9999 RVI TIRE PATROL Recalls, Complaints & Safety

No recalls found for this vehicle.

Complaint Statistics

1 total complaints

Top Reported Components

Component	Complaints
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS	1

Incident date: Jul 15, 2022

Blowout and tire separation, Drivers front, traveling N on I-25 mile marker 7, south of Trinidad Co. Using Tire Patrol sensors on all motorhome tires and tow vehicle. After replacing tire and rim and on our way back home I noticed a low tire pressure on the right front tire. On inspecting the sens... Read more

NHTSA Safety Investigations — RVI TIRE PATROL

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed

Device can break causing tire to deflate without notification to the operator

On June 8, 2023, Office of Defects Investigation (ODI) opened Preliminary Evaluation PE23009 to investigate reports of air pressure loss from tires equipped with Danko Manufacturing/RViBrake’s (RViBrake) Tire Patrol device, an aftermarket tire pressure monitoring system. ODI’s initial inquiry de... termined that RViBrake was aware of 408 sensors being returned under warranty for leaking pressure, including approximately 40 that were reported to have broken in half, leaving the tires’ valve stem core pressed open and leaking air. ODI sent an Information Request (IR) letter to RViBrake on June 8, 2023. By analyzing the IR Response data, ODI learned that the bulk of the sensors returned under warranty were for dead sensors, or minor but consistent air leaks. The manufacturer believes that many of the warranty claims are user-induced, such as damage from curb strikes or from car washes. However, 41 warranty claims were for lost upper sensor halves, a condition that can cause the tire to deflate, without notification to the operator. This condition is particularly concerning when it occurs to one of the vehicle’s steer axle tires. No crashes or injuries are known to be directly attributable to any of these sensors. RViBrake explained that in the event of a sensor half detachment, the operator would not immediately be warned. The system refreshes the tire pressure information every three minutes, but it is not uncommon for a packet of information to not be received due to interference, especially with the rear wheels, which may be further away from the receiver. If the system does not receive fresh information from the sensor three times in a row, the icon for that sensor becomes greyed out on the display screen. Furthermore, if the system does not receive information from the sensor five times in a row, an audible alert sounds to warn the operator. As part of the IR response, RViBrake supplied a video replicating the worst case scenario.In the video, a broken and separated sensor half was installed on a fully pressurized steer tire on a Class-A motorhome.The tire deflated by approximately twenty seven percent in ten minutes. With the majority of the air still remaining in the tire after ten minutes, it is believed that the vehicle could still be safely maneuvered off of the roadway, illustrating that a broken Tire Patrol sensor does not lead to an immediate or rapid air loss of the tire. After discussions with RViBrake to discuss ways to reduce the risk to operators, the company has pushed out a system software update that now triggers the audible alert after a loss of signal from the front tires in less than nine minutes. Due to the amount of time needed for a tire to deflate after a full sensor half detachment and in view of this software update action taken by RViBrake, which provides improved notification to the driver of a slow loss of pressure in the tire, ODI has closed this Preliminary Evaluation. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

RVI TIRE PATROL — All Years Overview

Complete safety history for the RVI TIRE PATROL across all model years.

0 Total Recalls

1 Total Complaints

1 Investigations

0 Reported Crashes

0 Reported Fires

0 Reported Deaths

Other RVI Models

Model	Recalls	Complaints
RVI	0	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

9999 RVI TIRE PATROL

Complaint Statistics

Top Reported Components

NHTSA Safety Investigations — RVI TIRE PATROL

RVI TIRE PATROL — All Years Overview

Other RVI Models