2009 TIFFIN ZEPHYR
6 recalls — 0 complaints — 11 TSBs
17V841000 Dec 22, 2017
EQUIPMENT
Defect Description
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2009-2018 Allegro and Allegro RED, Bus and Phaeton vehicles, 2009-2010 Bay vehicles, 2011-2018 Breeze vehicles, and 2009-2015, and 2017-2018 Zephyr vehicles. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fir... Read more
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy
Tiffin will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on February 5, 2018. Owners may contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more i... Read more
16V532000 Jul 13, 2016
VISIBILITY:WINDSHIELD WIPER/WASHER
Defect Description
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.
Consequence
If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.
Remedy
Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.
14V271000 May 22, 2014
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Defect Description
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2009-2011 Allegro, 2010-2011 Bus and Breeze, and 2008-2011 Phaeton and Zephyr recreational vehicles, equipped with LED clearance lights made by Command Electronics, Inc. In the affected vehicles, moisture may enter the light and cause... Read more
Consequence
A short in the circuit board increases the risk of a fire.
Remedy
Tiffin will notify owners, and dealers will install a one amp inline fuse into the front and rear circuits that will blow if there is a short in any of the clearance lights, free of charge. The recall began on July 31, 2014. Owners may contact Tiffin customer service at 1-256-356-8661.
12V071000 Feb 24, 2012
VEHICLE SPEED CONTROL:CRUISE CONTROL
Defect Description
TIFFIN IS RECALLING CERTAIN MODEL YEAR 2009-2010 BUS, AS WELL AS CERTAIN 2009-2011 AND 2013 ZEPHYR RECREATIONAL VEHICLE CHASSIS EQUIPPED WITH AN ELECTRONIC CONTROL MODULE, PART NUMBER 2791-NN2E-001 OR 2791-NN2E-002. WHEN THE BRAKE IS APPLIED, THE CRUISE CONTROL MAY NOT CANCEL. ADDITIONALLY, THESE ... Read more
Consequence
A DRIVER MAY EXPERIENCE REDUCED CONTROL OF THE VEHICLE IF EITHER THE DRIVER ATTEMPTS TO CANCEL THE CRUISE CONTROL BY APPLYING THE BRAKE OR THE VEHICLE SPEED INCREASES AND THE DRIVER IS UNAWARE OF THE INCREASED SPEED, INCREASING THE RISK OF A CRASH.
Remedy
THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 9, 2012. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.
10V585000 Nov 22, 2010
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Defect Description
TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A PO... Read more
Consequence
THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy
TIFFIN IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT N... Read more
09V069000 Feb 27, 2009
TRAILER HITCHES
Defect Description
TIFFIN IS RECALLING 1,408 MY 2006-2009 ALLEGRO BUS, MY 2007-2009 PHAETON AND MY 2005-2009 ZEPHYR VEHICLES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH PUTMAN HITCHES. CERTAIN TRAILER HITCHES MAY FRACTURE WHICH COULD RESULT IN THE LOSS OF THE TRAILER.
Consequence
SUSPECT HITCHES MAY DEVELOP FRACTURES AND SUBSEQUENT SEPARATION MAY OCCUR, RESULTING IN A VEHICLE CRASH, PROPERTY DAMAGE OR PEDESTRIAN HARM.
Remedy
TIFFIN IS WORKING WITH SPARTAN AND SPARTAN IS HANDLING THE REMEDY FOR THIS CAMPAIGN (PLEASE SEE 08V-567). THE TRAILER HITCH WILL BE REPLACED FREE OF CHARGE. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400 OR TIFFIN AT 256-356-8661.
No complaints found for this vehicle.
Technical Service Bulletins — 2009 TIFFIN ZEPHYR
11 manufacturer communications from 7 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 2 |
| 351000 EQUIPMENT:RECREATIONAL VEHICLE/TRAILER | 2 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 2 |
| 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER | 1 |
| 063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE | 1 |
| 113100 ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID | 1 |
| 114000 ELECTRICAL SYSTEM:WIRING | 1 |
| 114300 ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK | 1 |
Letter to dealer
Nov 10, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This was a letter to our dealers we sent out when we first heard of the Kidde fire extinguisher recall, even though it was still unofficial. We knew our coaches on the dealers' lots contained Kidde and could not be sold unreplaced.
SB-36
Nov 24, 2015
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
TIFFIN MOTORHOMES: TSB CONTAINS NOTIFICATION OF OWNER LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. TWO SCREWS WAS NOT INSTALLED ON THE AIR CONDITION UNITS ON THE ROOF. *TA UPDATED 11/24/15. *PE
16AWG
Jul 16, 2015
113100 ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID
RV: INSTRUCTIONS ON HOW TO INSTALL THE CHARGE SOLENOID WIRING IN A RV OR VEHICLE. *TA
16AWG
Jul 16, 2015
114000 ELECTRICAL SYSTEM:WIRING
RV: INSTRUCTIONS ON HOW TO INSTALL THE CHARGE SOLENOID WIRING IN A RV OR VEHICLE. *TA
16AWG
Jul 16, 2015
114300 ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK
RV: INSTRUCTIONS ON HOW TO INSTALL THE CHARGE SOLENOID WIRING IN A RV OR VEHICLE. *TA
C85-C86AC
Jun 26, 2015
350000 EQUIPMENT
TIFFIN MOTORHOMES: TSB CONTAINS NOTIFICATION OF OWNER LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. ALL TIFFIN MOTORHOMES WILL BE INSTALLING 2 BACK SCREWS OF THE C85 AND C86 A/C'S TO THE ROOF OF ALL TIFFIN MOTORHOMES. *TA.
WI-267
May 23, 2014
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
TIFFIN MOTORHOMES: INSTRUCTIONS ON HOW TO INSTALL AND SECURE ALL THE EXHAUST PIPES ON ALL ZEPHYR VEHICLES. *TA
WI-196
Mar 12, 2013
351000 EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
TIFFIN MOTORHOMES: TSB CONTAINS NOTIFICATION OF OWNER LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. SOME TIFFIN MOTORHOMES NEED DRIVER/PASSENGER SEATBELTS TIGHTENED ON THE MOUNTING BRACKETS LOCATED ON THE DRIVER/PASSENGER SIDEWALL. *TA
SB-25
Aug 8, 2008
350000 EQUIPMENT
TIFFIN MOTORHOMES: FLUSH FLOOR LIVING ROOM SLIDE SYSTEM PROVIDED BY LIPPERT COMPONENTS. UNITS WITH RESIDENTIAL REFRIGERATOR OPTION MAY EXPERIENCE DECREASED MOTOR EFFICIENCY OVER TIME DUE TO AN ISSUE INVOLVING THE SIZE OF ROLLER INSTALLED I
SB-25
Aug 8, 2008
351000 EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
TIFFIN MOTORHOMES: FLUSH FLOOR LIVING ROOM SLIDE SYSTEM PROVIDED BY LIPPERT COMPONENTS. UNITS WITH RESIDENTIAL REFRIGERATOR OPTION MAY EXPERIENCE DECREASED MOTOR EFFICIENCY OVER TIME DUE TO AN ISSUE INVOLVING THE SIZE OF ROLLER INSTALLED I
SB-25
Aug 8, 2008
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
TIFFIN MOTORHOMES: FLUSH FLOOR LIVING ROOM SLIDE SYSTEM PROVIDED BY LIPPERT COMPONENTS. UNITS WITH RESIDENTIAL REFRIGERATOR OPTION MAY EXPERIENCE DECREASED MOTOR EFFICIENCY OVER TIME DUE TO AN ISSUE INVOLVING THE SIZE OF ROLLER INSTALLED I
TIFFIN ZEPHYR — All Years Overview
Complete safety history for the TIFFIN ZEPHYR across all model years (1999–2025).
84
Total Recalls
10
Total Complaints
0
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
TIFFIN ZEPHYR — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2025 | 2 | 0 | View |
| 2024 | 2 | 0 | View |
| 2023 | 3 | 0 | View |
| 2022 | 5 | 0 | View |
| 2021 | 2 | 0 | View |
| 2020 | 3 | 0 | View |
| 2019 | 5 | 0 | View |
| 2018 | 6 | 0 | View |
| 2017 | 2 | 0 | View |
| 2015 | 1 | 0 | View |
| 2014 | 2 | 0 | View |
| 2013 | 3 | 6 | View |
| 2012 | 1 | 0 | View |
| 2011 | 4 | 0 | View |
| 2010 | 6 | 0 | View |
| 2009 (current) | 6 | 0 | |
| 2008 | 4 | 1 | View |
| 2007 | 5 | 0 | View |
| 2006 | 2 | 0 | View |
| 2005 | 6 | 0 | View |
| 2003 | 3 | 0 | View |
| 2002 | 3 | 1 | View |
| 2001 | 3 | 2 | View |
| 2000 | 3 | 0 | View |
| 1999 | 2 | 0 | View |