Technical Service Bulletins
Search 172,063 manufacturer communications covering 879 vehicle makes from 1955 to 2025.
Showing 3,689 bulletins for MAZDA
06-001-23
Feb 16, 2023
010000 STEERING
Some vehicles may exhibit wear/peel-off of the leather steering wheel surface causing a poor appearance. This concern may be caused by an insufficient wear resistance of the steering wheel surface.
01-005-23
Feb 16, 2023
060000 ENGINE AND ENGINE COOLING
Some customers may experience the check engine light ON with DTC P0126:00 (Thermostat stuck open) and one or more of the following symptoms: The engine takes longer to warm up. The engine temperature gauge fluctuates. The low coolant temper
09-013-23
Feb 16, 2023
110000 ELECTRICAL SYSTEM
Some customers may experience electrical devices that cannot be charged through the rear console or the trunk side trim USB power outlet. This may be caused by an excessive external force applied to the USB power outlet. To eliminate this c
04-001-23a
Feb 13, 2023
030000 SERVICE BRAKES, HYDRAULIC
Front Brake Noise Symptom 1: Some vehicles may exhibit a click noise when first moving forward or reverse from a stop OR when first applying the brakes while moving forward at slow speeds. This is caused by deteriorated grease between the b
01-002-23a
Feb 10, 2023
060000 ENGINE AND ENGINE COOLING
Some vehicles may have coolant leaks at the cylinder head around the exhaust manifold (as shown below). There may be cracks at the stud bolt hole (1) or at the outside of the exhaust manifold flange (2) on the cylinder head.
09-012-23
Feb 9, 2023
220000 SEATS
Some customers may complain that the seat warmer does not operate when turning the ignition on while the seat is warm but when turning the ignition off then on again, the seat warmer begins to operate appropriately. DTCs a??B1030:13a?? and/
09-011-23
Feb 9, 2023
130000 VISIBILITY
Some vehicles may exhibit power outer mirror(s) that do not completely fold in and/or out. NOTE: This concern is unrelated to frozen mirrors in icy weather where snow or ice need to be removed for the mirrors to fold in and/or out. This con
SA-010-23
Feb 9, 2023
030000 SERVICE BRAKES, HYDRAULIC
Some customers may experience one or more electrical malfunctions after a vehicle body repair. The newly painted fender stay (2) may be causing a poor front harness (1) ground connection.
09-010-23
Feb 9, 2023
130000 VISIBILITY
Some vehicles may exhibit a condition where the power outer mirror will not fold in and/or out when the outer mirror holding switch (1) is operated. This may be caused by: 1. The electric fold-in unit inside the outer mirror may be damaged
09-008-23
Feb 7, 2023
110000 ELECTRICAL SYSTEM
Some vehicles may experience the seat ventilation system still on after the engine has been turned off, in some cases this causes the battery to be completely discharged and not rechargeable. This is caused by a deterioration in the seat ve
SA-007-23
Feb 7, 2023
100000 POWER TRAIN
The rear differential case could develop a crack in the case. NOTE: This could affect new vehicles just delivered to the dealer as well as customer vehicles. This concern is caused when the sliding bearing (1) in the coupling (2) is seized
09-009-23
Feb 7, 2023
160000 STRUCTURE
Some customers may report hearing an unusual noise coming from the power liftgate (PLG) when it is unlatching to open or latching closed. This is caused by an internal fault in the liftgate latch and/or loose bolts holding the latch to the
RF-23-03
Feb 6, 2023
160000 STRUCTURE
Due to a supplier change in Dec 2022, bonnet part number BHY0-52-31XA (with seam sealer) will be discontinued and replaced by new part number BAY0-52-31X which does not contain seam sealer. Seam sealer will need to be applied when the hood
SA-009-23
Feb 6, 2023
060000 ENGINE AND ENGINE COOLING
Some customers may complain about any of the following: Infotainment Center Display does not provide the Authorization Code during the MyMazda App Connected Vehicle enrollment. Remote function(s) inoperative. Engine Start / Stop, Door Lock
01-004-23
Feb 3, 2023
060000 ENGINE AND ENGINE COOLING
Some vehicles may have the check engine light on with DTC P0524:00 or P055F:00 stored in memory. Contamination in the engine oil may cause the engine oil solenoid valve to become stuck, resulting in improper operation of the oil pump and im
01-001-23a
Feb 3, 2023
060000 ENGINE AND ENGINE COOLING
Some customers may complain about a poor acceleration and rough idling or the CHECK ENGINE light ON with DTC P0301:00, P0302:00, P0303:00, P0304:00.NOTE: Only turbo engines are applicable; non-turbo engines are NOT applicable. In most cases
SA-008-23
Feb 2, 2023
010000 STEERING
Some vehicles may exhibit a steering shimmy or body vibration during the PDI test drive or during the first few miles of driving after the vehicle has been delivered to the customer due to flat spots on the tires. Flat spots on tires may be
09-007-23
Feb 1, 2023
220000 SEATS
At PDI or when new vehicle is delivered, some customers may complain about wrinkles on the leather seat cushion and/or seat back surface. Customers having this concern should have their vehicle repaired by a qualified upholstery repair spec
07-002-23
Feb 1, 2023
110000 ELECTRICAL SYSTEM
Some customers may complain that the ambient temperature on the instrument cluster is displayed more than 50 A?F (10A?C) lower than the actual temperature, resulting in insufficient performance of the air conditioning. This is caused by ina
01-003-23
Jan 31, 2023
060000 ENGINE AND ENGINE COOLING
Some vehicles may have a "LOW ENGINE OIL LEVEL" warning message and an engine oil level warning light on in the instrument cluster with DTC P250F:00 stored in memory, and the oil level has actually decreased to near low. - DTC P250F:00 - E
SA-007/23
Jan 27, 2023
100000 POWER TRAIN
The rear differential case could develop a crack in the case NOTE: This could affect new vehicles just delivered to the dealer as well as customer vehicles. This concern is caused when the sliding bearing in the coupling is seized and cau
RF-23-02
Jan 25, 2023
110000 ELECTRICAL SYSTEM
Due to the supply chain shortages for BDGF-66-5G0G, hardware has been confirmed compatible between BDGF-66-5G0B up to the G suffix. This can be used for repair with vehicles originally equipped with C to G level suffix parts.
SA-006/23
Jan 23, 2023
110000 ELECTRICAL SYSTEM
Some customers may complain about the infotainment system and/or the MyMazda App showing incorrect clock and/or tire pressures and/or tire pressure missing. This may be caused by: - Incorrect calendar entry (month/day/year) after a batter
16-002-23
Jan 23, 2023
110000 ELECTRICAL SYSTEM
Some vehicles may experience the symptoms mentioned below, which can be fixed with the latest software update (Version 7000C0A-NA03_11048 or later).
RF-23-01
Jan 23, 2023
060000 ENGINE AND ENGINE COOLING
When servicing SKYACTIV engine vehicles requiring to replace the Oil Galley Plug and Crush Washer, order the required part numbers below. These parts are not listed in GEPC and were previously listed as "non-serviceable" in the cylinder blo