2007 VAN HOOL C2045
6 recalls — 0 complaints — 34 TSBs
26V191000 Mar 26, 2026
VISIBILITY:GLASS, SIDE/REAR
Defect Description
ABC BUS Inc is recalling certain 1999-2013 Van Hool C2045, 2004-2013 Van Hool T2145, 2013-2022 Van Hool TX45, 2013-2023 Van Hool CX45, and 2016-2022 Van Hool CX35 vehicles. The front entrance door may have the incorrect glaze on the lower curb view window. As such, these vehicles fail to comply with... Read more
Consequence
The incorrect glaze may reduce the driver's visibility, increasing the risk of a crash.
Remedy
Dealers will inspect and install a nontransparent vinyl cover over the window as necessary, free of charge. Owner notification letters were mailed April 20, 2026. Owners may contact ABC Bus customer service at 1-877-427-7278. Vehicle Identification Numbers (VINs) involved in this recall will be sear... Read more
21V799000 Oct 14, 2021
EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP
Defect Description
Van Hool N.V. (Van Hool) is recalling certain 2000-2014 C2045, 2016 CX45, and 1998-2013 T2145 vehicles equipped with Ricon Baylift Wheelchair Lifts. When the lift's outer barrier is fully deployed, it may not withstand a sufficient amount of force, which could cause it to fail. As such, these lift... Read more
Consequence
In the event that a mobility device pushes into the outer barrier, the barrier may fail, increasing the risk of injury for the lift occupant.
Remedy
Ricon will reinforce the outer barrier with additional supports, free of charge. Owner notification letters were mailed on November 30, 2021. Owners may contact Van Hool's customer service at 1-877-427-7278 or 1-407-656-7977. Van Hool's number for this recall is P1528-SB2067.
10V603000 Dec 1, 2010
VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR
Defect Description
VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2011 TRANSIT BUSES AND MOTORCOACHES MANUFACTURED FROM AUGUST 2002 THROUGH OCTOBER 2010, EQUIPPED WITH HADLEY REMOTE MIRROR SWITCHES, PART NUMBERS 509VH AND 509VH1F. THE REAR VIEW MIRROR SWITCH MAY OVERHEAT, CAUSING THE PLASTIC HOUSING TO MELT.
Consequence
EXCESSIVE HEATING CAN CAUSE A FIRE RESULTING IN SMOKE, OPERATOR DISTRACTION, OR PERSONAL INJURY. AN OVERHEATED MIRROR SWITCH COULD CAUSE THE EXTERIOR REAR VIEW MIRRORS TO NOT OPERATE. THE MIRRORS MAY NOT ADJUST PROPERLY FROM THE INTERIOR SWITCH OR OPERATE POORLY. THEREFORE, THE DRIVER MAY NOT BE ... Read more
Remedy
VAN HOOL WILL NOTIFY OWNERS VIA ITS DEALER ABC BUS INC. OWNERS WILL HAVE THE CHOICE TO PERFORM THE REPAIR THEMSELVES OR TO TAKE THE VEHICLE(S) TO AN ABC-LOCATION FOR REPAIR, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 10, 2011. OWNERS MAY CONTACT THE WARRANTY ADMINISTRATOR FOR ABC BUS, INC... Read more
08V237000 May 28, 2008
VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
Defect Description
VAN HOOL IS RECALLING 149 MY 2004-2007 C2045, T2140, AND T2145 MOTOR COACHES EQUIPPED WITH DOGA WINDSHIELD WIPER SYSTEMS. LINKAGES WERE POORLY FINISHED. THIS COULD LEAD TO A MISALIGNMENT OF THE WINDSHIELD WIPER SYSTEM, BLOCKING THE MOTOR.
Consequence
FAILURE OF THE WIPER LINKAGES WILL LEAD TO WIPER SYSTEM BREAKDOWN. THE OPERATOR WILL HAVE REDUCED VISIBILITY WHICH COULD RESULT IN A CRASH.
Remedy
VAN HOOL IS WORKING WITH DOGA AND DOGA WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JULY 23, 2008. OWNERS MAY CONTACT VAN HOOL (ABC COMPANIES) AT 1-407-656-7977.
08V126000 Mar 20, 2008
ENGINE AND ENGINE COOLING
Defect Description
VAN HOOL IS RECALLING 447 MY 2006-2007 C2045 MOTOR COACHES. THE B+ ALTERNATOR CABLE RETENTION ON THE C13 ENGINES MAY FAIL. THE FAILURE WOULD CONSIST OF BREAKAGE OF THE B+ RING TERMINAL.
Consequence
THE POSITIVE BATTERY CABLE DETACHING FROM THE REAR OF THE ALTERNATOR CAN CAUSE CABLE GROUNDING. THIS MAY RESULT IN A FIRE.
Remedy
DEALERS WILL INSPECT AND REPLACE THE NECESSARY CABLES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 20, 2008. OWNERS MAY CONTACT VAN HOOL AT 407-656-7977.
07V186000 Apr 27, 2007
EQUIPMENT
Defect Description
ON CERTAIN MOTOR COACHES EQUIPPED WITH ZF/ARENS AS TRONIC SHIFT SELECTORS, A CELL PHONE PLACED IN THE PROXIMITY OF THE SHIFTER TOUCH PAD COULD CAUSE THE DISPLAY TO CHANGE FROM "R" (REVERSE) TO "D" (DRIVE) SHOULD THE PHONE RECEIVE A CALL.
Consequence
THIS INTERFERENCE CAN CAUSE IMPROPER SHIFTING OF THE TRANSMISSION, AS FORWARD GEAR CAN BE ENGAGED FROM NEUTRAL ONLY, IF THE VEHICLE HAS BEEN STOPPED, AND IF THE BRAKE PEDAL HAS BEEN DEPRESSED. IF THE MALFUNCTION OCCURS WHILE 'R' (REVERSE) IS BEING SELECTED, THE SHIFTER MAY POSSIBLY CHANGE TO 'D' (D... Read more
Remedy
VAN HOOL IS WORKING WITH ZF/ARENS TO DEVELOP A MORE EFFECTIVE REMEDY FOR THIS CAMPAIGN. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT VAN HOOL AT 1-800-222-2871 OR ZF AT 1-734-416-6200.
No complaints found for this vehicle.
Technical Service Bulletins — 2007 VAN HOOL C2045
34 manufacturer communications from 21 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 5 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 4 |
| 200000 WHEELS | 3 |
| 100000 POWER TRAIN | 2 |
| 060000 ENGINE AND ENGINE COOLING | 2 |
| 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES | 2 |
| 136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR | 1 |
| 062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS | 1 |
SB2372
Jan 8, 2024
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
This service bulletin provides you with information about the location of emergency side window decals so that the vehicle meets the National Highway Traffic Safety Administrationa??s (NHTSA) Federal Motor Vehicle Safety Standards (FMVSS)
SB2255
Jan 3, 2023
353000 EQUIPMENT:ELECTRICAL
Service Information: In its production process, Bock, manufacturer of refrigerant compressors, has switched to a new type of motor protection switch for the electric motor of the refrigerant compressor. As the MP10 motor protection switch (
SB1709
Aug 31, 2022
200000 WHEELS
Product Improvement: ALL VEHICLES WITH LIGHT-ALLOY WHEELS - Introduction of wheel-end monitoring system (WEM). Van Hool has released a wheel-end monitoring system (WEM) which can be installed on all vehicles equipped with light-alloy wheels
SB1856
Mar 24, 2022
100000 POWER TRAIN
Service Information - Maintenance operations related to refrigerant compressor oil This service information bulletin is a reminder/update about refrigerant compressor oil maintenance. To ensure a reliable system, it is important to perform
SB2039A
Nov 19, 2021
103210 POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:VALVES/VALVE BODY
Service Information - Introduction of new 4/2 solenoid valve in compressed-air circuit Van Hool has switched over into production to a new type of 4/2 solenoid valve in the compressed-air system. As the previous Knorr-Bremse (Bosch) soleno
SB2039
Aug 16, 2021
350000 EQUIPMENT
SERVICE INFORMATION BULLETIN: Van Hool has switched over into production to a new type of 4/2 solenoid valve in the compressed-air system. As the previous Knorr-Bremse (Bosch) solenoid valve (VH11102170) is no longer made available as spare
SB2039
Aug 16, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
SERVICE INFORMATION BULLETIN: Van Hool has switched over into production to a new type of 4/2 solenoid valve in the compressed-air system. As the previous Knorr-Bremse (Bosch) solenoid valve (VH11102170) is no longer made available as spare
SB2039
Aug 16, 2021
061400 ENGINE AND ENGINE COOLING:ENGINE:SOLENOID/ACTUATOR
SERVICE INFORMATION BULLETIN: Van Hool has switched over into production to a new type of 4/2 solenoid valve in the compressed-air system. As the previous Knorr-Bremse (Bosch) solenoid valve (VH11102170) is no longer made available as spare
SB1961
Mar 3, 2021
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Service Information Bulletin: What to do in case of prolonged vehicle standstill. This service bulletin provides an overview of works to be performed during prolonged vehicle standstill.
MIC-VANH-090820
Sep 8, 2020
350000 EQUIPMENT
Van Hool N.V. and ABC Companies did not release any new service bulletins during the month of August 2020.
SB1702
Jun 2, 2020
060000 ENGINE AND ENGINE COOLING
Service information Bulletin: Stress-free installation of flex pipe This service bulletin gives step-by-step instructions on how to install the flex pipe properly. The flexible part of the flex pipe handles thermal expansion and engine vib
SB1796
May 13, 2020
060000 ENGINE (PWS)
Service Information: he purpose of this service bulletin is to inform you about the innocent traces of lubricant at the bottom of the transmission bell housing on new vehicles. They are caused by the protective anti-corrosion coating at the
SB1796
May 13, 2020
100000 POWER TRAIN
Service Information: he purpose of this service bulletin is to inform you about the innocent traces of lubricant at the bottom of the transmission bell housing on new vehicles. They are caused by the protective anti-corrosion coating at the
SB1777
May 13, 2020
160000 STRUCTURE
Service Information: This bulletin is being released as a reminder of the importance of wheel bearing preventive maintenance. Check the wheel bearing end-play every 50,000 miles*, and when having any work done on the brakes or any other com
WP1134
Dec 2, 2019
350000 EQUIPMENT
To retrofit from Iteris to Wabco LDW2 land departure warning system. Van Hool has released a work procedure to assist ABC Companies in successfully retrofitting a C2045 vehicle factory equipped with an Iteris LDW system to a Wabco LDW2 syst
WP1134
Dec 2, 2019
270000 LANE DEPARTURE
To retrofit from Iteris to Wabco LDW2 land departure warning system. Van Hool has released a work procedure to assist ABC Companies in successfully retrofitting a C2045 vehicle factory equipped with an Iteris LDW system to a Wabco LDW2 syst
WP1134
Dec 2, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
To retrofit from Iteris to Wabco LDW2 land departure warning system. Van Hool has released a work procedure to assist ABC Companies in successfully retrofitting a C2045 vehicle factory equipped with an Iteris LDW system to a Wabco LDW2 syst
SB1634
Dec 2, 2019
356000 EQUIPMENT ADAPTIVE/MOBILITY
Product Improvement. Introduction of new single check valves in cooling-circuits deaeration lines.Van Hool have recently switched over into production a new type of single check valve. Contrary to the previous type equipped with a plastic h
SB1634
Dec 2, 2019
350000 EQUIPMENT
Product Improvement. Introduction of new single check valves in cooling-circuits deaeration lines.Van Hool have recently switched over into production a new type of single check valve. Contrary to the previous type equipped with a plastic h
SB1634
Dec 2, 2019
060000 ENGINE AND ENGINE COOLING
Product Improvement. Introduction of new single check valves in cooling-circuits deaeration lines.Van Hool have recently switched over into production a new type of single check valve. Contrary to the previous type equipped with a plastic h
SB1645
Jun 3, 2019
200000 WHEELS
To remove/install wheel-nut caps. Some vehicles have plastic chrome-coloured wheel-nut caps on top of the wheel nuts. This service bulletin gives instructions on how to remove/install these wheel-nut caps correctly.
SB1252
Aug 23, 2017
162700 STRUCTURE:BODY:TRUNK LID
Change weather strip mounting lip of luggage compartment door.
1261A
Jun 16, 2016
010000 STEERING
Service Information: Bevel gear of front axle steering system Service records have shown that the grease in the bevel gear could affect performance at very low temperatures (below -20?C/-4?F). If the grease in the bevel gear becomes hard e
1261A
Jun 16, 2016
200000 WHEELS
Service Information: Bevel gear of front axle steering system Service records have shown that the grease in the bevel gear could affect performance at very low temperatures (below -20?C/-4?F). If the grease in the bevel gear becomes hard e
1261A
Jun 16, 2016
350000 EQUIPMENT
Service Information: Bevel gear of front axle steering system Service records have shown that the grease in the bevel gear could affect performance at very low temperatures (below -20?C/-4?F). If the grease in the bevel gear becomes hard e
SB1328
Mar 4, 2016
356000 EQUIPMENT ADAPTIVE/MOBILITY
Service Information: DANA wheel bearing end-play DANA, manufacturer of axles, has informed Van Hool that the procedure for checking the wheel bearing end-play has been changed. This change is related to the following axles: ? DANA 11.36
SB1328
Mar 4, 2016
021600 SUSPENSION:FRONT:WHEEL BEARING
Service Information: DANA wheel bearing end-play DANA, manufacturer of axles, has informed Van Hool that the procedure for checking the wheel bearing end-play has been changed. This change is related to the following axles: ? DANA 11.36
SB-1234
Nov 17, 2009
113100 ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID
VAN HOOL COACHES: STARTER SOLENOID FLYBACK DIODE. ALL COACHES FEATURING MULTIPLEX TECHNOLOGY. IN THE MAIN JUNCTION BOX OF THE UNITS, MULTICONNECTOR PIN E11 OF MULTIPLEX NODE 4 (PART #10690971) HAS BEEN CONNECTED TO THE STARTER MOTOR SOLE
CSB-2009-001
Mar 25, 2009
103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
ABC CO. (VAN HOOL INC.): COOLANT LINE SERVICE. THERE ARE 2 SECTIONS. SECTION 1 COVERS REPLACEMENT OF COOLANT HOSES AND SECTION 2 COVERS INSTALLATION OF BRACKETS FOR COOLANT LINE RETENTION. BOTH SECTIONS ARE INCLUDED IN THIS BULLETIN SO
CSB-2009-001
Mar 25, 2009
103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
VAN HOOL BUS: COOLANT LINE SERVICE. BULLETIN INCLUDES 2 SECTIONS. SEC. 1 REPLACEMENT OF COOLANT HOSES AND SEC. 2 INSTALLATION OF BRACKETS FOR COOLANT LINE RETENTION. NO MODEL YEARS LISTED. *PE
CSB-2009-001
Mar 25, 2009
062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
VAN HOOL BUS: COOLANT LINE SERVICE. BULLETIN INCLUDES 2 SECTIONS. SEC. 1 REPLACEMENT OF COOLANT HOSES AND SEC. 2 INSTALLATION OF BRACKETS FOR COOLANT LINE RETENTION. NO MODEL YEARS LISTED. *PE
CSB-2009-001
Mar 25, 2009
061000 ENGINE AND ENGINE COOLING:ENGINE
VAN HOOL BUS: COOLANT LINE SERVICE. BULLETIN INCLUDES 2 SECTIONS. SEC. 1 REPLACEMENT OF COOLANT HOSES AND SEC. 2 INSTALLATION OF BRACKETS FOR COOLANT LINE RETENTION. NO MODEL YEARS LISTED. *PE
SB1213
Jan 18, 2008
136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
VAN HOOL -- PRODUCT IMPROVEMENT - DOGA WIPER MOTOR CHANGE. *NJ
1205
Jun 18, 2007
171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH
LIFT DOOR LATCH COVER - VAN HOOL C2045 WITH WHEEL CHAIR LIFT. *NJ
NHTSA Safety Investigations — VAN HOOL C2045
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE08023
Opened: Mar 26, 2008 — Closed: Jul 21, 2008
WINDSHIELD WIPER REPLACEMENT PROGRAM
A JANUARY 2008 SERVICE BULLETIN SUGGESTS THAT CERTAIN MODEL BUSES SHOULD UPGRADE TO A HIGH TORQUE WIPER MOTOR.THE TSB ALSO ALLUDED TO WIPER MOTOR FAILURES. THEREFORE, ODI OPENED THIS INVESTIGATION TO DETERMINE THE FAILURE MODE, FREQUENCY AND SAFETY SIGNIFICANCE SINCE THE WIPER SYSTEM IS CONSIDERED T... Read more
PE08003
Opened: Jan 23, 2008 — Closed: Mar 26, 2008
ALTERNATOR B+ CABLE RETENTION
THIS INVESTIGATION STARTED FROM A TECHNICAL SERVICE BULLETIN REVIEW.DURING THE INVESTIGATION, ODI EXPRESSED CONCERN ABOUT THE FIRE RISK POSED FROM A SHORTING BATTERY CABLE. VAN HOOL REVISITED THE ISSUE AND DECIDED TO CONDUCT A SAFETY RECALL.UNDER THE SAFETY RECALL, VAN HOOL WILL ADD AN ADDITIONAL CL... Read more
PE04048
Opened: Jun 22, 2004 — Closed: Sep 1, 2004
LUGGAGE STRUT ARM SHORTS CIRCUITS
THIS INVESTIGATION WAS OPENED TO EVALUATE VAN HOOL'S DECISION TO CONDUCT A FIELD SERVICE CAMPAIGN INSTEAD OF A SAFETY RECALL TO REPLACE A DEFECTIVE LUGGAGE COMPARTMENT DOOR STRUT.THIS TYPE OF FAILURE COULD RESULT IN THE STRUT ARM MAKING CONTACT AND SHORTING AGAINST THE MAIN ELECTRICAL JUNCTION BOX.A... Read more
PE04047
Opened: Jun 18, 2004 — Closed: Aug 30, 2004
SERVICE BRAKE SUPPLY TANK SEPARATION
THIS INVESTIGATION WAS OPENED TO EVALUATE VAN HOOL'S DECISION TO CONDUCT A FIELD SERVICE CAMPAIGN INSTEAD OF A SAFETY RECALL TO REPAIR THE SERVICE BRAKE AIR TANK MOUNTING BRACKETS THAT ARE FAILING.THIS TYPE OF FAILURE COULD RESULT IN THE LOSS OF AIR PRESSURE NECESSARY FOR PROPER SERVICE BRAKE APPLIC... Read more
VAN HOOL C2045 — All Years Overview
Complete safety history for the VAN HOOL C2045 across all model years (1999–2014).
89
Total Recalls
0
Total Complaints
4
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
VAN HOOL C2045 — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.