHER DRIVE OR REVERSE POSITION, THE ENGINE WOULD IDLE POORLY AND SHUT OFF, AFTER COLD START, DUE TO SOFTWARE ISSUES. MODEL F56 (COOPER). *PE
SIB-B33-01-14
Jun 13, 2014
021300 SUSPENSION:FRONT:SHOCK ABSORBER
MINI: A REMINDER IS PROVIDED REGARDING THE PROCESSING FOR SHOCK ABSORBER AND IMPLEMENTATION OF VIN SPECIFIC PARTS ORDERING. MODEL F56 MINI HARDTOP. *PE UPDATED 9/4/14. *PE
SIM-33-01-14
Jun 5, 2014
022400 SUSPENSION:REAR:SHOCK ABSORBER
MINI: INSTRUCTION INFORMATION ON PERFORMING CAMPAIGN FOR SHOCK ABSORBER REAR AXLE. *PE A MALFUNCTIONING DAMPER VALVE OF REAR SHOCK ABSORBER WAS FITTED TO SOME VEHICLES. MODEL 2014 F56. UPDATED 10/10/14. *PE
M010514
Jun 1, 2014
100000 POWER TRAIN
MINI CVT Replacement Parts Warranty Extension: Additional 12 Months with Up to 50,000 Accumulated Miles. A MINI vehicle's CVT assembly or component that was previously repaired and/or replaced by an authorized MINI dealer or BMW center may