Vehicle Safety Recalls

VOLVO C40BEV (2023) — AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volvo Car USA, LLC (Volvo Car) is recalling certain 2023-2024 Volvo C40 vehicles. The clamps may be improperly crimped on the driver's side inner far side air bag module (FSAB), which can cause the air bag to deploy improperly.

2 vehicles affected Manufacturer: Volvo Car USA, LLC

Consequence: An air bag that deploys improperly may not protect the driver as intended during a crash, increasing the risk of injury.

Remedy: Dealers will replace the driver's side inner FSAB, free of charge. Owner notification letters were mailed January 24, 2025. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10296.

TESLA CYBERTRUCK (2017) — TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monit...

696,281 vehicles affected Manufacturer: Tesla, Inc.

Consequence: Driving with improperly inflated tires increases the risk of a crash.

Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.

CUMMINS POWER GENERATION GENERATOR SET (2022) — ELECTRICAL SYSTEM:WIRING

Cummins, Inc. (Cummins) is recalling certain 2022-2024 Power Generation C275D2RE trailer-mounted generators. The unsecured wire leads may chafe against the starter motor housing or terminal and short circuit.

205 vehicles affected Manufacturer: Cummins, Inc.

Consequence: A short increases the risk of electrical shock or a fire.

Remedy: Distributors or warranty repair locations will inspect and repair the generator set wiring harness and secure the wiring leads, free of charge. Owner notification letters were mailed February 7, 2025. Owners may contact Cummins customer service at 1-800-286-6467. Cummins' number for this recall i...

VINFAST VF 8 (2023) — AIR BAGS

VinFast Auto, LLC (VinFast) is recalling certain 2023-2025 VF8 vehicles. The center air bag mounted in the driver's seat may deploy improperly during a side impact crash and strike the driver's arm.

4,888 vehicles affected Manufacturer: VinFast Auto, LLC

Consequence: An air bag that strikes the driver increases the risk of injury.

Remedy: Dealers will replace the center air bag, free of charge. Owner notification letters were mailed January 23, 2025. Owners may contact VinFast customer service at 1-833-503-0600.

CUMMINS B6.7 — ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

Cummins, Inc. (Cummins) is recalling certain B6.7 Diesel Engines part numbers RA11741 and RA11769, and F3.8 Diesel Engines part numbers RA 11789 and RA00074. The incorrect rubber elbow was installed in the liquid cooling system. The elbow can expand and leak coolant.

203 vehicles affected Manufacturer: Cummins, Inc.

Consequence: A high temperature coolant leak increases the risk of injury to bystanders.

Remedy: Dealers will replace the rubber hose elbow, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Cummins customer service at 1-800-286-6467. Cummins' number for this recall is C7119.

INVISION 3-BURNER COOKTOP — EQUIPMENT:APPLIANCE:OVEN/STOVE/COOKTOP

Dicor Corporation (Dicor) is recalling certain InVision Three Burner Cooktops, model number 410-2030. The aluminum burner tube may crack and cause a gas leak.

876 vehicles affected Manufacturer: Dicor Corporation

Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.

Remedy: InVision will inspect and replace the center burner tube, as necessary, free of charge. Owner notification letters are expected to be mailed January 15, 2025. Owners may contact Dicor customer service at 1-574-264-2699.

MITSUBISHI FUSO RIZON FEC7K (E16) (2024) — ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION MOTOR:CONTROLLER

Mitsubishi Fuso Truck of America, Inc. (MFTA) is recalling certain 2024 FEC7K and FEC9K RIZON trucks. Excessive current may damage the circuit and cause the vehicle control unit to malfunction, resulting in a loss of drive power.

243 vehicles affected Manufacturer: Mitsubishi Fuso Truck of America, Inc.

Consequence: A loss of drive power can increase the risk of a crash.

Remedy: Dealers will inspect and replace any discolored or deformed connectors as necessary and install a sub harness, free of charge. Owner notification letters were mailed January 20, 2025. Owners may contact MFTA customer service at 1-877-711-0707. MFTA's number for this recall is C10131.

FEATHERLITE 7821 (2023) — EQUIPMENT:APPLIANCE:OVEN/STOVE/COOKTOP

Featherlite Trailer Manufacturing, LLC (Featherlite) is recalling certain 2023-2024 Living Quarters Horse Trailers, models 7821, 7841, 9807, and 9808. The cooktop may have a rubber gas line instead of a copper line.

30 vehicles affected Manufacturer: Featherlite Trailer Manufacturing, LLC

Consequence: The rubber line may overheat, increasing the risk of a fire.

Remedy: Dealers will install a copper extension, free of charge. Owner notification letters were mailed July 8, 2025. Owners may contact Featherlite customer service at 1-800-800-1230.

MERCEDES-BENZ SPRINTER 1500 (2019) — ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter vehicles. The instrument cluster illumination may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."

697 vehicles affected Manufacturer: Daimler Vans USA, LLC

Consequence: A display that is too bright can make it difficult for the driver to see critical safety information, increasing the risk of a crash.

Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed January 31, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BELKOM.

FOREST RIVER R-POD (2025) — EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS:TANK ASSEMBLY

Forest River, Inc. (Forest River) is recalling certain 2025 RPOD RPT197 and RPT205 travel trailers. The propane tank tray may be missing the required number of fasteners, allowing the tanks to detach.

116 vehicles affected Manufacturer: Forest River, Inc.

Consequence: A detached tank can become a road hazard, increasing the risk of a crash.

Remedy: Owners are advised to remove the tanks until the repair is performed. Dealers will install the correct number of fasteners, free of charge. Owner notification letters were mailed January 3, 2025. Owners may contact Forest River customer service at 1-574-642-3119. Forest River's number for this r...

OSHKOSH DEFENSE NGDV ICE (2025) — BACK OVER PREVENTION:DISPLAY FUNCTION

Oshkosh Corporation (Oshkosh) is recalling certain 2025 Defense NGDV ICE vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

144 vehicles affected Manufacturer: Oshkosh Corporation

Consequence: A blank rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: Oshkosh will replace the head units, free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Oshkosh customer service at 1-888-686-7278. Oshkosh's number for this recall is NGDV_TSB_024.

JAGUAR I-PACE (2019) — ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Jaguar Land Rover North America, LLC (Jaguar) is recalling certain 2019 Jaguar I-PACE vehicles that received an improper interim repair under recall number 24V-633. The high-voltage battery may overheat.

85 vehicles affected Manufacturer: Jaguar Land Rover North America, LLC

Consequence: A high-voltage battery that overheats increases the risk of a fire.

Remedy: Owners are advised to park and charge their vehicle outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will update the battery energy control module software as an interim repair, free of charge. Owner notification letters were ...

JEEP GRAND CHEROKEE (2024) — ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

Chrysler (FCA US, LLC) is recalling certain 2024 Jeep Grand Cherokee and Grand Cherokee L vehicles. The radiator crossmember bolts may not be properly secured, which can lead to improper air bag deployments and a fuel leak during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208, "Occupant Crash Protection" and 301,...

631 vehicles affected Manufacturer: Chrysler (FCA US, LLC)

Consequence: An improper air bag deployment can increase the risk of injury. A fuel leak can increase the risk of a fire.

Remedy: Dealers will inspect and secure the crossmember bolts as necessary, free of charge. Owner notification letters were mailed January 9, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is D1B.

CHEVROLET EQUINOX EV (2025) — ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

General Motors LLC (GM) is recalling certain 2025 Chevrolet Equinox EV vehicles. The pedestrian alert sound system may have incorrect software and not produce sound at a sufficient volume. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

7,606 vehicles affected Manufacturer: General Motors, LLC

Consequence: A vehicle that fails to make sufficient sound may result in pedestrians being unaware of an approaching vehicle, increasing the risk of injury.

Remedy: Dealers will update the software in the body control module (BCM), free of charge. Owner notification letters were mailed January 21, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242479760.

FREIGHTLINER BUSINESS CLASS M2 (2015) — ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

Daimler Trucks North America, LLC (DTNA) is recalling certain 2015-2020 Freightliner Business Class M2 emergency vehicles equipped with certain Cummins diesel engines. The engine protection and inducement software may cause the engine to shut down unexpectedly.

139 vehicles affected Manufacturer: Daimler Trucks North America, LLC

Consequence: An unexpected engine shutdown can delay emergency responders and increase the risk of injury.

Remedy: Cummins will update the electronic control module software and install a corrected data plate, free of charge. Owner notification letters were mailed February 5, 2025. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is F1012.

SUZUKI AN400 (2023) — FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Suzuki Motor USA, LLC (Suzuki) is recalling certain 2023-2025 Burgman 400 (AN400AM3-M5) scooters. The fuel supply hose assembly may contact the fuel vapor hose assembly, causing the fuel supply hose to become damaged and leak fuel.

556 vehicles affected Manufacturer: Suzuki Motor USA, LLC

Consequence: A fuel leak in the presence of an ignition source increases the risk of fire.

Remedy: Owners are advised that if they must ride the scooter before the safety recall repair has been completed, they should check the scooter for fuel leakage and proper operation as outlined in the "Inspection before riding" checklist in the owner's manual. Dealers will replace the fuel supply hose asse...

GREAT DANE CHAMPION (2025) — STRUCTURE:FRAME AND MEMBERS

Great Dane Trailers (Great Dane) is recalling certain 2025 Champion Dry Freight trailers. Missing kingpin welds may prevent the upper coupler from securely connecting the trailer.

225 vehicles affected Manufacturer: Great Dane Trailers

Consequence: An unsecure connect may allow the trailer to detach from the tow vehicle, increasing the risk of a crash.

Remedy: Great Dane will inspect and replace the upper couplers as necessary, free of charge. Owner notification letters were mailed December 19, 2024. Owners may contact Great Dane customer service at 1-877-369-3493.

GILLIG LOW FLOOR (2023) — ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Gillig, LLC (Gillig) is recalling certain 2023 Low Floor diesel-hybrid transit buses. During vehicle operations in full electric vehicle (EV) mode, the odometer will not display accumulated mileage. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."

9 vehicles affected Manufacturer: Gillig, LLC

Consequence: A missing odometer reading could lead to an unintended delay in critical safety-related maintenance, potentially impairing the safe operation of the vehicle and increasing the risk of a crash.

Remedy: Gillig will install a new speedometer gauge, free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Gillig customer service at 1-800-735-1500 or 1-510-264-5073.

OEC, TECHNIDOT AIR BRAKE TUBING — SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS

Advanced Technology Products, Inc (ATP) is recalling certain OEC/Technidot black 1/4" DOT air brake tubing with part numbers DOTA04ABK, DOTA04CBK, and DOTA04DBK. Sunlight exposure may cause the air brake tubing to crack and burst under pressure. As such, this equipment fails to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 106, "Brake Hoses."

235 vehicles affected Manufacturer: Advanced Technology Products, Inc

Consequence: An air brake tube that bursts can result in a loss of braking ability, increasing the risk of a crash.

Remedy: ATP will replace the air brake tubing, free of charge. Customer notification letters were mailed December 17, 2024. Customers may contact ATP customer service at 1-937-349-4055.

KIA SORENTO PHEV (2025) — FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia America, Inc. (Kia) is recalling certain 2025 Sorento Plug-In Hybrid vehicles. During a crash, the steering rack may damage the fuel line, which can result in a fuel leak.

1,385 vehicles affected Manufacturer: Kia America, Inc.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will install a cover around the fuel line, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC328.

ROADTREK WESTFALIA WAVE (2024) — SEAT BELTS:CRITICAL FASTENERS

Roadtrek Inc. (Roadtrek) is recalling certain 2024-2025 Westfalia Wave motorhomes. The seat belt guide bracket may be missing from the second-row seats. The seat belts' movement may be restricted without the bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 207, "Seating Systems" and 209, "Seat Belt Assemblies."

60 vehicles affected Manufacturer: Roadtrek Inc.

Consequence: A seat belt that does not retract properly may be loose and will not adequately restrain an occupant, increasing the risk of injury during a crash.

Remedy: Dealers will install the bracket, free of charge. Owner notification letters were mailed January 15, 2025. Owners may contact Roadtrek customer service at 1-888-762-3873. Roadtrek's number for this recall is 2024-01.

JEEP RENEGADE (2021) — EXTERIOR LIGHTING:BACK UP LIGHTS

Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Renegade vehicles. The incorrect bumper reverse light assembly may have been installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

2,135 vehicles affected Manufacturer: Chrysler (FCA US, LLC)

Consequence: The incorrect reverse lights may have reduced visibility, and not alert pedestrians and other drivers that the vehicle is backing up, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the bumper reverse light assembly, as necessary, free of charge. Owner notification letters were mailed January 30, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is D7B.

OSHKOSH S-SERIES (2022) — VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Oshkosh Corporation (Oshkosh) is recalling certain 2022-2024 S-Series vehicles. The throttle pedal assembly may contain an oversized magnet carrier, slowing the responsiveness or causing the pedal to stick.

800 vehicles affected Manufacturer: Oshkosh Corporation

Consequence: A pedal that sticks increases the risk of a crash.

Remedy: Oshkosh will replace the throttle pedal, free of charge. Owner notification letters were mailed January 31, 2025. Owners may contact Oshkosh customer service at 1-888-686-7278.

GRAND DESIGN MOMENTUM (2023) — EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:MATERIALS:FLOORING

Grand Design RV, LLC (Grand Design) is recalling certain 2023-2025 Momentum fifth wheel trailers. The interior step base does not adequately support the step tread.

508 vehicles affected Manufacturer: Grand Design RV, LLC

Consequence: The tread may detach from the step, increasing the risk of a trip and fall injury.

Remedy: Dealers will replace the step riser and step treads, free of charge. Owner notification letters were mailed January 16, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910047.

KENWORTH 337 (2021) — ELECTRICAL SYSTEM:SOFTWARE

PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop functioning.

220,764 vehicles affected Manufacturer: PACCAR Incorporated

Consequence: Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may not function properly or at all, increasing the risk of a crash.

Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed February 3, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWL and 24PBL.

AUTOCAR XSPOTTER (2023) — ELECTRICAL SYSTEM:SOFTWARE

Autocar, LLC (Autocar) is recalling certain 2023-2025 ACTT (Xspotter) vehicles. A software error may allow the vehicle to exceed the speed governor limit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 136, "Electronic Stability Control Systems on Heavy Vehicles."

104 vehicles affected Manufacturer: Autocar, LLC

Consequence: Driving at speeds greater than 33 mph can result in a loss of handling and control, increasing the risk of a crash.

Remedy: Dealers will update the vehicle and drive motor software, free of charge. Owner notification letters were mailed July 30, 2025. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is ACTT-2402.

FORTUNE HICOUNTRY M/T HM1 — TIRES:MARKINGS

Prinx Chengshan Tire North America, Inc. (PCTNA) is recalling certain Fortune Tormenta and Prinx Hicountry sold as replacements tires. Please refer to the 573 Safety Report for specific sizes. The tires are labeled as snow tires, but do not have sufficient traction to perform in all snow weather conditions. As such, these tires fail to comply with the requirements of Federal Motor Vehicle Safet...

541,632 vehicles affected Manufacturer: Prinx Chengshan Tire North America, Inc.

Consequence: Tires that do not provide sufficient traction in snow can increase the risk of a crash.

Remedy: Dealers will inspect and repair, or fully reimburse customers as necessary, free of charge. Owner notification letters were mailed January 27, 2025. Owners may contact PCTNA customer service at 1-855-544-4891.

MERITOR FRONT DRIVE STEER AXLE — POWER TRAIN:AXLE HUBS

Meritor, Inc. (Meritor) is recalling certain 10-16K and 18-23K front steer drive axles, part numbers FSD 8-16K and FSD 18. An insufficient amount of lubricant in the front steer drive (FSD) axle hubs may result in damage to the wheel bearings.

128 vehicles affected Manufacturer: Meritor, Inc.

Consequence: Damaged bearings can cause the wheel to separate and result in a loss of vehicle control, increasing the risk of a crash.

Remedy: The remedy program will be completed by the vehicle manufacturers and provided free of charge. Owners may call Meritor's customer service at 1-866-668-7221. Meritor's number for this recall is C24AM.

LAND ROVER DEFENDER (2020) — EQUIPMENT

Jaguar Land Rover North America, LLC (Land Rover) is recalling certain 2020-2025 Land Rover Defender vehicles equipped with Raised Air Intake (RAI) aftermarket accessory equipment, with part number VPLEP0543. The raised air intake may not be secured properly, which can allow the intake to detach from the vehicle.

485 vehicles affected Manufacturer: Jaguar Land Rover North America, LLC

Consequence: A detached raised air intake can fall off the vehicle and become a road hazard, increasing the risk of a crash.

Remedy: Dealers will inspect, and if necessary, remove and reinstall the RAI accessory, free of charge. Owner letters were mailed February 20, 2025. Owners may contact Land Rover customer service at 1-800-637-6837. Land Rover's number for this recall is N964.

MCNEILUS ATLANTIC (2024) — FUEL SYSTEM, OTHER

McNeilus Truck & Manufacturing, Inc. (McNeilus) is recalling certain 2024 Atlantic and Zero Radius Side Loader vehicles equipped with certain Agility Fuel Solutions CNG Fuel Systems, using part number 10300466. The manual cylinder valves may develop stress corrosion cracks in the bottom plugged port, causing a leak.

15 vehicles affected Manufacturer: McNeilus Truck & Manufacturing, Inc.

Consequence: A natural gas leak in the presence of an ignition source increases the risk of a fire.

Remedy: Agility will replace the valves, free of charge. Owner notification letters are expected to be mailed January 17, 2025 by Agility. Owners may contact Agility customer service at 1-844-474-7400 or McNeilus customer service at 1-888-686-7278.

FOREST RIVER GEORGETOWN (2009) — EXTERIOR LIGHTING:TURN SIGNAL

Forest River, Inc. (Forest River) is recalling certain 2009-2017 Georgetown Class A motorhomes. The amber turn signal lens has an undersized reflective surface. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

6,963 vehicles affected Manufacturer: Forest River, Inc.

Consequence: Inadequately reflective turn signals can make it difficult for other drivers to see when the vehicle intends to turn, increasing the risk of a crash.

Remedy: Dealers will replace the turn signal, and bulb, free of charge. Owner notification letters were mailed December 11, 2025. Owners may call Forest River customer service at 1-574-206-7600. Forest River's number for this recall is 68-1875.

FOREST RIVER CLIPPER CAMPING TRAILER (2024) — EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS:LINES AND FITTINGS

Forest River, Inc (Forest River) is recalling certain 2024-2025 Clipper and Viking travel trailers. Please see the recall report for a complete list of models. The bottle bracket welds may break and cause the propane tank to detach from the vehicle.

864 vehicles affected Manufacturer: Forest River, Inc.

Consequence: A detached propane tank may become a road hazard and increase the risk of a crash.

Remedy: Dealers will inspect and replace the bottle bracket as necessary, free of charge. Owner notification letters were mailed January 2, 2025. Owners may contact Forest River customer service at 1-269-467-8283. Forest River's number for this recall is 121-1874.

LEXUS NX (2024) — SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024 RAV4 and 2025 Lexus NX vehicles. Some of the bolts that secure the front brake caliper and the wheel hub bearing may be loose, which can result in a damaged caliper brake hose or possible wheel detachment.

70 vehicles affected Manufacturer: Toyota Motor Engineering & Manufacturing

Consequence: A damaged brake line can cause a brake fluid leak, reducing brake performance and increasing the distance required to stop the vehicle. Wheel detachment can result in a loss of vehicle control. Either condition increases the risk of a crash.

Remedy: Dealers will inspect and tighten the front brake caliper mounting bracket and hub bearing bolts, as necessary, free of charge. In addition, any damaged components will be replaced, free of charge. Owner notification letters were mailed January 23, 2025. Owners may contact Toyota customer service ...

BMW X4 (2025) — AIR BAGS

BMW of North America, LLC (BMW) is recalling certain 2025 X4 xDrive 30i, X4 M40i and X4 M vehicles. The inner-left roof frame near the head air bag may have a crack that can damage the head air bag during deployment.

130 vehicles affected Manufacturer: BMW of North America, LLC

Consequence: An air bag that is damaged during deployment can increase the risk of injury in a crash.

Remedy: Dealers will inspect and if necessary, repair the inner-left roof frame, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact BMW customer service at 1-800-525-7417.

BMW X3 (2025) — SUSPENSION:FRONT:WHEEL BEARING

BMW of North America, LLC (BMW) is recalling certain 2025 X3 30 vehicles. The front wheel left-side swivel bearing may crack, causing a loss of vehicle handling and control.

2 vehicles affected Manufacturer: BMW of North America, LLC

Consequence: A loss of vehicle handling and control increases the risk of a crash.

Remedy: Dealers will replace the front left-side swivel bearing, free of charge. One owner was contacted December 12, 2024. Owners may contact BMW customer service at 1-800-525-7417.

PRESTONE DOT 3 BRAKE FLUID — SERVICE BRAKES, HYDRAULIC:FLUID

Prestone Products LLC (Prestone) is recalling certain 1-gallon bottles of Prestone DOT 3 Brake Fluid, part number AS402 with date code 2PW24226 manufactured on August 13, 2024. The brake fluid bottles may contain power steering fluid.

320 vehicles affected Manufacturer: Prestone Products LLC

Consequence: Accidentally using power steering fluid as brake fluid can result in reduced braking performance and increase the risk of a crash.

Remedy: Prestone will provide a refund, free of charge. Owner notification letters are expected to be mailed December 16, 2024. Owners may contact Prestone's customer service at 1-888-269-0750.

KENWORTH 367 (2024) — STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM

PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 548, Kenworth T480, T800, 2024-2025 Peterbilt 520, 567 and Kenworth T880 vehicles with PACCAR 20k steer axles. The steering arm and/or tie rod bracket fasteners may fail, resulting in a loss of steering control.

68 vehicles affected Manufacturer: PACCAR Incorporated

Consequence: A loss of steering control increases the risk of a crash.

Remedy: Dealers will install new correctly torqued fasteners, free of charge. Owner notification letters were mailed January 21, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 or Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWK and 24PBK.

NOVA BUS LFS (2022) — EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR RESTRAINTS/SECUREMENT:CRITICAL FASTENERS

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2024 LFS buses. The wheelchair securement system may have been installed with the attachment points in the incorrect locations.

24 vehicles affected Manufacturer: Nova Bus (US) Inc.

Consequence: Incorrectly located attachment points may prevent the securement system from adequately restraining the occupant, increasing the risk of injury during a crash.

Remedy: Nova Bus will reinstall securement system, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact Nova Bus at 1-866-870-2046. Nova Bus's number for this recall is CR5674.

INTERNATIONAL EMV (2025) — VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT

International Motors, LLC (International) is recalling certain 2025 EMV vehicles. A circuit breaker may be missing, causing the defrosting system to be inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."

22 vehicles affected Manufacturer: International Motors, LLC

Consequence: An inoperative windshield defrosting system may decrease the driver's visibility, increasing the risk of a crash.

Remedy: Dealers will install a 5A circuit breaker and a label, free of charge. Owner notification letters were mailed January 17, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 24518.

PIERCE ENFORCER (2023) — TIRES

Pierce Manufacturing (Pierce) is recalling certain 2023-2024 Enforcer, Quantum, and Velocity fire trucks. The tires mounted on the front steer axles are incompatible with the wheels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims - Other Than Passenger Cars."

8 vehicles affected Manufacturer: Pierce Manufacturing

Consequence: The tires can separate from the wheels, increasing the risk of a crash.

Remedy: Pierce will supply new front steer axle wheel/tire assemblies and updated tire information labels, free of charge. Owner notification letters were mailed December 23, 2024. Owners may contact Pierce customer service at 1-888-974-3723.

TESLA MODEL X (2024) — EXTERIOR LIGHTING:HEADLIGHTS

Tesla, Inc. (Tesla) is recalling certain 2024 Model X vehicles. The parking lights and low beam headlights may flicker. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

25 vehicles affected Manufacturer: Tesla, Inc.

Consequence: Flickering headlights or parking lights may not suffciently illuminate the roadway, increasing the risk of a crash.

Remedy: Tesla released an over-the-air (OTA) software update, free of charge. All vehicles were updated by September 17, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-017.

KENWORTH 536 (2024) — POWER TRAIN:AXLE HUBS

PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 537, 2024-2025 Kenworth T380, T480, Peterbilt 548, and 2025 Peterbilt 536 trucks, equipped with certain Meritor 10-16K and 18-23K front steer drive axles. The front steer drive axles may have insufficient wheel bearing lubricant.

29 vehicles affected Manufacturer: PACCAR Incorporated

Consequence: Insufficient lubrication may cause the wheel hub to overheat, increasing the risk of a fire, or result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Dealers will inspect and repair the wheel end with new parts and lubricate the bearings as necessary, free of charge. Owner letters were mailed July 21, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 or Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for th...

RICH SPECIALITY TRAILERS OFFICE (2023) — EQUIPMENT:APPLIANCE:AIR CONDITIONER

Kuntry Kustom RV, LLC (Kuntry Kustom) is recalling certain 2023-2024 Rich Specialty Sanitation and Office trailers, equipped with certain GE air conditioners. The air conditioner soft start device may fail and overheat.

347 vehicles affected Manufacturer: Kuntry Kustom RV, LLC

Consequence: An air conditioner soft start device that overheats increases the risk of a fire.

Remedy: Dealers will remove the soft start, free of charge. As an interim measure, owners should have the ICM870-16A-BH5400 soft start removed from their air conditioner. Owner notification letters were mailed June 23, 2025. Owners may contact Kuntry Kustom customer service at 1-260-593-2208.

MCLAREN 765LT (2021) — STRUCTURE:BODY

McLaren Automotive Incorporated (McClaren) is recalling certain 2021 765LT Coupe vehicles. The rear cabin window may have insufficient adhesive bonding, which can allow the window to detach from the support frame.

163 vehicles affected Manufacturer: McLaren Automotive Incorporated

Consequence: A rear window that detaches from the vehicle can create a road hazard for other drivers, increasing the risk of a crash.

Remedy: Dealers will install bespoke fasteners into each corner of the polycarbonate panel, free of charge. Interim owner notification letters explaining the safety risk were mailed on December 4, 2024. Owners will receive a second notice when remedy parts become available, anticipated late September 2025...

JEEP GRAND CHEROKEE (2021) — AIR BAGS:SIDE/WINDOW

Chrysler (FCA US, LLC) is recalling certain 2022-2024 Jeep Grand Cherokee and 2021-2024 Jeep Grand Cherokee L vehicles. An improperly secured connector for the front seat side air bags (SAB) may prevent the air bags from deploying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."

14 vehicles affected Manufacturer: Chrysler (FCA US, LLC)

Consequence: An air bag that does not deploy during a crash increases the risk of injury.

Remedy: Dealers secured the connector, free of charge. All affected vehicles have been remedied. Owner notification letters were mailed December 17, 2024. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is B3B.

FOREST RIVER CONCORD (2025) — EXTERIOR LIGHTING:TAIL LIGHTS

Forest River, Inc. (Forest River) is recalling certain 2025 Concord, Entourage, Freelander, and Leprechaun motorhomes. The taillights may overheat and fail to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

17 vehicles affected Manufacturer: Forest River, Inc.

Consequence: Inoperative taillights can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.

Remedy: Dealers will replace the taillights, free of charge. Owner notification letters were mailed December 12, 2025. Owners may contact Forest River customer service at 1-574-825-8602. Forest River's number for this recall is 210-1872.

AUDI A7 (2022) — ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022-2023 Audi Q5 PHEV and 2022 Audi A7 PHEV vehicles. The high-voltage battery may overheat.

4,616 vehicles affected Manufacturer: Volkswagen Group of America, Inc.

Consequence: A high-voltage battery that overheats increases the risk of a fire.

Remedy: Dealers will install advanced diagnostic software as the final remedy, anticipated to be available in the second quarter of 2025. Volkswagen will monitor available online vehicle data and contact owners as necessary, to advise them not to charge the vehicle until the battery can be replaced. For v...

KEYSTONE ARCADIA (2025) — TRAILER HITCHES:FIFTH WHEEL ASSEMBLY

Keystone RV Company (Keystone) is recalling certain 2025 Arcadia and Cougar trailers equipped with Curt Helux Pin Boxes. The pin box fasteners may have been improperly tightened.

303 vehicles affected Manufacturer: Keystone RV Company

Consequence: The fasteners can loosen and fall out, allowing the towed vehicle to detach from the pin box and increasing the risk of a crash.

Remedy: Dealers will tighten the pin box fasteners, free of charge. Owner notification letters were mailed December 10, 2025. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 24-459.

RAM 2500 (2017) — SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Chrysler (FCA US, LLC) is recalling certain 2017-2018 Ram 2500 Pickup, Ram 3500 Pickup, 3500 Cab Chassis, 4500 and 5500 Cab Chassis vehicles. The hydraulic control unit (HCU) may fail, which can cause the anti-lock brake (ABS), electronic stability control (ESC), and traction control systems to fail.

317,630 vehicles affected Manufacturer: Chrysler (FCA US, LLC)

Consequence: A loss of anti-lock brakes, electronic stability control, or traction control can increase the risk of a crash.

Remedy: Dealers will replace the brake HCU, or replace the HCU motor, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed January 9, 2025. Some owner notification letters were mailed January 9, 2025. The remaining owner notification letters will be mailed at a f...

HONDA PASSPORT (2023) — FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

Honda (American Honda Motor Co.) is recalling certain 2023-2024 Passport and 2023-2025 Pilot vehicles. The fuel filler neck tube and fuel filler pipe may separate, allowing fuel to leak.

205,760 vehicles affected Manufacturer: Honda (American Honda Motor Co.)

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and repair the fuel filler neck tube and pipe as necessary, free of charge. Owner notification letters were mailed January 7, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is OKM.