2002 WORKHORSE W22

2 recalls — 76 complaints

SERVICE BRAKES, HYDRAULIC

Defect Description

NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED W... Read more

Consequence

THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy

WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.

48,876 vehicles affected

Manufacturer: NAVISTAR, INC

SERVICE BRAKES, HYDRAULIC

Defect Description

ON CERTAIN MOTORHOME CHASSIS EQUIPPED WITH BOSCH ZOPS, THE PADS CAN DRAG ON THE ROTOR SURFACE DUE TO THE PIN SLIDE.

Consequence

A HANG UP OR LOCK UP MAY CAUSE THE CALIPERS TO OVER HEAT AND NOT ALLOW THE DRIVER TO STOP SAFELY. THIS COULD CAUSE OVERHEATING OF THE BRAKE CALIPERS WHICH COULD RESULT IN A VEHICLE FIRE.

Remedy

DEALERS WILL INSPECT, REPAIR AND REPLACE ACCORDING TO THE PROCEDURE DEVELOPED BY BOSCH (SEE CAMPAIGN 03E064000). THE RECALL BEGAN ON AUGUST 1, 2004. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-294-6773.

10,235 vehicles affected

Manufacturer: WORKHORSE CUSTOM CHASSIS

Complaint Statistics

76 total complaints 1 crashes 6 fires

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC	59
ENGINE AND ENGINE COOLING	4
SERVICE BRAKES	3
POWER TRAIN:AUTOMATIC TRANSMISSION	1
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT	1
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER	1
SUSPENSION:FRONT:WHEEL BEARING	1
VEHICLE SPEED CONTROL:CRUISE CONTROL	1
ENGINE AND ENGINE COOLING:ENGINE	1
ELECTRICAL SYSTEM	1

Incident date: Mar 18, 2023

My ABS Brake Module failed with no warning until after failure. All dash warning lights illuminated after failure rear brakes locked up and would not release causing me to be stranded and requiring a tow service. Dealership confirmed failed ABS module and is currently being repaired but not covered ... Read more

Incident date: Jan 19, 2021

WE JUST PURCHASED THIS MOTORHOME AND DURING MY INVESTIGATION FOR VARIOUS REPAIRS FOUND THERE WERE 2 RECALLS ON THIS COACH. ONLY 1ST OF THE 2 OF THE RECALLS WAS ADDRESSED WITH THE 2ND RECALL BEING A MORE INTENSE MODIFICATION OF THE 1ST. I AM NOW TRYING TO FIND OUT HOW TO GET THE 2ND RECALL IMPLEMENT... Read more

Incident date: Aug 30, 2017

1) THE MANUFACTURE, WINNEBAGO INDUSTRIES, EQUIPPED THE DRIVER "COCKPIT" OF THE VEHICLE WITH THERMOPANE WINDOWS WITH AN IDENTIFIED WEAKNESS. THE SEALS IN THE WINDOWS ARE INADEQUATE TO MAINTAIN SEAL INTEGRITY, THUS ALLOWING AIR INFILTRATION. SAID AIR INFILTRATION CAUSED FOGGING OF THE GLASS, AND AN AC... Read more

Incident date: Jul 1, 2019

TL* THE CONTACT OWNS A 2002 WORKHORSE W22. THE CONTACT STATED THAT THE ABS WARNING INDICATOR FLASHED AND REMAINED ILLUMINATED. IN ADDITION, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD, CREATING THE RISK OF A POTENTIAL CRASH. THE CONTACT HAD TO APPLY FORCE TO THE BRAKE PEDAL TO STOP ... Read more

Incident date: Sep 1, 2010

NON-AVAILABILITY OF PARTS, NHTSA RECALL # EA02035. I HAVE TRIED TO MAKE AN APPT W/AN AUTHORIZED WORKHORSE CHASSIS SERVICE CENTER. THE TWO CENTERS NEAREST ME HAVE HAD THE CALIPER KITS ON ORDER FOR THE LONGEST TIME. I FEEL THAT WORKHORSE CUSTOM CHASSIS IS DRAGGING THEIR FEET WHEN SUPPLYING THE SERVICE... Read more

Incident date: Feb 25, 2011

2002 DAMON INTRUDER ON A 2002 WORKHORSE W22 CHASSIS. CONSUMER STATES DEFECTIVE CALIPERS AND SEEKS REIMBURSEMENT FOR REPAIRS *TGW THE CONSUMER STATED THE ROTORS, SEALS, PADS AND HOSES ALSO HAD TO BE REPLACED. THE CONSUMER BELIEVED THE DEFECTIVE CALIPERS CAUSED DAMAGE TO THE OTHER BRAKE COMPONENTS. ... Read more

Incident date: Jan 3, 2011

2002 WORKHORSE W22 CHASSIS. CONSUMER WRITES IN REGARDS TO PROBLEMS WITH WORKHORSE BRAKES AND REQUESTS REIMBURSEMENT *TGW THE CONSUMER STATED THE FIRST PROBLEM HE ENCOUNTERED WITH THE RV WAS THE SMELL OF BURNING BRAKES WHICH WAS NOTICED IN 2004 AND THE REPAIRS WERE DONE DURING THE BOSCH BRAKE CALIP... Read more

Incident date: Sep 16, 2010

2002 WORKHORSE W22 CHASSIS. CONSUMER IS SEEKING REIMBURSEMENT FOR A TOWING BILL DUE TO PROBLEMS WITH WORKHORSE CUSTOM CHASSIS *TGW THE CONSUMER STATED THE BRAKES FAILED TO RELEASE WHILE DRIVING.*JB

Incident date: Dec 1, 2010

2003 PACE ARROW MOTORHOME ON A 2002 WORKHORSE W22 CHASSIS. CONSUMER IS REQUESTING REIMBURSEMENT FOR BRAKE CALIPER REPLACEMENT SINCE THIS WAS A RECALL ISSUE FOR WORKHORSE W22 CHASSIS. *KB THE CONSUMER STATED AFTER THE RV WAS PURCHASED, THE ABS LIGHT ILLUMINATED AND THE BRAKE PEDAL WAS SOFT. BRAKE F... Read more

Incident date: Oct 29, 2010

TL*THE CONTACT OWNS A 2002 BOUNDER 36U RV EQUIPPED WITH A WORKHORSE CHASSIS W22. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 09V110000 (SERVICE BRAKES, HYDRAULIC). THE TECHNICIAN INFORMED THAT THE FRONT AND REAR ROTORS HAD SEVERE CRACKS SO BOTH ROTORS WERE REPLAC... Read more

Incident date: Oct 28, 2010

TL*THE CONTACT OWNS A 2002 WORKHORSE W22. WHILE CHANGING THE CALIPERS ON THE VEHICLE HE NOTICED THAT THERE WAS AN EXCESSIVE AMOUNT OF GREASE WITHIN THE MASTER CYLINDER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE BUT HE WAS INFORMED THE ENTIRE BRAKING SYSTEM... Read more

Incident date: Nov 1, 2010

2002 WORKHORSE W22 CHASSIS. CONSUMER WRITES REGARDING WORKHORSE RECALL *TGW THE CONSUMER STATED HE HAS BEEN UNABLE TO GET THE NECESSARY REPAIRS MADE TO HIS RV. THE CONSUMER IS SEEKING REIMBURSEMENT FOR PREVIOUS BRAKE REPAIRS. *JB

Incident date: May 18, 2010

TL*THE CONTACT OWNS A 2003 NATIONAL DOLPHIN MOTOR HOME WITH A 2002 W22 WORKHORSE CHASSIS. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHEN THE BRAKES FAILED. THE BRAKE ROTORS, BRAKE PADS AND THE SEALS WERE REPAIRED AT THE CONTACTS EXPENSE. HE RECEIVED A RECALL NOTICE ON THE CALIPERS FROM WORKHORSE BUT... Read more

Incident date: Oct 5, 2010

TL*THE CONTACT OWNS A 2002 FLEETWOOD ARROW EQUIPPED WITH A WORKHORSE W22 CHASSIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR RECALL 04V084000 (SERVICE BRAKES, HYDRAULIC) ON OCTOBER 5, 2010. THE DEALER REPLACED THE CALIPERS AND ADVISED THE CONTACT THAT THE ROTORS AND BRAKE PADS NEEDED TO BE RE... Read more

Incident date: Dec 1, 2004

2002 WORKHORSE W22 CHASSIS. CONSUMER WRITES REGARDING BRAKE FAILURE *TGW THE CONSUMER STATED HE EXPERIENCED BRAKE FAILURE IN DECEMBER 2004. THE BRAKES WERE TEMPORARILY REPAIRED, BECAUSE ACCORDING TO THE REPAIR SHOP A RECALL WAS ISSUED, HOWEVER, THE RECALL PARTS WERE NOT AVAILABLE. IN DECEMBER 200... Read more

Incident date: Oct 25, 2009

TL*THE CONTACT OWNS A 2002 FLEETWOOD SOUTHWIND RV EQUIPPED WITH A 2002 WORKHORSE W22 CHASSIS. THE CONTACT STATED THAT THE SINCE THE DATE OF PURCHASE, THE ABS LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE LIGHT DID NOT INDICATE A FAI... Read more

Fire

Incident date: Jan 1, 1901

2002 WORKHORSE CHASSIS DOLPHIN MOTORHOME. CONSUMER STATES PROBLEMS WITH THE ENGINE STALLING *TGW THE CONSUMER STATED THE RV HAS BEEN REPEATEDLY TOWED, SERVICED AND EVEN REPAIRED ONLY TO ENCOUNTER THE SAME PROBLEM. THE ENGINE WOULD SUDDENLY STALL WITH NO WARNING. WITHIN A PERIOD OF 10 SECONDS, THE ... Read more

Incident date: Apr 5, 2006

TL*THE CONTACT OWNS A 2002 FLEETWOOD BOUNDER WITH WORKHORSE W22 CHASSIS. WHILE DRIVING APPROXIMATELY 50-55 MPH HE ENGAGED THE BRAKES AND SMELLED THE BRAKES BURNING. HE DROVE ONTO THE EMERGENCY LANE AND ALLOWED THE VEHICLE TO COOL OFF AND WAS FORCED TO ALLOW THE VEHICLE TO COOL DOWN SEVERAL TIMES BEF... Read more

Fire

Incident date: Sep 15, 2002

TL* THE CONTACT OWNS A 2000 WORKHORSE W22. WHILE DRIVING AT APPROXIMATELY 40 MPH PRESSURE WAS APPLIED TO THE BRAKE PEDAL AND THE STEERING WHEEL BEGAN TO SHAKE. THE ANTI LOCK BRAKE SERVICES LIGHT ALSO BEGAN TO ILLUMINATE ON THE DASHBOARD. THE RV WAS TAKEN TO AN AUTHORIZED DEALER WHERE HE WAS INFOR... Read more

Incident date: May 22, 2009

TL* THE CONTACT OWNS A 2002 WORKHORSE W22 RV. THE CONTACT STATED HIS VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 09V110000 (SERVICE BRAKES, HYDRAULIC). BOTH THE DEALER AND MANUFACTURER ADVISED THE PARTS NEEDED TO MAKE THE REPAIR WERE NOT AVAILABLE AND COULD NOT PROV... Read more

Incident date: Mar 5, 2010

2002 WORKHORSE W22 CUSTOM CHASSIS OWNER. CONSUMER EXPRESSES DISCONTENT REGARDING WORKHORSE ONLY TAKING PARTIAL FINANCIAL RESPONSIBILITY FOR FAULTY BRAKE SYSTEM REPAIRS *TGW THE CONSUMER STATED THE ABS ILLUMINATED AND THERE WAS A VIBRATION DURING BRAKING. THE RV WAS TAKEN TO A REPAIR SHOP, WHERE IT... Read more

Incident date: Jun 3, 2010

TL*THE CONTACT OWNS A 2002 FLEETWOOD PACE ARROW RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS W22. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 50-50 MPH, PRESSURE WAS APPLIED TO THE BRAKES WITH A DELAY RESPONSE. THE VEHICLE WAS ABLE TO CONTINUE IN OPERATION. THE FAILURE OCCURRED INT... Read more

Incident date: Aug 27, 2007

TL* THE CONTACT OWNS A 2002 WORKHORSE W22 CHASSIS RV. THE CONTACT STATED THAT HE RECEIVED NOTIFICATION OF NHTSA RECALL CAMPAIGN ID NUMBER 04V084000 (SERVICE BRAKES, HYDRAULIC) IN DECEMBER 2009, YET THE DEALER ADVISED THE PARTS NEEDED TO MAKE THE REPAIRS WERE NOT YET AVAILABLE. THE MANUFACTURER STAT... Read more

Incident date: Jun 4, 2009

2002 WORKHORSE W22 CHASSIS RV. *DT THE CONSUMER STATED THE BRAKES ON THE RV LOCKED UP AND IS SEEKING REIMBURSEMENT SINCE A RECALL HAD BEEN ISSUED.

Incident date: May 20, 2004

2002 HOLIDAY RAMBLER. WORKHORSE W22 CHASSIS 2002. CONSUMER STATES PROBLEMS WITH THE BRAKES. *TGW THE CALIPERS AND ROTORS HAD TO BE REPLACED TWICE. WORKHORSE STATED THEY DIDN'T HAVE THE PROPER PARTS TO FIX THE PROBLEM. THEY PAID FOR HAVING THE PROBLEM FIXED THE FIRST TIME, BUT THEY REFUSED TO PAY ... Read more

Incident date: Mar 31, 2010

FAULTY BRAKING SYSTEM ON WORKHORSE RV CHASSIS ABS ANTILOCK SYSTEM. *TR

Fire

Incident date: Jul 1, 2007

MULTI-FAILURES OF THE BRAKING SYSTEM ON MY 2002 WORKHORSE W-22 CHASSIS. ALL FOUR CALIPERS HAVE BEEN REPLACED AS WELL AS FRONT WHEEL BEARING AND SEALS DUE TO THE EXTREME HEAT GENERATED WHEN THE SYSTEM FAILED. THIS OCCURRED IN JULY 1ST 2007, JULY 23,2007 AND FEB. 4 2008, .WHEN FAILURES OCCURRED THE... Read more

Incident date: Jul 1, 2007

Incident date: Sep 30, 2007

WORKHORSE W22 CHASSIS. 2002 FLEETWOOD BOUNDER. CONSUMER EXPRESSES DISCONTENT WITH DATE OF RECALL AS HIS PROBLEMS BEGAN ONE MONTH PRIOR. *TGW THE CONSUMER STATED HE DID DETECT A BURNING ODOR ON SEVERAL OCCASIONS. THE CONSUMER WAS INFORMED HE NEEDED NEW CALIPERS, THE ABS AND REAR BRAKES WERE HEAVIL... Read more

Incident date: Mar 1, 2005

NOVEMBER 16, 2007 EA07016 WAS OPENED. I STILL (2/24/2010) CAN'T USE MY VEHICLE AS WORKHORSE HAS NOT SCHEDULED ANY REPAIRS YET. WHY ARE YOU LETTING THEM GET AWAY WITH THIS. THE PROBLEM IS KNOWN AND IS A SAFETY ISSUE. *TR

Incident date: Jan 1, 2010

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 CHASSIS RECREATIONAL VEHICLE. HE STATED HE RECEIVED A RECALL LETTER FOR HIS VEHICLE IN APRIL 2009 INVOLVING SERVICE BRAKES (SEE NHTSA ACTION NUMBER: EA07016, NHTSA CAMPAIGN ID NUMBER: 09V110000: SERVICE BRAKES-HYDRAULIC). THE RECALL STATED A REMEDY WAS CURREN... Read more

Incident date: Oct 5, 2005

TL*THE CONTACT OWNS A 2002 HOLIDAY RAMBLER. THE VEHICLE WAS BUILT ON A WORKHORSE CHASSIS W22. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS WHEN THE BRAKE PEDAL TRAVELED TO THE FLOOR WITHOUT RESISTANCE. PRESSURE WAS APPLIED, THERE WERE SEVERAL ATTEMPTS BEFORE THE VEHICLE SLO... Read more

Incident date: Apr 30, 2003

TL* THE CONTACT OWNS A 2002 WORKHORSE W22. THE BRAKE PEDAL WOULD NOT RELEASE AFTER APPLICATION. ALSO THE BRAKE SYSTEM WOULD INTERMITTENTLY OVER-HEAT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, AND A SPRING ON THE BRAKE PEDAL AS INSTALLED. THE REPAIR DID NOT REMEDY THE FAILURE. THE CALIPER GU... Read more

Incident date: Aug 13, 2008

TL*THE CONTACT OWNS A 2002 NEWMAR MOUNTAIN AIRE RV WITH A W22 WORKHORSE CHASSIS. WHILE DRIVING BETWEEN 55 TO 60 MPH THE CONTACT BEGAN TO SMELL THE BRAKE PADS BURNING. THE CONTACT SHUT THE ENGINE OFF AND EXAMINED THE BRAKES. THE DEALER STATED THAT THE FRONT PASSENGER AND BOTH REAR CALIPERS WERE CRACK... Read more

Incident date: Sep 19, 2009

INCIDENT IN ENGLAND: SOFT PEDAL & LOSS OF BRAKING, ON IMPORTED AMERICAN MOTORHOME (RV). THERE ARE THOUSANDS OF IMPORTED RVS HERE. MY VEHICLE IS A 2002 'TRAIL LITE 262' BY R-VISION ON A WORKHORSE CHASSIS. IT IS USED REGULARLY & HAS 35,000 MILES. A RECENT SERVICE NOTED THE BRAKE CALIPERS WERE FREE... Read more

Crash

Incident date: Aug 17, 2006

TL*THE CONTACT OWNS A 2002 W22 WORKHORSE CHASSIS TRAILER. THERE IS AN ABNORMAL HEAT GENERATION AT THE WHEEL END WHICH CAUSED THE BRAKES TO DRAG. THE MANUFACTURER WAS NOTIFIED IN REFERENCE TO RECALL # 09V110000 (SERVICE BRAKES, HYDRAULIC). HE WAS ADVISED THAT A REMEDY HAS NOT BEEN DEVELOPED; THEREFOR... Read more

Incident date: Oct 15, 2004

LETTER FROM CONSUMER RE RECALL FOR BRAKE PROBLEMS WITH WORKHORSE CHASSIS. *NJ WHILE ON A TRIP, THE BRAKES OVERHEATED. THE RV WAS TAKEN TO THE DEALER AND IT WAS FOUND THAT THE ENTIRE BRAKING SYSTEM WAS DEFECTIVE. THE CONSUMER WAS INFORMED THE PARTS WOULD NOT BE AVAILABLE UNTIL NOVEMBER EVEN THOUGH... Read more

Incident date: Oct 15, 2004

Incident date: Aug 7, 2009

TL*THE CONTACT OWNS A 2002 HOLIDAY RAMBLER VACATIONER. THE CONTACT STATED HEAT BUILDS UP IN THE BRAKE SYSTEM. THE RV WAS TAKEN TO THE DEALER AND THE CALIPERS AND ROTORS WERE REPLACED. IMMEDIATELY AFTER THE REPAIR HE NOTICED THAT THE TRANSMISSION WOULD NOT CHANGE GEARS AND THE SPEEDOMETER WAS INOPER... Read more

Incident date: Jun 16, 2009

2002 WINNEBAGO ADVENTURER 35-U HAD A BRAKE PROBLEM. CONSUMER WANTS TO BE REIMBURSED FOR THE REPAIRS (SAFETY RECALL 50901-C). *NJ THE RIGHT FRONT CALIPER LOCKED UP AND THE LEFT REAR CALIPER WAS DRAGGING. 2002 WORKHORSE W22 CHASSIS. UPDATED 09/14/09. *JB THE CONSUMER IS SEEKING REIMBURSEMENT FOR... Read more

Incident date: Jan 1, 1901

CONSUMER IS SEEKING REIMBURSEMENT FOR REPAIRS AFTER RECEIVING SAFETY RECALL 50901-C FOR WORKHORSE RV. *NJ PRIOR TO RECEIVING THE RECALL, THE FRONT BRAKES OVERHEATED. THE ROTORS, CALIPERS, INNER SEALS, RIGHT REAR SPEED SENSOR, HUB SEALS AND OUTER GASKET WERE REPLACED. *JB

Incident date: Jul 10, 2009

DRIVER SIDE REAR BRAKE FIRE ON 2002 WORKHORSE MOTOR HOME CHASIS. FIRE WAS NOTED WHEN STOPPING AT CAMPGROUND ENTRANCE AFTER TRAVELING ABOUT 5 MILES ON LEVEL GROUND AT 25 MILES PER HOUR FROM HIGHWAY ON SIDE ROAD. IMMEDIATELY HOSED DOWN BRAKE ASSEMBLY. MOTORHOME WAS ALLOWED TO SET FOR 3 DAYS. DROVE... Read more

Fire

Incident date: Jun 1, 2009

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 MOTOR HOME. THE CONTACT STATED THAT THE BRAKES FAILED DURING STOP-AND-GO TRAFFIC. HE ALSO STATED THAT THE BRAKES WERE DRAGGING. THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. THE MANUFACTURER STATED THAT THEY WOULD ASSIST WITH THE REPAIRS AN... Read more

Incident date: Jun 14, 2009

TL*THE CONTACT OWNS A 2003 FOREST RIVER WINDSONG WITH A 2002 WORKHORSE W22 CHASSIS. WHILE DRIVING 55 MPH, THE FRONT END OF THE VEHICLE VIBRATED CONSTANTLY. THE CONTACT INSPECTED THE VEHICLE AND NOTICED AN ODOROUS SMOKE COMING FROM UNDERNEATH. HE POURED WATER ON THE BRAKE CALIPERS TO COOL THEM DOW... Read more

Incident date: Feb 11, 2009

WORKHORSE SAFETY RECALL 50901C. *NJ THE CONSUMER STATED THE BRAKES WERE HOLDING. THE CONSUMER TOOK THE RV TO A MECHANIC AND WAS TOLD THE ABS SENSORS HAD MELTED AND WOULD HAVE TO BE ORDERED. THE CONSUMER WENT BACK TO HAVE THE SENSORS INSTALLED, BUT WAS TOLD A THIRD SENSOR WAS BAD. THE BRAKES NEEDE... Read more

Incident date: Apr 11, 2008

TL*THE CONTACT OWNS A 2002 WINNEBAGO ADVENTURER RV, MODEL 35U. THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE BRAKING SYSTEM ON THE VEHICLE. IN OCTOBER OF 2008, THE BRAKES FAILED AND NEARLY CAUSED A CRASH. THE CONTACT CALLED THE DEALER AND A LAWYER AND WAS ADVISED TO FILE A COMPLAINT WITH THE... Read more

Incident date: Apr 11, 2008

Incident date: Jul 1, 2008

WE WERE TRAVELING ON INTERSTATE 83 HEADING NORTH PAST BALTIMORE WHEN WE SMELLED A BURNING BRAKE SMELL - WE PULLED OVER ON THE SIDE OF 83 AND THE FRONT DRIVERS SIDE BRAKE CALIBER HAD STUCK AND WOULD NOT RELEASE - THE RUBBER DUST BOOT CAUGHT FIRE - THE INSIDE OF THE TIRE CRACKED AND BEGAN TO MELT DUE ... Read more

Fire

Incident date: Nov 10, 2007

TL*THE CONTACT OWNS A 2002 WORKHORSE W22. THE CONTACT NOTICED THAT THE ABS WARNING INDICATOR WOULD CONSISTENTLY ILLUMINATE ON THE INSTRUMENT CONTROL PANEL. HE TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED ALL THE ABS SENSORS AT THE COST OF $618. SEVERAL MONTHS AFTER THE REPAIR, THE FAILURE RES... Read more

Incident date: Jul 17, 2004

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 CHASSIS. THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 04V084000 (SERVICE BRAKES, HYDRAULIC) IN 2004. SEVERAL YEARS LATER, THE CONTACT NOTICED THAT THE BRAKING SYSTEM WOULD HANG UP OR LOCK DURING EMERGENCY STOPPING. DURING THE FAILURE, THE... Read more

Showing 50 of 76 complaints.

WORKHORSE W22 — All Years Overview

Complete safety history for the WORKHORSE W22 across all model years (2000–2011).

19 Total Recalls

370 Total Complaints

0 Investigations

2 Reported Crashes

23 Reported Fires

0 Reported Deaths

WORKHORSE W22 — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2011	2	0	View
2009	0	2	View
2008	1	4	View
2007	1	6	View
2006	3	8	View
2005	3	22	View
2004	2	107	View
2003	1	130	View
2002 (current)	2	76
2001	3	14	View
2000	1	1	View

Other WORKHORSE Models

Model	Recalls	Complaints
W42	18	0	View
W20	15	38	View
W62	9	0	View
W21	8	3	View
P42	7	0	View
W24	5	4	View
W18	5	4	View
CLASS A	4	1	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2002 WORKHORSE W22

Complaint Statistics

Top Reported Components

WORKHORSE W22 — All Years Overview

WORKHORSE W22 — Year by Year

Other WORKHORSE Models