SEAT BELTS
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
1,496 vehicles affected
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
Remedy: VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
127,764 vehicles affected
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.
Remedy: DEALERS WILL REPLACE THE CIRCUIT BREAKERS WITH FUSES. THE RECALL BEGAN ON FEBRUARY 25, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
104,845 vehicles affected
WHEELS
ON CERTAIN TRUCKS, THE WHEEL SPACER MAY BECOME DISTORTED FROM HEAT WHICH POTENTIALLY COULD LEAD TO A LOSS OF CLAMP THAT MAY RESULT IN LOOSE WHEEL NUTS.
Remedy: DEALERS WILL REPLACE THE WHEEL SPACERS AND THE WHEEL EQUIPMENT (WHEELS,STUDS, AND HUB) WILL BE INSPECTED FOR DAMAGE AND REPLACED IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 26, 2006. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
873 vehicles affected
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
ON CERTAIN TRUCKS EQUIPPED WITH D12D ENGINES, THE EXHAUST GAS RECIRCULATION (EGR) COOLER INLET PIPES OR THE PIPES THAT CONNECT THE EGR VALVES TO THE COOLER MAY CRACK OR BREAK.
Remedy: DEALERS WILL INSPECT AND REPAIR THE EGR COOLER PIPES AS REQUIRED AND INSTALL A HEAT SHIELD FREE OF CHARGE. AN INTERIM OWNER LETTER WAS MAILED ON FEBRUARY 17, 2006, TO ADVISE ON PRECAUTIONS THAT THE OWNER CAN TAKE UNTIL PARTS BECOME AVAILABLE. OWNERS ARE BEING NOTIFIED STARTING MARCH 3, 2006, THAT PARTS ARE NOW AVAILABLE. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
33,102 vehicles affected
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
ON CERTAIN TRUCKS EQUIPPED WITH VALEO WIPER SYSTEMS, THE WIPER MOTOR MAY BE SUSCEPTIVE TO SALT INTRUSION THAT COULD POSSIBLY LEAD TO A CONDITION WHERE THE CONNECTOR OVERHEATS TO A POINT WHERE THE CONNECTOR COULD IGNITE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE CONNECTOR PLATE ON THE WINDSHIELD WIPER MOTOR. PHASE 2 OF THE RECALL BEGAN ON NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
56,154 vehicles affected
SEATS
CERTAIN TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, 'SEATING SYSTEMS.' THE BENCH SEAT, AS INSTALLED, DOES NOT THE SEAT PULL REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE BENCH SEAT WITH A DIFFERENT BRAND OF SEAT. THE RECALL BEGAN NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
126 vehicles affected
ENGINE AND ENGINE COOLING
ON CERTAIN HEAVY-DUTY CLASS 8 TRUCKS, THE ASSEMBLED ENGINE PRE-HEATER JUMPER WIRING HARNESS WAS INCORRECTLY ASSEMBLED.
Remedy: DEALERS WILL REPAIR THE AFFECTED CIRCUITS IN THE JUMPER WIRING HARNESS CONNECTOR. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
2,112 vehicles affected
STEERING:GEAR BOX:SHAFT PITMAN
ON CERTAIN HEAVY-DUTY CLASS 8 TRUCKS, THE PINCH BOLT ATTACHING THE STEERING DRAG LINK TO THE PITMAN ARM MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED.
Remedy: DEALERS WILL INSTALL A NEW PINCH BOLT AND TIGHTEN TO THE REQUIRED TORQUE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
92 vehicles affected
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.
Remedy: DEALERS WILL REPLACE THE BRACKET PINS AND REPAIR INSTRUCTIONS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT JOST INTERNATIONAL AT 616-846-7700 OR BY EMAIL TO
[email protected] OR VOLVO TRUCK AT 800-528-6586.
1,275 vehicles affected
SEAT BELTS:FRONT:ANCHORAGE
CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH AN OPTIONAL TWO-MAN PASSENGER BENCH SEAT FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." ON THE TWO-MAN PASSENGER BENCH SEAT INBOARD (CENTER) POSITION, SEAT BELT D-RING MOUNTING BRACKET WELDNUT, THE WELD IS NOT SUFFICIENT TO MEET THE SEAT BELT PULL REQUIREMENTS .
Remedy: DEALERS WILL REPLACE THE SEAT BELT D-RING MOUNTING BRACKET. OWNER NOTIFICATION BEGAN ON APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
396 vehicles affected
NOVEMBER 12, 2010, WHILE DRIVING ON A STATE HIGHWAY, AS SOLE OWNER/OPERATOR OF A 2003 VOLVO VHD 64F 10 WHEEL DUMP TRUCK THE ENGINE SUDDENLY AND WITHOUT WARNING STOPPED RUNNING. IT IMMEDIATELY BECAME A SAFETY ISSUE TO CONTROL THIS EMPTY TRUCK WITH NO EQUIPMENT TRAILER ATTACHED BECAUSE OF THE LOSS OF POWER STEERING. THE VEHICLE WAS TOWED TO A VOLVO DEALER. IT WAS DIAGNOSED BY VOLVO AS AN ENGINE COMPUTER FAILURE. VOLVO HAS NOT EXPLAINED WHICH PART OF THIS (EECU) ENGINE ELECTRONIC CONTROL UNIT FAILED, WHICH I REQUESTED TO KNOW. THE EECU WAS REPLACED WITH A VOLVO REBUILT UNIT. THIS IS A PRODUCT SAFETY AND RELIABILITY ISSUE. THIS TRUCK HAS FIFTEEN THOUSAND, (15,000), ORIGINAL MILES. *TR
NOVEMBER 12, 2010, WHILE DRIVING ON A STATE HIGHWAY, AS SOLE OWNER/OPERATOR OF A 2003 VOLVO VHD 64F 10 WHEEL DUMP TRUCK THE ENGINE SUDDENLY AND WITHOUT WARNING STOPPED RUNNING. IT IMMEDIATELY BECAME A SAFETY ISSUE TO CONTROL THIS EMPTY TRUCK WITH NO EQUIPMENT TRAILER ATTACHED BECAUSE OF THE LOSS OF POWER STEERING. THE VEHICLE WAS TOWED TO A VOLVO DEALER. IT WAS DIAGNOSED BY VOLVO AS AN ENGINE COMPUTER FAILURE. VOLVO HAS NOT EXPLAINED WHICH PART OF THIS (EECU) ENGINE ELECTRONIC CONTROL UNIT FAILED, WHICH I REQUESTED TO KNOW. THE EECU WAS REPLACED WITH A VOLVO REBUILT UNIT. THIS IS A PRODUCT SAFETY AND RELIABILITY ISSUE. THIS TRUCK HAS FIFTEEN THOUSAND, (15,000), ORIGINAL MILES. *TR
THE TRUCK WAS JUST WORKING AN AVERAGE DAY, HAULING HOT MIX ASPHALT, WHEN THE ENGINE BEGAN TO SKIP. BROUGHT THE TRUCK INTO DARIO DIESEL, THEY FOUND FAULTY INJECTOR CONNECTOR, HAD IT REPLACED. ONE MONTH LATER, THE SAME THING HAPPENED, AGAIN TOOK TRUCK TO DARIO DIESEL, THEY FOUND THE SAME PROBLEM, THEY REPAIRED THE CONNECTOR, AND SENT THE TRUCK ON ITS WAY. 2 MONTHS AFTER SECOND REPAIR, IT HAPPENED AGAIN, THEY FOUND THE SAME PROBLEM, CORRECTED IT AND SENT THE TRUCK ON ITS WAY AGAIN. ONE MONTH AFTER THIRD REPAIR, THE SAME THING HAPPENED AGAIN, AGAIN TOOK THE TRUCK TO DARIO DIESEL, THEY FOUND THE SAME PROBLEM AND SENT THE TRUCK ON ITS WAY. NOW THEY TELL US THE WHOLE WIRING HARNESS FOR THE CONNECTORS NEED TO BE REPLACED. WE HAVE ALREADY SPENT $1397.00 HAVING THIS PROBLEM SUPPOSEDLY REPAIRED. WE HAVE ALSO SENT A LETTER TO VOLVO TRUCKS TELLING THEM OF THE PROBLEM. *TR
ABS MALFUNCTION BRAKE SHUTDOWN AND UNIT TURNED OF COMPLETELY WHILE DRIVING VEHICLE. COULD NOT MAINTAIN CONTROL OF VEHICLE. I PLACED VEHICLE IN COMPANY SHOP SEVERAL TIMES AND INCIDENT CONTINUED TO OCCUR NUMEROUS TIMES. I SPOKE TO SWIFT OPERATION MANAGER SCOTT JOHNSON LOCATED IN OCALA FLORIDA ABOUT PROBLEM AND NOTHING WAS DONE. I SPOKE TO RICK PICKARD SWIFT FLEET MANAGE IN OCALA OFFICER AND NOTHING WAS DONE. I SPOKE TO ROB WHO IS THE HEAD SHOP MANAGER OF THE OCALA OFFICE. I REQUESTED THAT THE VEHICLE BE SENT TO VOLCO TECHNICIANS AND NOTHING WAS DONE. THEY PLACE THE VEHICLE IN THE SHOP FOR THE FOURTH TIME IN THREE CONSECUTIVE WEEKS FOR THE SAME INITIAL PROBLEM AND NOTHING WAS DONE. FURTHERMORE IT STATES IN THE VEHICLE MANUAL OF VOLVO, IF TOTAL SHUTDOWN OF VEHICLE OCCURS AT ANY TIME PLEASE NOTIFY VOLVO DIRECTLY AS WELL AS DOT TO REPORT VEHICLE PROBLEMS TO PREVENT ANY OUTCOME OF AN ACCIDENT, INJURY OR DEATH. PAGE 134 OF VEHICLE MANUAL. *JB
ABS MALFUNCTION BRAKE SHUTDOWN AND UNIT TURNED OF COMPLETELY WHILE DRIVING VEHICLE. COULD NOT MAINTAIN CONTROL OF VEHICLE. I PLACED VEHICLE IN COMPANY SHOP SEVERAL TIMES AND INCIDENT CONTINUED TO OCCUR NUMEROUS TIMES. I SPOKE TO SWIFT OPERATION MANAGER SCOTT JOHNSON LOCATED IN OCALA FLORIDA ABOUT PROBLEM AND NOTHING WAS DONE. I SPOKE TO RICK PICKARD SWIFT FLEET MANAGE IN OCALA OFFICER AND NOTHING WAS DONE. I SPOKE TO ROB WHO IS THE HEAD SHOP MANAGER OF THE OCALA OFFICE. I REQUESTED THAT THE VEHICLE BE SENT TO VOLCO TECHNICIANS AND NOTHING WAS DONE. THEY PLACE THE VEHICLE IN THE SHOP FOR THE FOURTH TIME IN THREE CONSECUTIVE WEEKS FOR THE SAME INITIAL PROBLEM AND NOTHING WAS DONE. FURTHERMORE IT STATES IN THE VEHICLE MANUAL OF VOLVO, IF TOTAL SHUTDOWN OF VEHICLE OCCURS AT ANY TIME PLEASE NOTIFY VOLVO DIRECTLY AS WELL AS DOT TO REPORT VEHICLE PROBLEMS TO PREVENT ANY OUTCOME OF AN ACCIDENT, INJURY OR DEATH. PAGE 134 OF VEHICLE MANUAL. *JB