2003 SAAB 9-3

5 recalls, 323 complaints - 110 TSBs

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.

Consequence

A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.

Remedy

TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.

4,887 vehicles affected

Manufacturer: TI GROUP AUTOMOTIVE SYSTEMS, LLC

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.

Consequence

OVER TIME, THIS COULD CAUSE THE FUEL LINES TO LOOSEN FROM THE PUMP RESULTING IN FUEL LEAKAGE. IF AN IGNITION SOURCE WERE PRESENT, THE FUEL MAY IGNITE RESULTING IN A VEHICLE FIRE.

Remedy

DEALERS WILL DEVELOP A SECURING BRACKET THAT WILL SECURE THE FUEL LINES TO THE FUEL PUMP EVEN IF THE PLASTIC RETAINING TABS SHOULD BREAK. THE RECALL BEGAN ON JUNE 13, 2007. THIS IS AN EXPANSION OF PREVIOUS RECALL CAMPAIGNS - SEE 04V557 AND 06V126. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.

94,377 vehicles affected

Manufacturer: SAAB CARS USA, INC.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.

Consequence

IF THIS CONDITION WERE TO OCCUR WHEN MINIMUM STOPPING DISTANCE IS REQUIRED, A CRASH COULD OCCUR.

Remedy

DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.

68,654 vehicles affected

Manufacturer: SAAB CARS USA, INC.

ENGINE AND ENGINE COOLING

Defect Description

ON CERTAIN PASSENGER VEHICLES, THE ENGINE MANAGEMENT SYSTEM SOFTWARE MAY CAUSE ENGINE HESITATION OR STALLING.

Consequence

IF THE VEHICLE STALLS AS A RESULT OF THIS CONDITION, IT CAN BE RESTARTED IMMEDIATELY.

Remedy

DEALERS WILL UPDATE THE ENGINE MANAGEMENT SYSTEM. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.

12,249 vehicles affected

Manufacturer: SAAB CARS USA, INC.

SEAT BELTS:FRONT:RETRACTOR

Defect Description

SOME SPORT SEDANS WERE BUILT WITH SEAT BELT RETRACTORS THAT WERE DAMAGED DURING THE MANUFACTURING PROCESS. IF DAMAGED, OVER TIME, THE AUTOMATIC TENSIONING SYSTEM (ATS) CABLE IN THE SEAT BELT RETRACTOR COULD BREAK CAUSING THE BELT WEBBING TO NOT RETRACT.

Consequence

IN THE EVENT OF A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SEVERE INJURIES.

Remedy

DEALERS WILL REPLACE THE SEAT BELT RETRACTOR ASSEMBLIES. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.

31,335 vehicles affected

Manufacturer: SAAB CARS USA, INC.

Complaint Statistics

323 total complaints 19 crashes 6 fires 25 injuries

Top Reported Components

Component	Complaints
ELECTRICAL SYSTEM	36
SUSPENSION:FRONT	27
POWER TRAIN:AUTOMATIC TRANSMISSION	23
ENGINE AND ENGINE COOLING	15
ENGINE AND ENGINE COOLING:ENGINE	14
AIR BAGS	12
STEERING	11
SUSPENSION:FRONT:SPRINGS:COIL SPRINGS	8
PARKING BRAKE	7
TIRES	7

Incident date: Nov 20, 2020

I WAS DRIVING MY 2003 SAAB 9-3 SE CONVERTIBLE TO THE NEARBY PUBLIX SUPERMARKET. THE CAR HAS NEVER BEEN IN AN ACCIDENT OR HIT. I PARKED IT IN THE LOT WITH THE TOP DOWN AND WENT INTO THE STORE FOR APPROXIMATELY 10 MINUTES. IT WAS A WARM DRY DAY IN FLORIDA ABOUT 85 DEGREES. I CAME OUT AND PUT THE KE... Read more

Incident date: Nov 20, 2019

TL* THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT WITH THE KEY FOB IN THE IGNITION, THE POWER STEERING WHEEL LOCK MALFUNCTION WARNING LIGHT ILLUMINATED. THE CONTACT MANUALLY TURNED THE IGNITION KEY TO THE LEFT TO RIGHT IN ORDER TO HAVE THE VEHICLE STARTED. THE VEHICLE WAS TAKEN TO FLIKKE... Read more

Incident date: May 17, 2019

TL* THE CONTACT OWNS A 2003 SAAB 9-3. WHEN THE VEHICLE DECELERATED, IT SHUT OFF WITHOUT WARNING AT WILL. THE CONTACT ALSO STATED THAT THE VEHICLE DECELERATED WHEN DRIVING UP A HILL. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 102,... Read more

Incident date: Oct 15, 2018

ECU IN CAR BECOMES COMPLETELY FRIED BECAUSE OF THE LOCATION IT IS MOUNTED FROM THE FACTORY BECAUSE OF HEAT SOAK

Incident date: Sep 3, 2018

I AM RECEIVING AN ONSTAR NOT AVAILABLE ERROR - THERE WAS A RECALL 08089-B PART # 10027804 - I WANT MY ONSTAR DISABLED. WHO DO I CONTACT?

Incident date: Jun 22, 2018

TAKATA RECALL. DRIVER'S SEAT AIRBAG DEPLOYED WHILE WAITING AT A RED LIGHT THIS MORNING.

1 injured

Incident date: Mar 1, 2016

2003 SAAB. CONSUMER WRITES IN REGARDS TO AIRBAG INFLATOR SAFETY RECALL. *LD THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR. *JS

Incident date: May 28, 2017

I WAS DRIVING AT ABOUT 15 - 20 MPH TRYING TO ENTER HWY I-75. UPON ROUTINE BRAKING,THE AIRBAG DEPLOYED, CAUSING AN ACCIDENT.AFTER I HIT THE CAR IN FRONT OF ME,THE SECOND AIRBAG DEPLOYED. I AM HURT. THE VEHICLE WAS DEEMED TOTALLED BECAUSE THE AIRBAGS DEPLOYED, AND TAKEN AWAY.

Crash 1 injured

Incident date: Mar 1, 2016

TAKATA RECALL I WAS NOTIFIED BY SAAB IN MARCH 2016 THAT I HAVE TAKATA AIRBAGS INSTALLED AND ARE SUBJECT TO RECALL. IT IS NOW SIX (6) MONTHS SINCE THE NOTIFICATION. I HAVE HAD NO FURTHER COMMUNICATION FROM SAAB. I FEEL THAT THE RECALL SHOULD TAKE PLACE IMMEDIATELY BEFORE I GET KILLED FROM THE AIR... Read more

Incident date: Mar 22, 2016

HIT CONCRETE WALL

Crash 2 injured

Incident date: Mar 22, 2016

HIT CONCRETE WALL

Crash 2 injured

Incident date: Mar 1, 2016

TAKATA RECALL I DO NOT HAVE A DATE FOR OR MY SAAB AIR BAG RECALL. THIS CLEARLY SENDS A MESSAGE ABOUT GM. "DON'T BUY GM, AND FROM THOSE COMPANIES WHICH PLACE PEOPLE AT RISK OF AIR BAG FAILURE"

Incident date: Mar 15, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART FOR THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE M... Read more

Incident date: Mar 22, 2016

COIL SPRING BROK CAUSED TIRE TO COME OFF TURNDED SIDEWAYS UNDER FIREWALL CAUSING US TO CRASH INTO CONCRETE BARRIER

Crash 2 injured

Incident date: Mar 22, 2016

COIL SPRING BROK CAUSED TIRE TO COME OFF TURNDED SIDEWAYS UNDER FIREWALL CAUSING US TO CRASH INTO CONCRETE BARRIER

Crash 2 injured

Incident date: Mar 22, 2016

COIL SPRING BROK CAUSED TIRE TO COME OFF TURNDED SIDEWAYS UNDER FIREWALL CAUSING US TO CRASH INTO CONCRETE BARRIER

Crash 2 injured

Incident date: Feb 3, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V063000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACT... Read more

Incident date: Apr 5, 2016

TAKATA RECALL...I AM ADVISED THAT THERE IS RISK OF INJURY/DEATH DUE TO DEPLOYMENT OF AIR BAGS. ASKING FOR REPAIR ADVISED TODAY 4/4/2016 BY (GENERAL MOTORS) THEY ARE NOT NOW DOING/CANNOT DO SAME. UNACCEPTABLE SAFETY.

Incident date: Mar 22, 2016

TL* THE CONTACT OWNED A 2003 SAAB 9-3. WHILE DRIVING APPROXIMATELY 55 MPH, THE STEERING LOST POWER. THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED INTO A CONCRETE WALL. THE DRIVER SIDE TIRE BECAME STUCK UNDER THE DRIVER SEAT WITHOUT WARNING. THE DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED. BOTH ... Read more

Crash 2 injured

Incident date: Dec 7, 2015

TL* THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT THE VEHICLE JERKED WHEN THE BRAKE PEDAL WAS DEPRESSED AND STALLED. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED INTERMITTENTLY. IN ADDITION, IT TOOK MULTIPLE ATTEMPTS TO OPEN THE DRIVER... Read more

Incident date: Dec 7, 2015

Incident date: Dec 4, 2015

TL* THE CONTACT OWNS A 2003 SAAB 9-3. WHILE DRIVING APPROXIMATELY 30 MPH, SMOKE EMITTED UNDERNEATH THE HOOD. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT MENTIONED THAT SMOKE EMITTED FROM THE BATTERY COMPARTMENT. THERE WERE NO FLAMES VISIBLE. THE VEHICLE WAS TAKEN TO AN INDEPENDE... Read more

Fire

Incident date: Jul 15, 2015

TL* THE CONTACT OWNS A 2003 SAAB 9-3. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING AND WAS ABLE TO BE RESTARTED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS NOT DIAGNOSED; HOWEVER, THE MECHANIC REPLACED THE DIC AND TH... Read more

Incident date: Jun 5, 2014

TL* THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE FAILED TO ACCELERATE AND DECELERATED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING... Read more

Incident date: Jun 5, 2014

Incident date: Oct 8, 2015

TL* THE CONTACT OWNS A 2003 SAAB 9-3. AFTER THE VEHICLE WAS STARTED, THE STEERING WHEEL LOCK WARNING LIGHT ILLUMINATED AND THE DOORS OF THE VEHICLE FAILED TO LOCK. ON ANOTHER OCCASION, THE IGNITION KEY FAILED TO MOVE INTO THE ON POSITION. A TOW TRUCK OPERATOR STATED THAT THE VEHICLE COULD NOT BE MOV... Read more

Incident date: Oct 8, 2015

Incident date: Jun 3, 2013

TL* THE CONTACT OWNS A 2003 SAAB 9-3. THE CONTACT STATED THAT THE KEY REFUSED TO TURN TO THE ON POSITION AND A STEERING WHEEL LOCK MALFUNCTION MESSAGE APPEARED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

Incident date: Nov 4, 2014

[XXX] BOUGHT JUST IN MAY. *TR

Incident date: Nov 4, 2014

[XXX] BOUGHT JUST IN MAY. *TR

Incident date: Nov 4, 2014

[XXX] BOUGHT JUST IN MAY. *TR

Incident date: Aug 21, 2014

DRIVING STEADY PACE, SID FADES OUT, RADIO SHUTS OFF, GAUGES TURN OFF, AND ENGINE SHUT OFF. PULLED OVER AND WHITE SMOKE CAME OUT FROM ENGINE BAY. IT WAS FROM THE SOLENOID ON THE STARTER. I GOT A NEW STARTER AND THE BATTERY WAS DEAD. I THEN BOUGHT A NEW BATTERY AND THE SAME ISSUE OCCURRED. I HAD TO CH... Read more

Incident date: Aug 30, 2014

AS I WAS DRIVING IN THE MIDDLE LANE OF THE 3 NORTHBOUND LANES OF U.S. 23, THE ENGINE SUDDENLY STALLED. I WAS GOING ABOUT 62 MPH. I ACTIVATED MY EMERGENCY FLASHERS, SHIFTED THE AUTOMATIC TRANSMISSION TO NEUTRAL, AND SHUT OFF THE IGNITION KEY. I THEN TURNED THE IGNITION KEY TO RESTART THE ENGINE AND I... Read more

Incident date: Aug 30, 2014

Incident date: Jul 1, 2014

WHILE DRIVING AT HIGHWAY SPEED, THE ENGINE SUDDENLY STALLED. SLOWED AND STOPPED VEHICLE OFF SIDE OF ROAD. TURNED KEY TO OFF POSITION, THEN RE-STARTED VEHICLE WHEN TURNED KEY TO ON. CAR RAN FINE AFTER RE-STARTED. THIS HAS HAPPENED MULTIPLE TIMES. SUSPECT DEFECTIVE IGNITION SWITCH, BUT THIS VEHICLE IS... Read more

Incident date: Jun 11, 2014

I HAVE ALSO BEEN HAVING ISSUES WITH THE FRONT PASSENGER SIDE SUSPENSION. I WOULD HAVE TO CHECK MY RECORDS, BUT I BELIEVE IT STARTED WHEN THE CAR HAD ABOUT 25K MILES ON IT. THE SPRINGS ARE STILL IN TACT, BUT I WOULD NOTICE A VERY LOUD CREAKING NOISE GOING OVER SPEED BUMPS IN PARKING LOTS, ESPECIALL... Read more

Incident date: May 15, 2014

MICHELIN PILOT SPORT A/S 3 DOT: B9N) 11RX 3213 THESE TIRES HAVE TO BE DEFECTED!!!! WITH NO WARNING, THE PILOT SPORT A/S 3 TIRE JUST BLEW! BAM CAR PULLED HARD TO THE SIDE OF THE FLAT TIRE AND DRIVER STEERED OVER TO THE SHOULDER OF I95 THE TIRE'S THREADS COMPLETELY SEPARATED FROM BOTH THE INNER ... Read more

1 injured

Incident date: Mar 29, 2014

I WAS DRIVING AND THE CAR SHUT DOWN 2 TIMES WHILE DRIVING. I DID SOME RESEARCH AND IT IS A KNOW PROBLEM THAT THE IGNITION SWITCH ON THE 2003 SAAB 9-3 CAUSES STALLING AND LOCK SYSTEM FAILURES. IF FACT AT ONE POINT THE IGNITION SWITCHES WERE BACK ORDERED FOR THIS PROBLEM. THIS IS A SPORADIC PROBLEM AN... Read more

Incident date: Feb 16, 2014

DRIVING DOWN STREET AT 30 MPH. LEFT SIDE FRONT SPRING BROKE. SPRING STUCK OUT AND SHREDDED TIRE. LEFT SIDE OF CAR DROPPED, WHICH THEN CAUSED RIGHT SIDE SPRING TO COME OFF AND CUT RIGHT SIDE TIRE. HAD TO REPLACE BOTH FRONT SPRING / STRUT ASSEMBLIES, AND REPLACE 2 TIRES. RESEARCHED PROBLEM, FOUND THAT... Read more

Incident date: Feb 16, 2014

Incident date: Feb 9, 2011

THE VEHICLE WILL BECOME ALMOST IMMOBILE IN FIRST AND SECOND GEAR (MANUAL TRANSMISSION). ONCE IN THIRD GEAR, PERFORMANCE IS BACK TO NORMAL. IF DRIVER IS NOT AWARE OF SITUATION (CRUISE LIGHT OFF IS ONLY INDICATION IF CRUISE CONTROL SYSTEM IS TURNED ON), DRIVER CAN EASILY GET INTO BAD SITUATION AS CAR ... Read more

Incident date: Feb 9, 2011

Incident date: Apr 18, 2012

MY VEHICLE WAS COVERED UNDER A SEAT BELT RECALL, AND WAS SERVICED IN 2005. I PURCHASED THE CAR USED, BUT ACCORDING TO THE PREVIOUS OWNER, THE SEAT BELT ON THE DRIVER'S SIDE HAS BEEN BROKEN FOR AT LEAST A YEAR. THE REPLACEMENT DID NOT FIX THE ISSUE, IN THIS CASE. *TR

Incident date: Apr 7, 2011

THE SAAB WILL INTERMITTENTLY FAIL TO START. WHEN THE KEY IS TURNED IN THE IGNITION, ALL ELECTRICAL COMPONENTS OPERATE AS DESIGNED, HOWEVER THE CAR WILL NOT TURN OVER. THIS IS NOT A BATTERY OR STARTER PROBLEM. THE CAR DOES NOT MAKE ANY CRANKING SOUNDS OR STARTER CLICKS. RATHER, THERE IS NO ENGINE TUR... Read more

Showing 50 of 323 complaints.

Technical Service Bulletins, 2003 SAAB 9-3

110 manufacturer communications from 75 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE AND ENGINE COOLING	14
110000 ELECTRICAL SYSTEM	13
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	8
200000 WHEELS	7
350000 EQUIPMENT	6
060000 ENGINE (PWS)	5
353000 EQUIPMENT:ELECTRICAL	5
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	5

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.

190000 TIRES

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

200000 WHEELS

060000 ENGINE AND ENGINE COOLING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

100000 POWER TRAIN

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

353000 EQUIPMENT:ELECTRICAL

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

060000 ENGINE (PWS)

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

190000 TIRES

200000 WHEELS

190000 TIRES

200000 WHEELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

IPC Odometer Programming Method Quick Reference Guide

117110 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER:SENSOR/SENDING UNIT

IPC Odometer Programming Method Quick Reference Guide

021300 SUSPENSION:FRONT:SHOCK ABSORBER

Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un

021400 SUSPENSION:FRONT:MACPHERSON STRUT

022400 SUSPENSION:REAR:SHOCK ABSORBER

060000 ENGINE (PWS)

THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBR

060000 ENGINE (PWS)

THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES.

110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN. THE VEHICLE'S XM RADIO ONLY HAS XM PREVEIW CHANNELS.

110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CA

110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

110000 ELECTRICAL SYSTEM

353000 EQUIPMENT:ELECTRICAL

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS.

110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification

060000 ENGINE (PWS)

OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification

110000 ELECTRICAL SYSTEM

OnStar? Voice Fallback Number Update Some customers may have received a letter from OnStar? stating that "We recently tried to provide a software update to the OnStar? hardware in your vehicle. However, your system could not be updated r

350000 EQUIPMENT

100000 POWER TRAIN

OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification

060000 ENGINE (PWS)

OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

XM Audio Traffic And Travel Link Availability And Operation.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Vehicle Recalls

353000 EQUIPMENT:ELECTRICAL

Programming And Activation Of Replacement OnStar Modules.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Canadian Customers Unable To Place Calls In The United States

350000 EQUIPMENT

Information On Requests To Add OnStar Bluetooth Option.

200000 WHEELS

Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

200000 WHEELS

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some fo

356000 EQUIPMENT ADAPTIVE/MOBILITY

161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

356000 EQUIPMENT ADAPTIVE/MOBILITY

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

353000 EQUIPMENT:ELECTRICAL

Programming And Activation Of Replacement OnStar Modules.

221300 SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

GENERAL MOTORS: INFORMATION PROVIDED BY BULLETIN FOR ALL 2012 AND PRIOR GENERAL MOTOR TRUCKS AND PASSENGER VEHICLES REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. *PE

181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

SAAB: ACCELERATOR PEDAL POSITION SENSOR DTCS SET IN ECM 2003-2009 SAAB. APP SENSOR DTC'S OF P2122-00, P2123-00, P2126-00, P2127-00, P2128-00, AND/OR P2138-00 IN THE ECM. THESE DTC'S MAY BE VERY INTERMITTENT AND ARE DIFFICULT TO REPRODUCE

021210 SUSPENSION:FRONT:SPRINGS:COIL SPRINGS

SAAB SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN VEHICLES, PARTICLES OF GRAVEL OR STONES MAY COLLECT BETWEEN THE COIL SPRING AND THE LOWER SPRING SEAT CAUSING THE SPRING TO CORRODE. THIS CORROSION MAY WEAKEN

162900 STRUCTURE:BODY:ROOF AND PILLARS

SAAB SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. UNDER CERTAIN CIRCUMSTANCES CONTROL MODULE'S ANALOGUE INPUTS MAY PRODUCE INVALID SIGNAL. THIS MEANS THE SOFT TOP'S CONTROL MODULE DOES NOT FUNCTION AS INTENDED. DIFFICULTIE

354000 EQUIPMENT:MECHANICAL

110000 ELECTRICAL SYSTEM

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

118000 ELECTRICAL SYSTEM:SOFTWARE

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

353000 EQUIPMENT:ELECTRICAL

BUICK\CADILLAC\CHEVROLET\GMC\HUMMER\OLDSMOBILE\PONTIAC\SAAB\SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. FCC RULED IN 2002 WIRELESS CARRIERS WOULD NO LONGER R

071110 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

SPECIAL COVERAGE ADJUSTMENT-FUEL TANK CAP. *KB

061000 ENGINE AND ENGINE COOLING:ENGINE

NOISE FROM THE TIMING CHAIN AND OIL SLUDGE IN THE ENGINE. *KB

134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

UPDATING THE SOFTWARE FOR SUNROOF PINCH PROTECTION. *TT

151300 SEAT BELTS:FRONT:RETRACTOR

SEAT BELT RETRACTORS THAT MAY HAVE BEEN DAMAGED DURING THE SUPPLIER'S MANUFACTURING PROCESSING. RECALL CAMPAIGN 15017 FRONT SEAT BELT REPLACEMENT. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

GEARBOX IS SLUGGISH, SPECIFICALLY DURING SHIFTING FROM 1ST TO 2ND AND FROM 3RD TO 2ND GEAR. *TT

060000 ENGINE AND ENGINE COOLING

REDUCED PERFORMANCE AND DIAGNOSTIC TROUBLE CODES FOR THE TURBO CONTROL VALVE. *EH

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

GENERAL FAULT DIAGNOSIS FOR AUTOMATIC TRANSMISSION. *EH

150000 SEAT BELTS

REPLACEMENT OF FRONT SEAT BELT. *EH

010000 STEERING

NOISE WITH STEERING WHEEL TURNING. *TT

110000 ELECTRICAL SYSTEM

ONSTAR MALFUNCTION MESSAGE ON SID AND DTC U1500 08 SET IN CU/PU. *EH

110000 ELECTRICAL SYSTEM

ONSTAR SOFTWARE UPDATE AND LOW BATTERY COMPLAINTS. *TT

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

ONSTAR SOFTWARE UPDATE AND LOW BATTERY COMPLAINTS. *EH

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

ADDITIONAL PROCEDURE FOR DISCONNECTING BATTERY POWER TO TELEMATICS UNIT. *EH

110000 ELECTRICAL SYSTEM

UPDATE OF ONSTAR ENGLISH VERSION. *EH

050000 PARKING BRAKE

HANDBRAKE LEVER JAMMING/CANNOT BE LOWERED. *MR

Showing 100 of 110 bulletins.

NHTSA Safety Investigations, SAAB 9-3

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2004

SEAT BELT RETRACTOR

ODI HAS RECEIVED EIGHT COMPLAINTS OF FRONT SEAT BELT RETRACTORS BREAKING ON MODEL YEAR 2004 SAAB 9-3 VEHICLES.A COMMON FAILURE SCENARIO INVOLVES THE DRIVER HEARING A NOISE AND THE BELT SUDDENLY LOSING TENSION.A NON-FUNCTIONING SEAT BELT INCREASES THE RISK AND SEVERITY OF INJURY IN THE EVENT OF A CRA... Read more

PE, Closed , Model Year: 2007

ENGINE COMPARTMENT FIRE

THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 7 SUBJECT VEHICLES THAT HAVE ALLEGEDLY EXPERIENCED ENGINE COMPARTMENT FIRES ORIGINATING AT THE COIL-ON-PLUG (COP) IGNITION COIL ASSEMBLY AND 28 ALLEGED NON-FIRE THERMAL EVENTS RESULTING IN DAMAGE LIMITED TO THE SUBJECT COMPONENT AND ASSOCIATED WI... RING. ALL REPORTED INCIDENTS OCCURRED WHILE THE VEHICLES WERE ATTENDED AND IN ALL BUT ONE CASE THE SUBJECT VEHICLES WERE REPAIRED AND RETURNED TO SERVICE AFTER THE INCIDENT INVOLVING THE ALLEGED DEFECT. ACCORDING TO GENERAL MOTORS (GM), A CERAMIC CAPACITOR USED IN THE ELECTROMAGNETIC NOISE FILTER CIRCUIT INSIDE THE SUBJECT COMPONENT MAY HAVE BEEN DAMAGED DURING THE MANUFACTURING PROCESS. A FRACTURE INSIDE THE CAPACITOR MAY, DEPENDING ON ITS SIZE AND LOCATION, RESULT IN A RESISTIVE SHORT CIRCUIT. WHEN ENERGIZED, THE RESISTIVE SHORT CIRCUIT MAY CAUSE HEAT THAT CAN MELT THE POTTING EPOXY AROUND THE CIRCUIT BOARD AND LEAD TO SMOKE, ODOR AND IN SOME INSTANCES FIRE. OTHER SYMPTOMS MAY INCLUDE A MISFIRE CONDITION RESULTING IN ROUGH RUNNING AND/OR ILLUMINATION OF THE SERVICE ENGINE SOON TELLTALE LIGHT. ALL 7 FIRES OCCURRED RELATIVELY EARLY IN THE SERVICE LIFE OF THE VEHICLE AT 120, 171, 198, 207, 297, 365 AND 394 DAYS IN SERVICE, RESPECTIVELY. ODI ANALYSIS INDICATES THAT APPROXIMATELY 98% OF THE SUBJECT VEHICLE POPULATION IS NOW BEYOND THE EXPOSURE AGE AT WHICH FIRE INCIDENTS WERE OBSERVED. THE LAST KNOWN FIRE INCIDENT OCCURRED IN MAY 2009 ON A VEHICLE THAT HAD 394 DAYS IN SERVICE AND THE LAST KNOW FIRE INCIDENT PREVIOUS TO THAT OCCURRED IN DECEMBER 2008 ON A VEHICLE THAT HAD 198 DAYS IN SERVICE. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR THE FIELD EXPERIENCE OF THE SUBJECT VEHICLES AS IT RELATES TO THE ALLEGED DEFECT AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. ADDITIONALLY, THE MANUFACTURER WILL PROVIDE THE AGENCY WITH AN UPDATE OF COMPLAINT AND WARRANTY INFORMATION IN 6 MONTHS FROM THE CLOSING DATE OF THIS INVESTIGATION AND UNTIL THAT TIME IT WILL NOTIFY THE AGENCY WITHIN 5 BUSINESS DAYS OF ANY FIRE INCIDENTS IT BECOMES AWARE OF THAT RELATES, OR MAY RELATE, TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.Read more

EA, Closed , Model Year: 2003

Front Suspension Coil Spring Fracture

To date, ODI is aware of 142 non-duplicative complaints related to the alleged defect.In addition, ODI is aware of 2,626 subject vehicles with one or more warranty claims related to the alleged defect.In total, ODI is aware of 2,714 unique subject vehicles that have experienced one or more front sus... Read more

PE, Closed , Model Year: 2003

FRONT SUSPENSION COIL SPRING FRACTURE

ON AUGUST 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE08-051) TO INVESTIGATE ALLEGED FRONT SUSPENSION COIL SPRING FRACTURES IN CERTAIN MODEL YEAR (MY) 2003-2004 SAAB 9-3 VEHICLES SOLD OR REGISTERED IN SALT BELT STATES.(NOTE: FOR PURPOSES OF THIS INVESTIGATI... Read more

PE, Closed , Model Year: 2006

REDUCED BRAKE POWER-ASSIST

SAAB AUTOMOBILE AB, A SUBSIDIARY OF GENERAL MOTORS CORP. (GM), MANUFACTURED 12,317 SUBJECT VEHICLES THROUGH FEBRUARY 15, 2008, EQUIPPED WITH THE HIGH FEATURE V6 TURBOCHARGED ENGINE IDENTIFIED BY REGULAR PRODUCTION OPTION LP9.A TANDEM VACUUM BRAKE BOOSTER ASSEMBLY PROVIDES BRAKE POWER-ASSIST.THE ENGI... NE IS THE PRIMARY VACUUM SOURCE TO THE BOOSTER AND ITS EFFECT IS AMPLIFIED BY A VENTURI.UNDER CERTAIN CONDITIONS, SUCH AS A COLD ENGINE START OR AT HIGH ALTITUDES, AN ELECTRIC VACUUM PUMP (EVP) SUPPLEMENTS ENGINE VACUUM.A PRESSURE SWITCH MEASURES BRAKE BOOSTER VACUUM AND COMMANDS THE EVP WHEN TO TURN ON/OFF.CHECK VALVES ARE LOCATED AT THE INTAKE MANIFOLD, VENTURI, AND PRESSURE SWITCH. GM IDENTIFIED TWO ISSUES THAT AFFECT EVP PERFORMANCE: CORROSION OF ELECTRICAL COMPONENTS INSIDE THE PUMP CAUSED BY MOISTURE INGRESS THROUGH THE AIR OUTLET WHEN THE EVP SHUTS OFF AND THE VACUUM IN A SECTION OF PIPING BETWEEN THE EVP AND THE PRESSURE SWITCH IS RELEASED TO THE ATMOSPHERE; AND SILICONE CONTAMINATION OF THE ELECTRICAL CONTACTS INSIDE THE PRESSURE SWITCH RESULTING IN A NOISY OR IMPEDED ELECTRICAL SIGNAL.GM ADDRESSED EVP PERFORMANCE WITH TWO DESIGN CHANGES.IN NOVEMBER 2007, GM MODIFIED THE RUBBER PROTECTIVE CAP THAT COVERS THE EVP AIR OUTLET TO IMPROVE SEALING AND IN FEBRUARY 2008, GM ADDED A CHECK VALVE TO THE SECTION OF PIPING BETWEEN THE EVP AND THE PRESSURE SWITCH AS CLOSE AS POSSIBLE TO THE EVP IN AN EFFORT TO REDUCE THE BACK FLOW OF MOISTURE THROUGH THE PUMP. IN TOTAL, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 240 SUBJECT VEHICLES AFFECTED BY THE ALLEGED DEFECT.COMPLAINANTS REPORT THAT SYMPTOMS OCCUR IMMEDIATELY AFTER A COLD ENGINE START AND ONLY FOR A SHORT DURATION (30 TO 60 SECONDS), DURING WHICH PERIOD THE AMOUNT OF BRAKE POWER-ASSIST PROVIDED TO THE OPERATOR MAY BE REDUCED DUE TO AN INOPERATIVE EVP.THE SYMPTOMS MAY BE MORE PRONOUNCED THE LONGER THE VEHICLE HAS BEEN PARKED AS THERE IS A NATURAL TENDENCY FOR THE BRAKE BOOSTER TO SLOWLY RELEASE THE VACUUM OVER TIME IF IT IS NOT REPLENISHED.FULL BRAKE POWER-ASSIST CAPABILITY RESUMES AFTER THIS BRIEF COLD START PERIOD OR IMMEDIATELY AFTER A WARM ENGINE START.THE THREE REPORTED CRASHES ALL OCCURRED AT LOW SPEEDS (< 5MPH) WHILE REVERSING FROM A GARAGE OR PARKING SPACE AND RESULTED IN MINIMAL TO MINOR PROPERTY DAMAGE. THE SUBJECT ISSUE DIFFERS FROM A PREVIOUS SAFETY RECALL (05V-236) AFFECTING CERTAIN MODEL YEAR (MY) 2003-2005 SAAB 9-3 VEHICLES EQUIPPED WITH A DEFECTIVE CHECK VALVE THAT COULD BECOME BRITTLE AND FRACTURE, RESULTING IN A LASTING AND TOTAL LOSS OF BRAKE POWER-ASSIST AT ANY TIME.THE DEFECTIVE CHECK VALVE DID NOT MEET LIFETIME DURABILITY REQUIREMENTS AND GM PREDICTED A 100% FAILURE RATE AT LESS THAN 4 YEARS OF SERVICE.IN COMPARISON, GM PREDICTS AN EVP FAILURE RATE OF APPROXIMATELY 6.4% AT 3 YEARS IN SERVICE FOR THE SUBJECT VEHICLES RESULTING IN REDUCED BRAKE POWER-ASSIST FOR A SHORT DURATION.THE SUBJECT ISSUE ALSO DIFFERS FROM A PREVIOUS ODI INFLUENCED SAFETY RECALL (03V-474) TO ADDRESS EVP MOISTURE INGRESS IN CERTAIN MY 2000 VOLVO S40 AND V40 VEHICLES.THE RECALLED VOLVO VEHICLES UTILIZED A STEEL VACUUM PIPE BETWEEN THE EVP AND THE BRAKE BOOSTER.MOISTURE INGRESS AND SUBSEQUENT CORROSION COULD COMPROMISE THE VACUUM PIPE RESULTING IN A LASTING AND TOTAL LOSS OF BRAKE POWER-ASSIST.MOISTURE DOES NOT APPEAR TO HAVE A SIGNIFICANT IMPACT ON THE POLYETHER-ESTER PLASTIC VACUUM PIPE USED IN THE SUBJECT VEHICLES. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATIONRead more

RQ, Closed , Model Year: 2001

FUEL LINE LEAKAGE

ON NOVEMBER 19, 2004 GM NOTIFIED ODI OF A DEFECT CONDITION THAT COULD RESULT IN FUEL LEAKAGE AT THE FUEL PUMP CONNECTIONS IN APPROXIMATELY 17,400 MODEL YEAR (MY) 2001 AND 2002 SAAB 9-3 PASSENGER VEHICLES BUILT AT THE UUSIKAUPUNKI, FINLAND ASSEMBLY PLANT BETWEEN MAY 2000 AND JULY 2002 (GM RECALL NO. ... Read more

PE, Closed , Model Year: 1999

ENGINE STALL/ ENGINE COMPARTMENT FIRES

ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTE... D SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE THE COMPLAINANTS ALLEGED A STALL OR FIRE.ON SEPTEMBER 13, 2005, GENERAL MOTORS (GM) NOTIFIED NHTSA OF A SAFETY DEFECT ON 95,081 MY 2000-2002 SAAB 9-3 AND 9-5 VEHICLES WITH 4-CYLINDER GASOLINE ENGINES AND 8,117 MY 2001 9-5 VEHICLES WITH 6- CYLINDER GASOLINE ENGINES (RECALL 05V-399).THE NOTIFICATION STATED THAT CERTAIN VEHICLES WITHIN THESE POPULATIONS MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IDM DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP FOR BOTH A 4-CYLINDER AND 6-CYLINDER ENGINE, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING.WHEN THE IDM FAILS ON A 4-CYLINDER WHILE IT IS RUNNING, THE ENGINE MAY STALL WITHOUT WARNING, WITH NO ABILITY TO BE RESTARTED.WHEN THE IDM FAILS ON A 6-CYLINDER ENGINE WHILE IT IS RUNNING, THE DRIVER WILL INITIALLY EXPERIENCE REDUCED POWER AND ROUGH OPERATION BECAUSE THE ENGINE WILL ONLY BE RUNNING ON THREE CYLINDERS.THE CHECK ENGINE LIGHT WILL FLASH.IF THE DRIVER CONTINUES, UNBURNT FUEL IN THE EXHAUST CAN CAUSE THERMAL DAMAGE TO THE CATALYTIC CONVERTER.THE ENGINE MAY STALL AND NOT RESTART.THERMAL DAMAGE TO OTHER UNDERHOOD COMPONENTS AND THE UNDERBODY MAY ALSO RESULT FROM PROLONGED DRIVING.THE RECALL POPULATION ENCOMPASSES 84% OF THE STALLING AND FIRE COMPLAINTS (215 FOR VEHICLES WITH 4-CYLINDER ENGINES AND 36 FOR VEHICLES WITH 6-CYLINDER ENGINES).THE 36 MONTHS IN SERVICE (MIS) STALLING RATES FOR EACH MODEL YEAR OF RECALLED VEHICLES WITH 4-CYLINDER ENGINES WERE ALL GREATER THAN TWO PERCENT.ALTHOUGH THE 36 MIS STALL RATE FOR THE RECALLED MY 2001 VEHICLES WITH V6 ENGINES WAS LOWER, AT 1.3 PERCENT, THESE VEHICLES ALSO HAD THE HIGHEST RATE OF CONFIRMED (OPEN FLAME VERIFIED) FIRES AT 62 PER 100,000 VEHICLES.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER FOR IDM INSPECTION AND REPLACEMENT, IF NECESSARY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE SCOPE AND REMEDY OF GM'S ACTION AND TAKE FURTHER ACTION IF WARRANTED.Read more

EA, Closed , Model Year: 2003

ENGINE STALL

ON DECEMBER 30, 2003, ODI OPENED A PRELIMINARY EVALUATION (PE03-059) TO INVESTIGATE 16 COMPLAINTS ALLEGING ENGINE STALL WHILE DRIVING IN MODEL YEAR 2003 SAAB 9-3 SPORT SEDANS WITH 2.0L TURBOCHARGED ENGINES.ON JANUARY 15, 2004, GENERAL MOTORS (GM) ADVISED ODI THAT GM AND SAAB HAD DECIDED TO CONDUCT A... Read more

PE, Closed , Model Year: 2003

ENGINE STALL

THE SUBJECT VEHICLES ARE EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND TURBOCHARGED ENGINES WITH TWO DIFFERENT POWER OUTPUTS, 175 HP AND 210 HP.SAAB HAS MODIFIED THE ELECTONIC CONTROL MODULE (ECM) SOFTWARE IN THE SUBJECT VEHICLES TO CORRECT PROBLEMS THAT COULD RESULT IN ENGINE STALL IN BOTH ENGINES. IN ... Read more

SAAB 9-3 - All Years Overview

Complete safety history for the SAAB 9-3 across all model years (1999, 2011).

47 Total Recalls

1,692 Total Complaints

9 Investigations

84 Reported Crashes

30 Reported Fires

4 Reported Deaths

SAAB 9-3 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2011	4	33	View
2010	4	31	View
2009	3	46	View
2008	3	218	View
2007	3	182	View
2006	3	227	View
2005	3	114	View
2004	6	236	View
2003 (current)	5	323
2002	4	52	View
2001	4	74	View
2000	2	72	View
1999	3	80	View
1994	0	1	View

Other SAAB Models

Model	Recalls	Complaints
900	44	552	View
99	31	0	View
9-5	30	662	View
9000	26	197	View
9-7X	16	237	View
9-2X	11	148	View
96	11	0	View
95	10	62	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2003 SAAB 9-3

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2003 SAAB 9-3

Most Affected Components

NHTSA Safety Investigations, SAAB 9-3

SAAB 9-3 - All Years Overview

SAAB 9-3 - Year by Year

Other SAAB Models