Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 3,689 bulletins for MAZDA
SA-049-19
Nov 20, 2019
060000 ENGINE AND ENGINE COOLING
Some customers may complain about a Mazda Mobile Start (MMS) system malfunction. Use the information below to troubleshoot the customers complaint: ??A?A? MAZDA MOBILE START (MMS) TROUBLESHOOTING GUIDE ??A?A? CANNOT COMMUNICATE WITH VEHICLE
SA-039-19a
Nov 20, 2019
060000 ENGINE AND ENGINE COOLING
During BCM replacement, MDARS may display a Configuration Error warning message. This may be caused by any of the following: ??A?A? Poor internet connection ??A?A? MDARS failure ??A?A? Low Battery Perform the BCM Recovery Procedure below to
SA-048-19
Nov 18, 2019
060000 ENGINE AND ENGINE COOLING
Some customers may expierience one or more of the following: ??A?A? intermittent no start ??A?A? engine stall ??A?A? many DTC's stored ??A?A? no communication with the PCM. This may be caused by a poor C-11 or C-12 electrical connection.
07-006-19-3629b
Nov 18, 2019
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Some customers may experience that after starting the engine, the auto A/C blows warm air for about 10 minutes and then blows cool air as desired. This concern occurs when the ambient temperature is within a certain range (approx. 16-25 C /
01-018-19-3642
Nov 14, 2019
060000 ENGINE AND ENGINE COOLING
Some vehicles that have a drained battery recovered may exhibit that the engine will not start and the ignition switch will not turn off. The following DTC's may also be stored: ??A?A? U3000:49 - BCM internal malfunction ??A?A? B10E7:12 - I
01-017-19-3601
Nov 14, 2019
060000 ENGINE AND ENGINE COOLING
Some customers may complain about a vibration through the driver and passenger seats at idle in (D)rive and (R)everse when the engine rpm drops down to 550. This vibration is caused by: 1.5L The No.3 and No.4 engine mount rubber hardening d
MSP27
Nov 14, 2019
118000 ELECTRICAL SYSTEM:SOFTWARE
Mazda Motor Corporation has decided to conduct a Mazda Service Program (MSP) on certain 2019 Mazda3 5HB vehicles produced from November 6, 2018 through May 28, 2019. Concern Outline: On certain subject Mazda3 5HB vehicles with the advanced
RF-18-02R3
Nov 14, 2019
200000 WHEELS
On May 1, 2018, Japan produced vehicles starting using 17 mm hex lug nuts instead of 21 mm on the same size thread. When installing new lug nuts or the accessory Wheel Lock Set, make sure to use the appropriate part number for the vehicle y
DRW27
Nov 8, 2019
130000 VISIBILITY
On certain subject vehicles, it is possible that the chrome plated window moldings may be dirty or have rust spots. The subject vehicles were parked outside when Typhoon No.17 passed through Hiroshima and Hofu, Japan, and might have been e
07-001-19-3630b
Nov 6, 2019
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
Be advised that TSB 07-001/19 is no longer valid and has been superseded to "SSPB8 - 2016-2017 CX-3 A/C CONDENSER WARRANTY EXTENSION".
SA-047-19
Nov 6, 2019
110000 ELECTRICAL SYSTEM
Some customers may have one or more of the following complaints: ??A?A? Infotainment system reboots at times ??A?A? SiriusXM function grayed out ??A?A? SiriusXM stops playing ??A?A? No sound from SiriusXM but other sources work ??A?A? Siriu
SA-046-19
Nov 5, 2019
110000 ELECTRICAL SYSTEM
On the 2019 Mazda3 (BP) and and all 2020 Mazda vehicles (except CX-3), the CR2032 button cell battery is required for the new type remote transmitter. If it is mistakenly replaced with the conventional CR2025 used in the previous type remot
09-038-19-3596
Nov 4, 2019
120000 EXTERIOR LIGHTING
Some customers may complain that the headlights are not as bright as they had previously been. This is caused by a dulled headlight reflector in the front combination light. To correct this issue, a service part reflector (internal part for
04-006-19-3643
Nov 4, 2019
030000 SERVICE BRAKES, HYDRAULIC
Some vehicles may exhibit a groan noise from the front brakes when braking at a very low speed (approximately 6 mph / 10 km/h). This may be caused by a brake torque variation at that speed due to an inappropriate machining process of the br
07-007-19-3638
Nov 4, 2019
060000 ENGINE (PWS)
Some customers may complain about poor heater performance even after the engine reaches normal operating temperature. This may be caused by a plugged heater core. For 2014-2016 Mazda6 and 2013-2016 (US spec) / 2017 (Mexico spec) CX-5, the C
15-003-3597a
Oct 30, 2019
260000 FORWARD COLLISION AVOIDANCE
Some vehicles may exhibit DTC B14F0:76 [VCM] (Forward sensing camera (FSC) deviation) stored in memory and the i-ACTIVSENSE warning light (amber) on after BCM replacement. This is caused by the learning value of the forward sensing camera (
SA-045-19
Oct 30, 2019
110000 ELECTRICAL SYSTEM
Currently, Mazda does not have a way to cut the auxiliary keys for the new style remote transmitter as they use a different key code than the previous transmitter key. Follow the repair procedure if one or both auxiliary keys are lost:
SA-044-19
Oct 24, 2019
060000 ENGINE AND ENGINE COOLING
The "FORCED IGNITION ON PROCEDURE" was made available to dealers through this service alert.
SSPB6b
Oct 17, 2019
110000 ELECTRICAL SYSTEM
2014-2016 Mazda3 - Mazda Connect Touch Screen Concern Warranty Extension Program - Special Service Program (SSP) B6
SA-043-19
Oct 17, 2019
110000 ELECTRICAL SYSTEM
On 7th generation vehicle (2019-2020 Mazda3 (BP) and 2020 CX-30 (DM)), when the door is opened/closed with the ignition switch off, the battery current is approximately 7A, which is three times larger than previous generation models (2.5A o
SSPB8a
Oct 17, 2019
350000 EQUIPMENT
The warranty coverage for the repair of the A/C Condenser due to refrigerant leak from condenser caused by corrosion is extended to 7 years (84 months) from the original New Vehicle Limited Warranty (Normal Warranty) start date, with no mil
09-037-19-3636
Oct 16, 2019
070000 FUEL SYSTEM, GASOLINE
Some customers may experience one or both of the following: The ??A?A?Next Service Date??A?A? setting under Vehicle Status Monitor in the center display changes to ??A?A?Manual??A?A? by itself after being set to ??A?A?Automatic??A?A? and ev
07-006-19-3629a
Oct 10, 2019
350000 EQUIPMENT
Some customers may experience that after starting the engine, the auto A/C blows warm air for about 10 minutes and then blows cool air as desired. This concern occurs when the ambient temperature is within a certain range (approx. 16-25 C /
SSPB6a
Oct 9, 2019
110000 ELECTRICAL SYSTEM
2014-2016 Mazda3 - Mazda Connect Touch Screen Concern Warranty Extension Program - Special Service Program (SSP) B6
MT-003-19
Oct 8, 2019
060000 ENGINE AND ENGINE COOLING
Some customers may complain about high engine oil consumption. Before attempting any repairs, verify the complaint by using the guideline below to determine if an engine repair is necessary: