Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 3,689 bulletins for MAZDA
05-001-17-3309c
Oct 9, 2017
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
Some vehicles may exhibit one or more of the following symptoms with the manual transmission. ? A grinding noise occurs when the transmission is shifted from 1st to 2nd and/or from 2nd to 3rd gear or in the neutral position with the engine
02-007-17-3337a
Oct 6, 2017
020000 SUSPENSION
Some vehicles may exhibit one or more of the following noises from the front suspension: 1. A creaking noise from under the front of the vehicle (front lower arm bushing) when driving over bumps at approximate 12 - 25 mph (20 - 40 Km/h). Th
15-006-17-3388
Oct 6, 2017
030000 BRAKES (PWS)
Some customers may complain about one or more warning lights ON when they start the vehicle during hot weather. The following DTCs are stored in memory: U3000:98 - Forward sensing camera (FSC) stops functioning due to temporary high tempera
05-003-17-3389
Oct 5, 2017
030000 BRAKES (PWS)
Some customers who drive at elevations higher than 3,300 ft (1,000 m) may complain of a shift shock felt when shifting into 3rd, 5th and/or Reverse with no AT related DTCs stored. The symptom can be temporarily repaired using the AT initial
09-012-17-3334b
Oct 3, 2017
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Some vehicles may experience unusual noise coming from inside the front door panel when playing the audio system. This is caused by the damper coming off the speaker frame due to corrosion. To correct the issue, a plating process was added
07-004-17-3332a
Sep 12, 2017
356000 EQUIPMENT ADAPTIVE/MOBILITY
Some customers may complain about warm air from the climate control vents. This may be caused by improper brazing (A) of the evaporator (B), causing a refrigerant leak from the joint between the tubes (C) and the header (D).
SA-067-17
Sep 12, 2017
114000 ELECTRICAL SYSTEM:WIRING
Due to a change in the 2017 Mazda3, Mazda6 and 2018 CX-9 A-pillar wiring harness, the EC Mirror w/compass / EC Mirror w/compass + Homelink installation instructions have been updated.
SA-068-17
Sep 12, 2017
140000 AIR BAGS
STOPPER PLATES FOR AIR BAG MODULE CONNECTORS HAVE BEEN ESTABLISHED AS NEW SERVICE PARTS. When removing the connector (1) to the air bag module (2), make sure to first lift the stopper plate (3) carefully using a flathead screwdriver (but do
09-039-17-3385
Sep 11, 2017
162700 STRUCTURE:BODY:TRUNK LID
Some vehicles may exhibit paint rust/blister on the vertical surface of the trunk lid. This is caused by silica contained in snow-melting agents adhering to the trunk lid. To correct this issue, the thickness of the clear coat has been incr
09-038-17-3383
Sep 8, 2017
110000 ELECTRICAL SYSTEM
Some vehicles may exhibit a buzzing noise from the driver (A) and/or passenger (B) side headrest speaker(s) when playing the audio system. This noise is caused by the upper part of the speaker interfering with the headrest pad. To correct t
07-007-17-3384
Sep 8, 2017
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Some customers may complain about poor heater performance even after the engine reaches normal operating temperature. This may be caused by a clogged heater unit. For Mazda6 and CX-5, the check engine light may illuminate with the DTC P011A
15-003-17-3284b
Sep 8, 2017
127000 EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS
Some customers may notice that the Lane Departure Warning System (LDWS) and High Beam Control (HBC) (amber) warning lights are on when they start driving around dusk or dawn under low temperatures. At that time, the windshield is clear but
SA-066-17
Sep 1, 2017
121300 EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH
Some vehicles may have DTC C1001:92 stored in memory. DTC C1001:92 sets as a past record for low visibility of the Forward Sensing Camera (FSC). It does not mean there is an actual FSC defect. In some cases the customer may have a concern
15-001-17-3301a
Sep 1, 2017
118000 ELECTRICAL SYSTEM:SOFTWARE
Some vehicles with Blind Spot Monitoring (BSM) may experience the following conditions (similar to when the BSM control modules detect dirt on the rear bumper surface): DTC U1A4B:97 - Radar sensor sensitivity temporarily decreases depending
02-003-17-3300c
Aug 29, 2017
010000 STEERING
Some vehicles may exhibit a knocking / squeaking noise from the front shock absorber when driving on rough roads and/or when turning the steering wheel while the vehicle is stopped. The noise may be due to: Upper front strut bearing (A) dam
09-030-17-3362a
Aug 29, 2017
160000 STRUCTURE
Some vehicles may exhibit a wind noise (A) from the area between the front (B) and middle (C) roofs when driving at speeds over 37 mph (60 km/h). Due to parts variation, some vehicles may have a poor sealing between the weatherstrips of the
01-011-17-3364a
Aug 25, 2017
060000 ENGINE (PWS)
If a customer brings their vehicles in with DTC P2183:00 stored, repair the vehicle using the following Repair Procedure and Caution. P2183:00: ECT sensor No.2 circuit range/performance problem. This is caused by the ECT sensor No.2 locate
01-012-17-3382
Aug 24, 2017
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This service information provides basic Q-85/T-110 battery handling procedures. Complete service information can be found in MGSS online or Workshop Manual (section 13-17).
09-037-17-3381
Aug 24, 2017
160000 STRUCTURE
Some customers may complain that the the middle headliner looks loose at the center rear. This is caused by parts variation. To correct the concern, an additional fastener can be installed in the headliner.
15-003-17-3284a
Aug 24, 2017
120000 EXTERIOR LIGHTING
Some customers may notice that the Lane Departure Warning System (LDWS) and High Beam Control (HBC) (amber) warning lights are on when they start driving around dusk or dawn under low temperatures. At that time, the windshield is clear but
09-017-17-3347c
Aug 23, 2017
110000 ELECTRICAL SYSTEM
Some vehicles may experience the symptoms mentioned below, which can be fixed with the latest software update (Version 59.00.502 or later). NOTE: For 2016 CX-9 with version earlier than 59.00.441, the tachometer function will be removed fro
06-002-17-3367
Aug 22, 2017
010000 STEERING
Some vehicles may exhibit an unusual noise (clacking) from under the front of the vehicle. This noise only occurs when starting to move the vehicle while the steering wheel is turned to the full left position. NOTE: The noise will not occu
04-002-17-3316b
Aug 11, 2017
030000 SERVICE BRAKES, HYDRAULIC
Some vehicles may exhibit a squeak noise when applying the brakes and/or groove marks (A) on the front disc plates. This is caused by abrasive metal from the front disc plate sticking to the brake pad, which damages the disc plate over time
SA-065-17
Aug 10, 2017
353000 EQUIPMENT:ELECTRICAL
Use the symptom troubleshooting tables below to diagnose MAZDA CONNECT concerns. MAZDA CONNECT Symptom Troubleshooting Table Sections: Audio System, Bluetooth?, Center Display, DTC, i-ACTIVESENSE, Maintenance Monitor, Navigation, Noise, Reb
09-036-17-3375
Aug 9, 2017
220000 SEATS
On some vehicles, the second-row seat back does not fold (B) or slide (C) forward when the walk-in lever (A) is pulled up to access to the 3rd row seats. Also, the recliner lever knob (D) may not operate on some vehicles. These concerns may