Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 3,689 bulletins for MAZDA
DRW50
Jul 1, 2022
171200 LATCHES/LOCKS/LINKAGES:DOORS:LOCK
A small number of vehicles were produced with the incorrect mechanical front door key and key lock cylinder installed. The repair will be an inspection or replacement of the key and key lock cylinder.
SA-029-22a
Jun 29, 2022
160000 STRUCTURE
Customers may report excess wind noise from the vehicle and that noise may be coming from the crossbars or that the sunroof will not open because it contacts a crossbar or the load on the cross bars. As noted in the crossbar instructions, t
SA-044-22
Jun 29, 2022
060000 ENGINE AND ENGINE COOLING
Some customers may complain about an unusual thumping / rattling noise coming from the engine compartment. The noise is most pronounced under the following conditions: - Engine at idle - Transmission in drive - Foot on the brake pedal -
01-007-22
Jun 27, 2022
060000 ENGINE AND ENGINE COOLING
Some vehicles may have coolant leaks at the cylinder head around the exhaust manifold (as shown below). There may be cracks at the stud bolt hole or at the outside of the exhaust manifold. Cracks may be caused by: - Deformation of the exh
SA-043-22
Jun 27, 2022
264100 FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA
FSC dynamic aiming (mid-drive aiming) may not complete if the vehicle is driven on a road as described below: - The road lane markings are covered by snow and are not visible. - There are no road lane markings on the road surface. - The
SA-041-22
Jun 22, 2022
110000 ELECTRICAL SYSTEM
Some customers may complain about infotainment center display: - Ghost Touch (Touch screen operates by itself) - Surface Peeling - Spider Cracks Repair kits are available to replace just the screen. There is no need to replace the entir
01-006-22
Jun 22, 2022
110000 ELECTRICAL SYSTEM
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. For new vehicles in st
SA-042-22
Jun 22, 2022
163100 STRUCTURE:INTERIOR PANELS:DASHBOARD
Some customers may complain about a vibration / rattle noise coming from the dash above the instrument cluster. This may be caused by an active driving display unit and or warped / deformed active driving display lens.
01-005-22
Jun 21, 2022
060000 ENGINE AND ENGINE COOLING
Some customers may experience a check engine light illumination with DTCs P24C6:00, P24C7:00, P24AE:00, P24B1:00 and/or P24AF:00 stored in PCM memory. - P24C6:00 - PM sensor: internal temperature sensor malfunction (1DC DTC) - P24C7:00 -
09-023-22
Jun 17, 2022
350000 EQUIPMENT
Some customers may complain about spider web-like cracking (as shown below) appearing in the corner(s) of the MAZDA CONNECT center display. The cracks are internal and cannot be felt by touch. This concern may be caused by a lack of glue b
SA-040-22
Jun 15, 2022
120000 EXTERIOR LIGHTING
Some customers may report hearing noise from their headlamps. While some noise is normal from the electric motor, if it is louder in one headlamp than the other or both are significantly louder than a known good vehicle, follow the steps be
09-022-22
Jun 14, 2022
170000 LATCHES/LOCKS/LINKAGES
Some vehicles may exhibit the fuel-filler or charge lid opening unintentionally when unlocking the front doors using the door lock switch, the touch sensor on the outer door handle, or the remote transmitter. This is caused by a mechanical
06-002-22
Jun 14, 2022
010000 STEERING
Some vehicle may exhibit a knocking noise from the steering column while driving. This may be caused by a gap between the intermediate shaft (upper side) and the joint bolt. To eliminate this concern, the intermediate shaft and the joint bo
30-001-22
Jun 14, 2022
110000 ELECTRICAL SYSTEM
Some customers may complain about insufficient driving range after the vehicle is fully charged in winter. This is caused by a larger power consumption of the high voltage battery from the heater, resulting in a shorter driving range. To el
SA-039-22
Jun 10, 2022
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Some customers may complain about scratches on the instrument cluster lens.
09-017-22a
Jun 9, 2022
160000 STRUCTURE
Some vehicles may have rust on the contact parts between the clips (for attaching the roof molding) and the roof panel (ditches of the roof rail). This is caused by the gap between the roof molding attachment clips and the roof panel not b
SA-027-22b
Jun 9, 2022
350000 EQUIPMENT
Before beginning installation of the accessory illuminated door sill plate, review the information in this Service Alert or the parts may not fit correctly.
SA-004-22c
Jun 9, 2022
110000 ELECTRICAL SYSTEM
Customers having MAZDA CONNECT concerns should have their vehicle repaired using the following repair procedure.
04-002-22a
Jun 9, 2022
030000 SERVICE BRAKES, HYDRAULIC
Some vehicles may exhibit a squeak noise from the rear brakes while braking lightly and occurs more frequently when driving at slow speeds. The noise is caused by poor contact between the guide plate and the mounting support. To eliminate t
SA-038-22
Jun 7, 2022
100000 POWER TRAIN
Service part Automatic Transaxles (ATX) manufactured on or after July, 2018 are shipped with a blank TCM that requires configuration.
09-021-22
Jun 7, 2022
350000 EQUIPMENT
Some vehicles may exhibit a malfunction where the touch screen operates by itself (ghost touch). An example ghost touch would be the map on the center display scrolls without touching it. This is caused by heat expansion and contraction of
09-003-22a
Jun 6, 2022
160000 STRUCTURE
Some vehicles may exhibit the following malfunctions: - The film on the center display is peeling off, as shown in the illustration below. This may be caused by cleaning the center display surface. Water and/or a cleaning solution may get
SA-037-22
Jun 3, 2022
160000 STRUCTURE
Customers may complain about either rear fender liner (mudguard) hanging down because it is too short to fit into the fender trim.
09-020-22
Jun 1, 2022
110000 ELECTRICAL SYSTEM
Some vehicles may exhibit a warning message displayed in the center display a few seconds after the brake system warning light in the instrument cluster has flashed for a moment at the time of departure or stop of the vehicle. This is caus
15-004-22
Jun 1, 2022
110000 ELECTRICAL SYSTEM
Some vehicles may exhibit the warning messages "Safety and Driver Support Systems Temporarily Disabled" or "Front Radar Obscured. Drive Safely." displayed in the instrument cluster despite no dirt on the front radar sensor while driving in