2010 VAN HOOL T2140
3 recalls — 0 complaints — 25 TSBs
17V064000 Jan 31, 2017
STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
Defect Description
Van Hool N.V. (Van Hool) is recalling certain 2010-2014 C2045 and T2145 motorcoaches, 2014-2015 TX40 motorcoaches, 2014-2017 TX45 motorcoaches, 2011-2015 TD925 motorcoaches, 2014-2016 CX45 motorcoaches and 2010-2013 T2140 motorcoaches. When the vehicle is started in low temperatures, the steering w... Read more
Consequence
Reduced steering ability can increase the risk of a crash.
Remedy
Van Hool will notify owners, and dealers will replace the steering box, free of charge. The recall began on February 21, 2017. Owners may contact ABC Bus, Inc. at 1-877-427-7278. Van Hool's number for this recall is P826.
16V857000 Nov 29, 2016
STEERING
Defect Description
Van Hool N.V. (Van Hool) is recalling certain model year 2010-2014 C2045 and T2145; 2010 C3045; 2016 CX35; 2014-2016 CX45 and TX45; 2009-2016 TD925; 2015-2016 TDX25 and TX40 and 2010-2013 T2140 motorcoaches. In the affected vehicles, the front steering knuckle carriers may crack.
Consequence
Cracking of a steering knuckle carrier may result in its total failure, allowing a wheel to separate from the vehicle, increasing the risk of a crash.
Remedy
Van Hool will notify owners, and dealers will replace the steering knuckle carriers that were produced from August 2009 through March 2011. Carriers that were produced from April 2011 to December 2014 will be inspected by ultrasonic measurement and replaced as necessary. These repairs will be perf... Read more
10V603000 Dec 1, 2010
VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR
Defect Description
VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2011 TRANSIT BUSES AND MOTORCOACHES MANUFACTURED FROM AUGUST 2002 THROUGH OCTOBER 2010, EQUIPPED WITH HADLEY REMOTE MIRROR SWITCHES, PART NUMBERS 509VH AND 509VH1F. THE REAR VIEW MIRROR SWITCH MAY OVERHEAT, CAUSING THE PLASTIC HOUSING TO MELT.
Consequence
EXCESSIVE HEATING CAN CAUSE A FIRE RESULTING IN SMOKE, OPERATOR DISTRACTION, OR PERSONAL INJURY. AN OVERHEATED MIRROR SWITCH COULD CAUSE THE EXTERIOR REAR VIEW MIRRORS TO NOT OPERATE. THE MIRRORS MAY NOT ADJUST PROPERLY FROM THE INTERIOR SWITCH OR OPERATE POORLY. THEREFORE, THE DRIVER MAY NOT BE ... Read more
Remedy
VAN HOOL WILL NOTIFY OWNERS VIA ITS DEALER ABC BUS INC. OWNERS WILL HAVE THE CHOICE TO PERFORM THE REPAIR THEMSELVES OR TO TAKE THE VEHICLE(S) TO AN ABC-LOCATION FOR REPAIR, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 10, 2011. OWNERS MAY CONTACT THE WARRANTY ADMINISTRATOR FOR ABC BUS, INC... Read more
No complaints found for this vehicle.
Technical Service Bulletins — 2010 VAN HOOL T2140
25 manufacturer communications from 17 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 4 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 3 |
| 200000 WHEELS | 3 |
| 060000 ENGINE AND ENGINE COOLING | 2 |
| 100000 POWER TRAIN | 2 |
| 135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR | 1 |
| 021600 SUSPENSION:FRONT:WHEEL BEARING | 1 |
| 010000 STEERING | 1 |
SB2372
Jan 8, 2024
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
This service bulletin provides you with information about the location of emergency side window decals so that the vehicle meets the National Highway Traffic Safety Administrationa??s (NHTSA) Federal Motor Vehicle Safety Standards (FMVSS)
SB2255
Jan 3, 2023
353000 EQUIPMENT:ELECTRICAL
Service Information: In its production process, Bock, manufacturer of refrigerant compressors, has switched to a new type of motor protection switch for the electric motor of the refrigerant compressor. As the MP10 motor protection switch (
SB1709
Aug 31, 2022
200000 WHEELS
Product Improvement: ALL VEHICLES WITH LIGHT-ALLOY WHEELS - Introduction of wheel-end monitoring system (WEM). Van Hool has released a wheel-end monitoring system (WEM) which can be installed on all vehicles equipped with light-alloy wheels
SB1856
Mar 24, 2022
100000 POWER TRAIN
Service Information - Maintenance operations related to refrigerant compressor oil This service information bulletin is a reminder/update about refrigerant compressor oil maintenance. To ensure a reliable system, it is important to perform
SB2039A
Nov 19, 2021
103210 POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:VALVES/VALVE BODY
Service Information - Introduction of new 4/2 solenoid valve in compressed-air circuit Van Hool has switched over into production to a new type of 4/2 solenoid valve in the compressed-air system. As the previous Knorr-Bremse (Bosch) soleno
SB2039
Aug 16, 2021
061400 ENGINE AND ENGINE COOLING:ENGINE:SOLENOID/ACTUATOR
SERVICE INFORMATION BULLETIN: Van Hool has switched over into production to a new type of 4/2 solenoid valve in the compressed-air system. As the previous Knorr-Bremse (Bosch) solenoid valve (VH11102170) is no longer made available as spare
SB2039
Aug 16, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
SERVICE INFORMATION BULLETIN: Van Hool has switched over into production to a new type of 4/2 solenoid valve in the compressed-air system. As the previous Knorr-Bremse (Bosch) solenoid valve (VH11102170) is no longer made available as spare
SB2039
Aug 16, 2021
350000 EQUIPMENT
SERVICE INFORMATION BULLETIN: Van Hool has switched over into production to a new type of 4/2 solenoid valve in the compressed-air system. As the previous Knorr-Bremse (Bosch) solenoid valve (VH11102170) is no longer made available as spare
SB1961
Mar 3, 2021
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Service Information Bulletin: What to do in case of prolonged vehicle standstill. This service bulletin provides an overview of works to be performed during prolonged vehicle standstill.
MIC-VANH-090820
Sep 8, 2020
350000 EQUIPMENT
Van Hool N.V. and ABC Companies did not release any new service bulletins during the month of August 2020.
SB1702
Jun 2, 2020
060000 ENGINE AND ENGINE COOLING
Service information Bulletin: Stress-free installation of flex pipe This service bulletin gives step-by-step instructions on how to install the flex pipe properly. The flexible part of the flex pipe handles thermal expansion and engine vib
SB1796
May 13, 2020
100000 POWER TRAIN
Service Information: he purpose of this service bulletin is to inform you about the innocent traces of lubricant at the bottom of the transmission bell housing on new vehicles. They are caused by the protective anti-corrosion coating at the
SB1796
May 13, 2020
060000 ENGINE (PWS)
Service Information: he purpose of this service bulletin is to inform you about the innocent traces of lubricant at the bottom of the transmission bell housing on new vehicles. They are caused by the protective anti-corrosion coating at the
SB1777
May 13, 2020
160000 STRUCTURE
Service Information: This bulletin is being released as a reminder of the importance of wheel bearing preventive maintenance. Check the wheel bearing end-play every 50,000 miles*, and when having any work done on the brakes or any other com
SB1634
Dec 2, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
Product Improvement. Introduction of new single check valves in cooling-circuits deaeration lines.Van Hool have recently switched over into production a new type of single check valve. Contrary to the previous type equipped with a plastic h
SB1634
Dec 2, 2019
350000 EQUIPMENT
Product Improvement. Introduction of new single check valves in cooling-circuits deaeration lines.Van Hool have recently switched over into production a new type of single check valve. Contrary to the previous type equipped with a plastic h
SB1634
Dec 2, 2019
060000 ENGINE AND ENGINE COOLING
Product Improvement. Introduction of new single check valves in cooling-circuits deaeration lines.Van Hool have recently switched over into production a new type of single check valve. Contrary to the previous type equipped with a plastic h
SB1645
Jun 3, 2019
200000 WHEELS
To remove/install wheel-nut caps. Some vehicles have plastic chrome-coloured wheel-nut caps on top of the wheel nuts. This service bulletin gives instructions on how to remove/install these wheel-nut caps correctly.
1261A
Jun 16, 2016
350000 EQUIPMENT
Service Information: Bevel gear of front axle steering system Service records have shown that the grease in the bevel gear could affect performance at very low temperatures (below -20?C/-4?F). If the grease in the bevel gear becomes hard e
1261A
Jun 16, 2016
200000 WHEELS
Service Information: Bevel gear of front axle steering system Service records have shown that the grease in the bevel gear could affect performance at very low temperatures (below -20?C/-4?F). If the grease in the bevel gear becomes hard e
1261A
Jun 16, 2016
010000 STEERING
Service Information: Bevel gear of front axle steering system Service records have shown that the grease in the bevel gear could affect performance at very low temperatures (below -20?C/-4?F). If the grease in the bevel gear becomes hard e
SB1328
Mar 4, 2016
356000 EQUIPMENT ADAPTIVE/MOBILITY
Service Information: DANA wheel bearing end-play DANA, manufacturer of axles, has informed Van Hool that the procedure for checking the wheel bearing end-play has been changed. This change is related to the following axles: ? DANA 11.36
SB1328
Mar 4, 2016
021600 SUSPENSION:FRONT:WHEEL BEARING
Service Information: DANA wheel bearing end-play DANA, manufacturer of axles, has informed Van Hool that the procedure for checking the wheel bearing end-play has been changed. This change is related to the following axles: ? DANA 11.36
SB1263
Apr 17, 2014
138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
Field Change Program: To change blower of driver's cab climate unit Field reports have determined that there is a frequent failure of the blower in the driver's cab climate unit. To address this issue, HeaVac (with the consent of Van Hool)
SB1241
Jan 7, 2011
135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
VAN HOOL: THE REAR VIEW MIRROR SWITCH MAY OVERHEAT AND CAUSE A FIRE HAZARD AND INOPERATIVE MOVEMENT OF MIRRORS. *RM
VAN HOOL T2140 — All Years Overview
Complete safety history for the VAN HOOL T2140 across all model years (1998–2013).
26
Total Recalls
4
Total Complaints
0
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
VAN HOOL T2140 — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.