2024 TOYOTA GRAND HIGHLANDER

4 recalls — 291 complaints — 48 TSBs

BACK OVER PREVENTION:DISPLAY FUNCTION

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or di... Read more

Consequence

A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy

Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.

1,024,407 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner ... Read more

Consequence

An instrument panel display that does not show critical information can increase the risk of a crash or injury.

Remedy

Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional let... Read more

591,377 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

EQUIPMENT:OTHER:LABELS

Defect Description

Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia ... Read more

Consequence

A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.

Remedy

GST will mail new labels to owners, free of charge. Owner notification letters were mailed September 16, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R2.

33,848 vehicles affected

Manufacturer: Gulf States Toyota, Inc.

AIR BAGS:SIDE/WINDOW:CURTAIN

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024 Toyota Grand Highlander, Grand Highlander Hybrid, Lexus TX350, TX500 Hybrid, and TX550 Hybrid+ vehicles. The driver and passenger side curtain air bags may not unroll as intended and could partially deploy outside of an ope... Read more

Consequence

An improper deployment of the side curtain air bag can reduce occupant protection during a crash, increasing the risk of injury.

Remedy

Dealers will replace the driver and passenger curtain shield air bag assemblies, free of charge. Owner letters were mailed November 4, 2024. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TB09/24TA09 and Lexus' numbers are 24LB05/24LA05.

145,254 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

Complaint Statistics

291 total complaints 11 crashes 5 fires 6 injuries

Top Reported Components

Component	Complaints
ENGINE	54
POWER TRAIN	35
ELECTRICAL SYSTEM	32
UNKNOWN OR OTHER	22
STEERING	16
SERVICE BRAKES	16
VEHICLE SPEED CONTROL	12
FUEL/PROPULSION SYSTEM	10
STRUCTURE:BODY	9
AIR BAGS	8

Incident date: May 2, 2026

What component or system failed or malfunctioned, and is it available for inspection upon request? I was driving when I heard a loud boom, it almost sounded like a gunshot. Not noticing anything I continued driving. After a short distance I started hearing wind whistling. It was at this point I pu... Read more

Incident date: May 21, 2026

My 2024 Used Toyota Grand Highlander Hybrid Platinum Max was at a slight decline stopped at a stop sign in Echo mode. The whole car began to violently shake and lurching forward. No one was in front of me and my foot was on the brake or I probably would have run into a car in front of me. The das... Read more

Incident date: May 16, 2026

On [XXX], while driving my 2024 Toyota Grand Highlander at approximately 45-50 mph on a gusty, high-wind day, the rear panoramic moonroof/sunroof panel blew out and shattered completely without warning. The failure occurred as I rolled up the vehicle windows during the wind gust. Rapid window clos... Read more

Incident date: May 19, 2026

3rd row seats do not want to lock into position, there is also broken plastic pieces from the locking mechanism area. Seats do not want to engage or disengage when trying to lay them flat. This had been a reported problem on other highlanders. This has been an issue since we purchased the vehicle in... Read more

Incident date: Mar 1, 2026

The primary component involved is the high-voltage charging system, specifically the charging port and connector interface. The vehicle previously experienced a confirmed failure involving a scorched charging port and a melted pin, which required replacement. The same symptoms have since returned, i... Read more

Incident date: May 5, 2025

I own a 2016 Tesla Model X P100D equipped with the Large Drive Unit (LDU). The component that fails is the rotor coolant seal in the rear drive unit motor. Coolant leaks internally into the motor and inverter, causing bearing wear, corrosion, isolation faults, and eventual complete drive unit failur... Read more

Incident date: Apr 24, 2026

While traveling at highway speed on I-75 northbound, the vehicle experienced a complete and total loss of electrical power. and propulsion. The following conditions were present simultaneously: - Complete loss of propulsion - Inability to shift transmission to neutral — vehicle could not be move... Read more

Incident date: Apr 24, 2026

Dealership replaced all 16 lifters and replaced camshaft. Dealerships repair took 28 days. Repair cost $4k out of my pocket and Chevrolet Corporate covered $4700 due to the know lifter issue with their engines. Within 24 hours & less than 100 miles, vehicle started making new abnormal noise, and the... Read more

Incident date: Apr 2, 2026

UNKNOWN -- I was turning 90 deg from the street into my 30' driveway, going very slow as usual with foot on brake pedal to slow further before entering the garage (the door had just finished lifting). But as I was straightening the steering coming out of turn, the car suddenly accelerated, brakes an... Read more

Crash

Incident date: Apr 14, 2026

The vehicle hesitates and does not accelerate immediately from a complete stop. This occurs more frequently when the car is on a slight incline. The delay in acceleration creates a safety concern, especially when attempting to merge into traffic or pull out onto a roadway. I have reported this issue... Read more

Incident date: Apr 14, 2026

The contact owns a 2026 N/A Forest River Economy Hauler. The contact stated that while inspecting under the trailer, one of the four bolts connecting the axle to the frame was loose. Additionally, only four of the eight axle bolts were installed on the frame. The contact sent photos of the failure t... Read more

Incident date: Apr 14, 2026

Incident date: Apr 19, 2026

When making turns under acceleration at various speeds, there is a noticeable clunk noise from the front section of the vehicle. The sound can be described as a coil that is being compressed/decompressed and creates the noise. The noise is heard when loading and unloading the steering wheel during... Read more

Incident date: Dec 1, 2025

Front brakes were worn prematurely and rotors had to be resurfaced multiple times under warranty and once more after warranty. Premature wear would cause shaking in the steering wheel when medium to heavy braking force was applied.

Incident date: Dec 1, 2025

Incident date: Apr 19, 2026

Incident date: Mar 17, 2026

My car read system malfunction and come to find out there was corrosion with the wires in the internal circuit of the driver side mirror that prevents it from warning you of blind spots and pre-collision.

Incident date: Mar 17, 2026

Incident date: Feb 1, 2026

The contact owns a 2024 Toyota Grand Highlander. The contact stated that the display was not functioning properly, and the screen was blank while operating. The contact stated that after the "Get Started" prompt was displayed and selected, the screen would go blank. Additionally, the back over preve... Read more

Incident date: Apr 2, 2026

It didn't work it didn't brake or didn't have an alert in which caused an accident

Crash

Incident date: Jan 7, 2026

Vehicle completely lost power and quite running in the middle of the desert in Arizona. This relates to Saftey Recall 93c. I had to have the car towed and repaired in Scottsdale, AZ. I have been told that this repair (which was expensive) might not remedy the problem and it could reoccur. It's b... Read more

Incident date: Jan 7, 2026

I was driving toward the perimeter of my neighborhood, approaching an arterial cross street. When I braked the pedal went straight to the floor. The breaks didn’t work despite pumping them multiple times. I also heard the engine revving. To avoid the intersection and busy street I steered into ... Read more

Crash 1 injured

Incident date: Jan 7, 2026

Crash 1 injured

Incident date: Mar 7, 2026

The transmission needs to be replaced per the dealership. I was told this on 3/7/26 with mileage of 69K. The transmission has been reported as defective to Toyota since 2016-2017 with multiple lawsuits that have been filed. According to the lawsuits found online, Toyota knowingly used the defective ... Read more

Incident date: Mar 21, 2026

The incidents most often occur when I try to accelerate after vehicle is stopped at an intersection. The car hesitates during acceleration regardless of how much I push the gas. Once it starts to go, it feels as though the car can't shift from 1st to 2nd gear. The RPMs get up 4500 while the car is g... Read more

Incident date: Mar 21, 2026

Incident date: Mar 19, 2026

Reported issues of lag in acceleration and harsh shifting into reverse, the vehicle has been brought to the dealership multiple times stemming from shortly after previous, there are no warnings lights on. I requested the dealership provide in writing if the deemed the vehicle safe for operation. The... Read more

Incident date: Mar 19, 2026

Incident date: Dec 23, 2025

The contact owns a 2019 Ford Flex. The contact received notifications of NHTSA Campaign Numbers: 24V951000 (Back Over Prevention) and 25V732000 (Structure); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time... Read more

Incident date: Dec 23, 2025

Race light tail lights went out. Water can get in around light . Known issue in class action lawsuit

Incident date: Dec 23, 2025

This is regarding recalls for my 2024 Toyota Grand Highlander Hybrid Platinum Max. The vehicle has been in the possession of Koons Tysons Toyota since December 23, 2025 (80 days as of 3/11/26), for repair of Safety Recall #25TA13 and #25TB13 NHTSA 25V744) involving the Panoramic View Monitor System... Read more

Incident date: Jun 24, 2025

The contact owns a 2015 Ford Escape. The contact stated that while attempting to reverse, the rearview camera became inoperable and the image appeared blank. The contact received notification of NHTSA Campaign Number: 25V695000 (Back Over Prevention); however, the remedy parts required to complete t... Read more

Incident date: Mar 6, 2026

Was given a 'critical brake fault' warning on the dashboard. Car defaulted into neutral and I was not able to put it park, drive, reverse or even turn off the car (had to keep my foot on the brake until someone could help me push it onto a flat surface). Could not open the car doors from the outside... Read more

Incident date: Dec 19, 2025

regarding the rear view camera. It stopped working intermittently and now it shows the picture inverted (backwards) I see an extensive list of vehicles that have been recalled, but my vin is not listed. How do I get this repaired?

Incident date: Mar 6, 2026

There is premature belt deterioration that ultimately caused the transmission to be a complete failure. It has been confirmed by the dealership. My parents were driving down the i95 when this randomly occurred. There was no warning message. TSB 21-047 Warranty Extension: 2016-20 HR-V CVT Prematur... Read more

Incident date: Mar 6, 2026

My car suddenly shook violently while at complete stop at a stop light. Also, the brake feels weird at times when slowing down.

Incident date: Feb 13, 2026

Engine developed a low knock type noise just above idle while beginning to move in the parking lot. It was also noted pulling away from an intersection at low rpm under light acceleration. Oil pressure was normal, 30 psi and approximately 50-60 at cruising speed. Low level knock began earlier in the... Read more

Incident date: Aug 24, 2024

The contact owns a 2024 Toyota Grand Highlander. The contact received notification of NHTSA Campaign Number: 25V595000 (Electrical System), and the vehicle was taken to the dealer on several occasions, but the dealer informed the contact that the part to do the recall repair was not yet available. T... Read more

Incident date: Aug 24, 2024

When shutting off the car, the fan continued to run. I started the car up again to see if this would allow the fan to turn off. No luck. The steering assist was dis-enabled on the dash. I took my car to the dealer to find out that it has a bad thermostat and that my radiator was leaking. The ... Read more

Incident date: Feb 9, 2026

The contact owns a 2022 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was idling, and while driving at various speeds, the engin... Read more

Incident date: Feb 11, 2026

The contact owns a 2020 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the instrument panel was blank. The contact pulled over and restarted the vehicle; however, the failure persisted. The contact associated the failure with NHTSA Campaign Number: 24V652000 (ELECTRICA... Read more

Incident date: Dec 18, 2025

I was driving on the highway and there was a sudden drop in power and hesitation in the engine. I slowed down too quickly on a busy highway and almost got rear ended. I took it to the shop and found out I had to replace the engine due to the cam and lifters were bad. It cost $12,000 to replace a fou... Read more

Incident date: Jan 16, 2026

Both Quad LED side strips (vertical daytime running lights) on my 2021 Ford F‑150 have burnt out. The failure occurred gradually, with the left strip failing first around [insert approximate date] and the right strip failing shortly after. These LED strips are a safety feature, and their failure r... Read more

Incident date: Jan 26, 2026

The contact owns a 2019 Land Rover Range Rover. The contact stated that while driving and slowing down to approximately 5 MPH, the braking system malfunctioned and the vehicle did not immediately stop. The contact indicated that while pressing the brake pedal, the vehicle continued to drive forward ... Read more

Crash

Incident date: Dec 23, 2025

The contact owns a 2018 Toyota CH-R. The contact stated that while driving in ECO Mode, there was a humming sound coming from the transmission. The vehicle was taken to the local dealer, who diagnosed that the transmission and torque converter were faulty and needed to be replaced. The vehicle was n... Read more

Incident date: Sep 15, 2024

The contact owns a 2013 Dodge Grand Caravan. The contact stated that the vehicle was taken to the local dealer, who replaced the motor mounts and transmission. Five months later, the transmission failed and needed to be replaced. The vehicle began driving roughly. The PCM update was completed by ano... Read more

Incident date: Jan 8, 2026

When I turn to the left or right I hear a clicking/popping noise. Took it to the dealer and they said it was the CV axle. So they replaced the driver side. After the repair, it would make the same sound from time to time so I took it back in to the dealer(Northside Toyota in San Antonio, TX) they co... Read more

Incident date: Jan 8, 2026

While driving on a service road at approximately 45 mph, the corner side glass on my 2025 Hyundai Santa Fe shattered suddenly and without warning. There was no impact from a rock or object, and no other vehicles were present that could have caused debris. We had just entered the service road, and ro... Read more

Showing 50 of 291 complaints.

NHTSA Safety Ratings — 2024 TOYOTA GRAND HIGHLANDER

2024 Toyota GRAND HIGHLANDER SUV AWD

Category	Rating
Rollover	4 / 5 ★★★★☆
Rollover Risk	17.4%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard
Lane Departure Warning	Standard

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins — 2024 TOYOTA GRAND HIGHLANDER

48 manufacturer communications from 28 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	10
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER	8
110000 ELECTRICAL SYSTEM	5
200000 WHEELS	3
060000 ENGINE AND ENGINE COOLING	3
980000 UNKNOWN OR OTHER	3
190000 TIRES	2
356000 EQUIPMENT ADAPTIVE/MOBILITY	1

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

DP: The subject vehicles were delivered with only one (1) Smart Key on select models since October 2022 due to a global semiconductor shortage impacting certain microchips. The affected vehicles were delivered with one (1) Smart Key and a s

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

RL: The supply of Smart Keys available for Toyota vehicles has been temporarily limited to one (1) on select models since October 2022 due to global semiconductor shortages impacting certain microchips. Affected vehicles have been delivered

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

TI: TECHNICAL INSTRUCTIONS FOR 23TJ01 Second Key Delivery Program Multiple Models and Model Years

060000 ENGINE AND ENGINE COOLING

TSB: Some 2024 model year Grand Highlander vehicles equipped with a T24A-FTS engine may exhibit a MIL ON condition with Diagnostic Trouble Code (DTC) P05CE00 (Cold Start ?B? Camshaft Position Timing Performance Bank 1). The Engine Control M

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

The table describes the phases currently planned for the Second Key Delivery Program and the estimated timing of announcement. This table will be updated during each phase launch and as more details become available.

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website.

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Another feature,

980000 UNKNOWN OR OTHER

081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

TSB: Hybrid vehicles (HV) and battery electric vehicles (BEV) are equipped with two types of batteries: ?Hybrid vehicle (HV) battery. ?Auxiliary (12V) battery. If a hybrid or battery electric vehicle is put into storage, the State-O

350000 EQUIPMENT

TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage cond

190000 TIRES

TSB: During the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires

270000 LANE DEPARTURE

TSB: Some 2018 ? 2024 model year Toyota vehicles equipped with an A25A-FKS, A25A-FXS, M20A-FKS, or M20A-FXS engine may exhibit one or more of the following conditions: ?Milky/discolored engine oil. ?An ?Oil Pressure Low? warning message

110000 ELECTRICAL SYSTEM

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

030000 SERVICE BRAKES, HYDRAULIC

355100 EQUIPMENT:OTHER:LABELS

TSB: A battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. Because of these factors, battery inspect

350000 EQUIPMENT

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

350000 EQUIPMENT

TSB: 2024 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. During

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

070000 FUEL SYSTEM, GASOLINE

TT: Some 2024 Grand Highlander / Grand Highlander Hybrid vehicles may have a concern of difficult to add more than 12 to 15 gallons of fuel from an empty condition. After refueling the gauge reads full.

353000 EQUIPMENT:ELECTRICAL

TT: Some MY23-24 Highlander and Grand Highlander/HV vehicles may experience a condition where the engine does not restart automatically following a start/stop event. However, the engine may be restarted normally after a period of time in th

350000 EQUIPMENT

200000 WHEELS

350000 EQUIPMENT

980000 UNKNOWN OR OTHER

TT: A very small percentage of customers experience operational difficulties with some telematics features which they cannot resolve on their own. These resources, in conjunction with the Repair Manual, are for dealership personnel to assis

346000 COMMUNICATION:MANUFACTURER TELEMATICS

061610 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

TSB: Flash reprogramming allows the Electronic Control Unit (ECU) software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Serv

200000 WHEELS

TSB: Some 2023 ? 2024 model year Toyota vehicles use hub bolts in place of studs/nuts to fasten the wheels to the vehicle. If non-compatible wheels or hub bolts/nuts are installed, there is increased risk that the wheel(s) could come off re

350000 EQUIPMENT

TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ?Careful inspection for paint chips/scratches and body

160000 STRUCTURE

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

190000 TIRES

200000 WHEELS

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: When setting up the Toyota Audio Multimedia (21MM) user profile, if the QR code is not working please use the following recommendations.

TOYOTA GRAND HIGHLANDER — All Years Overview

Complete safety history for the TOYOTA GRAND HIGHLANDER across all model years (2024–2026).

8 Total Recalls

377 Total Complaints

0 Investigations

12 Reported Crashes

6 Reported Fires

0 Reported Deaths

TOYOTA GRAND HIGHLANDER — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	18	View
2025	3	68	View
2024 (current)	4	291

Other TOYOTA Models

Model	Recalls	Complaints
TUNDRA	787	9,074	View
HIGHLANDER	677	6,756	View
RAV4	669	11,842	View
CROWN	548	141	View
TACOMA	406	10,562	View
VENZA	404	969	View
PRIUS	365	15,456	View
HIGHLANDER HYBRID	355	1,103	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2024 TOYOTA GRAND HIGHLANDER

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings — 2024 TOYOTA GRAND HIGHLANDER

Safety Technology

Technical Service Bulletins — 2024 TOYOTA GRAND HIGHLANDER

Most Affected Components

TOYOTA GRAND HIGHLANDER — All Years Overview

TOYOTA GRAND HIGHLANDER — Year by Year

Other TOYOTA Models