2001 TRIUMPH TT600

2 recalls — 12 complaints

04V156000 Apr 7, 2004
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
ON CERTAIN MOTORCYCLES, THE FUEL CONNECTOR LINKING EACH OF THE FEED AND RETURN FUEL HOSES TO THE FUEL PUMP MOUNTING PLATE MAY FRACTURE FOLLOWING IN-SERVICE HANDLING.
Remedy: DEALERS WILL REPLACE THE CONNECTOR. THE RECALL BEGAN ON JULY 30, 2004. OWNERS SHOULD CONTACT TRIUMPH AT 1-678-854-2010.
18,998 vehicles affected
01V339000 Nov 2, 2001
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
VEHICLE DESCRIPTION: MOTORCYCLES. THE CLUTCH CONTROL CABLE CAN FRAY AND FAIL. THE BARREL AT THE END OF THE INNER CABLE SEIZES IN THE CONTROL LEVER BORE, THEREBY STRESSING THE INNER CABLE.
Remedy: DEALERS WILL REPLACE THE CLUTCH CABLE. OWNER NOTIFICATIONBEGAN JANUARY 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TRIUMPH AT 678-854-2010.
3,427 vehicles affected
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS May 24, 2010
TL*THE CONTACT OWNS A 2001 TRIUMPH TT600 MOTORCYCLE. WHILE THE CONTACT WAS DRIVING AT APPROXIMATELY 45 MPH THE HIGH PRESSURE FUEL LINE SEPARATED AND THE FUEL SPRAYED OUT ONTO HIS CLOTHING. THE VEHICLE WAS PULLED OVER AND TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE HAD BEEN PREVIOUSLY REPAIRED IN 2004 UNDER NHTSA CAMPAIGN ID NUMBER 04V156000 (FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS). RECENTLY,THE IDENTICAL FAILURE OCCURRED RELATED TO A DIFFERENT FITTING. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT HAD CONCERN OF THE POTENTIAL SAFETY HAZARD. THE FAILURE MILEAGE WAS 8,367.
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS Jul 2, 2004
RECALL 04V156000 CONCERNING FUEL CONNECTORS. FUEL FITTINGS SEPARATED FROM THE GAS TANK, AND GAS WAS SPILLING ON TO THE ENGINE AND THE GROUND. CONSUMER CONTACTED THE DEALER, AND DEALER OR MANUFACTURER HELPED THE CONSUMER. ALSO, CONSUMER STATED THAT DEALER WILL REPAIR THE PROBLEM ONLY IF CONSUMER PAID FOR IT. *AK
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE Aug 13, 2002
THE CONSUMER STATES THAT THE ENGINE WOULD ACCELERATE FROM 800 TO 3500 RPM WHEN ENGAGED, CAUSING THE MOTORCYCLE TO TAKE OFF. THE MOTORCYCLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS, AND THE PROBLEM IS STILL OCCURRING. *AK THE CONSUMER STATES THAT THE VEHICLE HAS MAJOR FUEL INJECTION PROBLEMS. THE VEHICLE HAS BEEN IN THE SHOP 7 TIMES FOR THE SAME PROBLEM. (TWO BIKES WITH FUEL INJECTION PROBLEMS, HAS NOT BEEN CORRECTED, BOTH ARE FIRE HAZARDS.-THE CAT CONVERTER CAUGHT FIRE) THE CONSUMER HAS A VIDEO OF THE FIRE INCIDENT WHICH STARTED LIKE A SMALL BUSH FIRE ON THE SIDE OF THE ROAD. THE CONSUMER TALKED TO OTHER TT600 OWNER WITH THE SAME PROBLEM. THE BIKE GETS 18 MPG, AND THE TRANSMISSION STILL IS NOT SHIFTING PROPERLY. THE CONSUMER REQUESTS ANOTHER MOTORCYCLE-DIFFERENT MODEL, OR MONEY RETURNED. ADDITIONAL PROBLEMS WITH BIKE; TIME CONSUMING-THE BATTERY IS ALMOST COMPLETELY DRAINED BY THE TIME THE BIKE IS STARTED, THE FUEL MILEAGE-UNACCEPTABLE, IDLE ERRATIC, HAS DROPPED THE BIKE TWICE AT SLOW SPEED TURNS, DUE TO A RESULT IN IDLE SPEED SURGES (JUMPED FROM 600 TO 4500 RPM-HAPPENS AT RANDOM, THE MUFFLER GLOWS RED DUE TO THE EMMISIONS BEING GROSSLY OUT OF SPEC., PLUGS ARE FOWLED, CO'S & HC'S ARE EXTREMELY RICH DUE TO IMPROPER MAPPING OF THE FUEL SYSTEM, CANISTER PURGE VALVE LEAKING INTERNALLY, FOUND FUEL TRIM & ENGINE LOAD MAXED OUT, HAD TO ADJUST TPS TO HELP COMPENSATE FUEL RICH PROBLEMS JUST TO GET BIKE TO DESTINATION, THE FOOT REST RUBBER FRONT (LH/RH)-REPAIRS, PEG BANK ANGLE(?)-REPAIR, SCREW IN THE TORX-REPAIR, INDICATOR FRONT LH-REPAIR, LEVER ASSY-REPAIR, THE FAIRING SIDE RH PNTD (?)-REPAIR, THE INFILL PANEL RADIATOR-REPAIR, AND THE GASKET/CLUTCH COVER-DIAGNOSED REPAIR LOOSE SHIFTER. *SCC
Fire
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM Aug 13, 2002
THE CONSUMER STATES THAT THE ENGINE WOULD ACCELERATE FROM 800 TO 3500 RPM WHEN ENGAGED, CAUSING THE MOTORCYCLE TO TAKE OFF. THE MOTORCYCLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS, AND THE PROBLEM IS STILL OCCURRING. *AK THE CONSUMER STATES THAT THE VEHICLE HAS MAJOR FUEL INJECTION PROBLEMS. THE VEHICLE HAS BEEN IN THE SHOP 7 TIMES FOR THE SAME PROBLEM. (TWO BIKES WITH FUEL INJECTION PROBLEMS, HAS NOT BEEN CORRECTED, BOTH ARE FIRE HAZARDS.-THE CAT CONVERTER CAUGHT FIRE) THE CONSUMER HAS A VIDEO OF THE FIRE INCIDENT WHICH STARTED LIKE A SMALL BUSH FIRE ON THE SIDE OF THE ROAD. THE CONSUMER TALKED TO OTHER TT600 OWNER WITH THE SAME PROBLEM. THE BIKE GETS 18 MPG, AND THE TRANSMISSION STILL IS NOT SHIFTING PROPERLY. THE CONSUMER REQUESTS ANOTHER MOTORCYCLE-DIFFERENT MODEL, OR MONEY RETURNED. ADDITIONAL PROBLEMS WITH BIKE; TIME CONSUMING-THE BATTERY IS ALMOST COMPLETELY DRAINED BY THE TIME THE BIKE IS STARTED, THE FUEL MILEAGE-UNACCEPTABLE, IDLE ERRATIC, HAS DROPPED THE BIKE TWICE AT SLOW SPEED TURNS, DUE TO A RESULT IN IDLE SPEED SURGES (JUMPED FROM 600 TO 4500 RPM-HAPPENS AT RANDOM, THE MUFFLER GLOWS RED DUE TO THE EMMISIONS BEING GROSSLY OUT OF SPEC., PLUGS ARE FOWLED, CO'S & HC'S ARE EXTREMELY RICH DUE TO IMPROPER MAPPING OF THE FUEL SYSTEM, CANISTER PURGE VALVE LEAKING INTERNALLY, FOUND FUEL TRIM & ENGINE LOAD MAXED OUT, HAD TO ADJUST TPS TO HELP COMPENSATE FUEL RICH PROBLEMS JUST TO GET BIKE TO DESTINATION, THE FOOT REST RUBBER FRONT (LH/RH)-REPAIRS, PEG BANK ANGLE(?)-REPAIR, SCREW IN THE TORX-REPAIR, INDICATOR FRONT LH-REPAIR, LEVER ASSY-REPAIR, THE FAIRING SIDE RH PNTD (?)-REPAIR, THE INFILL PANEL RADIATOR-REPAIR, AND THE GASKET/CLUTCH COVER-DIAGNOSED REPAIR LOOSE SHIFTER. *SCC
Fire
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR Aug 13, 2002
THE CONSUMER STATES THAT THE ENGINE WOULD ACCELERATE FROM 800 TO 3500 RPM WHEN ENGAGED, CAUSING THE MOTORCYCLE TO TAKE OFF. THE MOTORCYCLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS, AND THE PROBLEM IS STILL OCCURRING. *AK THE CONSUMER STATES THAT THE VEHICLE HAS MAJOR FUEL INJECTION PROBLEMS. THE VEHICLE HAS BEEN IN THE SHOP 7 TIMES FOR THE SAME PROBLEM. (TWO BIKES WITH FUEL INJECTION PROBLEMS, HAS NOT BEEN CORRECTED, BOTH ARE FIRE HAZARDS.-THE CAT CONVERTER CAUGHT FIRE) THE CONSUMER HAS A VIDEO OF THE FIRE INCIDENT WHICH STARTED LIKE A SMALL BUSH FIRE ON THE SIDE OF THE ROAD. THE CONSUMER TALKED TO OTHER TT600 OWNER WITH THE SAME PROBLEM. THE BIKE GETS 18 MPG, AND THE TRANSMISSION STILL IS NOT SHIFTING PROPERLY. THE CONSUMER REQUESTS ANOTHER MOTORCYCLE-DIFFERENT MODEL, OR MONEY RETURNED. ADDITIONAL PROBLEMS WITH BIKE; TIME CONSUMING-THE BATTERY IS ALMOST COMPLETELY DRAINED BY THE TIME THE BIKE IS STARTED, THE FUEL MILEAGE-UNACCEPTABLE, IDLE ERRATIC, HAS DROPPED THE BIKE TWICE AT SLOW SPEED TURNS, DUE TO A RESULT IN IDLE SPEED SURGES (JUMPED FROM 600 TO 4500 RPM-HAPPENS AT RANDOM, THE MUFFLER GLOWS RED DUE TO THE EMMISIONS BEING GROSSLY OUT OF SPEC., PLUGS ARE FOWLED, CO'S & HC'S ARE EXTREMELY RICH DUE TO IMPROPER MAPPING OF THE FUEL SYSTEM, CANISTER PURGE VALVE LEAKING INTERNALLY, FOUND FUEL TRIM & ENGINE LOAD MAXED OUT, HAD TO ADJUST TPS TO HELP COMPENSATE FUEL RICH PROBLEMS JUST TO GET BIKE TO DESTINATION, THE FOOT REST RUBBER FRONT (LH/RH)-REPAIRS, PEG BANK ANGLE(?)-REPAIR, SCREW IN THE TORX-REPAIR, INDICATOR FRONT LH-REPAIR, LEVER ASSY-REPAIR, THE FAIRING SIDE RH PNTD (?)-REPAIR, THE INFILL PANEL RADIATOR-REPAIR, AND THE GASKET/CLUTCH COVER-DIAGNOSED REPAIR LOOSE SHIFTER. *SCC
Fire
POWER TRAIN:MANUAL TRANSMISSION Aug 13, 2002
THE CONSUMER STATES THAT THE ENGINE WOULD ACCELERATE FROM 800 TO 3500 RPM WHEN ENGAGED, CAUSING THE MOTORCYCLE TO TAKE OFF. THE MOTORCYCLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS, AND THE PROBLEM IS STILL OCCURRING. *AK THE CONSUMER STATES THAT THE VEHICLE HAS MAJOR FUEL INJECTION PROBLEMS. THE VEHICLE HAS BEEN IN THE SHOP 7 TIMES FOR THE SAME PROBLEM. (TWO BIKES WITH FUEL INJECTION PROBLEMS, HAS NOT BEEN CORRECTED, BOTH ARE FIRE HAZARDS.-THE CAT CONVERTER CAUGHT FIRE) THE CONSUMER HAS A VIDEO OF THE FIRE INCIDENT WHICH STARTED LIKE A SMALL BUSH FIRE ON THE SIDE OF THE ROAD. THE CONSUMER TALKED TO OTHER TT600 OWNER WITH THE SAME PROBLEM. THE BIKE GETS 18 MPG, AND THE TRANSMISSION STILL IS NOT SHIFTING PROPERLY. THE CONSUMER REQUESTS ANOTHER MOTORCYCLE-DIFFERENT MODEL, OR MONEY RETURNED. ADDITIONAL PROBLEMS WITH BIKE; TIME CONSUMING-THE BATTERY IS ALMOST COMPLETELY DRAINED BY THE TIME THE BIKE IS STARTED, THE FUEL MILEAGE-UNACCEPTABLE, IDLE ERRATIC, HAS DROPPED THE BIKE TWICE AT SLOW SPEED TURNS, DUE TO A RESULT IN IDLE SPEED SURGES (JUMPED FROM 600 TO 4500 RPM-HAPPENS AT RANDOM, THE MUFFLER GLOWS RED DUE TO THE EMMISIONS BEING GROSSLY OUT OF SPEC., PLUGS ARE FOWLED, CO'S & HC'S ARE EXTREMELY RICH DUE TO IMPROPER MAPPING OF THE FUEL SYSTEM, CANISTER PURGE VALVE LEAKING INTERNALLY, FOUND FUEL TRIM & ENGINE LOAD MAXED OUT, HAD TO ADJUST TPS TO HELP COMPENSATE FUEL RICH PROBLEMS JUST TO GET BIKE TO DESTINATION, THE FOOT REST RUBBER FRONT (LH/RH)-REPAIRS, PEG BANK ANGLE(?)-REPAIR, SCREW IN THE TORX-REPAIR, INDICATOR FRONT LH-REPAIR, LEVER ASSY-REPAIR, THE FAIRING SIDE RH PNTD (?)-REPAIR, THE INFILL PANEL RADIATOR-REPAIR, AND THE GASKET/CLUTCH COVER-DIAGNOSED REPAIR LOOSE SHIFTER. *SCC
Fire
UNKNOWN OR OTHER Aug 13, 2002
THE CONSUMER STATES THAT THE ENGINE WOULD ACCELERATE FROM 800 TO 3500 RPM WHEN ENGAGED, CAUSING THE MOTORCYCLE TO TAKE OFF. THE MOTORCYCLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS, AND THE PROBLEM IS STILL OCCURRING. *AK THE CONSUMER STATES THAT THE VEHICLE HAS MAJOR FUEL INJECTION PROBLEMS. THE VEHICLE HAS BEEN IN THE SHOP 7 TIMES FOR THE SAME PROBLEM. (TWO BIKES WITH FUEL INJECTION PROBLEMS, HAS NOT BEEN CORRECTED, BOTH ARE FIRE HAZARDS.-THE CAT CONVERTER CAUGHT FIRE) THE CONSUMER HAS A VIDEO OF THE FIRE INCIDENT WHICH STARTED LIKE A SMALL BUSH FIRE ON THE SIDE OF THE ROAD. THE CONSUMER TALKED TO OTHER TT600 OWNER WITH THE SAME PROBLEM. THE BIKE GETS 18 MPG, AND THE TRANSMISSION STILL IS NOT SHIFTING PROPERLY. THE CONSUMER REQUESTS ANOTHER MOTORCYCLE-DIFFERENT MODEL, OR MONEY RETURNED. ADDITIONAL PROBLEMS WITH BIKE; TIME CONSUMING-THE BATTERY IS ALMOST COMPLETELY DRAINED BY THE TIME THE BIKE IS STARTED, THE FUEL MILEAGE-UNACCEPTABLE, IDLE ERRATIC, HAS DROPPED THE BIKE TWICE AT SLOW SPEED TURNS, DUE TO A RESULT IN IDLE SPEED SURGES (JUMPED FROM 600 TO 4500 RPM-HAPPENS AT RANDOM, THE MUFFLER GLOWS RED DUE TO THE EMMISIONS BEING GROSSLY OUT OF SPEC., PLUGS ARE FOWLED, CO'S & HC'S ARE EXTREMELY RICH DUE TO IMPROPER MAPPING OF THE FUEL SYSTEM, CANISTER PURGE VALVE LEAKING INTERNALLY, FOUND FUEL TRIM & ENGINE LOAD MAXED OUT, HAD TO ADJUST TPS TO HELP COMPENSATE FUEL RICH PROBLEMS JUST TO GET BIKE TO DESTINATION, THE FOOT REST RUBBER FRONT (LH/RH)-REPAIRS, PEG BANK ANGLE(?)-REPAIR, SCREW IN THE TORX-REPAIR, INDICATOR FRONT LH-REPAIR, LEVER ASSY-REPAIR, THE FAIRING SIDE RH PNTD (?)-REPAIR, THE INFILL PANEL RADIATOR-REPAIR, AND THE GASKET/CLUTCH COVER-DIAGNOSED REPAIR LOOSE SHIFTER. *SCC
Fire
EQUIPMENT Aug 13, 2002
THE CONSUMER STATES THAT THE ENGINE WOULD ACCELERATE FROM 800 TO 3500 RPM WHEN ENGAGED, CAUSING THE MOTORCYCLE TO TAKE OFF. THE MOTORCYCLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS, AND THE PROBLEM IS STILL OCCURRING. *AK THE CONSUMER STATES THAT THE VEHICLE HAS MAJOR FUEL INJECTION PROBLEMS. THE VEHICLE HAS BEEN IN THE SHOP 7 TIMES FOR THE SAME PROBLEM. (TWO BIKES WITH FUEL INJECTION PROBLEMS, HAS NOT BEEN CORRECTED, BOTH ARE FIRE HAZARDS.-THE CAT CONVERTER CAUGHT FIRE) THE CONSUMER HAS A VIDEO OF THE FIRE INCIDENT WHICH STARTED LIKE A SMALL BUSH FIRE ON THE SIDE OF THE ROAD. THE CONSUMER TALKED TO OTHER TT600 OWNER WITH THE SAME PROBLEM. THE BIKE GETS 18 MPG, AND THE TRANSMISSION STILL IS NOT SHIFTING PROPERLY. THE CONSUMER REQUESTS ANOTHER MOTORCYCLE-DIFFERENT MODEL, OR MONEY RETURNED. ADDITIONAL PROBLEMS WITH BIKE; TIME CONSUMING-THE BATTERY IS ALMOST COMPLETELY DRAINED BY THE TIME THE BIKE IS STARTED, THE FUEL MILEAGE-UNACCEPTABLE, IDLE ERRATIC, HAS DROPPED THE BIKE TWICE AT SLOW SPEED TURNS, DUE TO A RESULT IN IDLE SPEED SURGES (JUMPED FROM 600 TO 4500 RPM-HAPPENS AT RANDOM, THE MUFFLER GLOWS RED DUE TO THE EMMISIONS BEING GROSSLY OUT OF SPEC., PLUGS ARE FOWLED, CO'S & HC'S ARE EXTREMELY RICH DUE TO IMPROPER MAPPING OF THE FUEL SYSTEM, CANISTER PURGE VALVE LEAKING INTERNALLY, FOUND FUEL TRIM & ENGINE LOAD MAXED OUT, HAD TO ADJUST TPS TO HELP COMPENSATE FUEL RICH PROBLEMS JUST TO GET BIKE TO DESTINATION, THE FOOT REST RUBBER FRONT (LH/RH)-REPAIRS, PEG BANK ANGLE(?)-REPAIR, SCREW IN THE TORX-REPAIR, INDICATOR FRONT LH-REPAIR, LEVER ASSY-REPAIR, THE FAIRING SIDE RH PNTD (?)-REPAIR, THE INFILL PANEL RADIATOR-REPAIR, AND THE GASKET/CLUTCH COVER-DIAGNOSED REPAIR LOOSE SHIFTER. *SCC
Fire
ELECTRICAL SYSTEM:12V/24V/48V BATTERY Aug 13, 2002
THE CONSUMER STATES THAT THE ENGINE WOULD ACCELERATE FROM 800 TO 3500 RPM WHEN ENGAGED, CAUSING THE MOTORCYCLE TO TAKE OFF. THE MOTORCYCLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS, AND THE PROBLEM IS STILL OCCURRING. *AK THE CONSUMER STATES THAT THE VEHICLE HAS MAJOR FUEL INJECTION PROBLEMS. THE VEHICLE HAS BEEN IN THE SHOP 7 TIMES FOR THE SAME PROBLEM. (TWO BIKES WITH FUEL INJECTION PROBLEMS, HAS NOT BEEN CORRECTED, BOTH ARE FIRE HAZARDS.-THE CAT CONVERTER CAUGHT FIRE) THE CONSUMER HAS A VIDEO OF THE FIRE INCIDENT WHICH STARTED LIKE A SMALL BUSH FIRE ON THE SIDE OF THE ROAD. THE CONSUMER TALKED TO OTHER TT600 OWNER WITH THE SAME PROBLEM. THE BIKE GETS 18 MPG, AND THE TRANSMISSION STILL IS NOT SHIFTING PROPERLY. THE CONSUMER REQUESTS ANOTHER MOTORCYCLE-DIFFERENT MODEL, OR MONEY RETURNED. ADDITIONAL PROBLEMS WITH BIKE; TIME CONSUMING-THE BATTERY IS ALMOST COMPLETELY DRAINED BY THE TIME THE BIKE IS STARTED, THE FUEL MILEAGE-UNACCEPTABLE, IDLE ERRATIC, HAS DROPPED THE BIKE TWICE AT SLOW SPEED TURNS, DUE TO A RESULT IN IDLE SPEED SURGES (JUMPED FROM 600 TO 4500 RPM-HAPPENS AT RANDOM, THE MUFFLER GLOWS RED DUE TO THE EMMISIONS BEING GROSSLY OUT OF SPEC., PLUGS ARE FOWLED, CO'S & HC'S ARE EXTREMELY RICH DUE TO IMPROPER MAPPING OF THE FUEL SYSTEM, CANISTER PURGE VALVE LEAKING INTERNALLY, FOUND FUEL TRIM & ENGINE LOAD MAXED OUT, HAD TO ADJUST TPS TO HELP COMPENSATE FUEL RICH PROBLEMS JUST TO GET BIKE TO DESTINATION, THE FOOT REST RUBBER FRONT (LH/RH)-REPAIRS, PEG BANK ANGLE(?)-REPAIR, SCREW IN THE TORX-REPAIR, INDICATOR FRONT LH-REPAIR, LEVER ASSY-REPAIR, THE FAIRING SIDE RH PNTD (?)-REPAIR, THE INFILL PANEL RADIATOR-REPAIR, AND THE GASKET/CLUTCH COVER-DIAGNOSED REPAIR LOOSE SHIFTER. *SCC
Fire
POWER TRAIN:MANUAL TRANSMISSION Aug 5, 2002
TRANSMISSION COOLANT LEAKING FROM UNDERNEATH MOTORCYCLE. DEALERSHIP IS AWARE OF PROBLEM.*AK
POWER TRAIN:MANUAL TRANSMISSION Aug 16, 2001
MOTORCYCLE WAS GOING 65MPH AND REAR WHEEL LOCKED UP. MOTORCYCLE WENT INTO A SIDEWAY SKID, BUT WAS ABLE TO GET MOTORCYCLE BACK TO A FORWARD MOTION, AND OVER TO SIDE ACROSS THE FREEWAY. DEALER STATED THAT MOTORCYCLE WAS EITHER BEING SHIFTED TOO HIGH OR TOO LOW. MECHANIC AT DEALER HAD TO BREAK MOTORCYCLE DOWN TO DIAGNOSIS THE CAUSE. FOUND THAT BEARING WENT, CAUSING THE BUSHING AND TRANSMISSION TO BLOW. *AK
POWER TRAIN:MANUAL TRANSMISSION Aug 2, 2001
I WAS HEADING WEST ON INTERSTATE 80 COMING IN TO AUBURN, CALIFORNIA, BETWEEN 65 AND 70 MPH IN 6TH GEAR AND COMING INTO A LIGHT TURN WHEN THERE WAS A GRINDING NOISE AND WITHIN A SECOND THE ENTIRE TRANSMISSION AND/OR GEARBOX FROZE LOCKING MY REAR TIRE. THE BIKE SLID SIDEWAYS ALL THE WAY AROUND THE TURN, I PUMPED THE CLUTCH 13 TIMES BEFORE THE REAR WHEEL DISENGAGED ENDING THE SLIDE. I DON'T KNOW HOW I STAYED ON THE BIKE AND SHOULD MOST LIKELY BE DEAD OR SEVERELY INJURED. THE MAIN PPROBLEM IS THAT THE DEALERSHIP HAS HAD MY BIKE FOR OVER A MONTH[SUNCE JULY 5] AND HAS CONTINUALLY LIED TO MY MOTHER AND I ABOUT WHY THIS HAPPENED AND WHEN IT WAS TO BE FIXED[THEY'VE MISSED THEIR DATE TWICE SO FAR] WE HAVE JUST CONTACTED OUR LAWYERS AND WOULD LIKE ADDITIONAL HELP IF POSSIBLE.THANK YOU.