FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
ON CERTAIN MOTORCYCLES, THE FUEL CONNECTOR LINKING EACH OF THE FEED AND RETURN FUEL HOSES TO THE FUEL PUMP MOUNTING PLATE MAY FRACTURE FOLLOWING IN-SERVICE HANDLING.
Remedy: DEALERS WILL REPLACE THE CONNECTOR. THE RECALL BEGAN ON JULY 30, 2004. OWNERS SHOULD CONTACT TRIUMPH AT 1-678-854-2010.
18,998 vehicles affected
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ON CERTAIN MOTORCYCLES, THERE IS A POSSIBILITY THAT THE FUEL PUMP PLATE SEAL MAY ALLOW FUEL TO LEAK FROM THE FUEL TANK.
Remedy: ALL MOTORCYCLES WERE CONTAINED AT THE U.S. WAREHOUSE AND HAVE BEEN REPAIRED.
14 vehicles affected
SERVICE BRAKES, HYDRAULIC
ON CERTAIN MOTORCYCLES, THE REAR BRAKE CLEVIS PIN CLIP MAY ROTATE WHILE ENGAGING THE REAR BRAKE, PREVENTING THE PEDAL FROM FULLY RETURNING THE ORIGINAL REST POSITION.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE RETAINING CLIP. OWNER NOTIFICATION BEGAN OCTOBER 27, 2003. OWNERS SHOULD CONTACT TRIUMPH AT 1-678-854-2010.
602 vehicles affected
THE RED NYLON FUEL CONNECTOR ON BOTTOM OF TANK HAS COMPLETELY SNAPPED OFF AND FAILED. BIKE WAS IN GARAGE AND WHEN I WENT TO START THE ENGINE I SMELLED GAS SO WITH FURTHER INVESTIGATION I FOUND THE FUEL LINE TO THE BOTTOM OF THE TANK WAS COMPLETELY FAILED. *TR
TL* THE CONTACT OWNS A 2004 TRIUMPH DAYTONA 600. THE CONTACT STATED THAT THE VEHICLE WAS EQUIPPED WITH A FUEL QUICK CONNECT, WHICH CONNECTS THE FUEL LINE TO THE FUEL TANK, AND THE QUICK CONNECT WOULD DETACH FROM THE VEHICLE AT ANY TIME. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOTIFIED, BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V156000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 8,000 AND THE CURRENT MILEAGE WAS 22,500.
FROM DATE OF PURCHASE, 3/23/05, NEW, LEFTOVER 2004, TRANSMISSION HAS BEEN DIFFICULT TO SHIFT. NOTED ON FIRST SERVICE RECORD, 4/21/05. ON MAY 4, 2005 I ASKED MY FATHER TO TAKE A TEST RIDE. HE HAS BEEN RIDING BIKES FOR 30+ YEARS. WHILE STOPPING, ALL INDICATIONS WHERE THE BIKE WAS IN NEUTRAL, REEVED THROTTLE, BIKE CAUGHT A GEAR, STOOD UP, THROWING BOTH DRIVER AND PASSENGER TO THE GROUND. WHEN WE PICKED THE BIKE UP ALL INDICATIONS WHERE IT WAS IN NEUTRAL. IT WOULD NOT ROLL FREELY. HAD TO RUN TRANSMISSION COMPLETELY THROUGH ALL GEARS TWICE TO GET IT INTO NEUTRAL SO THAT IT WOULD ROLL. AT THE REQUEST OF TRIUMPH AND THE DEALERSHIP, THE BIKE HAS BEEN TAKEN BACK TO BE INSPECTED. AS OF TODAY'S DATE, MAY 10, 2005 NOTHING HAS BEEN RESOLVED.
Crash
2 injured
CONSUMER TOOK VEHICLE TO DEALER FOR RECALL REPAIRS, AND LEFT IT WITH THE DEALER. THEN, CONSUMER WAS TOLD THAT DEALER TRYING TO GET INSTRUCTIONS ON HOW TO PUT THE FUEL CONNECTOR ON THE BIKE. NHTSA RECALL 04V156000. *AK
MY 2004 TRIUMPH DAYTONA 600, WITHOUT WARNING, AT FREEWAY SPEED, CAME OUT OF GEAR AND THE TRANSMISSION SELF DESTRUCTED. THIS CAUSED ME TO HAVE TO COAST TO A STOP ON THE FREEWAY, AT GREAT DANGER TO MYSELF AND OTHER MOTORISTS. THIS IS A VERY UNSAFE VEHICLE.*AK