SUSPENSION:FRONT
ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.
Remedy: DEALERS WILL REPLACE ALL FRONT AXLE HUBS. AN INTERIM NOTICE TO OWNERS WAS MAILED ON JUNE 25, 2003. FINAL OWNER NOTIFICATION BEGAN ON OCTOBER 6, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-528-6586.
433 vehicles affected
EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH
CERTAIN HEAVY DUTY CLASS 8 TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE TWO TAIL LAMPS, BACK-UP LAMP,AND LICENSE TAG LAMP WERE MOUNTED ON INSUFFICIENTLY RIGID MOUNTS.
Remedy: DEALERS WILL ATTACH THE TWO TAIL LAMPS, BACK-UP LAMP, AND THE LICENSE TAP LAMP ON STIFFER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 31, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
5,532 vehicles affected
SERVICE BRAKES, AIR:ANTILOCK
CERTAIN HEAVY DUTY CLASS 8 VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS", S5.1.6.3, "ANTILOCK POWER FOR TOWED VEHICLES." ELECTRICAL POWER FOR THE TRAILER ANTI-LOCK BRAKING SYSTEM (ABS) CAN BE DISRUPTED WHEN A SWITCH LOCATED ON THE VEHICLE INSTRUMENT PANEL IS ACTIVATED TO CONTROL LIGHTING WITHIN THE TRAILER.
Remedy: DEALERS WILL INSTALL A WIRING HARNESS WHICH WILL PROVIDE CONTINUOUS ELECTRICAL POWER TO THE TRAILER ABS WHENEVER THE IGNITION SWITCH IS IN THE ON OR RUN POSITION. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
208 vehicles affected
SERVICE BRAKES, AIR:ANTILOCK
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
Remedy: DEALERS WILL REPLACE THE ABS ECU.
18,362 vehicles affected
TIRES:BEAD
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CONTINENTAL GENERAL S380A 295/75R22.5 LR G TIRES, SERIAL NOS. A3371E5488 THROUGH A3371E5089. THESE TIRES HAVE BEEN OVERCURED.
Remedy: CONTINENTAL GENERAL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL EXCHANGE THE TIRE FOR AN IDENTICAL OR REASONABLY EQUIVALENT TIRE.
20 vehicles affected
TL* THE CONTACT OWNS A 1998 VOLVO VNL. THE CONTACT RECEIVED AN UNKNOWN MANUFACTURERS RECALL NOTICE CONCERNING THE STEERING DRAG LINK SEPTEMBER 2010. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THEY WOULD NOT ASSIST WITH REPAIRS DUE TO AGE OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 400,000 AND THE CURRENT MILEAGE WAS 600,000.
FRONT END VIBRATES AT ANY SPEED. CAUSE IS UNKNOWN, ALSO IT WEARS ON THE TIRES BY DIPPING ON THE SIDES. TOOK VEHICLE TO DEALER AND DEALER CAN'T DUPLICATE THE PROBLEM. *AK
PREMATURE WEAR FROM STEER TIRES RESULTING FROM IMPROPER COMBINATION OF RACE/BEARINGS IN MERITOR AXLES. LOST WHEEL ASSEMBLY. *MJS
PREMATURE WEAR FROM STEER TIRES RESULTING FROM IMPROPER COMBINATION OF RACE/BEARINGS IN MERITOR AXLES. *MJS
PREMATURE WEAR FROM STEER TIRES RESULTING FROM IMPROPER COMBINATION OF RACE/BEARINGS IN MERITOR AXLES. *MJS
PREMATURE WEAR FROM STEER TIRES RESULTING FROM IMPROPER COMBINATION OF RACE/BEARINGS IN MERITOR AXLES. *MJS
PREMATURE WEAR FROM STEER TIRES RESULTING FROM IMPROPER COMBINATION OF RACE/BEARINGS IN MERITOR AXLES. *MJS
PREMATURE WEAR FROM STEER TIRES RESULTING FROM IMPROPER COMBINATION OF RACE/BEARINGS IN MERITOR AXLES. *MJS