2006 PREVOST H3-41
5 recalls — 0 complaints — 61 TSBs
24V523000 Jul 9, 2024
EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP
Defect Description
Prevost Car (US) Inc. (Prevost) is recalling certain 2005-2024 X3-45, 2017-2019 and 2021-2023 X3-45 Commuter, 2006-2007, 2014, and 2018 H3-41, 2005-2020 and 2022-2024 H3-45, and 2019 H3-45 VIP buses equipped with a wheelchair lift. The wheelchair platform bridging device may be too steep, which can... Read more
Consequence
An unstable wheelchair increases the risk of injury to lift occupants.
Remedy
Prevost will replace the wheelchair lift bridging device, free of charge. Owner letters were mailed April 25, 2025. Owners may contact Prevost customer service at 1-866-870-2046. Prevost's number for this recall is SR24-26.
08V007000 Jan 9, 2008
EQUIPMENT
Defect Description
ON CERTAIN MOTOR COACHES EQUIPPED WITH ZF/ARENS ASTRONIC SHIFT SELECTORS, A CELL PHONE PLACED IN THE PROXIMITY OF THE SHIFTER TOUCH PAD COULD CAUSE THE DISPLAY TO CHANGE FROM 'R' (REVERSE) TO 'D' (DRIVE) SHOULD THE PHONE RECEIVE A CALL.
Consequence
THIS INTERFERENCE CAN CAUSE THE TRANSMISSION TO NOT OPERATE OR CAUSE IMPROPER SHIFTING, AS FORWARD GEAR CAN BE ENGAGED FROM NEUTRAL ONLY, IF THE VEHICLE HAS BEEN STOPPED, AND IF THE BRAKE PEDAL HAS BEEN DEPRESSED. IF THE MALFUNCTION OCCURS WHILE 'R' (REVERSE) IS BEING SELECTED, THE SHIFTER MAY POSS... Read more
Remedy
PREVOST WILL MAIL STICKERS AND INSTALLATION INSTRUCTIONS TO THEIR OWNERS AND WILL ALSO ARRANGE TO HAVE THE TRANSMISSION SOFTWARE UPGRADED. THE RECALL BEGAN ON FEBRUARY 13, 2008. OWNERS MAY CONTACT PREVOST AT 1-418-831-5432.
07V371000 Aug 20, 2007
PARKING BRAKE
Defect Description
ON CERTAIN MOTOR COACHES EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.
Consequence
THIS COULD CAUSE DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.
Remedy
PREVOST IS WORKING WITH BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 14, 2007. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000 OR PREVOST AT 1-418-831... Read more
06V243000 Jul 11, 2006
PARKING BRAKE:CONVENTIONAL:AIR
Defect Description
ON CERTAIN MOTOR COACHES EQUIPPED WITH BENDIX SR-7 BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE... Read more
Consequence
THE DELAYED PARKING BRAKE APPLICATION CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT THE VALVES AND REPLACE IT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 5, 2006. OWNERS MAY CONTACT PREVOST AT 418-831-2046.
05V516000 Nov 7, 2005
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Defect Description
ON CERTAIN MULTIPLEX MOTOR COACHES, THE WIPER MOTOR THERMAL PROTECTION IS STOPPING THE MOTOR WHEN THE WIPERS ARE FUNCTIONING FOR A LONG TIME IN SECOND SPEED.
Consequence
DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL INSTALL A NEW WIPER HARNESS AND A NEW MULTIPLEX PROGRAM WILL BE DOWNLOADED IN ALL COACHES. THE RECALL BEGAN ON NOVEMBER 23, 2005. OWNERS MAY CONTACT PREVOST AT 1-418-831-2046.
No complaints found for this vehicle.
Technical Service Bulletins — 2006 PREVOST H3-41
61 manufacturer communications from 42 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 11 |
| 110000 ELECTRICAL SYSTEM | 6 |
| 010000 STEERING | 5 |
| 020000 SUSPENSION | 4 |
| 060000 ENGINE AND ENGINE COOLING | 4 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 4 |
| 355100 EQUIPMENT:OTHER:LABELS | 3 |
| 040000 SERVICE BRAKES, AIR | 3 |
IS-23019
Dec 14, 2023
020000 SUSPENSION
SWAY BAR COLLARS IMPROVEMENT
IS-22106
Jul 4, 2023
350000 EQUIPMENT
H3 LAVATORY FAN RETROFIT KIT
MI22-12B
Dec 7, 2022
040000 SERVICE BRAKES, AIR
Air Tanks Draining Sequence. Revision: B - General Update
MI22-12A
Nov 17, 2022
040000 SERVICE BRAKES, AIR
Air Tanks Draining Sequence. Revision: A - Erroneous Secondary & Accessory tanks location.
MI22-12
Nov 2, 2022
040000 SERVICE BRAKES, AIR
Air Tanks Draining Sequence
IS20-925A
Jun 13, 2022
130000 VISIBILITY
CENTRAL HVAC MERV FILTERS INSTALLATION
IS-20925A
Jun 15, 2021
100000 POWER TRAIN
CENTRAL HVAC MERV FILTERS INSTALLATION REVA
MI20-08C
Jun 3, 2021
160000 STRUCTURE
STORAGE AND STARTUP GUIDELINES: Periodically, circumstances arise requiring operators to temporarily park a coach in storage. Whether it is a few weeks or several months, sporadic out of service times or a full stop, Prevost recommends foll
IS-18091A
Apr 5, 2021
010000 STEERING
TIE ROD 610052 FIRST INSTALLATION INSTRUCTIONS: Use these instructions when replacing the drop joint tie rod on S82, S84 / S84U I-beam axles. The new tie rod will be adjusted to the length of the original; however, a steering alignment ne
MI20-19A
Jan 15, 2021
350000 EQUIPMENT
Rev A: Mention added concerning DDC Series 60 engine SCA requirement
MI20-19A
Jan 15, 2021
060000 ENGINE AND ENGINE COOLING
Rev A: Mention added concerning DDC Series 60 engine SCA requirement
MI20-19
Dec 21, 2020
350000 EQUIPMENT
INTRODUCING A NEW ENGINE COOLANT INTO SERVICE
MI20-19
Dec 21, 2020
060000 ENGINE AND ENGINE COOLING
INTRODUCING A NEW ENGINE COOLANT INTO SERVICE
MI02-17A
Dec 11, 2020
350000 EQUIPMENT
Revision : A Torque value reduced
MI02-17A
Dec 11, 2020
200000 WHEELS
Revision : A Torque value reduced
MI02-17A
Dec 11, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Revision : A Torque value reduced
IS-19165A
Nov 9, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
LAVATORY FAN RETROFIT KIT Applicable for H3 Series coaches from R-1012 (1994) Revision A: Added installation detail at step 8
IS-19165A
Nov 9, 2020
350000 EQUIPMENT
LAVATORY FAN RETROFIT KIT Applicable for H3 Series coaches from R-1012 (1994) Revision A: Added installation detail at step 8
IS-19165A
Nov 9, 2020
110000 ELECTRICAL SYSTEM
LAVATORY FAN RETROFIT KIT Applicable for H3 Series coaches from R-1012 (1994) Revision A: Added installation detail at step 8
SCi20-16
Oct 26, 2020
060000 ENGINE AND ENGINE COOLING
FAN CLUTCH PLATE BOLTS RE-TORQUING
IS-20923
Oct 6, 2020
350000 EQUIPMENT
H3 DRIVERa??S PARTITION LITE INSTALLATION
MI20-08B
Aug 10, 2020
350000 EQUIPMENT
STORAGE AND STARTUP GUIDELINES Revision: B Parts added to Suggested Material 08-10-2020
MI20-12
Jul 10, 2020
010000 STEERING
JERKY, NOISY OR HARD TO TURN STEERING GEARBOX. HYDRAULIC END LIMITER ADJUSTMENT. All models a?? equipped with RB Bosch/ZF Servocom or Servocomtronic steering gearbox
MI20-08A
Jun 10, 2020
350000 EQUIPMENT
STORAGE AND STARTUP GUIDELINES: Rev A: 21516229 replaced by 23381562 20523393 replaced by 21454749 800383 removed 611471 replaced by 611360 70376808 replaced by 21036050 21396642 replaced by 20967831
MI20-09
Apr 24, 2020
355100 EQUIPMENT:OTHER:LABELS
PREVOST VEHICLE DISINFECTION PROCEDURE
MI20-08
Apr 20, 2020
980000 UNKNOWN OR OTHER
STORAGE AND STARTUP GUIDELINES - ALL PREVOST VEHICLES & VOLVO 9700
MI15-24
Mar 25, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Added: Power cables for L.H. side alternator & fan drive breaker box
MI15-24
Mar 25, 2020
350000 EQUIPMENT
Added: Power cables for L.H. side alternator & fan drive breaker box
MI15-24
Mar 25, 2020
110000 ELECTRICAL SYSTEM
Added: Power cables for L.H. side alternator & fan drive breaker box
IS-14076
Feb 20, 2020
080000 FUEL SYSTEM, DIESEL
This instruction sheets explains how to replace the fuel tank on H-series vehicles. (Replacing older series tanks by newer model)
IS-14076
Feb 20, 2020
350000 EQUIPMENT
This instruction sheets explains how to replace the fuel tank on H-series vehicles. (Replacing older series tanks by newer model)
MI19-32
Aug 29, 2019
110000 ELECTRICAL SYSTEM
This Maintenance Information explains how to install harness #7770134, designed to bypass the Engine Compartment Harness (Prevost part), connecting the DPF harness (10-pin connector) and the Engine Harness (31-pin connector).
MI19-32
Aug 29, 2019
060000 ENGINE AND ENGINE COOLING
This Maintenance Information explains how to install harness #7770134, designed to bypass the Engine Compartment Harness (Prevost part), connecting the DPF harness (10-pin connector) and the Engine Harness (31-pin connector).
IS-18091
Aug 19, 2019
010000 STEERING
This Instruction Sheet explains how to perform the first installation of Tie Rod 610052 on Prevost vehicles equipped with Dana S82, S84 / S84U I-beam axles, 1994- today
MI18-45A
Jun 7, 2019
100000 POWER TRAIN
Vehicles identified below are compatible with a new tie rod design. This new tie rod 610052 has updated ball joints and a fine adjuster sleeve. It replaces former drop type ball joint tie rods. Refer to IS-18091 for installation instruction
MI18-45A
Jun 7, 2019
020000 SUSPENSION
Vehicles identified below are compatible with a new tie rod design. This new tie rod 610052 has updated ball joints and a fine adjuster sleeve. It replaces former drop type ball joint tie rods. Refer to IS-18091 for installation instruction
MI18-45A
Jun 7, 2019
010000 STEERING
Vehicles identified below are compatible with a new tie rod design. This new tie rod 610052 has updated ball joints and a fine adjuster sleeve. It replaces former drop type ball joint tie rods. Refer to IS-18091 for installation instruction
IS-18091
Jun 6, 2019
020000 SUSPENSION
This instruction sheet explains how to install the Tie Rod 610052.
IS-18091
Jun 6, 2019
010000 STEERING
This instruction sheet explains how to install the Tie Rod 610052.
IS-17910A
Jun 5, 2019
350000 EQUIPMENT
MESSAGE CENTER DISPLAY (MCD) REPLACEMENT
IS-17910A
Jun 5, 2019
110000 ELECTRICAL SYSTEM
MESSAGE CENTER DISPLAY (MCD) REPLACEMENT
IS-19916
May 23, 2019
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
This instruction sheet explains how to install the Audio Converter 405842
IS-19916
May 23, 2019
110000 ELECTRICAL SYSTEM
This instruction sheet explains how to install the Audio Converter 405842
IS-08006A
May 16, 2019
170000 LATCHES/LOCKS/LINKAGES
This instruction sheet explains how to relocate engine door gas spring.
IS-08006
Apr 22, 2019
170000 LATCHES/LOCKS/LINKAGES
This instruction sheet explains how to relocate engine door gas spring.
IS-08006
Apr 22, 2019
060000 ENGINE (PWS)
This instruction sheet explains how to relocate engine door gas spring.
SCI17-35
Jan 16, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
This internal instruction explains how to bench program the FMS gateway module used in the ELD (Electronic Logging Device) interface kit for pre-OBD13 vehicles.
IS-16903
Jun 26, 2017
356000 EQUIPMENT ADAPTIVE/MOBILITY
This instruction sheet explains how to replace the two older generation (brush type) condenser fans by four newer style (brushless) fans.
IS-11003D
May 26, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Instruction sheet explains how to remplace MASTER ID? WITH ?MCM? MODULE
SCI09-28
Feb 1, 2010
150000 SEAT BELTS
PREVOST: INSTALLING THREE-POINT PASSENGER SEAT RESTRAINT SYSTEM. THE PURPOSE OF THE FOLLOWING PROCEDURE IS TO FACILITATE THE JOB AND TO HELP IDENTIFY THE DIFFICULT AREAS. ALSO INCLUDED MODELS HE-41 AND HE-45 COACHES MODEL YEARS 1998-2008; M
MI08-04
Aug 1, 2008
021800 SUSPENSION:FRONT:KING PIN
FRONT AND TAG AXLE HUB BEARING AND KING PIN PERIODIC MAINTENANCE. BEARINGS MUST BE INSPECTED AT INTERVALS OF 30,000 MILES (48 000KM). KING PINS SHOULD BE SERVICED EVERY 6, 250 MILES (10,000 KM) OR TWICE A YEAR. ALSO INCLUDED MODEL VIP-45 MT
MI08-04
Aug 1, 2008
021700 SUSPENSION:FRONT:HUB
FRONT AND TAG AXLE HUB BEARING AND KING PIN PERIODIC MAINTENANCE. BEARINGS MUST BE INSPECTED AT INTERVALS OF 30,000 MILES (48 000KM). KING PINS SHOULD BE SERVICED EVERY 6, 250 MILES (10,000 KM) OR TWICE A YEAR. ALSO INCLUDED MODEL VIP-45 MT
WB08-07
Apr 1, 2008
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
IMPROVED AIR CIRCULATION ON H3 COACHES EQUIPPED WITH WCL AND SLIDING DOOR. IN ORDER TO IMPROVE THE PASSENGERS COMFORT IT IS NECESSARY TO INCREASE THE AIR CIRCULATION IN THE OVERHEAD COMPARTMENT AS WELL AS BEHIND THE WHEELCHAIR LIFT DOOR. *
WB08-02A
Apr 1, 2008
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
POWER WINDOW HARNESS- REMOVAL OF ZENER SUPPRESSOR DIODES. A FAULTY DIODE WILL CAUSE THE BURNING OF THE FUSE PROTECTING THE CIRCUIT. ALSO INCLUDED MODEL XLII-40, XLII-45 MOTORHOMES & ENTERTAINER XLII-45. MODEL YEARS 2007-2008. MODEL VIP MOTO
WB08-02A
Apr 1, 2008
110000 ELECTRICAL SYSTEM
POWER WINDOW HARNESS- REMOVAL OF ZENER SUPPRESSOR DIODES. A FAULTY DIODE WILL CAUSE THE BURNING OF THE FUSE PROTECTING THE CIRCUIT. ALSO INCLUDED MODEL XLII-40, XLII-45 MOTORHOMES & ENTERTAINER XLII-45. MODEL YEARS 2007-2008. MODEL VIP MOTO
WB07-08
Aug 1, 2007
980000 UNKNOWN OR OTHER
PREVOST: REPLACE DECAL IN THE MAIN POWER COMPARTMENT. CB11 WAS CHANGED FROM 35A TO 50A. *JS
0708
Aug 1, 2007
355100 EQUIPMENT:OTHER:LABELS
DECAL REPLACEMENT IN THE MAIN POWER COMPARTMENT. *KB
0705
Jun 1, 2007
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
REMOVAL OF ZF TRANSMISSION NEUTRAL POSITION RELAY ON H3 MULTIPLEX VEHICLES. *KB
WB07-05
Jun 1, 2007
103800 POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
PREVOST: REMOVE ZF TRANSMISSION NEUTRAL POSITION RELAY ON H3 MULTIPLEX VEHICLES. RELAY INDICATING THAT ZF TRANSMISSION IS IN NEUTRAL POSITION MUST BE REMOVED TO AVOID FUSE BURNING AND TO BE STANDARDIZED WITH OTHER VEHICLES. *JS
MI07-06
May 1, 2007
020000 SUSPENSION
PREVOST: NEW FIXING HARDWARE FOR THE REAR HEIGHT CONTROL VALVE LINK ROD. THERE IS A POSSIBILTY THAT THE LINK ROD THAT CONNECTS THE HEIGHT CONTROL VALVE TO THE DRIVE AXELS SUPPORT FRAME COMES APART WHEN THE VEHICLE IS MOVING. MODEL VIP-45MTH
0703
May 1, 2007
355100 EQUIPMENT:OTHER:LABELS
PREVOST - INSTALLING DECAL WARNING AGAINST PERFORMING ANY WELDING WORK. *NJ
NHTSA Safety Investigations — PREVOST H3-41
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE05012
Opened: Feb 28, 2005 — Closed: Apr 14, 2005
POWER STEERING HOSE LEAKAGE
THIS INVESTIGATION WAS OPENED AS THE RESULT OF ODI'SREVIEW OF PREVOST SERVICE BULLETIN, WB04-10,ISSUED IN DECEMBER 2004 AND TITLED INSPECTION AND REPLACEMENT OF POWER STEERING PRESSURE HOSE.THE BULLETIN ADDRESSED THE POSSIBILITY THAT POWER STEERING ASSIST COULD BE LOST DUE TO A POWER STEERING PRESSU... Read more
PREVOST H3-41 — All Years Overview
Complete safety history for the PREVOST H3-41 across all model years (1989–2019).
150
Total Recalls
0
Total Complaints
1
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
PREVOST H3-41 — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2019 | 1 | 0 | View |
| 2018 | 4 | 0 | View |
| 2017 | 2 | 0 | View |
| 2016 | 3 | 0 | View |
| 2015 | 4 | 0 | View |
| 2014 | 9 | 0 | View |
| 2013 | 7 | 0 | View |
| 2012 | 8 | 0 | View |
| 2011 | 6 | 0 | View |
| 2010 | 8 | 0 | View |
| 2009 | 7 | 0 | View |
| 2008 | 6 | 0 | View |
| 2007 | 4 | 0 | View |
| 2006 (current) | 5 | 0 | |
| 2005 | 3 | 0 | View |
| 2004 | 4 | 0 | View |
| 2003 | 2 | 0 | View |
| 2002 | 3 | 0 | View |
| 2001 | 5 | 0 | View |
| 2000 | 6 | 0 | View |
| 1999 | 7 | 0 | View |
| 1998 | 6 | 0 | View |
| 1997 | 8 | 0 | View |
| 1996 | 7 | 0 | View |
| 1995 | 6 | 0 | View |
| 1994 | 6 | 0 | View |
| 1993 | 3 | 0 | View |
| 1992 | 3 | 0 | View |
| 1991 | 3 | 0 | View |
| 1990 | 3 | 0 | View |
| 1989 | 1 | 0 | View |