POWER TRAIN:CLUTCH ASSEMBLY
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
23,056 vehicles affected
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
Remedy: VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
127,764 vehicles affected
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.
Remedy: DEALERS WILL REPLACE THE CIRCUIT BREAKERS WITH FUSES. THE RECALL BEGAN ON FEBRUARY 25, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
104,845 vehicles affected
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.
Remedy: DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
6,519 vehicles affected
FUEL SYSTEM, DIESEL
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.
Remedy: DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
677 vehicles affected
STEERING
ON CERTAIN TRUCKS, THE NUT USED TO RETAIN THE STEERING SHAFT MAY OR MAY NOT BE A LOCK NUT THAT HAS THE LOCKING FEATURE. A LOCK NUT IS REQUIRED TO PROVIDE ADDITIONAL RESISTANCE TO ENSURE THAT THE NUT DOES NOT COME LOOSE.
Remedy: DEALERS WILL REPLACE THE STEERING SHAFT PINCH BOLTS AND LOCKNUTS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 24, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
9,102 vehicles affected
POWER TRAIN:AXLE ASSEMBLY
ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.
Remedy: DEALERS WILL REPAIR AND INSPECT THE AXLES AND REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON APRIL 9, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
84 vehicles affected
POWER TRAIN:DRIVELINE
ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR RPL20 HIGH ANGLE INTERAXLE DRIVESHAFTS, AN IMPROPER SEATED OR MISSING SNAP RING CAN RESULT IN THE BEARING CUP TO SEPARATE FROM THE SLIP YOKE SUB-ASSEMBLY. THE UNIVERSAL JOINT CROSS COULD THEN CONTACT THE SLIP YOKE CASTING AND EVENTUALLY CAUSE THE EAR WORK TO FRACTURE.
Remedy: DEALERS WILL INSPECT THE DRIVESHAFTS AND REPLACE THEM AS NEEDED. THE RECALL BEGAN ON OCTOBER 23, 2006. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
3,842 vehicles affected
CONSUMER WRITES IN REGARDS TO TWO HEAD ON COLLISIONS AND PROBLEM WITH AIRBAG DEPLOYMENT *TGW THE CONSUMER STATED THE COLLISIONS INVOLVED TWO DIFFERENT VOLVO TRACTORS.
Crash
TL* CONTACT OWNS A 2007 VOLVO VNM670. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN A CRASHED AND THE AIR BAGS FAILED TO DEPLOY. THE DRIVER SUSTAINED MINOR INJURIES. A POLICE REPORT WAS FILED. THE DEALER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 450,000.
Crash
1 injured
I WAS DRIVING A 2007 VOLVO VNM FOR YRCW TRUCKING CO. I DID ALL THE APPROPRIATE SAFETY CHECKS AND AFTER 140 MILES DRIVING,WHEN I SLOWED TO 5MPH TO PASS THROUGH THE EZPASS LANE AT LAKAWANA NY, THE FIFTH WHEEL RELEASED AND DROPPED THE TRAILERS IN THE ROADWAY. SOMEHOW THE AIR RELEASE WAS ACTIVATED AND OPENED THE FIFTH WHEEL JAWS OF THE FIFTH WHEEL. *TR
I WAS DRIVING A 2007 VOLVO VNM FOR YRCW TRUCKING CO. I DID ALL THE APPROPRIATE SAFETY CHECKS AND AFTER 140 MILES DRIVING,WHEN I SLOWED TO 5MPH TO PASS THROUGH THE EZPASS LANE AT LAKAWANA NY, THE FIFTH WHEEL RELEASED AND DROPPED THE TRAILERS IN THE ROADWAY. SOMEHOW THE AIR RELEASE WAS ACTIVATED AND OPENED THE FIFTH WHEEL JAWS OF THE FIFTH WHEEL. *TR
I WAS DRIVING A 2007 VOLVO VNM FOR YRCW TRUCKING CO. I DID ALL THE APPROPRIATE SAFETY CHECKS AND AFTER 140 MILES DRIVING,WHEN I SLOWED TO 5MPH TO PASS THROUGH THE EZPASS LANE AT LAKAWANA NY, THE FIFTH WHEEL RELEASED AND DROPPED THE TRAILERS IN THE ROADWAY. SOMEHOW THE AIR RELEASE WAS ACTIVATED AND OPENED THE FIFTH WHEEL JAWS OF THE FIFTH WHEEL. *TR
2007 VOLVO VNM CONVENTIONAL STALLED ON THE HIGHWAY. *BF WHEN THE TRUCK STALLED, THE DRIVER PANICKED AND ABRUPTLY TURNED HIS VEHICLE AND STUCK THE LANE EXTENDER. OHIO TRAFFIC CRASH REPORT # 10-0289-91 UPDATED 05/03/10 *BF
Crash